NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
235 reports60,000 miles · Mar 10, 2026
Electrical SystemEngine And Engine CoolingPower Train
The contact owns a 2019 Honda Ridgeline. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. A diagnostic test revealed codes for the catalytic converter efficiency below threshold Bank 2, and Bank 2 air-fuel ratio imbalance. The vehicle was taken to a dealer, and the dealer…
Read full complaint
The contact owns a 2019 Honda Ridgeline. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. A diagnostic test revealed codes for the catalytic converter efficiency below threshold Bank 2, and Bank 2 air-fuel ratio imbalance. The vehicle was taken to a dealer, and the dealer referenced NHTSA ID Number: 10187289 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 60,000.
NHTSA ODI #11723342
99,000 miles · Mar 9, 2026
Engine
The contact's boyfriend owns a 2019 Honda Ridgeline. The contact stated that while her boyfriend was driving at highway speeds, there was an abnormal banging sound coming from the vehicle. The vehicle entered LIMP Mode with the check engine and emissions warning lights illuminated. The vehicle was pulled off to the shoulder of t…
Read full complaint
The contact's boyfriend owns a 2019 Honda Ridgeline. The contact stated that while her boyfriend was driving at highway speeds, there was an abnormal banging sound coming from the vehicle. The vehicle entered LIMP Mode with the check engine and emissions warning lights illuminated. The vehicle was pulled off to the shoulder of the highway and was later towed to the dealer. Upon inspecting the vehicle, the mechanic discovered that an engine rod had gone through the engine block, resulting in engine failure. The manufacturer was notified of the failure, and the contact was informed that there were no recalls or warranties on the vehicle. A case was filed with the dealer for financial assistance, but the case was denied. The vehicle was not repaired. The failure mileage was approximately 99,000.
NHTSA ODI #11722998
Mileage unknown · Jan 24, 2026
Electrical SystemEngineFuel/propulsion System
I own a 2019 Honda Ridgeline rtl. I presently have 66000 miles and am having issues with my engine emmision system, the number 2 sensor keeps going off and on and fuel rpm at 1.5 make my truck sputter until it gets pass 2 rpms. The lights going off and on! And the media system goes from music to GPS and volume goes up and down…
Read full complaint
I own a 2019 Honda Ridgeline rtl. I presently have 66000 miles and am having issues with my engine emmision system, the number 2 sensor keeps going off and on and fuel rpm at 1.5 make my truck sputter until it gets pass 2 rpms. The lights going off and on! And the media system goes from music to GPS and volume goes up and down spontaneously! Honda in Calhallen Texas say no recalls on it! Not sure what is going on i just don't want it to leave me in the road! I take care of my vehicles with the miles it has it shouldn't be having these many mechanical problems. Hope you can help or advise!
NHTSA ODI #11713082
Mileage unknown · Jan 23, 2026
Engine
On 1/5/2026 while pulling unto a major intersection, my 2019 Honda Ridgeline with 64,000 miles suddenly jolted, lost engine power, and every dash light came on indicating that all electronics were inoperable. Fortunately there was no fast moving on coming traffic. After examination in mechanics shop, it was found that the camsha…
Read full complaint
On 1/5/2026 while pulling unto a major intersection, my 2019 Honda Ridgeline with 64,000 miles suddenly jolted, lost engine power, and every dash light came on indicating that all electronics were inoperable. Fortunately there was no fast moving on coming traffic. After examination in mechanics shop, it was found that the camshaft was bad. attached is the $3,900.00 invoice. Attached also is a picture of the sensor showing that the camshaft was moving and hitting the sensor which caused the truck to go into safe mode. According to your own investigation and speaking to the Honda service department, this obvious is a factory defect that Honda needs to address. The cam obviously is not strong enough. There are 4.3 million complaints. I want to be reimbursed or will never, ever buy a Honda product. This is a safety issue as well as a consumer protection issue.
NHTSA ODI #11712943
Mileage unknown · Dec 26, 2025
Engine
The engine light came on and cam shaft caused the rod bearing to fail. I see there is a recall 23v751. But my vehicle vin. Is not on it 2019 honda ridgeline
NHTSA ODI #11707126
Mileage unknown · Dec 22, 2025
Engine
This is my second Honda ridgeline. The first was a 2014 model. This 2019 ridgeline has a distinctive metal knocking noise in the engine when running. The noise gets quite loud the colder the initial startup and under initial load. It gets quieter after running on the highway for a distance. I took it to the dealer several years…
Read full complaint
This is my second Honda ridgeline. The first was a 2014 model. This 2019 ridgeline has a distinctive metal knocking noise in the engine when running. The noise gets quite loud the colder the initial startup and under initial load. It gets quieter after running on the highway for a distance. I took it to the dealer several years ago but the noise was hard to hear after running the interstate for 20 miles. The mechanic told me there was "nothing wrong". I think there is. I know what this engine is supposed to sound like. This VIN number should have been in the 2023 Ridgeline engine recall.
NHTSA ODI #11706637
Mileage unknown · Nov 26, 2025
Power Train
The Transmission error continues to flash on the dash. It has now happened on four (4) occasions. Transmission was flushed and still occurs. Diagnostic Error Code P0741 stored. Torque Converter issue. Honda has extended the warranty for most of these vehicles, mine is not showing in the extension. However, it appears to m…
Read full complaint
The Transmission error continues to flash on the dash. It has now happened on four (4) occasions. Transmission was flushed and still occurs. Diagnostic Error Code P0741 stored. Torque Converter issue. Honda has extended the warranty for most of these vehicles, mine is not showing in the extension. However, it appears to meet all the specifications that it should be covered. Have it at the dealership which confirms all above. They claim Honda Corporate has to decide to extend the warranty. Talked to Honda Corporate today and they said the NHTSA has to extend the warranty, they do not decide.
NHTSA ODI #11701650
Mileage unknown · Nov 23, 2025
Engine
My engine started knocking from the connecting rod bearings and my vehicle is now not usable. The active recall on 2017 and 2019 Ridgelines is not covering my VIN and I have read many others are having the same issue. This issue if left untreated could cause my vehicle to die resulting in a loss of power. The manufacturer is ref…
Read full complaint
My engine started knocking from the connecting rod bearings and my vehicle is now not usable. The active recall on 2017 and 2019 Ridgelines is not covering my VIN and I have read many others are having the same issue. This issue if left untreated could cause my vehicle to die resulting in a loss of power. The manufacturer is refusing to repair the issue.
NHTSA ODI #11701104
Mileage unknown · Nov 20, 2025
Power Train
(This incident report is for my replacement transmission, I have already submitted an incident report for my original transmission which also failed in the exact same manner.) 1. My replacement transmission started bucking and clanging and down shifted extremely hard while I was driving in traffic, I lost all power and the vehi…
Read full complaint
(This incident report is for my replacement transmission, I have already submitted an incident report for my original transmission which also failed in the exact same manner.) 1. My replacement transmission started bucking and clanging and down shifted extremely hard while I was driving in traffic, I lost all power and the vehicle would not accelerate but the RPM's kept rising. 2. My safety was at risk because I lost power while in traffic and my vehicle became disabled on the road and I required the assistance of good Samaritans to help move my car off the road way, causing their safety to be at risk too. 3. My vehicle has been inspected by Honda. Their recommendation was to replace the original transmission, so I did, and the second transmission (the subject of this incident report) also failed, in the same manner. 4. The vehicle monitoring system did not give any prior warning that something was wrong till after the vehicle bucked, down shifted and lost power, only then did the car warnings go off and say "Transmission system" and then "emissions system"
NHTSA ODI #11700702
Mileage unknown · Oct 29, 2025
Engine
I was driving to work, engine starting knocking, check engine and battery light came on, and truck shut down. I coasted to a stop and had truck trailered 110mi. to dealer.
NHTSA ODI #11696255
Official recalls
11Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 23, 2022
Honda (American Honda Motor Co.) is recalling certain 2017-2019 Ridgeline vehicles. Opening and closing the tailgate may break the rearview camera wiring harness, causing the rearview camera to fail.
Consequence & remedy
Consequence: An inoperative rearview camera can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera wiring harness, free of charge. Owner notification letters were mailed August 31, 2023. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is 6RW.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 25, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
Apr 12, 2019
Honda (American Honda Motor Co.) is recalling certain 2018-2019 Acura MDX and Honda Pilot vehicles and 2019 Acura RLX, RLX Sport Hybrid, TLX and Honda Odyssey and Ridgeline vehicles. The timing belt teeth may separate from the belt.
Consequence & remedy
Consequence: Teeth separation from the timing belt may result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will inspect the vehicle and replace any affected timing belt free of charge. Vehicles receiving a replacement timing belt will also have the engine inspected and any damaged components will be replaced for free. The recall began June 7, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is L4M. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is Z4L.
Jan 24, 2019
Honda (American Honda Motor Co.) is recalling certain 2017-2019 Ridgeline trucks. Exposure to acids, such as from car wash soaps, can result in the fuel pump feed port cracking.
Consequence & remedy
Consequence: A crack in the fuel pump feed port can allow pressurized fuel to leak out, increasing the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel pump, if necessary, and install a fuel pump cover, free of charge. The recall began March 14, 2019. Owners may contact Honda customer service at 1-888-234-2138. The recall number for this recall is Q3V.
Nov 28, 2018
Honda (American Honda Motor Co.) is recalling certain 2019 Honda Ridgeline and Pilot vehicles. The mounting holes for the clip that secures the right center pillar trim panel may be larger than intended. In the event of a crash necessitating right side curtain air bag deployment, the clip may not hold the center pillar trim panel in position and it may potentially interfere with the curtain air bag deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection," and 226, "Ejection Mitigation."
Consequence & remedy
Consequence: In the event of a crash, if the curtain air bag does not deploy as intended, it can increase the risk of injury.
Remedy: Honda will notify owners, and dealers will install a bracket on the right center pillar that will securely hold the center pillar trim clip, free of charge. The recall began January 22, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is D3D.
Sep 27, 2018
Honda (American Honda Motor Co.) is recalling certain 2019 Honda Insight, Odyssey, and Ridgeline vehicles. The Supplemental Restraint System (SRS) control unit may have a manufacturing error, possibly resulting in the air bags or seatbelt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash, if the air bags or seatbelt pretensioners do not function as intended, there would be an increased risk of injury.
Remedy: Honda will notify owners, and dealers will replace the SRS unit, free of charge. The recall began November 8, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are B2R, C2P, and Z2Q.
Additional source detail variants (3)
Air Bags: Air Bag/restraint Control Module
Honda (American Honda Motor Co.) is recalling certain 2019 Honda Insight, Odyssey, and Ridgeline vehicles. The Supplemental Restraint System (SRS) control unit may have a manufacturing error, possibly resulting in the air bags or seatbelt pretensioners not deploying in the event of a crash.
Consequence: In the event of a crash, if the air bags or seatbelt pretensioners do not function as intended, there would be an increased risk of injury.
Remedy: Honda will notify owners, and dealers will replace the SRS unit, free of charge. The recall began November 8, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are B2R, C2P, and Z2Q.
Seat Belts:pretensioner
Honda (American Honda Motor Co.) is recalling certain 2019 Honda Insight, Odyssey, and Ridgeline vehicles. The Supplemental Restraint System (SRS) control unit may have a manufacturing error, possibly resulting in the air bags or seatbelt pretensioners not deploying in the event of a crash.
Consequence: In the event of a crash, if the air bags or seatbelt pretensioners do not function as intended, there would be an increased risk of injury.
Remedy: Honda will notify owners, and dealers will replace the SRS unit, free of charge. The recall began November 8, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are B2R, C2P, and Z2Q.
Air Bags
Honda (American Honda Motor Co.) is recalling certain 2019 Honda Insight, Odyssey, and Ridgeline vehicles. The Supplemental Restraint System (SRS) control unit may have a manufacturing error, possibly resulting in the air bags or seatbelt pretensioners not deploying in the event of a crash.
Consequence: In the event of a crash, if the air bags or seatbelt pretensioners do not function as intended, there would be an increased risk of injury.
Remedy: Honda will notify owners, and dealers will replace the SRS unit, free of charge. The recall began November 8, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are B2R, C2P, and Z2Q.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25003 · Rear-View Camera Failure
Opened Feb 11, 2025 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention
On June 26, 2024, the Office of Defects Investigation (ODI) opened a Recall Query (RQ24011) to assess the long-term suitability of the remedy for recall 22V-867, which was filed on November 23, 2022 by American Honda Motor Co. (Honda). Recall 22V-867 addressed concerns of a loss of the Rear-View Camera (RVC) function in model year (MY) 2017-2019 Honda Ridgeline vehicles. Recall 22V-867 states that the RVC wire harness was manufactured with a protective corrugated tubing which was insufficient to protect against bending wear and zip ties which were insufficiently tightened and would not keep the protective tubing in place. The consequence is that the RVC wire harness may fatigue and break after repeated opening and closing of the tailgate. This ultimately results in the failure of the RVC image to display due to a lack of connectivity. Honda’s remedy identified in the recall filing was a replacement harness with longer protective corrugated tubing and sufficiently tightened zip ties. This remedy part was also installed as a production part in certain MY 2019 Ridgeline vehicles. On May 3, 2024, Honda submitted recall 24V-321 to ODI, addressing concerns of a loss of the RVC function in MY 2020-2024 Honda Ridgeline vehicles. Recall 24V-321 states that the RVC wire harness was manufactured with a material which was susceptible to breakage upon repeated opening and closing of the tailgate, which ultimately leads to a complete loss of RVC function. Honda’s remedy identified in the recall filing was a replacement harness manufactured by a new supplier with improved material properties to withstand wear from bending. Since the remedy parts for recall 22V-867 and the production parts recalled under 24V-321 use the same supplier and materials for critical components in the RVC wire harness, ODI opened RQ24011. To date, ODI has received 1 allegation of a 22V-867 remedy RVC wire harness failure. Honda indicated that it is aware of a total of 14 reports regarding remedy RVC wire harness failures associated with Recall 22V-867. Additional remedy parts may not have yet seen sufficient wear to induce the failure. ODI also believes further testing is necessary to assess the potential failures in these parts. This Engineering Analysis is being opened to further assess the scope, frequency, and potential safety related consequences of the rear view camera harness failures in 2017-2019 Honda Ridgeline vehicles. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
RQ24011 · Rear-View Camera Failure
Opened Jun 26, 2024 · Closed Feb 11, 2025
Status: closed (inferred from source dates) · Back Over Prevention
On June 26, 2024, the Office of Defects Investigation (ODI) opened a Recall Query (RQ24011) to assess the long-term suitability of the remedy for recall 22V-867, which was filed on November 23, 2022 by American Honda Motor Co. (Honda). Recall 22V-867 addressed concerns of a loss of the Rear-View Camera (RVC) function in model year (MY) 2017-2019 Honda Ridgeline vehicles. Recall 22V-867 states that the RVC wire harness was manufactured with a protective corrugated tubing which was insufficient to protect against bending wear and zip ties which were insufficiently tightened and would not keep the protective tubing in place. The consequence is that the RVC wire harness may fatigue and break after repeated opening and closing of the tailgate. This ultimately results in the failure of the RVC image to display due to a lack of connectivity. Honda’s remedy identified in the recall filing was a replacement harness with longer protective corrugated tubing and sufficiently tightened zip ties. This remedy part was also installed as a production part in certain MY 2019 Ridgeline vehicles. On May 3, 2024, Honda submitted recall 24V-321 to ODI, addressing concerns of a loss of the RVC function in MY 2020-2024 Honda Ridgeline vehicles. Recall 24V-321 states that the RVC wire harness was manufactured with a material which was susceptible to breakage upon repeated opening and closing of the tailgate, which ultimately leads to a complete loss of RVC function. Honda’s remedy identified in the recall filing was a replacement harness manufactured by a new supplier with improved material properties to withstand wear from bending. Since the remedy parts for recall 22V-867 and the production parts recalled under 24V-321 use the same supplier and materials for critical components in the RVC wire harness, ODI opened RQ24011. To date, ODI has received 1 allegation of a 22V-867 remedy RVC wire harness failure. Honda indicated that it is aware of a total of 14 reports regarding remedy RVC wire harness failures associated with Recall 22V-867. Additional remedy parts may not have yet seen sufficient wear to induce the failure. ODI also believes further testing is necessary to assess the potential failures in these parts. RQ24011 is being upgraded to an Engineering Analysis (EA25003) to further assess the scope, frequency, and potential safety related consequences of the Rear View Camera harness failures in 2017-2019 Honda Ridgeline vehicles. To review the ODI report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration