NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
170 reportsClear category filter107,000 miles · Jan 9, 2021
Fuel/propulsion System
CHECK ENGINE LIGHT ON AND WHEN DIAGNOSED BY THE REPAIR SHOP THE CODE P0456 WHICH IS VERY SMALL EVAP LEAK. THIS SHOULD HAVE BEEN TAKEN CARE OF WITH THE RECALL ON THIS CAR. THE REPAIR SHOP PRINTED ALL OF THE RECALLS AND TOLD ME MOST LIKELY IT WOULD NEED THE FUEL TANK REPLACED WHICH IS COVER UNDER A RECALL. THEY TOLD ME TO GO TO …
Read full complaint
CHECK ENGINE LIGHT ON AND WHEN DIAGNOSED BY THE REPAIR SHOP THE CODE P0456 WHICH IS VERY SMALL EVAP LEAK. THIS SHOULD HAVE BEEN TAKEN CARE OF WITH THE RECALL ON THIS CAR. THE REPAIR SHOP PRINTED ALL OF THE RECALLS AND TOLD ME MOST LIKELY IT WOULD NEED THE FUEL TANK REPLACED WHICH IS COVER UNDER A RECALL. THEY TOLD ME TO GO TO THE DEALERSHIP AND SEE OF THE RECALL WORK HAS BEEN COMPLETED. THE DEALERSHIP ADVISED THAT THE RECALL WAS DONE IN THE PAST.
NHTSA ODI #11387318
77,000 miles · Jan 5, 2021
Electrical SystemFuel/propulsion SystemPower Train
CHECK ENGINE LIGHT (CEL) APPEARS, RANDOMLY WHEN PARKED OR IN MOTION, INDICATING A PROBLEM WITH EMISSIONS SYSTEM. CEL BEGAN TO APPEAR AT APPROXIMATELY 77,000 MILES. CAR NOW HAS OVER 85,000 MILES. I PURCHASED THE VEHICLE USED, WHEN IT HAD 68,000 MILES. I HAVE NEVER DRIVEN OUTSIDE OF THE U.S.. CEL APPEARS AT VARIOUS SPEEDS BET…
Read full complaint
CHECK ENGINE LIGHT (CEL) APPEARS, RANDOMLY WHEN PARKED OR IN MOTION, INDICATING A PROBLEM WITH EMISSIONS SYSTEM. CEL BEGAN TO APPEAR AT APPROXIMATELY 77,000 MILES. CAR NOW HAS OVER 85,000 MILES. I PURCHASED THE VEHICLE USED, WHEN IT HAD 68,000 MILES. I HAVE NEVER DRIVEN OUTSIDE OF THE U.S.. CEL APPEARS AT VARIOUS SPEEDS BETWEEN 0 AND 60 MPH. WHEN IN MOTION AND CEL IS DISPLAYED, ENGINE HESITATION OCCURS CAUSING ME TO INCREASE VEHICLE SPEED AND ENGINE RPM TO ENSURE I HAVE SUFFICIENT POWER TO: COMPLETE A TURN, PASS ANOTHER VEHICLE, OR MAKE IT UP A HILL. I AM NEVER SURE I WILL HAVE ENOUGH POWER. ADDITIONALLY, THE MILEAGE ECONOMY DISPLAY CHANGES FROM SHADES OF GREEN TO SOLID WHITE. CEL REMAINS VISIBLE ON DASHBOARD UNTIL IT RANDOMLY DISAPPEARS. CEL WILL REMAIN LIT RANGING FROM 30 MINUTES TO SEVERAL DAYS AND DISAPPEAR AT VARIOUS SPEEDS. WHEN IT DISAPPEARS, ENGINE HESITATION STOPS AND ECONOMY DISPLAY RETURNS TO SHADES OF GREEN DEPENDING ON WHETHER ACCELERATING OR DECELERATING. I FIRST BELIEVED IT TO BE A PROBLEM WITH THE FUEL TANK CAP. HOWEVER, THE CAP IS A HINGED FLAP THAT RETURNS TO THE CLOSED POSITION AFTER I HAVE FINISHED REFUELING. I PREDOMINANTLY USE E87 OCTANE WITH ETHANOL. BUT E89 FUEL MAKES NO DIFFERENCE BECAUSE THE CEL AND HESITATION RANDOMLY STILL OCCUR. I HAVE NOT TAKEN TO A REPAIR SHOP BECAUSE I HAVE NOT HAD THE OPPORTUNITY TO WHEN THE CEL IS DISPLAYED. THE REPAIR SHOP STATED THEY CAN ONLY DIAGNOSE WHEN THE CEL IS DISPLAYED. SIMILAR DESCRIPTIONS FROM OTHER HONDA PILOT OWNERS CAN BE FOUND AT HTTPS://WWW.PILOTEERS.ORG/THREADS/EMISSIONS-SYSTEM-PROBLEM-CHECK-ENGINE-LIGHT.157705/.
NHTSA ODI #11386601
Mileage unknown · Jan 4, 2021
Fuel/propulsion System
WHEN MY CAR FUEL WENT DOWN TO EMPTY THE LIGHT CAME ON AND I PULLED OVER TO GET GAS. WHEN I PUSHED THE AUTOMATIC RELEASE BUTTON MY FUEL DOOR WOULD NOT OPEN. I SEARCHED UP POSSIBLE CAUSES AND FOUND A VIDEO OF A MAN DEMONSTRATING WHERE YOU CAN FIND A MANUAL LEVER TO POLE TO RELEASE THE FUEL DOOR. I FOUND THE LEVER AND PULLED IT AT …
Read full complaint
WHEN MY CAR FUEL WENT DOWN TO EMPTY THE LIGHT CAME ON AND I PULLED OVER TO GET GAS. WHEN I PUSHED THE AUTOMATIC RELEASE BUTTON MY FUEL DOOR WOULD NOT OPEN. I SEARCHED UP POSSIBLE CAUSES AND FOUND A VIDEO OF A MAN DEMONSTRATING WHERE YOU CAN FIND A MANUAL LEVER TO POLE TO RELEASE THE FUEL DOOR. I FOUND THE LEVER AND PULLED IT AT THE DOOR WOULD NOT OPEN. THANKFULLY I WAS NOT TOO FAR AWAY FROM HOME AND DROVE HOME ON MY EMPTY TANK. IF I HAD BEEN SOMEWHERE FAR AWAY THIS COULD HAVE BEEN DISASTROUS. I TOOK IT TO THE HONDA DEALER WHO HAD TO PULL APART HALF OF MY CAR TO GET TO THE PLACE TO FIX IT. I HAD ALSO READ ONLINE THAT THIS HAS HAPPENED TO OTHER HONDA PILOT OWNERS. IT SEEMS DANGEROUS.
NHTSA ODI #11386419
35,000 miles · Nov 7, 2020
Fuel/propulsion System
WHEN PRESSING THE GAS PEDAL, THE VEHICLE HAS A HESITATIONIN TO IT. MY FOOT REMAINS ON THE GAS PEDAL AND STILL HAS THE HESITATION OR JERKING MOTION, WHICH CAN BE FELT IN THE FRONT PASSENGER SEAT. WE HAD THE OIL CHANGED THE WEEK BEFORE WE LEFT TO GO OUT OF STATE. IT HAS CONTINUED ON SINCE THEN.
NHTSA ODI #11373543
53,737 miles · Nov 4, 2020
Fuel/propulsion System
A KNOWN TSB# 18-025 (FUEL INJECTOR PROBLEM) WAS OUTSIDE OUR WARRANTY AND HONDA WOULD NOT REPLACE IT. DUE TO THE FUEL INJECTOR ISSUE THE VEHICLE BURNS EXCESSIVE AMOUNTS OF GASOLINE PER TANK. I HAVE RECORDED APPROXIMATELY 160 MILES PER TANK OF FUEL. IN ADDITION TO THROWING EMISSIONS RELATED CHECK ENGINE CODES.
NHTSA ODI #11373092
55,000 miles · Oct 17, 2020
EngineFuel/propulsion SystemPower Train
MY CAR WILL DIE AFTER BEING STOPPED (EX. AT A RED LIGHT, STOP SIGN) AND WILL NOT RESTART RIGHT AWAY. SOMETIMES IT DOESN'T DIE COMPLETELY. WHEN IT DOES YOU ARE UNABLE TO PUT THE CAR INTO PARK OR ENGAGE THE EMERGENCY LIGHTS. THIS HAS HAPPENED WHERE WE WERE STOPPED AT A RED-LIGHT AND THE CAR DIED AND WOULD NOT RESTART. A CAR BEHIND…
Read full complaint
MY CAR WILL DIE AFTER BEING STOPPED (EX. AT A RED LIGHT, STOP SIGN) AND WILL NOT RESTART RIGHT AWAY. SOMETIMES IT DOESN'T DIE COMPLETELY. WHEN IT DOES YOU ARE UNABLE TO PUT THE CAR INTO PARK OR ENGAGE THE EMERGENCY LIGHTS. THIS HAS HAPPENED WHERE WE WERE STOPPED AT A RED-LIGHT AND THE CAR DIED AND WOULD NOT RESTART. A CAR BEHIND US WAS APPROACHING THE LIGHT AND SAW THAT IT WAS GREEN, QUICKLY CAME UP BEHIND US HONKING THEIR HORN AND LUCKY WAS ABLE TO MOVE TO THE OTHER LANE TO AVOID HITTING US. THIS SEAMS TO HAPPEN WHEN WE FORGET TO TURN OFF THE AUTO IDLE STOP. THIS IS SOMETHING YOU HAVE TO PUSH EVERYONE YOU START THE CAR. I TOOK THE CAR TO THE DEALER THEY PUT IN A NEW TRANSMISSION AND CHANGED THE TIMING BELT. PREVIOUSLY I HAD THE CARS FUEL INJECTORS REPLACED. AFTER ALL THIS WORK THE CAR IS STILL DYING AND IT IS HAPPENING MORE FREQUENTLY. THE DEALERSHIP SAYS THEY HAVE HEARD OF THIS PROBLEM BUT DON'T KNOW OF A FIX YET.
NHTSA ODI #11364808
88,000 miles · Oct 13, 2020
Fuel/propulsion System
BOUGHT MY HONDA IN FEBRUARY A MONTH LATER A EMISSION SYSTEM STARTED POPPING UP I HAVE REPLACED ALL 4 SENSORS MAF MAP SENSORS STILL ISNT FIXED THEY ARE TELLING ME IT'S THE FUEL INJECTORS AND I HAVE NO WARRANTY SAID IT'S A HONDA THING AND NEEDS RECALLED CAN CAUSE POOR DRIVING HONDA REALLY NEEDS TO FIX IT AND THE AWD LIGHT POPS UP …
Read full complaint
BOUGHT MY HONDA IN FEBRUARY A MONTH LATER A EMISSION SYSTEM STARTED POPPING UP I HAVE REPLACED ALL 4 SENSORS MAF MAP SENSORS STILL ISNT FIXED THEY ARE TELLING ME IT'S THE FUEL INJECTORS AND I HAVE NO WARRANTY SAID IT'S A HONDA THING AND NEEDS RECALLED CAN CAUSE POOR DRIVING HONDA REALLY NEEDS TO FIX IT AND THE AWD LIGHT POPS UP AND GOES AWAY AND COMES BACK NO MECHANICS CAN FIGURE THAT OUT
NHTSA ODI #11364168
80,000 miles · Oct 9, 2020
Electronic Stability Control (esc)Fuel/propulsion System
I'VE HAD SEVERAL ISSUES WITH MY 2016 HONDA PILOT IN THE PAST FEW MONTHS. I CURRENTLY HAVE 110K MILES ON MY VEHICLE BUT MY PROBLEMS BEGAN AT AROUND 80K. MY CHECK ENGINE LIGHT AND SEVERAL OTHER LIGHTS ILLUMINATE CONSTANTLY. AT FIRST THEY WOULD LIGHT UP AND GO AWAY. BROUGHT IT TO SERVICE. THEY SAID THERE WERE NO RECALLS AND THEY CH…
Read full complaint
I'VE HAD SEVERAL ISSUES WITH MY 2016 HONDA PILOT IN THE PAST FEW MONTHS. I CURRENTLY HAVE 110K MILES ON MY VEHICLE BUT MY PROBLEMS BEGAN AT AROUND 80K. MY CHECK ENGINE LIGHT AND SEVERAL OTHER LIGHTS ILLUMINATE CONSTANTLY. AT FIRST THEY WOULD LIGHT UP AND GO AWAY. BROUGHT IT TO SERVICE. THEY SAID THERE WERE NO RECALLS AND THEY CHANGE MY SPARK PLUGS AND TOLD ME TO DRIVE MY CAR ON AT LEAST A HALF TANK OF GAS. PROBLEM CONTINUED AND THEN MY CAR STARTED RUNNING ROUGH AND IDLING ROUGHER. I BROUGHT IT IN AGAIN AND WAS TOLD I NEEDED TO REPLACE MY FUEL INJECTORS. THAT WAS TAKEN CARE AND I STILL HAVE A CHECK ENGINE LIGHT ILLUMINATES ALONG WITH EMISSIONS SYSTEM PROBLEM WARMING AND MY CAR STILL RUNS ROUGH AND HAS TROUBLE ACCELERATING. SONG WITH ALL OF THESE ISSUES I'VE ALSO HAD TO REPLACE MY IGNITION AND KEY FOB AND MY AUTO START IS NOT WORKING. I HAVE OVER A100K ON THE CAR WHICH I UNDERSTAND CAN CAUSE WEAR AND TEAR BUT ALL OF THESE PROBLEMS FAR EXCEED THE DEFINITION OF NORMAL WEAR AND TEAR. I'D LIKE TO KNOW IF THERE IS A RECALL ON ANYTHING AND WHAT CAN BE DONE TO REMEDY THESE SITUATIONS. MY CAR IS AT SERVICE YET AGAIN TRYING TO FIND OUT WHAT IS CAUSING IT TO RUN SO ROUGH. ANY FEEDBACK WOULD BE GREATLY APPRECIATED. THANK YOU.
NHTSA ODI #11363548
69,700 miles · Oct 8, 2020
Fuel/propulsion System
THE FUEL INJECTORS FAILED JUST BEFORE 70,000 MILES ON MY 2016 PILOT AND HAD TO BE REPLACED AT A COST OF $1000. AFTER SOME RESEARCH, I HAVE DISCOVERED THIS IS A RIDICULOUSLY COMMON OCCURRENCE ON THE 2016 PILOT; SO COMMON THAT I CANNOT BELIEVE HONDA HASN'T DONE ANYTHING ABOUT IT. THE FUEL INJECTORS SHOULD NOT BE FAILING...PERIOD…
Read full complaint
THE FUEL INJECTORS FAILED JUST BEFORE 70,000 MILES ON MY 2016 PILOT AND HAD TO BE REPLACED AT A COST OF $1000. AFTER SOME RESEARCH, I HAVE DISCOVERED THIS IS A RIDICULOUSLY COMMON OCCURRENCE ON THE 2016 PILOT; SO COMMON THAT I CANNOT BELIEVE HONDA HASN'T DONE ANYTHING ABOUT IT. THE FUEL INJECTORS SHOULD NOT BE FAILING...PERIOD. I'M DISAPPOINTED WITH HONDA AND DONE WITH HONDA AFTER THIS CAR.
NHTSA ODI #11363500
52,500 miles · Sep 18, 2020
Fuel/propulsion System
MY WIFE WAS DRIVING THE 2016 PILOT BACK HOME ONE AFTERNOON(8/15/2019) AND SHE SAW THE EMISSIONS SYSTEM PROBLEM LIGHT CAME ON. THE MILES ARE EXACTLY 52500(3.5 YEARS OF OWNERSHIP). I DROVE THE PILOT TO THE HONDA DEALER NEXT DAY MORNING AND THE TECHNICIAN SAID THE FUEL INJECTORS HAVE GONE BAD AND THE COST IS AROUND $1239.48 TO REPL…
Read full complaint
MY WIFE WAS DRIVING THE 2016 PILOT BACK HOME ONE AFTERNOON(8/15/2019) AND SHE SAW THE EMISSIONS SYSTEM PROBLEM LIGHT CAME ON. THE MILES ARE EXACTLY 52500(3.5 YEARS OF OWNERSHIP). I DROVE THE PILOT TO THE HONDA DEALER NEXT DAY MORNING AND THE TECHNICIAN SAID THE FUEL INJECTORS HAVE GONE BAD AND THE COST IS AROUND $1239.48 TO REPLACE THE FUEL INJECTORS. AS WE NEED TO HAVE THE PILOT ALL THE TIME FOR OUR FAMILY FOR OUR DAILY NEEDS, I DIDN'T HAVE TIME TO TALK TO HONDA AND EXPLAIN WHAT HAPPENED. SO, I PAID THE SAID AMOUNT AND GOT IT REPAIRED IMMEDIATELY. THEN I CONTACTED HONDA BY EMAIL(CASE #09801917) TO REIMBURSE ME AND THE HONDA CUSTOMER SERVICE AGENT SAID I'M OUT OF WARRANTY AND HONDA CAN'T HELP ME IN ANY WAY. I TOLD THEM THAT FUEL INJECTORS ARE LIKE THE HEART OF A VEHICLE, AND THEY SHOULD NOT FAIL SO EARLY IN A CAR'S LIFE AND THAT THEY SHOULD RUN FOR LIFE OF THE CAR. BUT STILL THE HONDA REPRESENTATIVE INSISTED THAT MY 2016 PILOT IS OUT OF WARRANTY AND HONDA CAN'T REIMBURSE ME. I'VE ALL THE RECEIPTS OF THE WORK DONE AND CAN PROVIDE UPON REQUEST
NHTSA ODI #11359872
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration