Sudden loss of throttle control. Fist incident I had left my house and ridden a 1/2 mile and the throttle suddenly became unresponsive. The motorcycle then after restart would only go aprx 10-15mph with throttle applied. I replaced the battery as it was 3yrs of age. Motorcycle then operated normally for the next trip aprx 5 mile…
Read full complaint
Sudden loss of throttle control. Fist incident I had left my house and ridden a 1/2 mile and the throttle suddenly became unresponsive. The motorcycle then after restart would only go aprx 10-15mph with throttle applied. I replaced the battery as it was 3yrs of age. Motorcycle then operated normally for the next trip aprx 5 miles. The following day as I went to turn left and enter a roadway in a gap in traffic the motorcycle lurched forward a few feet and then had no throttle response. This put me into the oncoming traffic lane with no propulsion and caught the other vehicles by surprise. I was almost struck by the oncoming car. In both incidence the throttle which is a fly by wire electronic throttle become completely unresponsive. The LCD dash display says "TC Failure" and the check engine, TC, and ADS lights are all illuminated. When the motorcycle is turned off and back on the problem either goes away for a minute or two or is still active. There are multiple accounts of "Husqvarna Vitpilen TC Failure with loss of throttle" accounts on forums. The Husqvarna Vitpilen 701 is essentially the same motorcycle mechanically as the KTM 690 Duke. On the forums there are reports of this happening on the Vitpilen 401 and Duke 390 as well. As a motorcyclist with 47 years of ridding experience I have owned 34 motorcycles. This is a serious safety issue know to KTM/ Husqvarna that is going to kill someone. If there was every anything that should be a recall this is it. Feel free to call me [XXX] [XXX] My 2020 Vitpilen 701 is in immaculate condition and has been serviced to specs. It has 2650 miles on it and is 3 yrs old. The warranty for the motorcycle is 2 yrs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
KTM North America, Inc. (KTM) is recalling certain 2018-2020 690 Enduro R, Vitpilen 701, 701 Enduro, 701 Supermoto, 2019-2020 690 SMC R, Svartpilen, 2018-2019 690 Duke, and 2020 701 Enduro LR motorcycles. The bellow-style gasket on the clutch slave cylinder may have been damaged during manufacturing, which could cause the clutch to become inoperable and not disengage when the clutch lever is pulled in.
Consequence & remedy
Consequence: An inoperable clutch increases the risk of a crash.
Remedy: Dealers will inspect the clutch slave cylinder and replace it if necessary, free of charge. Owner notification letters are expected to be mailed December 3, 2021. Owners may contact KTM customer service at 1-888-985-6090. KTM's numbers for this recall are KTB2112 and HTB2110.
KTM North America, Inc. (KTM) is recalling certain 2018-2020 Husqvarna Motorcycle 701 Vitpilen and 2019-2020 701 Svartpilen motorcycles. The gear teeth on the license plate holder and swingarm may be positioned incorrectly, possibly resulting in a loose rear axle nut, causing the license plate holder to contact the rear wheel.
Consequence & remedy
Consequence: License plate bracket interference with the rear wheel can increase the risk of a crash or injury.
Remedy: Dealers will inspect and realign the gear teeth on the license plate holder and swingarm, and inspect the tightness of the rear wheel axle collar, free of charge. Owner notification letters were mailed on October 1, 2021. Owners may contact KTM customer service at 1-888-985-6090. KTM's number for this recall is HTB2106.
KTM North America, Inc. (KTM) is recalling certain 2018-2020 Husqvarna Motorcycle 701 Vitpilen and 2019-2020 701 Svartpilen motorcycles. The gear teeth on the license plate holder and swingarm may be positioned incorrectly, possibly resulting in a loose rear axle nut, causing the license plate holder to contact the rear wheel.
Consequence: License plate bracket interference with the rear wheel can increase the risk of a crash or injury.
Remedy: Dealers will inspect and realign the gear teeth on the license plate holder and swingarm, and inspect the tightness of the rear wheel axle collar, free of charge. Owner notification letters were mailed on October 1, 2021. Owners may contact KTM customer service at 1-888-985-6090. KTM's number for this recall is HTB2106.
Suspension:rear:motorcycle Fork/swingarm
KTM North America, Inc. (KTM) is recalling certain 2018-2020 Husqvarna Motorcycle 701 Vitpilen and 2019-2020 701 Svartpilen motorcycles. The gear teeth on the license plate holder and swingarm may be positioned incorrectly, possibly resulting in a loose rear axle nut, causing the license plate holder to contact the rear wheel.
Consequence: License plate bracket interference with the rear wheel can increase the risk of a crash or injury.
Remedy: Dealers will inspect and realign the gear teeth on the license plate holder and swingarm, and inspect the tightness of the rear wheel axle collar, free of charge. Owner notification letters were mailed on October 1, 2021. Owners may contact KTM customer service at 1-888-985-6090. KTM's number for this recall is HTB2106.
KTM North America, Inc. (KTM) is recalling certain 2019-2020 Husqvarna 701 Svartpilen and 2018-2020 Husqvarna 701 Vitpilen motorcycles. Fuel may leak from the fuel level sensor and fuel pump mounting area.
Consequence & remedy
Consequence: A fuel leak can increase the risk of a fire in the presence of an ignition source, and increase the risk of damage or injury.
Remedy: KTM will notify owners, and Husqvarna Motorcycle Dealers will replace the affected fuel tank, install new gaskets, and update software for proper fuel calibration, free of charge. Owners will be notified to take their motorcycles to a Husqvarna Motorcycle North America, Inc. (HMNA) dealership for repairs. The recall began July 7, 2020. Owners may contact HMNA customer service at 1-888-985-6090. HMNA's number for this recall is HTB2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2020 Husqvarna Vitpilen 701 Problems, Complaints & Recalls | Skip That Year