IllustrationCOMPLAINT REGARDING THE TETHER LOCKS ATTACHED TO THE BACK SEAT OF THE CAR THAT HOLDS THE CAR SEAT.*MR WHILE TAKING A TURN, CONSUMER'S SON FELL OFF FROM CAR SEAT. UPON INSPECTION OF CONSUMER, IT WAS FOUND THAT TETHER LOCK WHICH HOLD CAR SEAT HAD BROKEN. *LA
2002 Hyundai Elantra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Hyundai Elantra do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Elantra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
410–25K
3825–50K
5050–75K
3975–100K
58100–150K
17150K+
243 reports with mileage · 99 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
58 crash reports4 fire reports30 injury reports
Child Seat complaints
1 reportsOfficial recalls
609V125000 · Suspension:front:control Arm
Apr 16, 2009
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
Consequence & remedy
Consequence: THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
08V533000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Oct 14, 2008
HYUNDAI IS RECALLING CERTAIN MY 2001-2002 ELANTRA VEHICLES. MOVEMENT OF THE SIDE IMPACT AIR BAG WIRING HARNESS MOUNTED UNDER EACH FRONT SEAT, POSSIBLY CAUSED BY CONTACT FROM MATERIALS PLACED UNDER THE SEAT, MAY RESULT IN AN ELECTRICAL RESISTANCE THAT WOULD CAUSE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) WARNING LIGHT ILLUMINATION.
Consequence & remedy
Consequence: THIS CONDITION ONLY RELATES TO THE DRIVER AND PASSENGER SEAT MOUNTED SIDE IMPACT AIR BAGS AND MAY PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS AIR BAGS MAY INCREASE THE RISK OF INJURY TO THE DRIVER AND FRONT PASSENGER UNDER CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL INSTALL NEW SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR CLIPS AND REVISED SIDE IMPACT AIR BAG WIRING HARNESS ATTACHMENTS UNDER THE DRIVER'S AND FRONT PASSENGER'S SEATS. THE RECALL IS EXPECTED TO BEGIN DURING THE FOURTH QUARTER OF 2008, AND WILL BE SENT OUT IN SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
04V369000 · Fuel System, Gasoline:storage
Jul 26, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
04V178000 · Fuel System, Gasoline:storage:tank Assembly
Apr 9, 2004
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
03V496000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Dec 3, 2003
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
Consequence & remedy
Consequence: CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
03V257000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 22, 2003
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE09011 · Front Lower Control Arms Rusting
Opened Feb 18, 2009 · Closed Apr 21, 2009
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm
ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN INCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (3)
Suspension:front:control Arm
ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN INCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.
Suspension:front:control Arm:lower Arm
ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN INCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.
Suspension:front
ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN INCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.
EA08012 · Air Bag Light Illumination
Opened Jul 10, 2008 · Closed Nov 14, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION APPLIES TO 78,369 MY 2001 VEHICLES (BUILT THROUGH 4/26/2001).THE AIR BAG CONTROL MODULE CONNECTOR IN MY 2001 VEHICLES BUILT AFTER 4/26/2001 IS COVERED BY THE CARPET.TO IMPROVE THE INTEGRITY OF THE SIDE IMPACT AIR BAG WIRING HARNESS UNDER THE DRIVER AND FRONT PASSENGER SEATS, HYUNDAI WILL INSTALL NEW CLIPS AND REVISE THE WIRING HARNESS ATTACHMENTS UNDER SAFETY RECALL 08V-533.THIS APPLIES TO 150,541 MY 2001 THROUGH MY 2002 VEHICLES (BUILT THROUGH 12/18/2001).HYUNDAI UPGRADED THE WIRING HARNESS ROUTING/CONNECTOR CLIP ON MY 2002 VEHICLES BUILT AFTER 12/18/2001.HYUNDAI DESIGNED THE SUBJECT VEHICLES (UNDER SAFETY RECALL 08V-532) SUCH THAT THE AIR BAG CONTROL MODULE CONNECTOR IS LOCATED DIRECTLY BELOW THE CENTER CONSOLE CUP HOLDERS.SPILLAGE OF LIQUID FROM CUPS PLACED IN THE CUP HOLDERS MAY CONTAMINATE THE CONTROL MODULE AND THE CONNECTOR AND PREVENT PROPER DEPLOYMENT OF THE AIR BAGS.IN ADDITION, IN THE SUBJECT VEHICLES UNDER SAFETY RECALL 08V-533, HYUNDAI LOCATED A WIRING HARNESS FOR THE SIDE IMPACT AIR BAGS UNDER EACH FRONT SEAT.MOVEMENT OF THE SEAT OR PLACEMENT OF OBJECTS UNDER THE SEAT MAY DISTURB THE ELECTRICAL CONNECTION IN THE SIDE IMPACT AIR BAG WIRING CIRCUIT.FOR EACH OF THE ABOVE DESCRIBED CONDITIONS, THE AIR BAG WARNING LIGHT WILL ILLUMINATE WHEN THE VEHICLE DIAGNOSTIC SYSTEM DETECTS A FAULT.THIS INVESTIGATION IDENTIFIED SEVERAL CRASH REPORTS (TWO FATAL AND 17 CRASH REPORTS RESULTING IN NINE INJURY REPORTS) THAT INCLUDED ALLEGATIONS OF PRIOR AIR BAG WARNING LIGHT ILLUMINATION AND NON-DEPLOYMENT OF THE AIR BAGS, WHICH ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALLS 08V-532 & 08V533).
Additional source detail variants (6)
Air Bags:frontal
HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION APPLIES TO 78,369 MY 2001 VEHICLES (BUILT THROUGH 4/26/2001).THE AIR BAG CONTROL MODULE CONNECTOR IN MY 2001 VEHICLES BUILT AFTER 4/26/2001 IS COVERED BY THE CARPET.TO IMPROVE THE INTEGRITY OF THE SIDE IMPACT AIR BAG WIRING HARNESS UNDER THE DRIVER AND FRONT PASSENGER SEATS, HYUNDAI WILL INSTALL NEW CLIPS AND REVISE THE WIRING HARNESS ATTACHMENTS UNDER SAFETY RECALL 08V-533.THIS APPLIES TO 150,541 MY 2001 THROUGH MY 2002 VEHICLES (BUILT THROUGH 12/18/2001).HYUNDAI UPGRADED THE WIRING HARNESS ROUTING/CONNECTOR CLIP ON MY 2002 VEHICLES BUILT AFTER 12/18/2001.HYUNDAI DESIGNED THE SUBJECT VEHICLES (UNDER SAFETY RECALL 08V-532) SUCH THAT THE AIR BAG CONTROL MODULE CONNECTOR IS LOCATED DIRECTLY BELOW THE CENTER CONSOLE CUP HOLDERS.SPILLAGE OF LIQUID FROM CUPS PLACED IN THE CUP HOLDERS MAY CONTAMINATE THE CONTROL MODULE AND THE CONNECTOR AND PREVENT PROPER DEPLOYMENT OF THE AIR BAGS.IN ADDITION, IN THE SUBJECT VEHICLES UNDER SAFETY RECALL 08V-533, HYUNDAI LOCATED A WIRING HARNESS FOR THE SIDE IMPACT AIR BAGS UNDER EACH FRONT SEAT.MOVEMENT OF THE SEAT OR PLACEMENT OF OBJECTS UNDER THE SEAT MAY DISTURB THE ELECTRICAL CONNECTION IN THE SIDE IMPACT AIR BAG WIRING CIRCUIT.FOR EACH OF THE ABOVE DESCRIBED CONDITIONS, THE AIR BAG WARNING LIGHT WILL ILLUMINATE WHEN THE VEHICLE DIAGNOSTIC SYSTEM DETECTS A FAULT.THIS INVESTIGATION IDENTIFIED SEVERAL CRASH REPORTS (TWO FATAL AND 17 CRASH REPORTS RESULTING IN NINE INJURY REPORTS) THAT INCLUDED ALLEGATIONS OF PRIOR AIR BAG WARNING LIGHT ILLUMINATION AND NON-DEPLOYMENT OF THE AIR BAGS, WHICH ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALLS 08V-532 & 08V533).
Air Bags:frontal
HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION APPLIES TO 78,369 MY 2001 VEHICLES (BUILT THROUGH 4/26/2001).THE AIR BAG CONTROL MODULE CONNECTOR IN MY 2001 VEHICLES BUILT AFTER 4/26/2001 IS COVERED BY THE CARPET.TO IMPROVE THE INTEGRITY OF THE SIDE IMPACT AIR BAG WIRING HARNESS UNDER THE DRIVER AND FRONT PASSENGER SEATS, HYUNDAI WILL INSTALL NEW CLIPS AND REVISE THE WIRING HARNESS ATTACHMENTS UNDER SAFETY RECALL 08V-533.THIS APPLIES TO 150,541 MY 2001 THROUGH MY 2002 VEHICLES (BUILT THROUGH 12/18/2001).HYUNDAI UPGRADED THE WIRING HARNESS ROUTING/CONNECTOR CLIP ON MY 2002 VEHICLES BUILT AFTER 12/18/2001.HYUNDAI DESIGNED THE SUBJECT VEHICLES (UNDER SAFETY RECALL 08V-532) SUCH THAT THE AIR BAG CONTROL MODULE CONNECTOR IS LOCATED DIRECTLY BELOW THE CENTER CONSOLE CUP HOLDERS.SPILLAGE OF LIQUID FROM CUPS PLACED IN THE CUP HOLDERS MAY CONTAMINATE THE CONTROL MODULE AND THE CONNECTOR AND PREVENT PROPER DEPLOYMENT OF THE AIR BAGS.IN ADDITION, IN THE SUBJECT VEHICLES UNDER SAFETY RECALL 08V-533, HYUNDAI LOCATED A WIRING HARNESS FOR THE SIDE IMPACT AIR BAGS UNDER EACH FRONT SEAT.MOVEMENT OF THE SEAT OR PLACEMENT OF OBJECTS UNDER THE SEAT MAY DISTURB THE ELECTRICAL CONNECTION IN THE SIDE IMPACT AIR BAG WIRING CIRCUIT.FOR EACH OF THE ABOVE DESCRIBED CONDITIONS, THE AIR BAG WARNING LIGHT WILL ILLUMINATE WHEN THE VEHICLE DIAGNOSTIC SYSTEM DETECTS A FAULT.THIS INVESTIGATION IDENTIFIED SEVERAL CRASH REPORTS (TWO FATAL AND 17 CRASH REPORTS RESULTING IN NINE INJURY REPORTS) THAT INCLUDED ALLEGATIONS OF PRIOR AIR BAG WARNING LIGHT ILLUMINATION AND NON-DEPLOYMENT OF THE AIR BAGS, WHICH ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALLS 08V-532 & 08V533).
Air Bags:frontal:sensor/control MODULE-INACTIVE
HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION APPLIES TO 78,369 MY 2001 VEHICLES (BUILT THROUGH 4/26/2001).THE AIR BAG CONTROL MODULE CONNECTOR IN MY 2001 VEHICLES BUILT AFTER 4/26/2001 IS COVERED BY THE CARPET.TO IMPROVE THE INTEGRITY OF THE SIDE IMPACT AIR BAG WIRING HARNESS UNDER THE DRIVER AND FRONT PASSENGER SEATS, HYUNDAI WILL INSTALL NEW CLIPS AND REVISE THE WIRING HARNESS ATTACHMENTS UNDER SAFETY RECALL 08V-533.THIS APPLIES TO 150,541 MY 2001 THROUGH MY 2002 VEHICLES (BUILT THROUGH 12/18/2001).HYUNDAI UPGRADED THE WIRING HARNESS ROUTING/CONNECTOR CLIP ON MY 2002 VEHICLES BUILT AFTER 12/18/2001.HYUNDAI DESIGNED THE SUBJECT VEHICLES (UNDER SAFETY RECALL 08V-532) SUCH THAT THE AIR BAG CONTROL MODULE CONNECTOR IS LOCATED DIRECTLY BELOW THE CENTER CONSOLE CUP HOLDERS.SPILLAGE OF LIQUID FROM CUPS PLACED IN THE CUP HOLDERS MAY CONTAMINATE THE CONTROL MODULE AND THE CONNECTOR AND PREVENT PROPER DEPLOYMENT OF THE AIR BAGS.IN ADDITION, IN THE SUBJECT VEHICLES UNDER SAFETY RECALL 08V-533, HYUNDAI LOCATED A WIRING HARNESS FOR THE SIDE IMPACT AIR BAGS UNDER EACH FRONT SEAT.MOVEMENT OF THE SEAT OR PLACEMENT OF OBJECTS UNDER THE SEAT MAY DISTURB THE ELECTRICAL CONNECTION IN THE SIDE IMPACT AIR BAG WIRING CIRCUIT.FOR EACH OF THE ABOVE DESCRIBED CONDITIONS, THE AIR BAG WARNING LIGHT WILL ILLUMINATE WHEN THE VEHICLE DIAGNOSTIC SYSTEM DETECTS A FAULT.THIS INVESTIGATION IDENTIFIED SEVERAL CRASH REPORTS (TWO FATAL AND 17 CRASH REPORTS RESULTING IN NINE INJURY REPORTS) THAT INCLUDED ALLEGATIONS OF PRIOR AIR BAG WARNING LIGHT ILLUMINATION AND NON-DEPLOYMENT OF THE AIR BAGS, WHICH ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALLS 08V-532 & 08V533).
Air Bags:frontal:sensor/control MODULE-INACTIVE
HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION APPLIES TO 78,369 MY 2001 VEHICLES (BUILT THROUGH 4/26/2001).THE AIR BAG CONTROL MODULE CONNECTOR IN MY 2001 VEHICLES BUILT AFTER 4/26/2001 IS COVERED BY THE CARPET.TO IMPROVE THE INTEGRITY OF THE SIDE IMPACT AIR BAG WIRING HARNESS UNDER THE DRIVER AND FRONT PASSENGER SEATS, HYUNDAI WILL INSTALL NEW CLIPS AND REVISE THE WIRING HARNESS ATTACHMENTS UNDER SAFETY RECALL 08V-533.THIS APPLIES TO 150,541 MY 2001 THROUGH MY 2002 VEHICLES (BUILT THROUGH 12/18/2001).HYUNDAI UPGRADED THE WIRING HARNESS ROUTING/CONNECTOR CLIP ON MY 2002 VEHICLES BUILT AFTER 12/18/2001.HYUNDAI DESIGNED THE SUBJECT VEHICLES (UNDER SAFETY RECALL 08V-532) SUCH THAT THE AIR BAG CONTROL MODULE CONNECTOR IS LOCATED DIRECTLY BELOW THE CENTER CONSOLE CUP HOLDERS.SPILLAGE OF LIQUID FROM CUPS PLACED IN THE CUP HOLDERS MAY CONTAMINATE THE CONTROL MODULE AND THE CONNECTOR AND PREVENT PROPER DEPLOYMENT OF THE AIR BAGS.IN ADDITION, IN THE SUBJECT VEHICLES UNDER SAFETY RECALL 08V-533, HYUNDAI LOCATED A WIRING HARNESS FOR THE SIDE IMPACT AIR BAGS UNDER EACH FRONT SEAT.MOVEMENT OF THE SEAT OR PLACEMENT OF OBJECTS UNDER THE SEAT MAY DISTURB THE ELECTRICAL CONNECTION IN THE SIDE IMPACT AIR BAG WIRING CIRCUIT.FOR EACH OF THE ABOVE DESCRIBED CONDITIONS, THE AIR BAG WARNING LIGHT WILL ILLUMINATE WHEN THE VEHICLE DIAGNOSTIC SYSTEM DETECTS A FAULT.THIS INVESTIGATION IDENTIFIED SEVERAL CRASH REPORTS (TWO FATAL AND 17 CRASH REPORTS RESULTING IN NINE INJURY REPORTS) THAT INCLUDED ALLEGATIONS OF PRIOR AIR BAG WARNING LIGHT ILLUMINATION AND NON-DEPLOYMENT OF THE AIR BAGS, WHICH ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALLS 08V-532 & 08V533).
Air Bags
HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION APPLIES TO 78,369 MY 2001 VEHICLES (BUILT THROUGH 4/26/2001).THE AIR BAG CONTROL MODULE CONNECTOR IN MY 2001 VEHICLES BUILT AFTER 4/26/2001 IS COVERED BY THE CARPET.TO IMPROVE THE INTEGRITY OF THE SIDE IMPACT AIR BAG WIRING HARNESS UNDER THE DRIVER AND FRONT PASSENGER SEATS, HYUNDAI WILL INSTALL NEW CLIPS AND REVISE THE WIRING HARNESS ATTACHMENTS UNDER SAFETY RECALL 08V-533.THIS APPLIES TO 150,541 MY 2001 THROUGH MY 2002 VEHICLES (BUILT THROUGH 12/18/2001).HYUNDAI UPGRADED THE WIRING HARNESS ROUTING/CONNECTOR CLIP ON MY 2002 VEHICLES BUILT AFTER 12/18/2001.HYUNDAI DESIGNED THE SUBJECT VEHICLES (UNDER SAFETY RECALL 08V-532) SUCH THAT THE AIR BAG CONTROL MODULE CONNECTOR IS LOCATED DIRECTLY BELOW THE CENTER CONSOLE CUP HOLDERS.SPILLAGE OF LIQUID FROM CUPS PLACED IN THE CUP HOLDERS MAY CONTAMINATE THE CONTROL MODULE AND THE CONNECTOR AND PREVENT PROPER DEPLOYMENT OF THE AIR BAGS.IN ADDITION, IN THE SUBJECT VEHICLES UNDER SAFETY RECALL 08V-533, HYUNDAI LOCATED A WIRING HARNESS FOR THE SIDE IMPACT AIR BAGS UNDER EACH FRONT SEAT.MOVEMENT OF THE SEAT OR PLACEMENT OF OBJECTS UNDER THE SEAT MAY DISTURB THE ELECTRICAL CONNECTION IN THE SIDE IMPACT AIR BAG WIRING CIRCUIT.FOR EACH OF THE ABOVE DESCRIBED CONDITIONS, THE AIR BAG WARNING LIGHT WILL ILLUMINATE WHEN THE VEHICLE DIAGNOSTIC SYSTEM DETECTS A FAULT.THIS INVESTIGATION IDENTIFIED SEVERAL CRASH REPORTS (TWO FATAL AND 17 CRASH REPORTS RESULTING IN NINE INJURY REPORTS) THAT INCLUDED ALLEGATIONS OF PRIOR AIR BAG WARNING LIGHT ILLUMINATION AND NON-DEPLOYMENT OF THE AIR BAGS, WHICH ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALLS 08V-532 & 08V533).
Air Bags
HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION APPLIES TO 78,369 MY 2001 VEHICLES (BUILT THROUGH 4/26/2001).THE AIR BAG CONTROL MODULE CONNECTOR IN MY 2001 VEHICLES BUILT AFTER 4/26/2001 IS COVERED BY THE CARPET.TO IMPROVE THE INTEGRITY OF THE SIDE IMPACT AIR BAG WIRING HARNESS UNDER THE DRIVER AND FRONT PASSENGER SEATS, HYUNDAI WILL INSTALL NEW CLIPS AND REVISE THE WIRING HARNESS ATTACHMENTS UNDER SAFETY RECALL 08V-533.THIS APPLIES TO 150,541 MY 2001 THROUGH MY 2002 VEHICLES (BUILT THROUGH 12/18/2001).HYUNDAI UPGRADED THE WIRING HARNESS ROUTING/CONNECTOR CLIP ON MY 2002 VEHICLES BUILT AFTER 12/18/2001.HYUNDAI DESIGNED THE SUBJECT VEHICLES (UNDER SAFETY RECALL 08V-532) SUCH THAT THE AIR BAG CONTROL MODULE CONNECTOR IS LOCATED DIRECTLY BELOW THE CENTER CONSOLE CUP HOLDERS.SPILLAGE OF LIQUID FROM CUPS PLACED IN THE CUP HOLDERS MAY CONTAMINATE THE CONTROL MODULE AND THE CONNECTOR AND PREVENT PROPER DEPLOYMENT OF THE AIR BAGS.IN ADDITION, IN THE SUBJECT VEHICLES UNDER SAFETY RECALL 08V-533, HYUNDAI LOCATED A WIRING HARNESS FOR THE SIDE IMPACT AIR BAGS UNDER EACH FRONT SEAT.MOVEMENT OF THE SEAT OR PLACEMENT OF OBJECTS UNDER THE SEAT MAY DISTURB THE ELECTRICAL CONNECTION IN THE SIDE IMPACT AIR BAG WIRING CIRCUIT.FOR EACH OF THE ABOVE DESCRIBED CONDITIONS, THE AIR BAG WARNING LIGHT WILL ILLUMINATE WHEN THE VEHICLE DIAGNOSTIC SYSTEM DETECTS A FAULT.THIS INVESTIGATION IDENTIFIED SEVERAL CRASH REPORTS (TWO FATAL AND 17 CRASH REPORTS RESULTING IN NINE INJURY REPORTS) THAT INCLUDED ALLEGATIONS OF PRIOR AIR BAG WARNING LIGHT ILLUMINATION AND NON-DEPLOYMENT OF THE AIR BAGS, WHICH ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALLS 08V-532 & 08V533).
PE08017 · Air Bag Light Illumination
Opened Mar 10, 2008 · Closed Jul 10, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.ODI IS ALSO AWARE OF COMPLAINTS REGARDING AIR BAG LIGHT ILLUMINATION DUE TO LOSS OF PROPER AIR BAG ELECTRICAL INTEGRITY IN WIRING AND CONNECTIONS LOCATED UNDER THE FRONT SEATS.UNDER INVESTIGATION PE08-017, HYUNDAI PROVIDED 472 OWNER REPORTS AND 9,108 WARRANTY CLAIMS RELATED TO THESE ISSUES FOR MY 2001 AND 2002 VEHICLES BUILT THROUGH 12/14/2001.ODI IS ALSO AWARE OF SIX INCIDENTS OF SEAT BELT PRETENSIONER/AIR BAG INADVERTENT DEPLOYMENTS DUE TO LIQUID SPILLS.TO ADDRESS THE ABOVE ISSUES, ON 04/25/2001, HYUNDAI ADDED A CARPET COVER/SHIELD OVER THE AIR BAG CONTROL MODULE CONNECTOR AREA AND UPGRADED THE CABLE ROUTING AND ATTACHMENT POINTS TO IMPROVE THE ELECTRICAL CONNECTIONS ON VEHICLES BUILT AFTER 12/14/2008.THIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-012) FOR FURTHER INVESTIGATION OF CERTAIN MY 2001-2002 SUBJECT VEHICLES BUILT THROUGH 12/14/2002.
Additional source detail variants (3)
Air Bags:frontal
IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.ODI IS ALSO AWARE OF COMPLAINTS REGARDING AIR BAG LIGHT ILLUMINATION DUE TO LOSS OF PROPER AIR BAG ELECTRICAL INTEGRITY IN WIRING AND CONNECTIONS LOCATED UNDER THE FRONT SEATS.UNDER INVESTIGATION PE08-017, HYUNDAI PROVIDED 472 OWNER REPORTS AND 9,108 WARRANTY CLAIMS RELATED TO THESE ISSUES FOR MY 2001 AND 2002 VEHICLES BUILT THROUGH 12/14/2001.ODI IS ALSO AWARE OF SIX INCIDENTS OF SEAT BELT PRETENSIONER/AIR BAG INADVERTENT DEPLOYMENTS DUE TO LIQUID SPILLS.TO ADDRESS THE ABOVE ISSUES, ON 04/25/2001, HYUNDAI ADDED A CARPET COVER/SHIELD OVER THE AIR BAG CONTROL MODULE CONNECTOR AREA AND UPGRADED THE CABLE ROUTING AND ATTACHMENT POINTS TO IMPROVE THE ELECTRICAL CONNECTIONS ON VEHICLES BUILT AFTER 12/14/2008.THIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-012) FOR FURTHER INVESTIGATION OF CERTAIN MY 2001-2002 SUBJECT VEHICLES BUILT THROUGH 12/14/2002.
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.ODI IS ALSO AWARE OF COMPLAINTS REGARDING AIR BAG LIGHT ILLUMINATION DUE TO LOSS OF PROPER AIR BAG ELECTRICAL INTEGRITY IN WIRING AND CONNECTIONS LOCATED UNDER THE FRONT SEATS.UNDER INVESTIGATION PE08-017, HYUNDAI PROVIDED 472 OWNER REPORTS AND 9,108 WARRANTY CLAIMS RELATED TO THESE ISSUES FOR MY 2001 AND 2002 VEHICLES BUILT THROUGH 12/14/2001.ODI IS ALSO AWARE OF SIX INCIDENTS OF SEAT BELT PRETENSIONER/AIR BAG INADVERTENT DEPLOYMENTS DUE TO LIQUID SPILLS.TO ADDRESS THE ABOVE ISSUES, ON 04/25/2001, HYUNDAI ADDED A CARPET COVER/SHIELD OVER THE AIR BAG CONTROL MODULE CONNECTOR AREA AND UPGRADED THE CABLE ROUTING AND ATTACHMENT POINTS TO IMPROVE THE ELECTRICAL CONNECTIONS ON VEHICLES BUILT AFTER 12/14/2008.THIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-012) FOR FURTHER INVESTIGATION OF CERTAIN MY 2001-2002 SUBJECT VEHICLES BUILT THROUGH 12/14/2002.
Air Bags
IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.ODI IS ALSO AWARE OF COMPLAINTS REGARDING AIR BAG LIGHT ILLUMINATION DUE TO LOSS OF PROPER AIR BAG ELECTRICAL INTEGRITY IN WIRING AND CONNECTIONS LOCATED UNDER THE FRONT SEATS.UNDER INVESTIGATION PE08-017, HYUNDAI PROVIDED 472 OWNER REPORTS AND 9,108 WARRANTY CLAIMS RELATED TO THESE ISSUES FOR MY 2001 AND 2002 VEHICLES BUILT THROUGH 12/14/2001.ODI IS ALSO AWARE OF SIX INCIDENTS OF SEAT BELT PRETENSIONER/AIR BAG INADVERTENT DEPLOYMENTS DUE TO LIQUID SPILLS.TO ADDRESS THE ABOVE ISSUES, ON 04/25/2001, HYUNDAI ADDED A CARPET COVER/SHIELD OVER THE AIR BAG CONTROL MODULE CONNECTOR AREA AND UPGRADED THE CABLE ROUTING AND ATTACHMENT POINTS TO IMPROVE THE ELECTRICAL CONNECTIONS ON VEHICLES BUILT AFTER 12/14/2008.THIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-012) FOR FURTHER INVESTIGATION OF CERTAIN MY 2001-2002 SUBJECT VEHICLES BUILT THROUGH 12/14/2002.