NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,699 reports2,000 miles · Feb 18, 2016
Seat Belts
WHEN SECURING THE DRIVER'S SIDE SEATBELT, IT SEEMED TO BE TOO TIGHT AND DID NOT ALLOW ROOM TO REACH THE DASH. TOOK IT BACK TO THE DEALERSHIP AND THEY LUBRICATED IT AND SAID IT WAS WORKING FINE. IT STILL CONTINUED TO FEEL TOO TIGHT - ESPECIALLY WHEN COMPARED TO THE PASSENGER SIDE. SO, I STOPPED BY A HONDA DEALERSHIP AND TRIED …
Read full complaint
WHEN SECURING THE DRIVER'S SIDE SEATBELT, IT SEEMED TO BE TOO TIGHT AND DID NOT ALLOW ROOM TO REACH THE DASH. TOOK IT BACK TO THE DEALERSHIP AND THEY LUBRICATED IT AND SAID IT WAS WORKING FINE. IT STILL CONTINUED TO FEEL TOO TIGHT - ESPECIALLY WHEN COMPARED TO THE PASSENGER SIDE. SO, I STOPPED BY A HONDA DEALERSHIP AND TRIED THE SEATBELT IN ONE OF THEIR 2016 MODELS AND FOUND THAT IT HAD THE SAME SNUGNESS AS MY VEHICLE. I HAVE SINCE MEASURED BOTH THE DRIVER'S SEATBELT AND THE FRONT PASSENGER SEATBELT. THE RESULT WAS THAT THE DRIVER'S SIDE BELT IS A FULL 24 INCHES SHORTER THAN THE FRONT PASSENGER BELT, WHEN FULLY EXTENDED. I FEEL THAT IF IT IS TIGHT ON ME, IT COULD POSE A PROBLEM FOR OTHERS AS WELL. IT SHOULD BE NOTED THAT, EVEN THOUGH THE BELT WAS A LITTLE SNUG, I REALLY DID NOT NOTICE IT UNTIL I WAS WEARING BULKY WINTER CLOTHING AND HEAVY COAT.
NHTSA ODI #10836865
29 miles · Feb 16, 2016
Electrical System
EVER SINCE THE DAY I PURCHASED THE CAR THE RADIO RECEPTION HAS BEEN VERY BAD AT ALL TIMES MOVING OR PARKED.. THIS IS WITH AM/FM AND XM RADIO. THE ONLY WAY I CAN LISTEN TO MUSIC IS USING MY CELL PHONE VIA BLUETOOTH. I HAVE TAKEN MY PILOT TO THE DEALER AND WAS TOLD I NEED TO WAIT FOR AMERICAN HONDA TO FIGURE OUT A FIX FOR THIS. TH…
Read full complaint
EVER SINCE THE DAY I PURCHASED THE CAR THE RADIO RECEPTION HAS BEEN VERY BAD AT ALL TIMES MOVING OR PARKED.. THIS IS WITH AM/FM AND XM RADIO. THE ONLY WAY I CAN LISTEN TO MUSIC IS USING MY CELL PHONE VIA BLUETOOTH. I HAVE TAKEN MY PILOT TO THE DEALER AND WAS TOLD I NEED TO WAIT FOR AMERICAN HONDA TO FIGURE OUT A FIX FOR THIS. THE SERVICE DEPARTMENT EVEN CHECKED ALL 6 PILOTS ON THE LOT AND THEY ALL HAD THE SAME ISSUES. I ALSO FILED A COMPLAINT WITH AMERICAN HONDA AND WAS TOLD THEY ARE AWARE OF THE ISSUE AND I NEED TO WAIT FOR A FIX. MY CASE MANAGERISSUED ME A $400 HONDA LOYALTY CARD WHICH CAN BE USED FOR PARTS OR SERVICE AT ANY HONDA DEALER (SHE SAID THE CARD FOR FOR MY TROUBLES). I HAVE BEEN WAITING SINCE END NOVEMBER 2015 WHEN I PURCHASED THE CAR. THIS IS A PROBLEM WITH ALL 2016 HONDA PILOTS, THERE ARE MANY COMPLAINTS IN THE ONLINE FORUMS ABOUT THIS PROBLEM.
NHTSA ODI #10836513
6,500 miles · Feb 10, 2016
Unknown Or Other
WE ARE EXPERIENCING A SNAP/CLUNK THAT CAN BE HEARD AND SLIGHTLY FELT THROUGH FOOT WHEN APPLYING OR RELEASING THE ACCELERATOR AND ALSO APPLICATION OF THE BRAKE. THIS ONLY OCCURS WHEN THE VEHICLE IS IN A COLDER (PROBABLY LESS THAN 30 DEGREES FAHRENHEIT) OUTSIDE TEMPS. HONDA DEALER HAD LOOK AT IT TWICE AND ITS BEEN IN THE SHOP 3 TH…
Read full complaint
WE ARE EXPERIENCING A SNAP/CLUNK THAT CAN BE HEARD AND SLIGHTLY FELT THROUGH FOOT WHEN APPLYING OR RELEASING THE ACCELERATOR AND ALSO APPLICATION OF THE BRAKE. THIS ONLY OCCURS WHEN THE VEHICLE IS IN A COLDER (PROBABLY LESS THAN 30 DEGREES FAHRENHEIT) OUTSIDE TEMPS. HONDA DEALER HAD LOOK AT IT TWICE AND ITS BEEN IN THE SHOP 3 THREE TIMES SO FAR WITH THE FOURTH VISIT BEING THIS MORNING 2/10/2016. SO FAR THEY ADJUSTED BOLTS AND FASTENERS ON VISIT ONE. ON VISIT THREE THEY REPLACED THE CENTER DRIVE SHAFT. PROBLEM STILL EXISTS. BECAUSE THERE IS NO KNOW DIAGNOSIS AT THIS TIME ITS UNCLEAR IF THIS IS A SAFETY ISSUE.
NHTSA ODI #10825255
600 miles · Feb 4, 2016
Power TrainService BrakesUnknown Or Other
2016 HONDA PILOT SURGE WHILE TRYING TO STOP ON A CITY STREET AND 2 TIMES ENDED UP PART WAY IN THE INTERSECTION. NO WARNING LIGHTS ON DASH. HAD PILOT ABOUT A MONTH. ONLY DROVE ABOUT 500 MILES. CONCERNED, SO KEEP LONGER DISTANCES IN TRAFFIC. SETUP AN APPOINTMENT TODAY WITH LOCAL DEALER TO INSPECT PER HIS SCHEDULE IN 4 DAYS.
NHTSA ODI #10824191
19,000 miles · Feb 1, 2016
Power Train
9-SPEED TRANSMISSION IN THE "TOURING" TRIM LEVEL OF 2016 HONDA PILOT HAS AN ELECTRONIC PUSH-BUTTON SHIFTER. THIS SHIFTER INTERMITTENTLY FAILS TO RESPOND TO FIRM BUTTON PUSHES. THIS IS ESPECIALLY PROBLEMATIC WHEN SHIFTING FROM FORWARD TO REVERSE OR VICE VERSA IN PARKING SITUATIONS. ON SEVERAL OCCASIONS, AFTER COMING TO A COMPLETE…
Read full complaint
9-SPEED TRANSMISSION IN THE "TOURING" TRIM LEVEL OF 2016 HONDA PILOT HAS AN ELECTRONIC PUSH-BUTTON SHIFTER. THIS SHIFTER INTERMITTENTLY FAILS TO RESPOND TO FIRM BUTTON PUSHES. THIS IS ESPECIALLY PROBLEMATIC WHEN SHIFTING FROM FORWARD TO REVERSE OR VICE VERSA IN PARKING SITUATIONS. ON SEVERAL OCCASIONS, AFTER COMING TO A COMPLETE STOP AND FIRMLY DEPRESSING THE SHIFTER BUTTON TO REVERSE DIRECTION, THE VEHICLE HAS ACCELERATED IN THE ORIGINAL DIRECTION UPON RELEASE OF THE BRAKE. THIS HAS NECESSITATED EMERGENCY BRAKING TO AVOID COLLISION. NO WARNING MESSAGE OR CHIME IS GENERATED DURING THESE FAILURES, THE VEHICLE SIMPLY FAILS TO ACKNOWLEDGE OR RESPOND TO THE BUTTON PRESS. DEALER SERVICE HAS BEEN UNABLE TO REPLICATE OR REPAIR THE PROBLEM.
NHTSA ODI #10823370
19,000 miles · Feb 1, 2016
Power Train
VEHICLE SURGES FORWARD WHEN 9-SPEED AUTOMATIC TRANSMISSION SHIFTS DURING COASTING OR LIGHT BRAKING. SURGING ROUTINELY OCCURS AT MODERATE SPEEDS ( 35-45MPH ) WHEN COASTING DOWNHILL ON A SECONDARY HIGHWAY. SURGING HAS ALSO OCCURRED AT PARKING LOT SPEEDS, AND HAS NECESSITATED EMERGENCY BRAKING TO AVOID COLLISION. HONDA MOTOR COMPAN…
Read full complaint
VEHICLE SURGES FORWARD WHEN 9-SPEED AUTOMATIC TRANSMISSION SHIFTS DURING COASTING OR LIGHT BRAKING. SURGING ROUTINELY OCCURS AT MODERATE SPEEDS ( 35-45MPH ) WHEN COASTING DOWNHILL ON A SECONDARY HIGHWAY. SURGING HAS ALSO OCCURRED AT PARKING LOT SPEEDS, AND HAS NECESSITATED EMERGENCY BRAKING TO AVOID COLLISION. HONDA MOTOR COMPANY HAS ACKNOWLEDGED SIMILAR BEHAVIOR IN ANOTHER MODEL THAT SHARES IDENTICAL ENGINE AND TRANSMISSION WITH THIS VEHICLE ( ASIDE FROM DIFFERENCES IN TUNING ), THE 2016 ACURA MDX, AND A SOFTWARE REPAIR CAMPAIGN IS UNDERWAY FOR THAT VEHICLE. AT THIS TIME, NO SOFTWARE REPAIR HAS BEEN ANNOUNCED FOR THE 2016 HONDA PILOT TOURING. SEVERAL REPAIR ATTEMPTS HAVE BEEN MADE BY A LOCAL HONDA SERVICE DEPARTMENT, WITH NO IMPROVEMENT.
NHTSA ODI #10823367
750 miles · Jan 29, 2016
Structure
ENGINE HOOD BENDS IN ALL DIRECTIONS IN HIGH WINDS & WHEN PASSING COMMERCIAL TRUCKS: LOOKS LIKE IT WILL COME OFF AT ANY MOMENT, TO STRIKE THE WINDSHIELD. EXPERIENCED THIS ON THE SAME HIGHWAY ON EVERY TRIP FROM CALIFORNIA TO ARIZONA AND BACK.SPEED WAS 75 MPH (LEGAL LIMIT). WILL VIDEO TAPE THIS ON THE NEXT TRIP.VERY FRIGHTENING! …
Read full complaint
ENGINE HOOD BENDS IN ALL DIRECTIONS IN HIGH WINDS & WHEN PASSING COMMERCIAL TRUCKS: LOOKS LIKE IT WILL COME OFF AT ANY MOMENT, TO STRIKE THE WINDSHIELD. EXPERIENCED THIS ON THE SAME HIGHWAY ON EVERY TRIP FROM CALIFORNIA TO ARIZONA AND BACK.SPEED WAS 75 MPH (LEGAL LIMIT). WILL VIDEO TAPE THIS ON THE NEXT TRIP.VERY FRIGHTENING! HAS BEEN TO DEALER THREE TIMES RE THIS ISSUE: THEY HAVE NO ANSWERS AND NO REPAIR OFFERED.
NHTSA ODI #10823162
1,400 miles · Jan 29, 2016
Engine
TL* THE CONTACT OWNS A 2016 HONDA PILOT. THE CONTACT STATED THAT AN ABNORMAL SOUND WAS HEARD, AFTER THE VEHICLE WAS STARTED AND THE VEHICLE TEMPERATURE WARM. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN CONFIRMED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2016 HONDA PILOT. THE CONTACT STATED THAT AN ABNORMAL SOUND WAS HEARD, AFTER THE VEHICLE WAS STARTED AND THE VEHICLE TEMPERATURE WARM. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN CONFIRMED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,400.
NHTSA ODI #10823005
2,800 miles · Jan 26, 2016
StructureUnknown Or Other
WHILE DRIVING STRAIGHT ON A HIGHWAY, I HEARD A LOUD NOISE FROM THE TOP OF MY CAR. THE SUNROOF GLASS HAD SPONTANEOUSLY SHATTERED. WHEN I LOOKED THROUGH MY REAR VIEW MIRROR I COULD SEE SOME PIECES FLYING. THANKFULLY, THE CAR BEHIND ME WAS FAR AWAY ENOUGH THAT THEY WERE NOT HIT BY THESE GLASS PIECES AND ALSO HAD MY INTERIOR SLIDER …
Read full complaint
WHILE DRIVING STRAIGHT ON A HIGHWAY, I HEARD A LOUD NOISE FROM THE TOP OF MY CAR. THE SUNROOF GLASS HAD SPONTANEOUSLY SHATTERED. WHEN I LOOKED THROUGH MY REAR VIEW MIRROR I COULD SEE SOME PIECES FLYING. THANKFULLY, THE CAR BEHIND ME WAS FAR AWAY ENOUGH THAT THEY WERE NOT HIT BY THESE GLASS PIECES AND ALSO HAD MY INTERIOR SLIDER CLOSED. A SERIOUS ACCIDENT COULD HAVE OCCURRED IF BOTH MY SLIDER WASN'T CLOSED AND/OR THE CAR BEHIND ME WAS CLOSE TO ME. I'VE HAD THE CAR FOR LESS THAN 3 MONTHS, I CONTACTED HONDA AND ADVISED THEM OF THE INCIDENT AND BROUGHT IT IN TO THEIR SERVICE DEPARTMENT. THEY CLAIMED TO HAVE NEVER HEARD OF ANYTHING LIKE THIS HAPPENING BEFORE. THEY HAVE ORDERED A REPLACEMENT GLASS FOR MY SUNROOF. I'M STILL WAITING FOR IT COME IN. I ALSO WENT ONLINE AND RESEARCHED SUNROOFS BREAKING OUT OF NOWHERE AND DID COME ACROSS MANY OTHER SIMILAR COMPLAINTS. IT SEEMS THAT IT MAY BE HAPPENING MORE FREQUENTLY WITH NEWER VEHICLES BECAUSE THEY ARE BUILT LIGHTER WITH THINNER METALS AND THINNER GLASS. THE GLASS USED ON SUNROOFS MORE COMMONLY IS TEMPERED GLASS, NOT LAMINATED GLASS. TEMPERED GLASS IS MORE PRONE TO SHATTERING WHEN PRESSURE BUILDS UP INSIDE THE CAR. WHEN I SPOKE TO HONDA CORPORATE AND THE DEALER, NEITHER ONE COULD TELL ME WHAT KIND OF GLASS WAS ON THE SUNROOF BECAUSE THEY DIDN'T KNOW. I HOPE THIS MATTER CAN BE FURTHER LOOKED INTO. I HOPE IT DOESN'T HAPPEN AGAIN. THIS WAS A VERY FRIGHTENING EXPERIENCE THAT COULD HAVE VERY EASILY BEEN WORSE.
NHTSA ODI #10822375
1,000 miles · Jan 6, 2016
Electrical SystemEngineFuel/propulsion System
ON NOVEMBER 10, 2015, AT APPROXIMATELY 5:30PM, MY WIFE AND I WERE TRAVELING ON NORTH I-75 IN SOUTHWEST OHIO. BESIDES OURSELVES, WE HAD OUR TWO YOUNG GRANDCHILDREN IN THE CAR. THE CAR'S COMPUTER STARTED DISPLAYING A CHANGING SERIES OF WARNINGS GENERALLY INDICATING VARIOUS SYSTEM FAILURES. THE CAR BASICALLY STARTED TO SHUT DOWN. S…
Read full complaint
ON NOVEMBER 10, 2015, AT APPROXIMATELY 5:30PM, MY WIFE AND I WERE TRAVELING ON NORTH I-75 IN SOUTHWEST OHIO. BESIDES OURSELVES, WE HAD OUR TWO YOUNG GRANDCHILDREN IN THE CAR. THE CAR'S COMPUTER STARTED DISPLAYING A CHANGING SERIES OF WARNINGS GENERALLY INDICATING VARIOUS SYSTEM FAILURES. THE CAR BASICALLY STARTED TO SHUT DOWN. SINCE WE WERE IN THE FAR RIGHT LANE, MY WIFE WAS ABLE TO COAST OVER TO THE SHOULDER. IF WE HAD BEEN TRAVELING IN THE MIDDLE OR LEFT LANE OF TRAFFIC, THERE WOULD HAVE BEEN LITTLE IF ANY CHANCE OF MOVING OVER TO THE CURB. THE CAR, WITH TWO YOUNG CHILDREN IN THE BACK SEAT, WOULD HAVE SHUT DOWN LEAVING US IN THE PATH OF VERY FAST MOVING CARS AND TRUCKS. THE ONLY OUTCOME WAS A POTENTIALLY DEADLY HIGH-SPEED REAR END COLLISION. WE HAD TO HAVE THE CAR TOWED TO OUR HONDA DEALER APPROXIMATELY 40 MILES AWAY. ON NOVEMBER 27, THE DAY AFTER THANKSGIVING, THE SAME FAILURE OCCURRED AT APPROXIMATELY 2:30PM. THIS TIME WE WERE 400 MILES FROM HOME TRAVELING EAST ON HIGHWAY 11-E, BETWEEN GREENEVILLE AND JOHNSON CITY, TENNESSEE. I CAUGHT THE FAILURE EARLY ENOUGH BEFORE THE ENGINE SHUT DOWN AND WAS ABLE TO COAST THE CAR TO A PARKING LOT OF AN OUT-OF-BUSINESS STORE. THIS TIME INSTEAD OF TWO YOUNG CHILDREN, WE HAD TWO ELDERLY GREAT GRANDPARENTS. THE DEALER THAT HANDLED THE FIRST INCIDENT DIAGNOSED THE PROBLEM AS A SOFTWARE ISSUE. HOWEVER, THE SECOND DEALER DIAGNOSED IT AS A FUEL PUMP RELAY NOT PROPERLY CONNECTED. THIS RELAY REQUIRES A SPECIAL TOOL TO INSTALL IT. SEE ATTACHED LETTER WITH ATTACHMENTS FOR ALL DETAILS INCLUDING SERVICE INVOICES.
NHTSA ODI #10818535
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration