NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
28 reportsClear category filterMileage unknown · Mar 10, 2022
EngineFuel/propulsion System
Upon exiting or entering the highway, the truck loses power and will not accelerate. This happens after multiple hours of highway driving and seems to only happen when the temperature is near or below freezing. The Check Engine Light (CEL) comes on and is flashing. This has happened to me four times. Three of which were exitin…
Read full complaint
Upon exiting or entering the highway, the truck loses power and will not accelerate. This happens after multiple hours of highway driving and seems to only happen when the temperature is near or below freezing. The Check Engine Light (CEL) comes on and is flashing. This has happened to me four times. Three of which were exiting one highway to merge onto another and there was ample room to slow down and pull over. One time was merging onto a highway from a Rest Stop with a great deal of traffic and I was fortunate the shoulder was available to avoid being collided with. The first time was on 11/6/2021 (2200miles), second and third was on 12/19/2021 (5600miles) and last time was 3/9/2022 (10100miles). All occurrences the gas tank had ample gas. Shutting the truck off and turning it back on clears the CEL and no error codes are stored (according to the dealer). This problem has been reported multiple times and yet there has been no response from Honda. Also, even though the error codes are not present after the vehicle is turned off and back on, I was able to capture three error codes prior to turning the vehicle off P0302, P0303, P0300.
NHTSA ODI #11456074
1,800 miles · Mar 9, 2022
Engine
The contact owns a 2021 Honda Ridgeline. The contact stated that upon either exiting or merging onto a highway at various speeds, the vehicle would independently go into Limp Mode with the check engine warning light illuminated. The contact had filed a complaint with the manufacturer through the website; however, the contact had…
Read full complaint
The contact owns a 2021 Honda Ridgeline. The contact stated that upon either exiting or merging onto a highway at various speeds, the vehicle would independently go into Limp Mode with the check engine warning light illuminated. The contact had filed a complaint with the manufacturer through the website; however, the contact had not received a response from the manufacturer. The contact had taken the vehicle to the dealer where the mechanic was informed by the manufacturer to check the engine valves however, the dealer had not been able to diagnose the failure. The vehicle had yet to be repaired. The failure mileage was approximately 1,800.
NHTSA ODI #11455884
Mileage unknown · Mar 4, 2022
EngineFuel/propulsion SystemPower Train
Vehicle went into "limp mode" after exiting a freeway. When attempting to merge into roadway, vehicle flashed CEL for engine. Vehicle shut down 3 cylinders giving very little power to merge into traffic. Unable to get vehicle over 30 mph on a busy road. Honda dealer said no codes were stored and haven't heard of the complaint pr…
Read full complaint
Vehicle went into "limp mode" after exiting a freeway. When attempting to merge into roadway, vehicle flashed CEL for engine. Vehicle shut down 3 cylinders giving very little power to merge into traffic. Unable to get vehicle over 30 mph on a busy road. Honda dealer said no codes were stored and haven't heard of the complaint previously. Vehicle had no issues previously. 6,000 miles on a new vehicle.
NHTSA ODI #11455186
Mileage unknown · Feb 14, 2022
Engine
On 1/21/22,After driving an hour at 75mph exited onto off street. While driving through traffic truck began to "sputter" and wouldn't accelerate. I then noticed flashing engine light. After driving about 5 minutes through traffic because I had no place to go, I parked and shut it off. Turned back on no light and no issue. Since …
Read full complaint
On 1/21/22,After driving an hour at 75mph exited onto off street. While driving through traffic truck began to "sputter" and wouldn't accelerate. I then noticed flashing engine light. After driving about 5 minutes through traffic because I had no place to go, I parked and shut it off. Turned back on no light and no issue. Since I needed to drive home later that night I brought to a dealership for diagnostics. Like everyone else in the Honda forum, no codes or errors. 2675 miles on the truck, about 1/2 tank of gas. Temp around 20 deg. On 2/12/22, Drove 160 miles, 70-75mph, temp 10 degrees, gas tank 3/4 full. Didn't stop that entire time. Got off on an exit and continued to drive between 30-45 mph for about 4 miles without coming to a full stop. Finally I reached a stop sign. Cross traffic did not have to stop. After stopping (engine idle was on but don't think engaged) and no oncoming traffic, I turned left. Immediately as I pressed the gas pedal, truck started to sputter and engine light started flashing. Luckily no traffic coming up from behind and I had room to pull over and stop. However, since this is the SECOND time this has happened, I had my wife video the dashboard. Yep got it all on video. This has to be FIXED. Can't imagine if that were my kids driving and traffic was barreling up on them. Imagine a semi coming up at 60mph and no power or place to move out of the way. After stopping and turning off the truck, the issue went away. Coming home the same day, there were no issues. Closet Honda dealer is an hour away so I can't drop off conveniently. 2021 Honda RTLE, 3500 miles
NHTSA ODI #11451939
Mileage unknown · Jan 31, 2022
EngineFuel/propulsion SystemPower Train
This is an unsafe vehicle to drive and can cause injury or DEATH. I along with many others have been having problems with the CEL flashing and engine running properly. The dealers can't find a cause because the code deletes itself and the problem temporary goes away when you shut the engine off and is NOT saved in the computer…
Read full complaint
This is an unsafe vehicle to drive and can cause injury or DEATH. I along with many others have been having problems with the CEL flashing and engine running properly. The dealers can't find a cause because the code deletes itself and the problem temporary goes away when you shut the engine off and is NOT saved in the computer. It has been a complete waste of time going to the dealer only to find no codes stored. I am not alone in this, as many others are starting to have this exact same problem during the exact same driving conditions. See the forum below: https://www.ridgelineownersclub.com/threads/2021-check-engine-light-flashing.229929/#post-3220773 Here is the first time it happened. (THIS HAS HAPPENED 3 TIMES ALREADY) (DEC 7, 2021) Hello all, I have a 2021 RTL-E. After driving on highway for an hour and a half at 80mph, I exited the highway and as soon as I pulled onto a secondary road the check engine light started flashing and the engine was hesitating with little to no power and poor shifting. I limped it to safe place to pull over (aprox 3 miles) and shut the truck off. I checked under the hood and didn't see anything and after approximately two minutes I restarted the truck and the light was gone and it drove fine after that. (It was 15°F with 10,250 miles at the time and not towing or hauling anything) I drove it the next day 4 hours on Highway without any issues. Has anybody else experienced this issue on the 2021's? There's not enough room to type the other times this problem occurred!!! This is an unsafe vehicle to drive and can cause injury or DEATH. The 2021 Honda Ridgeline is no longer the dependable vehicle that I was hoping to have when I purchased it NEW in June of 2021. I live in a rural area and do not have a dealer that is close by which is why I bought a Honda in the first place because it was Supposed to be a dependable vehicle. This needs to get resolved and I would appreciate any help on how to resolve this.
NHTSA ODI #11449572
Mileage unknown · Jan 2, 2022
EnginePower TrainUnknown Or Other
Drove the pickup 3 hours in 10 degree weather at 60-70 mph. Exited the freeway, stopped at light, went through the intersection and truck began to bog down. Engine light started flashing and truck wouldn’t go over 35 mph. Pulled off road, shut down the engine for 5 minutes, started truck up and drove like normal the 3 miles home…
Read full complaint
Drove the pickup 3 hours in 10 degree weather at 60-70 mph. Exited the freeway, stopped at light, went through the intersection and truck began to bog down. Engine light started flashing and truck wouldn’t go over 35 mph. Pulled off road, shut down the engine for 5 minutes, started truck up and drove like normal the 3 miles home. Could have been dangerous at the intersection as the truck wouldn’t accelerate as normal and I had very little power to the wheels.
NHTSA ODI #11445874
Mileage unknown · Jun 16, 2021
EnginePower Train
When vehicle is in drive, stopped on a steep hill, and allowed to slip backward the software puts the transmission in neutral and shuts of the engine off. This leaves the vehicle coasting backwards with very little steering or brakes. This happened to me and I coasted backward across a street. If a car had been coming it would …
Read full complaint
When vehicle is in drive, stopped on a steep hill, and allowed to slip backward the software puts the transmission in neutral and shuts of the engine off. This leaves the vehicle coasting backwards with very little steering or brakes. This happened to me and I coasted backward across a street. If a car had been coming it would have hit me sideways. I can reproduce this in drive forward or in reverse, and I reproduced this in a second 2021 Ridge Line truck. There is no warning or message.
NHTSA ODI #11421198
Mileage unknown · Jun 16, 2021
EnginePower Train
When the vehicle is in drive, stopped on a steep hill, and allowed to slip backward the software puts the transmission in neutral and shuts of the engine off. This leaves the vehicle coasting backwards with very little steering or brakes. This happened to me and I coasted backward across a street before I could get it stopped. …
Read full complaint
When the vehicle is in drive, stopped on a steep hill, and allowed to slip backward the software puts the transmission in neutral and shuts of the engine off. This leaves the vehicle coasting backwards with very little steering or brakes. This happened to me and I coasted backward across a street before I could get it stopped. If a car had been coming it would have hit me sideways. I can reproduce this in drive forward or in reverse, and I reproduced this in a second 2021 Ridge Line truck. There is no warning or message.
NHTSA ODI #11421121
Official recalls
7Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
May 9, 2024
Honda (America Honda Motor Co) is recalling certain 2020-2024 Ridgeline vehicles. The rearview camera (RVC) tailgate wire harness may fatigue and break, which can prevent the rearview camera image from displaying.
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will replace the RVC tailgate wire harness, free of charge. Owner letters were mailed November 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's number for this recall is YI7.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Jun 29, 2023
Honda (American Honda Motor Co.) is recalling certain 2020-2021 Civic, 2020-2023 Ridgeline, 2021-2023 Passport, 2021-2022 Pilot, and 2020 Acura MDX vehicles. The tie rod fastener that connects the brake booster and the brake master cylinder may have been improperly assembled during manufacturing, which can cause the brake master cylinder to separate from the booster assembly.
Consequence & remedy
Consequence: Brake master cylinder separation can cause a loss of brake function and increase the risk of a crash.
Remedy: Dealers will inspect and repair the brake booster assembly as necessary, free of charge. Owner notification letters were mailed August 7, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are VEU, AEV, and ZET.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Nov 18, 2021
Honda (American Honda Motor Co.) is recalling certain 2021 Accord Sedan, Accord Hybrid, CR-V, Ridgeline, 2022 Insight and CR-V Hybrid vehicles. The automatic locking retractor on the second-row center seat belt assembly may deactivate improperly, which can result in an unsecured child restraint system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will replace the second-row center seat belt assembly, free of charge. Owner notification letters were mailed January 14, 2022. Owners may contact Honda customer service at 1-888-234-2138.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24004 · Rear-View Camera Failure
Opened Feb 13, 2024 · Closed Aug 5, 2024
Status: closed (inferred from source dates) · Back Over Prevention
On February 13, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24004 to assess alleged failures of the rear-view camera (RVC) in 2020-2023 Model Year (MY) Honda Ridgeline vehicles. At this time, ODI has received a total of 50 complaints with allegations of the RVC image failing to display when the vehicle was in reverse. The RVC wire harness is routed near the hinge in the tailgate, in a location where frequent opening and closing of the tailgate causes bending stress on the harness. Honda determined the wire harness was manufactured with a material which is permeable to water and salt, which when it freezes and thaws, combined with tailgate usage, ultimately leads to breakage of the wiring in the tailgate harness. This results in a failure to display the RVC image. On May 9, 2024, Honda filed a Part 573 Safety Recall Report recalling all 2020-2024 MY Honda Ridgeline vehicles. The dealer will replace the RVC tailgate harness with a wire harness that is manufactured by a new supplier and has improved material properties to withstand wear from bending. In view of Honda filing recall 24V-321 addressing the subject of this investigation, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration