IllustrationWHILE PULLING INTO A PARKING SPOT AND PUSHING THE BRAKE LIGHTLY, THE CAR ACCELERATED UNCONTROLLABLY AND STRUCK A CONCRETE WALL. THE ENGINE REVVED UP AS IF IT WAS REALLY TAKING OFF. IT JUMPED A CURB ON THE WAY TO THE WALL, STRUCK THE BUILDING AND THEN ENGINE WENT BACK TO NORMAL RUNNING.
2016 Honda Pilot
Owner reports · Recalls · Investigations
More warning signs than most Pilot years
Owner complaints for the 2016 Honda Pilot are substantially higher than the model-year median of 239.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pilot years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1400–25K
22025–50K
18050–75K
9775–100K
74100–150K
23150K+
734 reports with mileage · 965 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 767 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 200 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports9 fire reports10 injury reports
Service Brakes complaints
29 reportsVEHICLE IS 16 MONTHS OLD WITH ONLY 5,200 MILES ON IT. BRAKING ACTION CURRENTLY SEEMS UNAFFECTED, HOWEVER, THE BRAKE FLUID RESERVOIR HAD GREEN ALGAE ON THE STRAINER, HEAVY BLACK SEDIMENT ON THE FLOOR OF RESERVOIR, AND THE FLUID WAS BROWN. THE RESERVOIR WAS NEVER OPENED UNTIL 2 DAYS AGO WHEN I NOTICED THE FLUID WAS BROWN WHILE LOO…
Read full complaint
VEHICLE IS 16 MONTHS OLD WITH ONLY 5,200 MILES ON IT. BRAKING ACTION CURRENTLY SEEMS UNAFFECTED, HOWEVER, THE BRAKE FLUID RESERVOIR HAD GREEN ALGAE ON THE STRAINER, HEAVY BLACK SEDIMENT ON THE FLOOR OF RESERVOIR, AND THE FLUID WAS BROWN. THE RESERVOIR WAS NEVER OPENED UNTIL 2 DAYS AGO WHEN I NOTICED THE FLUID WAS BROWN WHILE LOOKING THROUGH THE SIDE OF THE RESERVOIR AS I WAS CHECKING THE FLUID LEVEL AND DECIDED TO INVESTIGATE FURTHER. THE CAP WAS PROPERLY SEALED BECAUSE THERE WAS A SLIGHT SUCTION AS I BEGAN TO LIFT THE CAP AFTER TWISTING AND THE SEAL WAS IN PERFECT CONDITION. THE HONDA DEALER STATED THAT HONDA WOULD NOT COVER UNDER WARRANTY A FLUID FLUSH BECAUSE THEY ASSUME IT WAS FROM SOMETHING I DID AND FURTHER ASSUMED IT WOULD NOT BE FROM CONTAMINATED FLUID THEY PUT IN AT THE FACTORY. AS A RESULT I JUST FLUSHED THE SYSTEM MYSELF WITH DOT 3/4 SYNTHETIC FLUID. MY COMPLAINT IS THAT HONDA MAY HAVE USED CONTAMINATED BRAKE FLUID AT THE FACTORY THAT COULD HAVE AFFECTED OTHER CARS OR, IF NOT, SOMETHING SPECIFICALLY HAPPENED TO MY VEHICLE PRIOR TO MY PURCHASING OF IT FROM HONDA.
I HAVE THE HONDA AWD 2016 TOURING MODEL WITH Z TRANSMISSION. SINCE PURCHASE, THE VEHICLE WILL ACCELERATE BY ITSELF WHEN DRIVING DOWN THE SLOPE BETWEEN 25 -30 MILES PER HOUR, THE BRAKE WILL NOT STOP THE SPEEDING, AND ACTUALLY WILL REDUCE THE SPEED AND IT APPEARS TRANSMISSION WILL FORCE THE SPEED GOES UP AGAINST THE BRAKE. DURING …
Read full complaint
I HAVE THE HONDA AWD 2016 TOURING MODEL WITH Z TRANSMISSION. SINCE PURCHASE, THE VEHICLE WILL ACCELERATE BY ITSELF WHEN DRIVING DOWN THE SLOPE BETWEEN 25 -30 MILES PER HOUR, THE BRAKE WILL NOT STOP THE SPEEDING, AND ACTUALLY WILL REDUCE THE SPEED AND IT APPEARS TRANSMISSION WILL FORCE THE SPEED GOES UP AGAINST THE BRAKE. DURING THE DRIVE, AT THIS RANGE, WHEN ACCELERATE, THE VEHICLE WILL MAKE A SQUEAKY SOUND BY THE TIRE LEVEL, ALMOST FEEL THE TIRE IS TRYING TO CATCH UP WITH THE SPEED OF TRANSMISSION AND WON'T TURN AS FAST AS IT COULD AND HENCE THE SQUEAKY SOUND, THE VEHICLE IS ABOUT 24 K MILES AND VERY CHALLENGING IN DRIVING THIS CAR. NEED THIS TO BE REPLACED AS THE Z TRANSMISSION RECALL IS STARTING BY OTHER MANUFACTURES.. THE WORST IS THE SPEED OF THE CAR AT DRIVE DOWN SLOPE AND COULD KILL ANYONE DUE TO IT ACTUALLY AUTOMATICALLY START SPEEDING EVEN THOUGH MY FOOT IS ON BRAKE. *TR
I WAS DRIVING IN THE RAIN AT ABOUT 30 MILES AND HOUR TOWARDS A RED LIGHT. I BEGAN TO SLOW DOWN WITH THE BRAKES, BUT THE CAR WOULD NOT STOP AND SKIDDED RIGHT THROUGH THE RED LIGHT. I ALSO TRIED STEERING THE CAR TO THE RIGHT, BUT THE CAR WOULD NOT STEER RIGHT AND KEPT SKIDDING THROUGH THE RED LIGHT UNTIL IT SLIGHTLY HIT THE MEDIAN…
Read full complaint
I WAS DRIVING IN THE RAIN AT ABOUT 30 MILES AND HOUR TOWARDS A RED LIGHT. I BEGAN TO SLOW DOWN WITH THE BRAKES, BUT THE CAR WOULD NOT STOP AND SKIDDED RIGHT THROUGH THE RED LIGHT. I ALSO TRIED STEERING THE CAR TO THE RIGHT, BUT THE CAR WOULD NOT STEER RIGHT AND KEPT SKIDDING THROUGH THE RED LIGHT UNTIL IT SLIGHTLY HIT THE MEDIAN AND STOPPED. LUCKILY, NO ONCOMING CARS WERE COMING OR MY CAR WOULD HAVE WENT RIGHT INTO THEM. THE TIRES CLAIM TO BE "ALL WEATHER TIRES" WHICH ARE BRIDGESTONE DUELER TIRES, 245/60R18. ON OTHER OCCASIONS IN THE RAIN, I HAVE FELT THE CAR SKID WHEN TAPPING ON THE BRAKES WHILE TURNING, BUT NOT TO THE EXTENT OF YESTERDAY WHEN I COULD HAVE BEEN IN A TERRIBLE ACCIDENT. I ALSO READ ON LINE OF ANOTHER PERSON REPORTING SKIDDING WHILE TURNING IN THE RAIN IN A HONDA PILOT. SOMETHING HAPPENS WITH THIS CAR IN THE RAIN THAT CAUSES THE BRAKES TO NOT STOP THE CAR AND INSTEAD SKID AS IF IT IS ON ICE WITHOUT CONTROL OF THE STEERING AT THE SAME TIME. *TR
SINCE PURCHASING NEW, I HAVE NOTICED A PECULIAR PHENOMENON WHEREBY THE BRAKE PEDAL DEVELOPS A VERY HIGH RESISTANCE FROM THE TIME OF BEING PARKED, UNTIL THE NEXT TIME I GET IN THE VEHICLE. I WILL ROUTINELY DEPRESS THE BRAKE PEDAL TO PLACE THE VEHICLE IN PARK AT THE CONCLUSION OF A DRIVE. THE PEDAL FEELS NORMAL AT THIS POINT. A…
Read full complaint
SINCE PURCHASING NEW, I HAVE NOTICED A PECULIAR PHENOMENON WHEREBY THE BRAKE PEDAL DEVELOPS A VERY HIGH RESISTANCE FROM THE TIME OF BEING PARKED, UNTIL THE NEXT TIME I GET IN THE VEHICLE. I WILL ROUTINELY DEPRESS THE BRAKE PEDAL TO PLACE THE VEHICLE IN PARK AT THE CONCLUSION OF A DRIVE. THE PEDAL FEELS NORMAL AT THIS POINT. APPROXIMATELY 80-85% OF THE TIME UPON RE-ENTRY IN TO THE VEHICLE AFTER ALLOWING THE VEHICLE TO SIT STATIONARY (OFF) FOR 2-12 HOURS, THE BRAKE PEDAL BECOMES VERY FIRM. TO THE POINT WHERE I FEEL UNCOMFORTABLE WITH THE AMOUNT OF FORCE I MUST PRESS WITH MY FOOT, IN ORDER TO THE ENGINE TO START. I DON'T WANT TO OVER-PRESSURE THE BRAKE LINES UNNECESSARILY. HOWEVER, MOST OF THE TIME, IF I SIMPLY PRESS THE BRAKE WITH AN AVERAGE AMOUNT OF FORCE TO START THE CAR, I PRESS THE "START" BUTTON, AND THE SYSTEM WILL ONLY TURN ON TO AUX MODE, THE ENGINE STARTER WILL NOT ACTIVATE. DUE TO THE HIGHLY FIRM PEDAL, MY "ACCEPTABLE" LEVEL OF FOOT FORCE WILL NOT SUFFICIENTLY DISPLACE THE BRAKE PEDAL TO ENABLE "ENGINE START" READY MODE. I AM PERPLEXED BY THIS ODD BEHAVIOR. I HAVE NEVER EXPERIENCED THIS IN ANY OTHER VEHICLE I HAVE OWNED IN MY 17 YEARS OF DRIVING EXPERIENCE. I WOULD REALLY LIKE TO KNOW HOW THE BRAKE SYSTEM BECOMES "LOADED" IF IT IS JUST SITTING. THIS IS THE SORT OF RESULT I MIGHT EXPECT IF ONE WERE TO "PUMP" THE BRAKES WITHOUT THE ENGINE RUNNING, BUT I AM DOING NOTHING OF THE SORT. PLEASE HONDA, ADDRESS THIS. I REALLY HAVE TO WONDER IF OTHER 2016 AND NEWER PILOT AND RIDGELINE OWNERS ARE EXPERIENCING THIS.
COLLISION MITIGATION BRAKING SYSTEM (CMBS) DOES NOT WORK IN STAGE 2 OR STAGE 3. ONLY THE WARNING LIGHT COMES ON. BRAKES ARE NEVER APPLIED. GOING MORE THAN 10 MPH FASTER THAN THE CAR AHEAD OF YOU, ONLY STAGE 1 COMES ON WITH A WARNING NOTICE. NO LIGHT BRAKING FOR STAGE 2. NO HARD BRAKING FOR STAGE 3. I AM EMERGENCY VEHICLE OPERAT…
Read full complaint
COLLISION MITIGATION BRAKING SYSTEM (CMBS) DOES NOT WORK IN STAGE 2 OR STAGE 3. ONLY THE WARNING LIGHT COMES ON. BRAKES ARE NEVER APPLIED. GOING MORE THAN 10 MPH FASTER THAN THE CAR AHEAD OF YOU, ONLY STAGE 1 COMES ON WITH A WARNING NOTICE. NO LIGHT BRAKING FOR STAGE 2. NO HARD BRAKING FOR STAGE 3. I AM EMERGENCY VEHICLE OPERATOR COURSE TRAINED. I HAD SOMEONE WHO I KNOW KEEP A CONSTANT SPEED OF 30 MPH AND THEN RETESTED AGAIN GOING 50 MPH. I WOULD APPROACH GOING 10 MPH FASTER THAN THE LEAD CAR AND ONLY STAGE 1 WARNING WOULD ACTIVATE, EVEN WHEN I WAS ONLY 10 FEET AWAY BEFORE I HAD TO MANUALLY APPLY THE BRAKES HARD. APPARENTLY HONDA/ACCURA HAD AN EARLIER ISSUE WITH THE CMBS FALSELY ACTIVATING DUE TO BEING TOO SENSITIVE. THEY DID A SOFTWARE UPDATE BUT NOW IT IS NOT ACTIVATING STAGE 2 OR STAGE 3. THIS OCCURS NO MATTER WHAT SETTING ( LONG, NORMAL, SHORT) YOU HAVE THE CMBS SET TO. I BROUGHT IT IN TWICE TO THE DEALER AND ALTHOUGH THE SERVICE TECH TEST DROVE IT AND COULDN'T GET THE BRAKES TO WORK THE COMPUTER STATED EVERYTHING WAS FINE. HONDA TECH LINE WAS ALSO CALLED BY THE DEALER AND THEY SAID IF THE COMPUTER SAID THERE WAS NO ERRORS THERE IS NOTHING TO DO. I CALLED HONDA CORPORATION AND THEY ALSO SAID THERE WAS NOTHING THAT COULD BE DONE. AUTOMATIC CRUISE CONTROL WORKS SO IT CAN'T BE THE RADAR OR CAMERA. THIS IS A 2016 HONDA PILOT ELITE WITH CMBS
I MOVED CAR OUT OF DRIVEWAY SO FRIEND COULD LEAVE GARAGE. WHEN I WENT TO PUT CAR BACK IN DRIVEWAY, THE CAR WOULD NOT STOP AND HIT THE CAR IN OTHER SIDE OF GARAGE. WHEN I PUT THE CAR IN REVERSE TO MOVE AWAY FROM CAR/GARAGE THE CAR WOULD NOT STOP IN REVERSE. I TURNED THE WHEEL TO PREVENT CAR FROM HITTING TRUCKS IN DRIVEWAY ACROS…
Read full complaint
I MOVED CAR OUT OF DRIVEWAY SO FRIEND COULD LEAVE GARAGE. WHEN I WENT TO PUT CAR BACK IN DRIVEWAY, THE CAR WOULD NOT STOP AND HIT THE CAR IN OTHER SIDE OF GARAGE. WHEN I PUT THE CAR IN REVERSE TO MOVE AWAY FROM CAR/GARAGE THE CAR WOULD NOT STOP IN REVERSE. I TURNED THE WHEEL TO PREVENT CAR FROM HITTING TRUCKS IN DRIVEWAY ACROSS THE STREET I HIT NEIGHBORS MAILBOX AND BROKE TAIL LIGHT AND LEFT A PAINT SCRATCH ALONG ENTIRE DRIVER SIDE OF VEHICLE. I CALLED A TOW TRUCK DRIVE WHO SAID THERE WAS SOMETHING WRONG WITH CAR BRAKES WHEN HE MOVED CAR TO BED OF HIS TRUCK. HE USED EMERGENCY BRAKE TO STOP CAR. THE HONDA DEALER I HAD THE CAR TOWED TO WAS IN MYRTLE BEACH, SC. THE TECH SAID HE RAN ALL THE DIAGNOSTIC TESTS AND DID NOT FIND ANYTHING EXCEPT AN AC ISSUE. THE AREA SERVICE REPRESENTATIVE ALSO TESTED THE CAR AND SAID IT WAS "SAFE TO DRIVE". I DID DRIVE IT TO RALEIGH LATER IN THE WEEK AND THEN HOME TO CHANTILLY VA. I HAVE HAD NO REPEAT ISSUES BUT I AM VERY CAUTIOUS WHEN I APPLY THE BRAKES AT A LOW SPEED FOR A STOP SIGN OR RED LIGHT.
2/4/16: BACKED OUT OF GARAGE, PUT CAR IN PARK, LOWERED GARAGE DOOR. WAS ABOUT TO EXIT VEHICLE TO ADJUST PASSENGER SIDE MIRROR, CAR SURGED FORWARD, CRASHING THROUGH GARAGE DOOR. BRAKES WOULD NOT STOP VEHICLE AS IT WAS CRASHING THROUGH THE GARAGE; IMMEDIATELY APPLIED EMERGENCY BRAKES, CAR FINALLY STOPPED AGAINST SHELVING IN GARA…
Read full complaint
2/4/16: BACKED OUT OF GARAGE, PUT CAR IN PARK, LOWERED GARAGE DOOR. WAS ABOUT TO EXIT VEHICLE TO ADJUST PASSENGER SIDE MIRROR, CAR SURGED FORWARD, CRASHING THROUGH GARAGE DOOR. BRAKES WOULD NOT STOP VEHICLE AS IT WAS CRASHING THROUGH THE GARAGE; IMMEDIATELY APPLIED EMERGENCY BRAKES, CAR FINALLY STOPPED AGAINST SHELVING IN GARAGE AND WTEN BECAME WEDGED IN GARAGE. CAR EXPERIENCED SEVERE DAMAGE TO FRONT, HOOD, TOP, SIDES AND COULD NOT BE REMOVED FROM GARAGE UNTIL GARAGE DOORS WERE REMOVED BY GARAGE DOOR COMPANY THE NEXT DAY. ON 2/5/16 TOOK CAR TO HONDA DEALER. SAID THEY NEEDED TIME TO INVESTIGATE, WOULD NEED UNTIL MONDAY, 2/15 WHEN MANUFACTUERE'S REP COULD BE THERE; GAVE LOANER VEHICLE TO USE IN INTERIM. CAR STILL HAD DEALER TAG, ONE MONTH OLD. ON 2/17, RECEIVED A CALL FROM SERVICE MANAGER STATING THAT HONDA REP'S INVESTIGATION FOUND NOTHING WRONG WITH VEHICLE AND THAT I WOULD NEED TO LOOK TO MY INSURANCE COMPANY TO REPAIR VEHICLE. I WAS TOLD TO RETURN LOANER VEHICLE THAT DAY, WHICH WE DID. THERE WAS OVER $2,000 DAMAGE TO HOME; AND $8,836 DAMAGE TO VEHICLE. I FIND IT AMAZING THAT HONDA COULD FIND NOTHING WRONG WITH VEHICLE. I KNOW FOR A FACT THAT THE CAR WAS IN PARK AND NOTHING WOULD MAKE IT STOP. THE CAR IS BRAND NEW - HONDA KNOWS THAT SOMETHING IS WRONG; THERE ARE OTHER VEHICLES THAT HAVE HAD THE SAME PROBLEM. I WILL NOT FEEL SAFE IN THE CAR FOR ONE MINUTE WHEN THE REPAIRS ARE COMPLETED (TAKING 24 DAYS TO REPAIR). AND, IT IS A DAMAGED VEHICLE WITH THE DEALER TAG STILL ON IT!
2016 HONDA PILOT SURGE WHILE TRYING TO STOP ON A CITY STREET AND 2 TIMES ENDED UP PART WAY IN THE INTERSECTION. NO WARNING LIGHTS ON DASH. HAD PILOT ABOUT A MONTH. ONLY DROVE ABOUT 500 MILES. CONCERNED, SO KEEP LONGER DISTANCES IN TRAFFIC. SETUP AN APPOINTMENT TODAY WITH LOCAL DEALER TO INSPECT PER HIS SCHEDULE IN 4 DAYS.
Official recalls
826V365000 · Structure:frame And Members; Suspension:rear
Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
23V858000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
23V751000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
21V932000 · Latches/locks/linkages:hood:latch; Structure:body:hood
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
17V219000 · Fuel System, Gasoline:storage
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
16V417000 · Fuel System, Gasoline:storage:tank Assembly
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
15V668000 · Electrical System: Instrument Cluster/panel
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
15V424000 · Seat Belts:rear/other
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.