NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
11 reportsClear category filterMileage unknown · Jul 10, 2025
Electrical SystemEnginePower Train
Truck was waiting at a stop light in drive mode and foot on brake pedal. When the light changed to green. I tried to accelerate to go and the whole vehicle shook/lunges forward and shut off. Vehicle went into neutral and wouldn't allow me to go into drive mode. I had to restart the vehicle twice before it allowed me to go into d…
Read full complaint
Truck was waiting at a stop light in drive mode and foot on brake pedal. When the light changed to green. I tried to accelerate to go and the whole vehicle shook/lunges forward and shut off. Vehicle went into neutral and wouldn't allow me to go into drive mode. I had to restart the vehicle twice before it allowed me to go into drive again. Vehicle was stuck in the middle of the street with oncoming/ongoing traffic. I had this vehicle at the honda dealer(with documents) three times previous for this issue and its still not resolved. Please help.
NHTSA ODI #11672492
Mileage unknown · Nov 3, 2023
Power Train
1. Vehicle shift to neutral while driving. 2. Shift vehicle from park to drive, but vehicle shift to neutral and alert for transmission failure comes on. 3. While waiting at a stop light in drive and on brake, vehicle shift to neutral and alert for transmission failure comes on.
NHTSA ODI #11553507
Mileage unknown · Dec 20, 2022
EnginePower Train
When driving at 70mph for a couple of hours and exiting the freeway, the truck will go into limp mode and won’t accelerate. This only happens when it’s very cold, less than 10 degrees Fahrenheit both times it happened to me. The engine service light will start to flash. You need to park and restart in order to clear the issue. T…
Read full complaint
When driving at 70mph for a couple of hours and exiting the freeway, the truck will go into limp mode and won’t accelerate. This only happens when it’s very cold, less than 10 degrees Fahrenheit both times it happened to me. The engine service light will start to flash. You need to park and restart in order to clear the issue. The last time it happened, I needed to merge onto a busy freeway with very little room to pull over. It was quite dangerous for my family and I. I spoke with Burnsville Honda in MN when I was there for service this summer and Honda is aware, but there is currently no known fix. It sounds like it’s affecting multiple models of newer Honda vehicles with the v6 engine.
NHTSA ODI #11498322
Mileage unknown · Jun 8, 2022
EnginePower Train
I will be filing a issue with our 21 Honda Pilot too as the same problem has occurred in both vehicles with the same engine and transmission. This has happened a total of 3 different times. When I drive the Ridgeline for a long time (over 4 hours)on the expressway and then pull off on a ramp and turn left the vehicle will go i…
Read full complaint
I will be filing a issue with our 21 Honda Pilot too as the same problem has occurred in both vehicles with the same engine and transmission. This has happened a total of 3 different times. When I drive the Ridgeline for a long time (over 4 hours)on the expressway and then pull off on a ramp and turn left the vehicle will go into safe mode. The engine light will start flashing and you can not drive over 30 mph. The engine runs rough and idles hard. I have contacted Honda and the dealership I purchased it from. Honda has acknowledged this is a problem and has occurred multiples with many different vehicles. The dealership I work with has acknowledged the same thing as they have several vehicles that have been brought in with this problem. I have waited several months for Honda to come up with a solution, so far they have not. This is a safety concern because what would happen if this same situation came up when I'm pulling my trailer or on the expressway at higher speeds. This could cause an accident. This first started on my Ridgeline in November of 2021. It has happened several times since then. Every time there is no code the computer keeps, even though each time the engine light is flashing. What I have been told is the computer thinks the engine has backfired and goes into safe mode, but Honda doesn't know why it does this. If you turn the vehicle off and restart it, the problem goes away. When the dealership has run a diagnosis off the computer, there are no codes the computer throws. Even though the check engine light is flashing when this occurs.
NHTSA ODI #11468181
Mileage unknown · Mar 23, 2022
EnginePower Train
After driving for long distance (over 200 miles) in cold weather at highway speeds, and then making a slow right-hand turn, the Check Engine light came on and vehicle went into 'limp' mode. This happened twice, 2 weeks apart. Vehicle has less than 8,000 miles on it.
NHTSA ODI #11458019
Mileage unknown · Mar 4, 2022
EngineFuel/propulsion SystemPower Train
Vehicle went into "limp mode" after exiting a freeway. When attempting to merge into roadway, vehicle flashed CEL for engine. Vehicle shut down 3 cylinders giving very little power to merge into traffic. Unable to get vehicle over 30 mph on a busy road. Honda dealer said no codes were stored and haven't heard of the complaint pr…
Read full complaint
Vehicle went into "limp mode" after exiting a freeway. When attempting to merge into roadway, vehicle flashed CEL for engine. Vehicle shut down 3 cylinders giving very little power to merge into traffic. Unable to get vehicle over 30 mph on a busy road. Honda dealer said no codes were stored and haven't heard of the complaint previously. Vehicle had no issues previously. 6,000 miles on a new vehicle.
NHTSA ODI #11455186
Mileage unknown · Jan 31, 2022
EngineFuel/propulsion SystemPower Train
This is an unsafe vehicle to drive and can cause injury or DEATH. I along with many others have been having problems with the CEL flashing and engine running properly. The dealers can't find a cause because the code deletes itself and the problem temporary goes away when you shut the engine off and is NOT saved in the computer…
Read full complaint
This is an unsafe vehicle to drive and can cause injury or DEATH. I along with many others have been having problems with the CEL flashing and engine running properly. The dealers can't find a cause because the code deletes itself and the problem temporary goes away when you shut the engine off and is NOT saved in the computer. It has been a complete waste of time going to the dealer only to find no codes stored. I am not alone in this, as many others are starting to have this exact same problem during the exact same driving conditions. See the forum below: https://www.ridgelineownersclub.com/threads/2021-check-engine-light-flashing.229929/#post-3220773 Here is the first time it happened. (THIS HAS HAPPENED 3 TIMES ALREADY) (DEC 7, 2021) Hello all, I have a 2021 RTL-E. After driving on highway for an hour and a half at 80mph, I exited the highway and as soon as I pulled onto a secondary road the check engine light started flashing and the engine was hesitating with little to no power and poor shifting. I limped it to safe place to pull over (aprox 3 miles) and shut the truck off. I checked under the hood and didn't see anything and after approximately two minutes I restarted the truck and the light was gone and it drove fine after that. (It was 15°F with 10,250 miles at the time and not towing or hauling anything) I drove it the next day 4 hours on Highway without any issues. Has anybody else experienced this issue on the 2021's? There's not enough room to type the other times this problem occurred!!! This is an unsafe vehicle to drive and can cause injury or DEATH. The 2021 Honda Ridgeline is no longer the dependable vehicle that I was hoping to have when I purchased it NEW in June of 2021. I live in a rural area and do not have a dealer that is close by which is why I bought a Honda in the first place because it was Supposed to be a dependable vehicle. This needs to get resolved and I would appreciate any help on how to resolve this.
NHTSA ODI #11449572
Mileage unknown · Jan 2, 2022
EnginePower TrainUnknown Or Other
Drove the pickup 3 hours in 10 degree weather at 60-70 mph. Exited the freeway, stopped at light, went through the intersection and truck began to bog down. Engine light started flashing and truck wouldn’t go over 35 mph. Pulled off road, shut down the engine for 5 minutes, started truck up and drove like normal the 3 miles home…
Read full complaint
Drove the pickup 3 hours in 10 degree weather at 60-70 mph. Exited the freeway, stopped at light, went through the intersection and truck began to bog down. Engine light started flashing and truck wouldn’t go over 35 mph. Pulled off road, shut down the engine for 5 minutes, started truck up and drove like normal the 3 miles home. Could have been dangerous at the intersection as the truck wouldn’t accelerate as normal and I had very little power to the wheels.
NHTSA ODI #11445874
Mileage unknown · Oct 24, 2021
Power Train
On this model of vehicle, if the vehicle dies and cannot be restarted, as an example if you are on a busy highway or intersection, there is no way to get the vehicle in Neutral so it can safely be moved WITHOUT having a special tool, Honda part #07AAA-TZ3A100. This tool is currently not available to purchase from any Honda deale…
Read full complaint
On this model of vehicle, if the vehicle dies and cannot be restarted, as an example if you are on a busy highway or intersection, there is no way to get the vehicle in Neutral so it can safely be moved WITHOUT having a special tool, Honda part #07AAA-TZ3A100. This tool is currently not available to purchase from any Honda dealer. This tool has to be used with the front hood open and reaching down and turning a bolt & manually locking the transmission in Neutral. The location of this bolt outside the truck & under the hood is also a hazard for the vehicle rolling and not being able to easily disengage it from neutral by having to get back out of the truck again and get under the hood. It is also a hazard to have to get out of the vehicle, on a highway or busy intersection or other hazardous area. In prior models of this vehicle, there was a method to manually put the vehicle in neutral while seated in the drivers seat, minimizing the risk of injury by having to get out of the truck and pop the hood. This is a very hazardous design flaw that should be remedied by Honda immediately. Honda should provide remedy to all vehicle owners and provide the method for manually putting the vehicle in neutral back inside the vehicle as it was in prior models as it is a safety hazard as it is designed now with the manual release under the front hood.
NHTSA ODI #11437980
Mileage unknown · Jun 16, 2021
EnginePower Train
When vehicle is in drive, stopped on a steep hill, and allowed to slip backward the software puts the transmission in neutral and shuts of the engine off. This leaves the vehicle coasting backwards with very little steering or brakes. This happened to me and I coasted backward across a street. If a car had been coming it would …
Read full complaint
When vehicle is in drive, stopped on a steep hill, and allowed to slip backward the software puts the transmission in neutral and shuts of the engine off. This leaves the vehicle coasting backwards with very little steering or brakes. This happened to me and I coasted backward across a street. If a car had been coming it would have hit me sideways. I can reproduce this in drive forward or in reverse, and I reproduced this in a second 2021 Ridge Line truck. There is no warning or message.
NHTSA ODI #11421198
Official recalls
7Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
May 9, 2024
Honda (America Honda Motor Co) is recalling certain 2020-2024 Ridgeline vehicles. The rearview camera (RVC) tailgate wire harness may fatigue and break, which can prevent the rearview camera image from displaying.
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will replace the RVC tailgate wire harness, free of charge. Owner letters were mailed November 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's number for this recall is YI7.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Jun 29, 2023
Honda (American Honda Motor Co.) is recalling certain 2020-2021 Civic, 2020-2023 Ridgeline, 2021-2023 Passport, 2021-2022 Pilot, and 2020 Acura MDX vehicles. The tie rod fastener that connects the brake booster and the brake master cylinder may have been improperly assembled during manufacturing, which can cause the brake master cylinder to separate from the booster assembly.
Consequence & remedy
Consequence: Brake master cylinder separation can cause a loss of brake function and increase the risk of a crash.
Remedy: Dealers will inspect and repair the brake booster assembly as necessary, free of charge. Owner notification letters were mailed August 7, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are VEU, AEV, and ZET.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Nov 18, 2021
Honda (American Honda Motor Co.) is recalling certain 2021 Accord Sedan, Accord Hybrid, CR-V, Ridgeline, 2022 Insight and CR-V Hybrid vehicles. The automatic locking retractor on the second-row center seat belt assembly may deactivate improperly, which can result in an unsecured child restraint system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will replace the second-row center seat belt assembly, free of charge. Owner notification letters were mailed January 14, 2022. Owners may contact Honda customer service at 1-888-234-2138.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24004 · Rear-View Camera Failure
Opened Feb 13, 2024 · Closed Aug 5, 2024
Status: closed (inferred from source dates) · Back Over Prevention
On February 13, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24004 to assess alleged failures of the rear-view camera (RVC) in 2020-2023 Model Year (MY) Honda Ridgeline vehicles. At this time, ODI has received a total of 50 complaints with allegations of the RVC image failing to display when the vehicle was in reverse. The RVC wire harness is routed near the hinge in the tailgate, in a location where frequent opening and closing of the tailgate causes bending stress on the harness. Honda determined the wire harness was manufactured with a material which is permeable to water and salt, which when it freezes and thaws, combined with tailgate usage, ultimately leads to breakage of the wiring in the tailgate harness. This results in a failure to display the RVC image. On May 9, 2024, Honda filed a Part 573 Safety Recall Report recalling all 2020-2024 MY Honda Ridgeline vehicles. The dealer will replace the RVC tailgate harness with a wire harness that is manufactured by a new supplier and has improved material properties to withstand wear from bending. In view of Honda filing recall 24V-321 addressing the subject of this investigation, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration