IllustrationTL*THE CONTACT OWNS A 2009 HYOSUNG GB250 MOTORCYCLE (NA). THE CONTACT STATED THAT WHEN HE PUT ON ANY TYPE OF TINTED EYE-WEAR THE INSTRUMENT GAUGE BECAME UNREADABLE. THE MANUFACTURER WAS NOTIFIED ABOUT THE FAILURE BUT THEY WERE UNABLE TO OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70.
2007 Hyosung GV650
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all GV650 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Electrical System complaints
3 reportsUNITED MOTORS MOTORCYCLE MODEL V2C650S. CONSUMER REQUESTS REIMBURSEMENT DUE TO DEFECTS *TGW THE CONSUMER STATED THE MOTORCYCLE HAS BEEN PARKED DUE TO A DEFECTIVE GAS TANK THAT LEAKED AT THE SEAMS AND DEFECTIVE WORKMANSHIP OF THE ELECTRIC STARTER WHEN THE SLIGHTEST AMOUNT OF MOISTURE CAME INTO CONTACT WITH IT. WHICH ULTIMATELY …
Read full complaint
UNITED MOTORS MOTORCYCLE MODEL V2C650S. CONSUMER REQUESTS REIMBURSEMENT DUE TO DEFECTS *TGW THE CONSUMER STATED THE MOTORCYCLE HAS BEEN PARKED DUE TO A DEFECTIVE GAS TANK THAT LEAKED AT THE SEAMS AND DEFECTIVE WORKMANSHIP OF THE ELECTRIC STARTER WHEN THE SLIGHTEST AMOUNT OF MOISTURE CAME INTO CONTACT WITH IT. WHICH ULTIMATELY CAUSED THE STARTER TO STOP WORKING. *JB
IN SEPTEMBER 2008 MY HYOSUNG GV250; PURCHASED IN NOVEMBER 2007, EXPERIENCED A FAILURE OF THE STARTER SYSTEM AND WOULD NOT START. AFTER ABOUT 5 WEEKS AT A HYOSUNG DEALER (SF MOTO IN SAN FRANCISCO, CA) THE STARTER MOTOR AND STARTER SOLENOID WAS REPLACED, AND THE MOTORCYCLE WAS PICKED UP. WITHIN TWO WEEKS THE MOTORCYCLE STARTING…
Read full complaint
IN SEPTEMBER 2008 MY HYOSUNG GV250; PURCHASED IN NOVEMBER 2007, EXPERIENCED A FAILURE OF THE STARTER SYSTEM AND WOULD NOT START. AFTER ABOUT 5 WEEKS AT A HYOSUNG DEALER (SF MOTO IN SAN FRANCISCO, CA) THE STARTER MOTOR AND STARTER SOLENOID WAS REPLACED, AND THE MOTORCYCLE WAS PICKED UP. WITHIN TWO WEEKS THE MOTORCYCLE STARTING SYSTEM FAILED AGAIN, AND THE MOTORCYCLE WAS RETURNED TO THE DEALER A SECOND TIME FOR REPAIR (MID NOVEMBER 2008). ON DECEMBER 3, 2008, I CONTACTED THE DEALER AND WAS INFORMED THAT THEY WERE JUST STARTING TO WORK ON THE MOTORCYCLE AND THAT HYOSUNG AMERICA HAD INFORMED THEM THAT THEY HAVE HEARD OF THIS PROBLEM. AS THE DEALER DESCRIBES THE PROBLEM "THE FUEL PETCOCK WAS LEFT ON; WHEN NOT RUNNING, AND FUEL HAS GOTTEN INTO THE STARTER CAUSING IT TO FAIL". THIS EXPLANATION MAKES NO SENSE TO ME, SINCE THE START IS NO WHERE NEAR THE FUEL PETCOCK OR EVEN THE CARBURETORS. IF THIS IS THE CASE THEN IT IS A POTENTIAL SAFETY ISSUE; AS SPARKS CAN BE GENERATED BY THE STARTER SHOULD IT TURN AND COULD IGNITE ANY FUEL VAPOR IN OR NEAR THE INTERNAL WORKING OF THE STARTER. I REQUEST THIS BE INVESTIGATED AS A SAFETY ISSUE, AND IF NECESSARY HYOSUNG AMERICA BE REQUIRED TO CORRECT THE ISSUE OR RECALL THE PRODUCT FOR RECTIFICATION. DAVID MCNARY *TR
Official recalls
108V071000 · Fuel System, Gasoline
Feb 14, 2008
HYOSUNG IS RECALLING 3,292 MY 2005-2007 GT650 AND GV650 MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH FUEL TANK CAP GASKETS THAT PREVENT PROPER TANK VENTILATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN VEHICLE STALLING WHICH COULD RESULT IN A CRASH AND/OR FUEL LEAKAGE WHICH COULD RESULT IN A FIRE.
Remedy: DEALERS WILL MODIFY THE EXISTING GAS CAP GASKET. THE RECALL BEGAN ON APRIL 1, 2008. OWNERS MAY CONTACT HYOSUNG AT 1-770-447-5571.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ10001 · Handlebar Separation
Opened Jan 25, 2010 · Closed May 10, 2010
Status: closed (inferred from source dates) · Steering: Steering Wheel/handle Bar
In February 2007, Hyosung launched recall 07V-015 addressing fractures of handlebar fasteners on MY 2006 GV650 model motorcycles.In some instances, the handlebar could then separate from the front fork.ODI received a Vehicle Owner Questionnaire (VOQ) alleging a MY 2007 Hyosung GV650 had the same issue, i.e., fractured handlebar retaining bolts.To explore the adequacy of Hyosung?s recall scope, we opened this Recall Query (RQ).Since opening, we interviewed Hyosung dealer service personnel, continued monitoring related web-forums and media, and reviewed Hyosung's response to our information request.Currently, we are only aware of the incident prompting this RQ and, consequently find no defect trend exists justifying expanding the scope of 07V-015 to include the 2007 model year GV650's.Therefore, this Preliminary Evaluation is closed. We will continue to monitor these motorcycles for any changes in the complaint trends.
PE07056 · Fuel Leak / Stalling
Opened Nov 14, 2007 · Closed Feb 20, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
ODI RECEIVED A VEHICLE OWNER QUESTIONNAIRE (VOQ) ALLEGING A HYOSUNG GV650 LEAKED FUEL FROM A FUEL TANK SEAM.AFTER A HYOSUNG DEALER REPLACED THE TANK, FUEL AGAIN LEAKED FROM THE MOTORCYCLE AND IT BEGAN TO STALL.SUBSEQUENTLY, HYOSUNG ADVISED THE CUSTOMER THAT THE PROBLEM COULD HAVE BEEN AVOIDED IF THE DEALER HAD FOLLOWED THE INSTRUCTIONS IN ITS APRIL 2007 TSB.THAT TSB ACKNOWLEDGED THE SUBJECT VEHICLES FUEL TANK WAS NOT VENTING PROPERLY DUE TO AN IMPROPERLY FABRICATED GAS CAP GASKET.WITHOUT PROPER VENTING, THE BIKES WOULD STALL OR THE FUEL TANK WOULD COLLAPSE AND LEAK OR BOTH.ON FEBRUARY 12, 2008, AFTER DISCUSSING THE ISSUE WITH ODI STAFF, HYOSUNG AGREED TO CONDUCT A SAFETY RECALL TO MODIFY THE GAS CAP GASKET.WITH THAT RECALL, THIS PE IS CLOSED.