NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
290 reportsClear category filter16,000 miles · Jul 24, 2017
Fuel/propulsion SystemUnknown Or OtherVehicle Speed Control
MY FAMILY TRAVELED IN THIS VEHICLE TO CARLSBAD LAST WEEK FOR VACATION, INCLUDING MYSELF, MY WIFE, OUR 13 YEAR OLD DAUGHTER AND 11 YEAR OLD SON. THE VEHICLE WORKED PERFECTLY UNTIL WE WERE ON OUR WAY HOME SATURDAY, JULY 22, 2017. WE WERE ON I-10 APPROXIMATELY 1 HOUR EAST OF PHOENIX IN THE RIGHT LANE WITH THE CRUSE SET AT THE 75M…
Read full complaint
MY FAMILY TRAVELED IN THIS VEHICLE TO CARLSBAD LAST WEEK FOR VACATION, INCLUDING MYSELF, MY WIFE, OUR 13 YEAR OLD DAUGHTER AND 11 YEAR OLD SON. THE VEHICLE WORKED PERFECTLY UNTIL WE WERE ON OUR WAY HOME SATURDAY, JULY 22, 2017. WE WERE ON I-10 APPROXIMATELY 1 HOUR EAST OF PHOENIX IN THE RIGHT LANE WITH THE CRUSE SET AT THE 75MPH SPEED LIMIT. THERE WERE NO CARS IN FRONT OF US FOR AT LEAST A MILE. ALL THE SUDDEN, WITHOUT ANY WARNING WHATSOEVER, NEARLY ALL THE VEHICLE SYSTEM LIGHTS CAME ON AND THE VEHICLE SLOWED AT AN EMERGENCY RATE DOWN TO APPROXIMATELY 40MPH IN ABOUT 2 SECONDS. I IMMEDIATELY HIT 'CANCEL' ON THE CRUISE AND STEPPED ON THE GAS, BUT THE VEHICLE CONTINUED TO SLOW QUICKLY. I IMMEDIATELY STARTED TO MOVE TO THE SHOULDER OF THE ROAD AND NOTICED THE 18 WHEEL TRACTOR TRAILER BEHIND US MAKE AN EMERGENCY SWERVE TO THE LEFT AND MISSED HITTING US BY INCHES. WE WERE NEARLY INVOLVED IN AN ACCIDENT THAT COULD HAVE EASILY BEEN FATAL. ALL THIS TOOK PLACE IN ABOUT A 5-10 SECOND TIMEFRAME. AFTER STOPPING ON THE SHOULDER OF THE ROAD I MADE NOTE THAT THE VEHICLE WAS SHOWING A TRANSMISSION PROBLEM, AN EMISSIONS PROBLEM, AN AWD PROBLEM AND I THINK JUST ABOUT EVERY OTHER ISSUE LIGHT WAS LIT UP. I TRIED TO GET THE VEHICLE BACK ON THE ROAD, BUT IT WOULD NOT GO ANY HIGHER THAN 3RD GEAR AND THE DASH KEPT INDICATING A TRANSMISSION AND AWD PROBLEM. I PULLED OVER AGAIN AND TURNED THE VEHICLE OFF AND BACK ON. AT THAT POINT THE ONLY INDICATOR LIGHT THAT LIT UP WAS THE EMISSION SYSTEM PROBLEM (SEE ATTACHED PICTURE). I REENTERED THE INTERSTATE AND THE TRANSMISSION WAS WORKING PROPERLY AGAIN. WE STOPPED AT THE NEXT GAS STATION AND FILLED THE GAS TANK AND UPON RESTARTING THE ENGINE THE EMISSION LIGHT WAS STILL ON. WE CAREFULLY DROVE HOME AT 65'70MPH. THE FOLLOWING DAY (SUNDAY), THE EMISSION LIGHT WAS NO LONGER ON.
NHTSA ODI #11010410
10,000 miles · Jul 17, 2017
Unknown Or Other
SUNROOF SHATTERED WHILE CLOSED UPON GETTING ON THE HIGHWAY, NOT HIT BY ANY OBJECT.
NHTSA ODI #11005975
15,000 miles · May 12, 2017
Unknown Or Other
WHILE DRIVING ON THE HIGHWAY, I ADJUSTED THE RADIO VOLUME. IT INSTANTLY WENT TO THE MAXIMUM VOLUME, AND ALL CONTROLS TO ADJUST THE VOLUME BECAME INACTIVE. THE RADIO WAS SO LOUD I FEARED MY SPEAKERS WOULD BLOW OR MY EARS WOULD BE DAMAGED. UNABLE TO TURN THE RADIO OFF, I PULLED OFF THE ROAD AND SHUT OFF THE ENGINE. AN ONLINE SEARC…
Read full complaint
WHILE DRIVING ON THE HIGHWAY, I ADJUSTED THE RADIO VOLUME. IT INSTANTLY WENT TO THE MAXIMUM VOLUME, AND ALL CONTROLS TO ADJUST THE VOLUME BECAME INACTIVE. THE RADIO WAS SO LOUD I FEARED MY SPEAKERS WOULD BLOW OR MY EARS WOULD BE DAMAGED. UNABLE TO TURN THE RADIO OFF, I PULLED OFF THE ROAD AND SHUT OFF THE ENGINE. AN ONLINE SEARCH REVEALED THAT OTHERS HAVE EXPERIENCED THE SAME PROBLEM. THERE APPEARS TO BE A SOFTWARE GLITCH THAT CAUSES THE PROBLEM TO OCCUR WHEN THE VOLUME IS ADJUSTED WHILE THE TURN SIGNAL IS ACTIVE.
NHTSA ODI #10985086
3,000 miles · Apr 26, 2017
Electrical SystemUnknown Or Other
TL* THE CONTACT OWNS A 2016 HONDA PILOT. THE CONTACT STATED THAT THE SOUND OF THE HORN WAS TOO LOW TO ALERT OTHER DRIVERS OF HIS PRESENCE WHILE DRIVING ON THE FREEWAY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE HORN WAS TOO LOW AND IT NEEDED TO BE CHANGED TO A DUAL TONE HORN. THE MANUFACTURER WAS NOTIFIE…
Read full complaint
TL* THE CONTACT OWNS A 2016 HONDA PILOT. THE CONTACT STATED THAT THE SOUND OF THE HORN WAS TOO LOW TO ALERT OTHER DRIVERS OF HIS PRESENCE WHILE DRIVING ON THE FREEWAY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE HORN WAS TOO LOW AND IT NEEDED TO BE CHANGED TO A DUAL TONE HORN. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT WAS INFORMED THAT THE DEALER WOULD NOT PAY FOR ANY MODIFICATIONS TO THE VEHICLE. THE CONTACT WAS GIVEN CASE NUMBER: 05709111. THE FAILURE MILEAGE WAS 3,000.
NHTSA ODI #10980931
13,000 miles · Feb 20, 2017
Unknown Or Other
WHEN THE REAR TAILGATE IS OPENED ELECTRONICALLY, THE TAILGATE OPENS COMPLETELY AND THEN IMMEDIATELY BEGINS THE CLOSING PROCESS (BEEPS AND THEN CLOSES). IT CAN BE STOPPED MANUALLY OTHERWISE IT WILL FINISH THE CLOSING PROCESS. IF YOU STOP IT MANUALLY, THE ELECTRONIC CLOSING SYSTEM (BUTTON ON DOOR, KEY FOB OR BUTTON BY DRIVER SEA…
Read full complaint
WHEN THE REAR TAILGATE IS OPENED ELECTRONICALLY, THE TAILGATE OPENS COMPLETELY AND THEN IMMEDIATELY BEGINS THE CLOSING PROCESS (BEEPS AND THEN CLOSES). IT CAN BE STOPPED MANUALLY OTHERWISE IT WILL FINISH THE CLOSING PROCESS. IF YOU STOP IT MANUALLY, THE ELECTRONIC CLOSING SYSTEM (BUTTON ON DOOR, KEY FOB OR BUTTON BY DRIVER SEAT) IS DISABLED. DEALER HAS REPLACED THE CONTROL UNIT BUT THAT DID NOT FIX THE PROBLEM. WE HAVE BEEN TOLD THAT THE NEXT SOLUTION WILL BE TO REPLACE THE LIFTGATE MOTOR. WE HAVE A 7YR OLD DAUGHTER AND OUR CONCERN IS THAT IT COULD BE A BIGGER ISSUE IF A SMALL PERSON IS PRESENTED WITH THE PROBLEM.
NHTSA ODI #10955587
19,000 miles · Dec 24, 2016
Unknown Or Other
1. RATTLING AT INSTRUMENT PANEL. 2. FREQUENT FREEZING OF TOUCH SCREEN, ESPECIALLY WHEN CAR IS BEING DRIVEN ON THE HIGHWAY.
NHTSA ODI #10937318
9,000 miles · Dec 20, 2016
Unknown Or OtherVisibility
LONG STORY SHORT..TODAY AROUND 4:10 PM (2016 HONDA PILOT EX-L), AS I WAS DRIVING ON THE HIGHWAY DOING 65 MPH, I HEAR A LOUD BOOM.. I'M WHAT THE [XXX]... AS I LOOK BACK IN MY REAR VIEW MIRROR, I SEE A PIECE OF THE GLASS FROM MY SUN ROOF, SLAM ONTO THE GROUND AND THE TRUCK BEHIND STARTED TO DODGE THE GLASS, AFTER THAT I STARTED TO…
Read full complaint
LONG STORY SHORT..TODAY AROUND 4:10 PM (2016 HONDA PILOT EX-L), AS I WAS DRIVING ON THE HIGHWAY DOING 65 MPH, I HEAR A LOUD BOOM.. I'M WHAT THE [XXX]... AS I LOOK BACK IN MY REAR VIEW MIRROR, I SEE A PIECE OF THE GLASS FROM MY SUN ROOF, SLAM ONTO THE GROUND AND THE TRUCK BEHIND STARTED TO DODGE THE GLASS, AFTER THAT I STARTED TO HEAR WIND NOISE FROM THE SUN ROOF. SO I TOOK A LOOK AND MY SUN ROOF GLASS WAS GONE, IF I WERE TO HAVE MY SUN ROOF COVER OPEN, THAT GLASS WOULD OF HIT ME RIGHT IN THE FACE OR EVEN IN MY EYES. AFTER GOING RESEARCH THERE WAS COUPLE SUV THAT HAVE SIMILAR BLOW OUT..HTTP://M.CARCOMPLAINTS.COM/HONDA/PILOT/2016/WINDOWS_WINDSHIELD/SUNROOF_EXPLODED.SHTML. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10936617
125 miles · Dec 14, 2016
SeatsStructureUnknown Or Other
WE CANNOT FIND A COMFORTABLE POSITION FOR DRIVING THIS CAR. IT HURTS OUR FOOT AND LEG EVERY TIME WE DRIVE IT. *TR
NHTSA ODI #10935197
24,000 miles · Dec 9, 2016
Power TrainUnknown Or Other
I WAS DRIVING WITH MY FAMILY INSIDE THE CAR I WOULD SAY BETWEEN 35 - 45 MILES / HOUR THEN I STEP ON THE GAS JUST FOR LITTLE BIT WHAT HAPPEN THE REVOLUTION WENT UP TO 3000- 4000 RPM & STAYS THERE FOR A WHILE I HEAR LIKE ENGINE NOISE SOUND & FEELS LIKE IT WENT TO STALL SO AT THIS POINT. I LOOK AT DASH BOARD STILL ON DRIVE MODE W…
Read full complaint
I WAS DRIVING WITH MY FAMILY INSIDE THE CAR I WOULD SAY BETWEEN 35 - 45 MILES / HOUR THEN I STEP ON THE GAS JUST FOR LITTLE BIT WHAT HAPPEN THE REVOLUTION WENT UP TO 3000- 4000 RPM & STAYS THERE FOR A WHILE I HEAR LIKE ENGINE NOISE SOUND & FEELS LIKE IT WENT TO STALL SO AT THIS POINT. I LOOK AT DASH BOARD STILL ON DRIVE MODE WHEN I STEP ON THE GAS IM NOT SPEEDING UP THE RPM REMAINS ON 3000 4000 RPM CAR SLOWING DOWN I HAVETO GO TO THE SIDE OF THE ROAD I PRESS THE DRIVE BUTTON IT WENT TO SPORTS MODE THE REVS CLIMB EVEN HIGHER SO I PRESS IT AGAIN TO GO TO REGULAR DRIVE MODE THAT'S THE ONLY TIME THE REVOLUTION CAME DOWN TO LESS THAN 2000 RPM ENGINE NOISE SUBSIDED. SO I THINK THE CAR UNEXPECTEDLY RANDOMLY SHIFTING TO NEUTRAL WHILE U DRIVING I HAPPEN TO ME 2 -3 TIMES. THIS IS HONDA PILOT TOURING MODEL WITH NINE SPEED ZF TRANSMISSION. I CALL HONDA USA MENTION WHAT HAPPEN BECAUSE I READ THAT THERE WAS ALOT OF COMPLAINED ABOUT THISTRANSMISSION ISSUE. IN THE ARTICLE & FORUM I READ IT WAS STATING THAT SOFTWARE UPDATE RECALL TO FIX THE PROBLEM BUT HONDA CUSTOMER SERVICE JUST ADVISE ME TO BRING THE CAR TO SERVICE I THINK THEY AWARE OF THE PROBLEM BUT TOLD ME THAT THERE IS NO RECALL TO FIX THE TRANSMISSION ISSUE ACCORDING TO HONDA USA CUSTOMER SERVICE. ALL THIS EVENT HAPPEN WHEN THE CAR IS IN MOTION IN THE CITY STREET. THANKS *TR
NHTSA ODI #10934108
4,000 miles · Aug 23, 2016
Unknown Or Other
AS I WAS DRIVING 65 MPH ON THE FREEWAY ONE NIGHT THE ENGINE SUDDENLY STARTED REVVING UP SUPER HIGH AND THE CAR BEGAN SLOWING DOWN. IT WAS QUITE FRIGHTENING. BECAUSE IT WAS DARK, IT TOOK A MINUTE TO IDENTIFY THE PROBLEM- THAT THE CAR SLIPPED INTO NEUTRAL. I SLID THE STICK BACK TO DRIVE AND RESUMED MY COMMUTE. I DIDN'T INTENTI…
Read full complaint
AS I WAS DRIVING 65 MPH ON THE FREEWAY ONE NIGHT THE ENGINE SUDDENLY STARTED REVVING UP SUPER HIGH AND THE CAR BEGAN SLOWING DOWN. IT WAS QUITE FRIGHTENING. BECAUSE IT WAS DARK, IT TOOK A MINUTE TO IDENTIFY THE PROBLEM- THAT THE CAR SLIPPED INTO NEUTRAL. I SLID THE STICK BACK TO DRIVE AND RESUMED MY COMMUTE. I DIDN'T INTENTIONALLY SWITCH GEARS BUT ACCIDENTALLY (SLIGHTLY) BUMPED THE GEAR SHIFT INTO NEUTRAL. TURNS OUT THAT THE GEAR SHIFT HAS NO RESISTANCE BETWEEN DRIVE AND NEUTRAL IN THAT IT MOVES EASILY BETWEEN BOTH GEARS WITH NO STOP MECHANISM. I TOOK IT TO THE DEALER YESTERDAY AND THEY SAID IT WAS "NORMAL," I CALLED HONDA AND THEY SAID "NO RECALLS" AND SUGGESTED I TAKE IT TO ANOTHER DEALER FOR A SECOND OPINION. COULD HONDA BE IN DENIAL OF A NEW RECALL ISSUE?
NHTSA ODI #10897918
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration