IllustrationI WAS BACKING OUT OF THE DRIVEWAY WHEN I HEARD A NOISE AND FELT MY CAR JOLT. I GOT OUT AND MY PASSENGER SIDE TIRE SNAPPED OFF THE CAR. *TR
2003 Hyundai Elantra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Hyundai Elantra do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Elantra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
300–25K
3725–50K
3350–75K
2975–100K
28100–150K
11150K+
168 reports with mileage · 66 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
42 crash reports1 fire reports25 injury reports
Suspension complaints
61 reports8/11/2009, MY DAUGHTER AND I WERE DRIVING A 2003 HYUNDAI ELANTRA DOWN A SMALL STREET IN CHICAGO WHEN THE PASSENGER SIDE FRONT LOWER CONTROL ARM FRACTURED AT THE BALL JOINT ATTACHMENT . THE TIRE THEN CAME AWAY FROM THE ASSEMBLY AND WAS RENDERED INOPERABLE. IN OCTOBER OF 2009, I BECAME AWARE OF THE RECALL REGARDING THIS AND FILED …
Read full complaint
8/11/2009, MY DAUGHTER AND I WERE DRIVING A 2003 HYUNDAI ELANTRA DOWN A SMALL STREET IN CHICAGO WHEN THE PASSENGER SIDE FRONT LOWER CONTROL ARM FRACTURED AT THE BALL JOINT ATTACHMENT . THE TIRE THEN CAME AWAY FROM THE ASSEMBLY AND WAS RENDERED INOPERABLE. IN OCTOBER OF 2009, I BECAME AWARE OF THE RECALL REGARDING THIS AND FILED A COMPLAINT HERE AND HYUNDAI MOTOR AMERICA REIMBURSED ME FOR THE REPLACEMENT OF THE CONTROL ARM. I THEN TOOK THE CAR TO MY LOCAL HYUNDAI DEALER WHO SIMPLY "ADDED A PLUG KIT AND RUST PREVENTATIVE." AN INSPECTION OF THE SUBFRAME DID NOT OCCUR AT THAT TIME; WHICH SHOULD HAVE OCCURRED SINCE A CONTROL ARM HAD ALREADY FRACTURED AND THE RECALL C/091 CALLS FOR THIS INSPECTION, AS WELL AS REPAIR AND. OR REPLACEMENT OF ANY PARTS ATTACHED TO THESE ASSEMBLIES. ON 3/28/2011 , WHILE HAVING SOME BRAKE AND TIRE WORK DONE, A LOCAL GOODYEAR DEALERS SERVICE DEPARTMENT NOTICED SEVERE CORROSION ON THE DRIVERS SIDE CONTROL ARM AS WELL AS THE SUBFRAME. I IMMEDIATELY HAD THE CONTROL ARM REPLACED DUE TO MY NEAR FATAL PREVIOUS EXPERIENCE. I HAVE THE ORIGINAL CONTROL DRIVERS SIDE CONTROL ARM IN MY POSSESSION, AS WELL AS SEVERAL PHOTOS OF MY SUBFRAME. PLEASE PASS THIS COMPLAINT ALONG TO HYUNDAI FOR REVIEW.I HAVE ALREADY SPOKEN TO THE ATTORNEYS IN THE CIRULLI,D'ELIA CASE #[XXX] AND THEY URGED ME TO TRY TO DISCUSS THIS WITH HYUNDAI . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 15-20 MPH, THE DRIVER SIDE FRONT WHEEL SEPARATED FROM THE VEHICLE AND CAUSED THE AXLE FRACTURE FROM THE VEHICLE BEFORE STALLING. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THE CONTACT WAS ADVISED OF A POTENTIAL RECALL ASSOCIATED WITH THE VEHICLE (NHTS…
Read full complaint
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 15-20 MPH, THE DRIVER SIDE FRONT WHEEL SEPARATED FROM THE VEHICLE AND CAUSED THE AXLE FRACTURE FROM THE VEHICLE BEFORE STALLING. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THE CONTACT WAS ADVISED OF A POTENTIAL RECALL ASSOCIATED WITH THE VEHICLE (NHTSA CAMPAIGN ID NUMBER: 09V125000-SUSPENSION: FRONT: CONTROL ARM). THE CONTACT WAS ADVISED BY AN AUTHORIZED DEALER THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL AND ANY FURTHER REPAIRS WOULD BE AT THE EXPENSE OF THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 80,540.
I WAS DRIVING 11 MILES TO THE AIRPORT, INVOLVING 8 MILES OF 60 MPH FREEWAY DRIVING; THE REST WAS CITY DRIVING, 25-45 MPH WITH SEVERAL STOPS. AFTER I STOPPED AT THE SECURITY GATE AND PROCEEDED FORWARD, I HEARD A LOUD CRUNCHING THUD ON THE FRONT END; THE CAR SCREECHED TO A HALT; AND I THOUGHT I COLLIDED WITH A CONCRETE BLOCK OR A …
Read full complaint
I WAS DRIVING 11 MILES TO THE AIRPORT, INVOLVING 8 MILES OF 60 MPH FREEWAY DRIVING; THE REST WAS CITY DRIVING, 25-45 MPH WITH SEVERAL STOPS. AFTER I STOPPED AT THE SECURITY GATE AND PROCEEDED FORWARD, I HEARD A LOUD CRUNCHING THUD ON THE FRONT END; THE CAR SCREECHED TO A HALT; AND I THOUGHT I COLLIDED WITH A CONCRETE BLOCK OR A DEEP POTHOLE. THE RIGHT FRONT WHEEL WAS TURNED NEARLY 90 DEGREES TO THE RIGHT, WHILE THE LEFT WHEEL WAS STRAIGHT. THE DRIVE SHAFT AND TIE ROD WERE HOLDING THE WHEEL ON THE CAR, BUT THE MAIN STRUCTURAL COMPONENT OF THE RIGHT FRONT END WAS COMPLETELY BROKEN OFF. THE LOWER CONTROL ARM HAD SNAPPED, APPARENTLY BECAUSE OF RUST AND CORROSION. MY CAR WAS PARTIALLY OBSTRUCTING THE PARKING LOT ENTRANCE AND COULD NOT BE MOVED. I INFORMED THE AIRPORT POLICE OF THE INCIDENT AND PROMISED TO HAVE THE CAR TOWED OFF THE LOT WHEN I COMPLETED MY 3-HOUR SHIFT. I MET THE AIRPORT POLICE AND THE AAA TOW DRIVER AT 1:45 AM. THE BROKEN FRONT END MADE TOWING VERY DIFFICULT, AND SOME BODY DAMAGE RESULTED FROM THE WHEEL WELL AND FENDER RESTING ON THE TIRE IN TRANSIT. THE CAR WAS TAKEN TO THE AAA SHOP AT 2AM. I RESEARCHED THE FRONT END FAILURE ON THE INTERNET AND FOUND MANY SIMILAR COMPLAINTS AND DISCOVERED THAT THERE WAS A PRODUCT RECALL ON THE FAILED PART. I CALLED 800-633-5151 AND WAS TOLD THAT MY VIN WAS NOT PART OF THE RECALL. THE CATASTROPHIC FAILURE OF THE FRONT END COULD HAVE KILLED ME, IF IT HAPPENED 5 MINUTES SOONER, SO I FILED A FORMAL COMPLAINT. I WAS ASSIGNED A CASE NUMBER AND ADVISED TO HAVE THE HYUNDAI DEALER INSPECT THE DAMAGE. THE DEALER CONFIRMED THAT I WAS NOT INCLUDED IN THE RECALL, BUT SAID IT WAS VERY LIKELY THAT HYUNDAI WOULD REPAIR THE CAR BASED ON "GOOD WILL." THE RECALL EXCLUDED NEBRASKA CARS, ALTHOUGH IT WAS PURCHASED IN MO AND DRIVEN TO WORK DAILY IN IOWA. MY LIFE WAS PLACED IN JEOPARDY BECAUSE I WAS NOT INCLUDED IN THE RECALL. HOPEFULLY, HYUNDAI WILL ACCEPT RESPONSIBILITY FOR CORRECTING AN OBVIOUSLY DANGEROUS DEFECT FOUND IN ALL 2003 ELANTRAS. *TR
2003 HYUNDAI ELANTRA. CONSUMER STATES SEVERAL PROBLEM WITH VEHICLE *TGW THE CONSUMERS STATED HE RECEIVED A RECALL LETTER FROM HYUNDAI AND TEN DAYS LATER, THE FRONT END OF THE VEHICLE COLLAPSED AND CAUSED DAMAGE TO OTHER COMPONENTS WITHIN THE VEHICLE.
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED WHILE PULLING INTO HIS DRIVEWAY AT RELATIVELY LOW SPEEDS, THE PASSENGERS SIDE WHEEL FRACTURED FROM THE VEHICLE. THE FAILURE OCCURRED DUE TO RUST AND CORROSION OF THE FRAME AND CONTROL ARM. THE CONTACT PREVIOUSLY EXPERIENCED THE FAILURE ON THE DRIVERS SIDE WHEEL. TH…
Read full complaint
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED WHILE PULLING INTO HIS DRIVEWAY AT RELATIVELY LOW SPEEDS, THE PASSENGERS SIDE WHEEL FRACTURED FROM THE VEHICLE. THE FAILURE OCCURRED DUE TO RUST AND CORROSION OF THE FRAME AND CONTROL ARM. THE CONTACT PREVIOUSLY EXPERIENCED THE FAILURE ON THE DRIVERS SIDE WHEEL. THE MANUFACTURER ADVISED THE VEHICLE WAS UNDER RECALL BUT THE PARTS WERE NOT YET AVAILABLE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 120,000.
AS I WAS DRIVING MY 2003 HYUNDAI ELANTRA OUT OF WORK, THE STRUCTURAL METAL COMPONENT THAT CONNECTS TO THE FRONT, PASSENGER SIDE TIRE (OR REFERRED TO AS LOWER ARM OR A-FRAME) SNAPPED AND THE VEHICLE LOST CONTROL AND STOPPED MOVING IMMEDIATELY. THE TIRE WAS ESSENTIALLY DETACHED FROM THE VEHICLE AND DAMAGE TO THE PASSENGER SIDE DO…
Read full complaint
AS I WAS DRIVING MY 2003 HYUNDAI ELANTRA OUT OF WORK, THE STRUCTURAL METAL COMPONENT THAT CONNECTS TO THE FRONT, PASSENGER SIDE TIRE (OR REFERRED TO AS LOWER ARM OR A-FRAME) SNAPPED AND THE VEHICLE LOST CONTROL AND STOPPED MOVING IMMEDIATELY. THE TIRE WAS ESSENTIALLY DETACHED FROM THE VEHICLE AND DAMAGE TO THE PASSENGER SIDE DOOR, FRONT BUMPER AND WHEEL COVER. THANK GOODNESS I WAS NOT ON A MAIN ROAD YET IN RUSH HOUR TRAFFIC DRIVING 40-50 MPH OR I AM CERTAIN THERE WOULD HAVE BEEN AN ACCIDENT WHEN I WOULD HAVE LOST CONTROL OF THE VEHICLE DUE TO THIS LATENT STRUCTURAL DEFECT. I HAD THE TRUCK TOWED TO THE NEAREST HYUNDAI DEALER TO BE EXAMINED AND TOOK PHOTOS OF THE CONDITION OF THE RUSTED METAL CONTROL ARM THAT HAD SNAPPED. I DID SOME RESEARCH ON RECALLS WITH THIS VEHICLE AND THERE WAS A 4/2009 RECALL IN CERTAIN STATES WITH HEAVY WINTERS AND USE OF SALT TO CLEAR ROADS, ETC. MY STATE (NEBRASKA) WAS NOT LISTED AS AN AFFECTED STATED BUT ALL OF THE SURROUNDING STATES (I.E. IOWA, MINNESOTA, MISSOURI, ILLINOIS, INDIANA, COLORADO, WISCONSIN) WERE. NEBRASKA HAS JUST AS MUCH SNOW OR MORE SNOW THAN IOWA IN MY OPINION. THE VEHICLE WAS ORIGINALLY PURCHASED IN OMAHA, NE WHICH IS RIGHT ON THE BORDER OF IOWA. I BELIEVE THIS WILL ALSO BE A PROBLEM IN NEBRASKA AND SURROUNDING STATES POSSIBLY. IF THIS CONTROL ARM SNAPS WHILE SOMEONE IS DRIVING ON THE INTERSTATE OR OTHER ROADS AT HIGHER SPEEDS, SOMEONE WILL BE SERIOUSLY INJURED. I AM EVEN MORE UPSET BY THE FACT THAT MY ONE YEAR OLD SON VERY WELL COULD HAVE BEEN IN THE VEHICLE WITH ME WHEN THIS HAPPENED. NOT GOOD. THANKFULLY, NO ONE WAS INJURED AND THE ONLY DAMAGE WAS TO THE VEHICLE ITSELF. THE DEALER CALLED TODAY AND THEY EXPLAINED WE ARE NOT A PART OF THE RECALL BUT THE EVIDENCE IS PRETTY OBVIOUS THAT THIS IS THE SAME IDENTICAL PROBLEM AND THEY ARE TRYING TO USE ARBITRARY STATE BOUNDARIES TO GET OUT OF THEIR RESPONSIBILITY. WE ALSO CARRY A FULL WARRANTY UNTIL 2013 ON THE VEHICLE SO WE WILL SEE WHAT HAPPENS. *TR
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT WHILE DRIVING 5 MPH AND MAKING A LEFT TURN, THE FRONT PASSENGER WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 09V125000, SUSPENSION, FRONT CONTROL ARM AND THE PART NEEDED TO…
Read full complaint
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT WHILE DRIVING 5 MPH AND MAKING A LEFT TURN, THE FRONT PASSENGER WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 09V125000, SUSPENSION, FRONT CONTROL ARM AND THE PART NEEDED TO CORRECT THE FAILURE WAS NOT AVAILABLE. THE DEALER ALSO CONFIRMED THAT THE FRONT DRIVERS SIDE WHEEL WAS CORRODED AND WOULD ALSO NEED TO BE REPLACED. TWO MONTHS FOLLOWING THE FAILURE, THE PARTS WERE STILL NOT AVAILABLE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 89,000.
2003 HYUNDAI ELANTRA 4DSD VIN # [XXX] ....I HAVE HAD A RECALL FOR SEVERAL MONTHS, SINCE 1/1/10, HERE IN SELDEN, NY 11784 FOR THE "SUSPENSION: FRONT CONTROL ARMS". I HAD THE VEHICLE INSPECTED FOR THE RECALL ON 4/1/10. THE DEALERSHIP AT HUSTED HYUNDAI AT 1752 MIDDLE COUNTRY ROAD CENTEREACH 11720 PH# 631-580-0800 INFORMED ME IT Q…
Read full complaint
2003 HYUNDAI ELANTRA 4DSD VIN # [XXX] ....I HAVE HAD A RECALL FOR SEVERAL MONTHS, SINCE 1/1/10, HERE IN SELDEN, NY 11784 FOR THE "SUSPENSION: FRONT CONTROL ARMS". I HAD THE VEHICLE INSPECTED FOR THE RECALL ON 4/1/10. THE DEALERSHIP AT HUSTED HYUNDAI AT 1752 MIDDLE COUNTRY ROAD CENTEREACH 11720 PH# 631-580-0800 INFORMED ME IT QUALIFIED FOR REPLACEMENT OF SAID SUSPENSION FRAME, BUT THE "PART(S) ARE NOT AVAILABLE". THEY DID NOT OFFER ME A LOANER VEHICLE OR ANY SHORT TERM REPLACEMENT PLAN. BEING THAT IT IS MY ONLY VEHICLE, I CANNOT LEAVE THE VEHICLE THERE WHILE THEY "WAIT FOR THE PARTS", AND I HAD NO CHOICE BUT TO SIGN A DISCLAIMER OF "TAKING THE CAR AT MY OWN RISK" UNTIL THE PART(S) ARRIVE. I HAVE CALLED TODAY,5/3/10, AND THE PART(S) ARE NOT IN, AND THEY SAY THE DO NOT KNOW WHEN THEY WILL BE IN. I AM CONCERNED ABOUT MY, AND MY FAMILY'S, SAFETY IN DRIVING THIS VEHICLE WHILE IT IS DEEMED "UNSAFE" BY THE MANUFACTURER. I DO NOT KNOW WHAT TO DO ABOUT THIS ISSUE AS THEY HAVE GIVEN ME NO OPTIONS BUT TO WAIT FOR THE PART TO COME IN, WHILE JEOPARDIZING MY SAFETY WITH THE CURRENT RECALL DUE TO BACK ORDER OF PARTS. IS THERE ANY AUTHORITATIVE OR GOVERNING ORGANIZATION THAT CAN HELP ME(AND OTHER RECALL CUSTOMERS) PROMPTLY RECTIFY THIS PROBLEM WITH HYUNDAI'S OBLIGATION TO RECALLS? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH IN A PARKING LOT AND HEARD A NOISE WHEN THE VEHICLE APPEARED TO ENCOUNTER A POTHOLE. SUDDENLY, THE VEHICLE BEGAN TO SKID AND STOPPED IMMEDIATELY. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT PASSENGER WHEEL WAS POSITIONE…
Read full complaint
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH IN A PARKING LOT AND HEARD A NOISE WHEN THE VEHICLE APPEARED TO ENCOUNTER A POTHOLE. SUDDENLY, THE VEHICLE BEGAN TO SKID AND STOPPED IMMEDIATELY. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT PASSENGER WHEEL WAS POSITIONED AT AN ANGLE. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN REPAIRED THE CONTROL ARM ASSOCIATED WITH THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER 09V125000 (SUSPENSION: FRONT: CONTROL ARM). THE FAILURE AND CURRENT MILEAGES WERE 91,000.
Official recalls
509V125000 · Suspension:front:control Arm
Apr 16, 2009
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
Consequence & remedy
Consequence: THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
04V369000 · Fuel System, Gasoline:storage
Jul 26, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
04V178000 · Fuel System, Gasoline:storage:tank Assembly
Apr 9, 2004
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
03V496000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Dec 3, 2003
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
Consequence & remedy
Consequence: CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
03V257000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 22, 2003
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE09011 · Front Lower Control Arms Rusting
Opened Feb 18, 2009 · Closed Apr 21, 2009
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm
ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN INCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (3)
Suspension:front:control Arm
ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN INCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.
Suspension:front:control Arm:lower Arm
ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN INCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.
Suspension:front
ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN INCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.
PE08017 · Air Bag Light Illumination
Opened Mar 10, 2008 · Closed Jul 10, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.ODI IS ALSO AWARE OF COMPLAINTS REGARDING AIR BAG LIGHT ILLUMINATION DUE TO LOSS OF PROPER AIR BAG ELECTRICAL INTEGRITY IN WIRING AND CONNECTIONS LOCATED UNDER THE FRONT SEATS.UNDER INVESTIGATION PE08-017, HYUNDAI PROVIDED 472 OWNER REPORTS AND 9,108 WARRANTY CLAIMS RELATED TO THESE ISSUES FOR MY 2001 AND 2002 VEHICLES BUILT THROUGH 12/14/2001.ODI IS ALSO AWARE OF SIX INCIDENTS OF SEAT BELT PRETENSIONER/AIR BAG INADVERTENT DEPLOYMENTS DUE TO LIQUID SPILLS.TO ADDRESS THE ABOVE ISSUES, ON 04/25/2001, HYUNDAI ADDED A CARPET COVER/SHIELD OVER THE AIR BAG CONTROL MODULE CONNECTOR AREA AND UPGRADED THE CABLE ROUTING AND ATTACHMENT POINTS TO IMPROVE THE ELECTRICAL CONNECTIONS ON VEHICLES BUILT AFTER 12/14/2008.THIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-012) FOR FURTHER INVESTIGATION OF CERTAIN MY 2001-2002 SUBJECT VEHICLES BUILT THROUGH 12/14/2002.
Additional source detail variants (3)
Air Bags:frontal
IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.ODI IS ALSO AWARE OF COMPLAINTS REGARDING AIR BAG LIGHT ILLUMINATION DUE TO LOSS OF PROPER AIR BAG ELECTRICAL INTEGRITY IN WIRING AND CONNECTIONS LOCATED UNDER THE FRONT SEATS.UNDER INVESTIGATION PE08-017, HYUNDAI PROVIDED 472 OWNER REPORTS AND 9,108 WARRANTY CLAIMS RELATED TO THESE ISSUES FOR MY 2001 AND 2002 VEHICLES BUILT THROUGH 12/14/2001.ODI IS ALSO AWARE OF SIX INCIDENTS OF SEAT BELT PRETENSIONER/AIR BAG INADVERTENT DEPLOYMENTS DUE TO LIQUID SPILLS.TO ADDRESS THE ABOVE ISSUES, ON 04/25/2001, HYUNDAI ADDED A CARPET COVER/SHIELD OVER THE AIR BAG CONTROL MODULE CONNECTOR AREA AND UPGRADED THE CABLE ROUTING AND ATTACHMENT POINTS TO IMPROVE THE ELECTRICAL CONNECTIONS ON VEHICLES BUILT AFTER 12/14/2008.THIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-012) FOR FURTHER INVESTIGATION OF CERTAIN MY 2001-2002 SUBJECT VEHICLES BUILT THROUGH 12/14/2002.
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.ODI IS ALSO AWARE OF COMPLAINTS REGARDING AIR BAG LIGHT ILLUMINATION DUE TO LOSS OF PROPER AIR BAG ELECTRICAL INTEGRITY IN WIRING AND CONNECTIONS LOCATED UNDER THE FRONT SEATS.UNDER INVESTIGATION PE08-017, HYUNDAI PROVIDED 472 OWNER REPORTS AND 9,108 WARRANTY CLAIMS RELATED TO THESE ISSUES FOR MY 2001 AND 2002 VEHICLES BUILT THROUGH 12/14/2001.ODI IS ALSO AWARE OF SIX INCIDENTS OF SEAT BELT PRETENSIONER/AIR BAG INADVERTENT DEPLOYMENTS DUE TO LIQUID SPILLS.TO ADDRESS THE ABOVE ISSUES, ON 04/25/2001, HYUNDAI ADDED A CARPET COVER/SHIELD OVER THE AIR BAG CONTROL MODULE CONNECTOR AREA AND UPGRADED THE CABLE ROUTING AND ATTACHMENT POINTS TO IMPROVE THE ELECTRICAL CONNECTIONS ON VEHICLES BUILT AFTER 12/14/2008.THIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-012) FOR FURTHER INVESTIGATION OF CERTAIN MY 2001-2002 SUBJECT VEHICLES BUILT THROUGH 12/14/2002.
Air Bags
IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.ODI IS ALSO AWARE OF COMPLAINTS REGARDING AIR BAG LIGHT ILLUMINATION DUE TO LOSS OF PROPER AIR BAG ELECTRICAL INTEGRITY IN WIRING AND CONNECTIONS LOCATED UNDER THE FRONT SEATS.UNDER INVESTIGATION PE08-017, HYUNDAI PROVIDED 472 OWNER REPORTS AND 9,108 WARRANTY CLAIMS RELATED TO THESE ISSUES FOR MY 2001 AND 2002 VEHICLES BUILT THROUGH 12/14/2001.ODI IS ALSO AWARE OF SIX INCIDENTS OF SEAT BELT PRETENSIONER/AIR BAG INADVERTENT DEPLOYMENTS DUE TO LIQUID SPILLS.TO ADDRESS THE ABOVE ISSUES, ON 04/25/2001, HYUNDAI ADDED A CARPET COVER/SHIELD OVER THE AIR BAG CONTROL MODULE CONNECTOR AREA AND UPGRADED THE CABLE ROUTING AND ATTACHMENT POINTS TO IMPROVE THE ELECTRICAL CONNECTIONS ON VEHICLES BUILT AFTER 12/14/2008.THIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-012) FOR FURTHER INVESTIGATION OF CERTAIN MY 2001-2002 SUBJECT VEHICLES BUILT THROUGH 12/14/2002.