Electrical System. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports7 fire reports1 injury reports

Engine complaints

83 reports

Clear category filter

Mileage unknown · Jun 11, 2025

EnginePower Train

Read full complaint

I have a 2017 Ridgeline. I bought it brand new. Always keep up with the maintenance, keep it clean and well taken care of. I only have 45,000 miles on it. A few days ago the engine failed on me while on the freeway. Limped it off the freeway as it made a horrendous sound, like marbles in the engine. I had it towed, at a cost of $275. I took it to Honda. I told them I was aware of the NHTSA investigation into the the 2017-2019 Ridgeline reports of failing connecting rod bearings. They said they were not aware of that and it was not showing on the recall list for my specific vehicle . Their diagnostic came back requiring a short block replacement as "oil was coming from the oil pan rod bearing." They took it the warranty department, as the original warranty of 5yrs/60,000mi has passed. Honda is going to cover 75% of a $9,738.35 bill because of the low mileage on the vehicle, which brings the cost to "only $1,850." They’re giving me a 12 month/12,000 mile warranty on their work. They’re also recommending that I do a 100,000 miles service that would require a replacement of a timing belt, water pump, drive belt, etc. that would cost an additional $2,123.58. It seems a bit counterintuitive to do that service since I only have 45,000 miles on an eight year-old truck that has been kept up on its regular maintenance schedule. The initial cost to do the diagnostic was stated at $199. I received a call to approve $697 to break down the engine to do further evaluation. After receiving the results of their evaluation, I am now awaiting the estimate with a breakdown of costs. I have yet to receive that, but can provide it when available. The vehicle is still sitting at the Honda service center. I have also contacted Honda directly and have opened a case with them.

NHTSA ODI #11666390

Mileage unknown · May 23, 2025

Electrical SystemEngine

Read full complaint

I was driving home climbing a hill in the slight rain when the check engine light came on. I drove with the light on to get to the next closest city about 2 minutes out from where the light came on. The engine was running rough and shaking the car and was having issues stopping at a light before I could pull into a parking lot. I pulled into the parking lot, my book said that it was a misfire and to let the engine cool off so I sat for about 2 hours, checked fluids then started the car. the ticking noise was there but there were no lights on my dash at the time and assumed it could make it home after I let it idle for 5 minutes. I proceeded to get on the road and the vehicle did ok. I got on the freeway to get home, slowly let the car climb to 50 and kept it there. 1 minute later the whole dash glowed saying everything was not working and giving special pop-ups on the dash explaining the VSA, ABS, and electronic power steering were not working to name a few. I stopped the car and pulled over immediately and called for a tow. I took it to my local electric shop to see because the brakes still worked and they said that it was possibly the ECM, that they couldn't fix it, and the ticking was a heatshield, and to take it to the dealer. I then towed it to the dealer. The Honda techs said that they didn't know what was wrong because the car wasn't throwing any codes. They replaced the tailgate harness that the previous dealer I took it to didn't and said to replace the pully and tensioner before they drove and diagnosed it further. I had it towed to another shop to get those replaced. This shop listed some of the same fault codes as the first shop and when they tested the vehicle they had called me to come in and inspect the vehicle as they started it after it was at the dealer and told me it was an engine knock and that the engine would need to be replaced with the drive shaft. I called Honda's corporate office and they took my complaint and documented it only.

NHTSA ODI #11662715

Mileage unknown · May 6, 2025

EnginePower Train

Read full complaint

Most likely a connecting rod bearing failure leading to catastrophic engine failure per dealership service department. Vehicle is currently available for inspection. Safety was put at risk by engine part (likely connecting rod bearing) coming loose. It flew through my oil pan and bounced off the road, fortunately no people or other vehicles were hit by the part. Vehicle lost power and engine started smoking, oil spilled all over the road. I had to evacuate vehicle on busy highway (70 mph speed limit) since it was smoking. The vehicle was towed to the dealer which inspected it and said most likely connecting rod bearing failure but could not confirm unless engine taken apart. To my knowledge no one else has inspected it. All service for the life of the vehicle has been performed at Honda dealerships at recommended times. A check engine light had come on shortly before the problem occurred.

NHTSA ODI #11659354

Mileage unknown · Apr 21, 2025

EngineFuel/propulsion SystemUnknown Or Other

Read full complaint

My vehicle has less than 95k miles on it. Purchased it brand new from the dealer in 2016. It was one of the first few Ridgelines in the state. I've always had it serviced on time at the dealer, and kept up with its maintenance and care. The engine started to fail out of nowhere - making a weird tapping/knocking noise. I made an appointment to have it checked out by the dealership, and that same day my check engine light came on while I was on the freeway going 70mph. It began shaking at an idle. I got off the freeway, and parked. I was afraid to turn the car back on. The check engine light listed off numerous warnings of failed systems. Since my appointment wasn't until the next day, I left my car near the dealership overnight, instead of driving it back home for fear of causing an accident, or having my engine overheat or explode. I brought it to the dealership the next day, and they confirmed that I had a fuel injector issue, consistent with a known issue, for which I had an extended warranty letter re: the MIL warnings. However, they also noted a possible connection rod issue in the engine, and said the engine would have to be completely replaced or rebuilt. I have read and heard from many other people with a 2017 Honda Ridgeline that they have experienced this issue with their engines failing well before they should - at 90k miles, 140k miles, etc. There is a known issue with many of the 2017 Honda Ridgelines - and a recall did occur, but my VIN says my vehicle is not part of this recall - however, clearly my engine had the problem that Honda was aware of. My whole family was in the car when the check engine light came on, and the sound got worse - we could have been injured in an accident on the freeway, or had the engine overheat/explode while we were in the car. The issue was reproduced and confirmed by the dealer service center, and has been inspected by them. No warnings or symptoms before the failure - just complete shutdown out of nowhere.

NHTSA ODI #11655920

Mileage unknown · Apr 13, 2025

Engine

Read full complaint

Recently, while driving approximately an hour and a half from home, traveling at 80–100 km/h, the vehicle suddenly began to shake violently, almost ripping the steering wheel from my hands. I immediately turned down the radio and heard a loud squealing and clacking noise coming from the engine. At that time, no warning lights or codes were present. Moments later, multiple errors appeared on the dashboard, and the engine lost power and shut down completely. With nowhere safe to pull over, I attempted to restart the vehicle just to get it off the roadway into a nearby farm entrance, but it died again shortly after. I had the vehicle towed on a flatbed back home, where I began diagnostics. I initially suspected a timing issue or tensioner failure, so I checked timing components, replaced the spark plugs and swapped coils. A compression test showed over 150 psi across all cylinders. I then brought it into my shop for further inspection. A scan revealed a cylinder #3 misfire, and upon removing the oil pan, I discovered the rod bearing on cylinder #3 had failed catastrophically. When I contacted Honda about the rod bearing recall, I was told that although over 250,000 vehicles were recalled for similar issues, mine did not qualify as it was manufactured in July 2016, just outside the affected range. I was advised to transport the vehicle 2.5 hours to a dealership for a technician inspection, as my diagnosis would not be accepted. This failure was not only unexpected and costly—it was a serious safety concern that could have resulted in injury or worse. Given the severity of the situation and the number of similar cases reported, I respectfully request that Honda cover the repair under warranty or goodwill. This failure should not have happened on a well-maintained engine and is clearly part of a wider issue.

NHTSA ODI #11654377

Mileage unknown · Apr 9, 2025

Engine

Read full complaint

After taking my 2017 Honda Ridgeline to First Honda in Simi Valley, CA for its 100,000-mile maintenance, including a brake service and an oil change, I experienced a major engine failure just two days later. I let my son drive the vehicle from Simi Valley to the East Bay area for college. The next day, the vehicle broke down and had to be towed to Hayward Honda. At Hayward Honda, they informed me that the oil was extremely dark and looked like it had not been changed, despite being billed for it at First Honda. Furthermore, they diagnosed that the engine failure was due to a connecting rod bearing failure — the same issue currently under investigation by the NHTSA. This breakdown happened without warning right after scheduled maintenance and may indicate both negligence by the servicing dealer and a defect in the engine. I believe this incident should be included in the NHTSA investigation related to engine failures in 2017 Honda Ridgeline models.

NHTSA ODI #11653708

122,255 miles · Jan 28, 2025

Engine

Read full complaint

I started getting a p0306 code on my truck on Thursday Jan 2, 2025. I took it to my mechanic and he said that it is a lower engine problem. On Saturday Jan 11,2025 there was a loud clunk from the engine and the vehicle lost power. My mechanic said that the connector rod broke. I contacted Honda but they said my vin is not in the recall and I would have to deal with the dealership. I know that they won't do anything so I am in the process of trying to install a used engine myself.

NHTSA ODI #11639098

116,399 miles · Jan 27, 2025

Engine

My engine started to have a clicking or a ticking sound, and then abruptly stop running. The dealer said that the engine is seized up. From what I have read, it sounds like the connecting rod problem that other 2017 models have had. I think that my engine needs to also be on the recall. Honda has offered NO help with this,…

Read full complaint

NHTSA ODI #11638750

Mileage unknown · Dec 29, 2024

Engine

Read full complaint

Have taken in a few times for engine knocking, Honda has down oil changes and reported noise is normal but is getting louder, purchased extended warranty from Honda dealer. Also had at Honda for oil and filter change a month ago, they also were supposed to have completed the tailgate harness but told me it had be previously complied with but never took it off the list of open recalls. Honda isn’t the company it used to be. After my purchase of my new Honda pilot and issues- it will be my last Honda period.

NHTSA ODI #11632954

Mileage unknown · Dec 20, 2024

Engine

Read full complaint

Connecting rod bearing on the #6 cylinder...after the injectors failed and the vehicle was barely drivable the Honda mechanic heard a knocking in the motor which was confirmed when I agreed to pay $700 for them to tear it down to look. Mechanic confirmed issue which is EXACTLY same issue as the recall for other 2017 Ridgelines. I am somewhat lucky as I had purchased an extended warranty but it will still cost me over $700 to get a used motor. The insurance company confirmed issue. There were no warning lights or anything that came on prior to the injectors failing. Could have been a major issue as mechanic said it was just a matter of time before motor completely blew up.

NHTSA ODI #11631809

Official recalls

26V365000 · Structure:frame And Members; Suspension:rear

Jun 4, 2026

American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.

Consequence & remedy

Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.

Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.

Additional source detail variants (2)

Suspension:rear

Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.

Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.

Structure:frame And Members

Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.

26V332000 · Air Bags:sensor:occupant Classification:front Passenger

May 21, 2026

Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.

Consequence & remedy

Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.

Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.

23V858000 · Fuel System, Gasoline:delivery:fuel Pump

Dec 18, 2023

Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.

Consequence & remedy

Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.

Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.

23V751000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Nov 13, 2023

Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.

Consequence & remedy

Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.

Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.

22V867000 · Back Over Prevention: Sensing System: Camera

Nov 23, 2022

Honda (American Honda Motor Co.) is recalling certain 2017-2019 Ridgeline vehicles. Opening and closing the tailgate may break the rearview camera wiring harness, causing the rearview camera to fail.

Consequence & remedy

Consequence: An inoperative rearview camera can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: Dealers will replace the rearview camera wiring harness, free of charge. Owner notification letters were mailed August 31, 2023. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is 6RW.

21V932000 · Latches/locks/linkages:hood:latch; Structure:body:hood

Nov 29, 2021

Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.

Consequence & remedy

Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.

Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.

Additional source detail variants (2)

Latches/locks/linkages:hood:latch

Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.

Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.

Structure:body:hood

Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.

19V053000 · Fuel System, Gasoline:delivery:fuel Pump

Jan 24, 2019

Honda (American Honda Motor Co.) is recalling certain 2017-2019 Ridgeline trucks. Exposure to acids, such as from car wash soaps, can result in the fuel pump feed port cracking.

Consequence & remedy

Consequence: A crack in the fuel pump feed port can allow pressurized fuel to leak out, increasing the risk of a fire.

Remedy: Honda will notify owners, and dealers will replace the fuel pump, if necessary, and install a fuel pump cover, free of charge. The recall began March 14, 2019. Owners may contact Honda customer service at 1-888-234-2138. The recall number for this recall is Q3V.

16V888000 · Electrical System:wiring

Dec 9, 2016

Honda (American Honda Motor Co.) is recalling certain model year 2017 Ridgeline AWD vehicles manufactured April 1, 2016, to August 11, 2016. Water may enter the rear wiring harness through the connector located under the truck bed drain hole, possibly causing the connection terminals to corrode.

Consequence & remedy

Consequence: Corrosion of the wiring harness can cause increased electrical resistance, unexpectedly activating the vehicle stability assist (VSA) system, increasing the risk of a crash.

Remedy: Honda will notify owners, and dealers will inspect the rear wiring harness and related components, replacing them as necessary, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KD3.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE25008 · Engine Failure

Opened Aug 20, 2025 · No close date supplied

Status: open (inferred from source dates) · Engine

The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

EA25003 · Rear-View Camera Failure

Opened Feb 11, 2025 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention

On June 26, 2024, the Oﬃce of Defects Investigation (ODI) opened a Recall Query (RQ24011) to assess the long-term suitability of the remedy for recall 22V-867, which was ﬁled on November 23, 2022 by American Honda Motor Co. (Honda). Recall 22V-867 addressed concerns of a loss of the Rear-View Camera (RVC) function in model year (MY) 2017-2019 Honda Ridgeline vehicles. Recall 22V-867 states that the RVC wire harness was manufactured with a protective corrugated tubing which was insufficient to protect against bending wear and zip ties which were insufficiently tightened and would not keep the protective tubing in place. The consequence is that the RVC wire harness may fatigue and break after repeated opening and closing of the tailgate. This ultimately results in the failure of the RVC image to display due to a lack of connectivity. Honda’s remedy identified in the recall filing was a replacement harness with longer protective corrugated tubing and sufficiently tightened zip ties. This remedy part was also installed as a production part in certain MY 2019 Ridgeline vehicles. On May 3, 2024, Honda submitted recall 24V-321 to ODI, addressing concerns of a loss of the RVC function in MY 2020-2024 Honda Ridgeline vehicles. Recall 24V-321 states that the RVC wire harness was manufactured with a material which was susceptible to breakage upon repeated opening and closing of the tailgate, which ultimately leads to a complete loss of RVC function. Honda’s remedy identified in the recall filing was a replacement harness manufactured by a new supplier with improved material properties to withstand wear from bending. Since the remedy parts for recall 22V-867 and the production parts recalled under 24V-321 use the same supplier and materials for critical components in the RVC wire harness, ODI opened RQ24011. To date, ODI has received 1 allegation of a 22V-867 remedy RVC wire harness failure. Honda indicated that it is aware of a total of 14 reports regarding remedy RVC wire harness failures associated with Recall 22V-867. Additional remedy parts may not have yet seen sufficient wear to induce the failure. ODI also believes further testing is necessary to assess the potential failures in these parts. This Engineering Analysis is being opened to further assess the scope, frequency, and potential safety related consequences of the rear view camera harness failures in 2017-2019 Honda Ridgeline vehicles. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

RQ24013 · Engine Failure

Opened Nov 8, 2024 · Closed Aug 20, 2025

Status: closed (inferred from source dates) · Engine

On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.

RQ24011 · Rear-View Camera Failure

Opened Jun 26, 2024 · Closed Feb 11, 2025

Status: closed (inferred from source dates) · Back Over Prevention

On June 26, 2024, the Oﬃce of Defects Investigation (ODI) opened a Recall Query (RQ24011) to assess the long-term suitability of the remedy for recall 22V-867, which was ﬁled on November 23, 2022 by American Honda Motor Co. (Honda). Recall 22V-867 addressed concerns of a loss of the Rear-View Camera (RVC) function in model year (MY) 2017-2019 Honda Ridgeline vehicles. Recall 22V-867 states that the RVC wire harness was manufactured with a protective corrugated tubing which was insufficient to protect against bending wear and zip ties which were insufficiently tightened and would not keep the protective tubing in place. The consequence is that the RVC wire harness may fatigue and break after repeated opening and closing of the tailgate. This ultimately results in the failure of the RVC image to display due to a lack of connectivity. Honda’s remedy identified in the recall filing was a replacement harness with longer protective corrugated tubing and sufficiently tightened zip ties. This remedy part was also installed as a production part in certain MY 2019 Ridgeline vehicles. On May 3, 2024, Honda submitted recall 24V-321 to ODI, addressing concerns of a loss of the RVC function in MY 2020-2024 Honda Ridgeline vehicles. Recall 24V-321 states that the RVC wire harness was manufactured with a material which was susceptible to breakage upon repeated opening and closing of the tailgate, which ultimately leads to a complete loss of RVC function. Honda’s remedy identified in the recall filing was a replacement harness manufactured by a new supplier with improved material properties to withstand wear from bending. Since the remedy parts for recall 22V-867 and the production parts recalled under 24V-321 use the same supplier and materials for critical components in the RVC wire harness, ODI opened RQ24011. To date, ODI has received 1 allegation of a 22V-867 remedy RVC wire harness failure. Honda indicated that it is aware of a total of 14 reports regarding remedy RVC wire harness failures associated with Recall 22V-867. Additional remedy parts may not have yet seen sufficient wear to induce the failure. ODI also believes further testing is necessary to assess the potential failures in these parts. RQ24011 is being upgraded to an Engineering Analysis (EA25003) to further assess the scope, frequency, and potential safety related consequences of the Rear View Camera harness failures in 2017-2019 Honda Ridgeline vehicles. To review the ODI report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

PE22001 · Rear-View Camera Failure

Opened Feb 7, 2022 · Closed Dec 19, 2022

Status: closed (inferred from source dates) · Back Over Prevention; Back Over Prevention: Sensing System: Camera

On February 7, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22-001) to assess alleged failures of the rear-view camera (RVC) in 2017-2018 Model Year Honda Ridgeline vehicles. At this time, ODI has received a total of 107 complaints with allegations of the RVC image failing to display when the vehicle was in reverse.The RVC wire harness is manufactured with a protective corrugated tubing and harness guide to help mitigate stress on the RVC wire harness when the tailgate was opened and closed. Honda determined the length of corrugated tubing inserted into the harness guide was insufficient to provide optimal protection for the wire harness. This lack of protection for RVC wire harness led to severe wire harness damage that ultimately led to the failure of the RVC image to display due to a lack of connectivity.On November 23, 2022, Honda filed a defect information report recalling all 2017-2019MY Honda Ridgeline vehicles. The dealer will replace the RVC tailgate harness with an improved wire harness that has longer corrugated tubing to protect the wire harness.In view of the recall action being taken by Honda, 22V-867, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances. The ODI reports cited above are available to review at NHTSA.gov under the following ODI identification numbers:11206191, 11298458, 11319870, 11329993, 11341373, 11343035, 11343035, 11343441, 11350026, 11350162, 11361959, 11362378, 11362758, 11363268, 11372604, 11373525, 11374112, 11388328, 11395026, 11397565, 11397936, 11398930, 11399178, 11400366, 11403360, 11403368, 11404149, 11408414, 11413184, 11415248, 11415847, 11417394, 11419669, 11420068, 11422394, 11422938, 11428514, 11431246, 11437880, 11438172, 11440548, 11441551, 11443328, 11447502, 11448600, 11449291, 11450413, 11451727, 11451728, 11451753, 11451793, 11451847, 11451959, 11452077, 11452433, 11452769, 11453044, 11453189, 11453403, 11453442, 11453622, 11455106, 11456922, 11456929, 11457013, 11457158, 11457908, 11458258, 11458430, 11458861, 11459046, 11459437, 11459517, 11460875, 11461017, 11461047, 11461083, 11461652, 11462082, 11462401, 11462703, 11464525, 11464749, 11465214, 11466731, 11466931, 11470232, 11470656, 11470768, 11471427, 11471889, 11471950, 11472343, 11472927, 11473801, 11473970, 11476348, 11479379, 11479629, 11480475, 11482614, 11484718, 11485708, 11485720, 11485774, 11485930, 11486546

Additional source detail variants (2)

Back Over Prevention

Back Over Prevention: Sensing System: Camera