NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
13 reportsClear category filter128,271 miles · Mar 29, 2011
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 HONDA PASSPORT. WHILE THE VEHICLE WAS BEING SERVICED THE MECHANIC ADVISED HER THAT THE PAN ROD ARM WAS DETACHED FROM THE FRAME. THE LOCAL MECHANIC ADVISED HER THAT THE VEHICLE WAS NOT REPAIRABLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO ADVISED HER THAT THE VEHICLE WAS NOT REPAIRABLE. THE CON…
Read full complaint
TL*THE CONTACT OWNS A 2000 HONDA PASSPORT. WHILE THE VEHICLE WAS BEING SERVICED THE MECHANIC ADVISED HER THAT THE PAN ROD ARM WAS DETACHED FROM THE FRAME. THE LOCAL MECHANIC ADVISED HER THAT THE VEHICLE WAS NOT REPAIRABLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO ADVISED HER THAT THE VEHICLE WAS NOT REPAIRABLE. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 128,271.
NHTSA ODI #10393594
60,000 miles · Sep 15, 2010
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2000 HONDA PASSPORT EX. THE CONTACT STATED WHEN STARTING THE VEHICLE, THE VEHICLE HAS A VERY ROUGH IDLE. AS HE DEPRESSES THE ACCELERATOR, THE ENGINE SMOOTHES OUT. THE FAILURE HAS BEEN HAPPENING FOR APPROXIMATELY A YEAR. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALER AND HE WAS ADVISED THAT THE INTAKE…
Read full complaint
TL* THE CONTACT OWNS A 2000 HONDA PASSPORT EX. THE CONTACT STATED WHEN STARTING THE VEHICLE, THE VEHICLE HAS A VERY ROUGH IDLE. AS HE DEPRESSES THE ACCELERATOR, THE ENGINE SMOOTHES OUT. THE FAILURE HAS BEEN HAPPENING FOR APPROXIMATELY A YEAR. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALER AND HE WAS ADVISED THAT THE INTAKE MANIFOLD CASKET WAS DEFECTIVE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 66,000. UPDATED 01/11/2011*LJ THE COSNUMER STATED THE VEHICLE HAS STALLED AT HIGHWAY SPEEDS. UPDATED 03/30/11
NHTSA ODI #10355748
Mileage unknown · Dec 18, 2006
Engine And Engine CoolingPower Train
TL*- THE CONTACT SAID THAT HER ENGINE WOULD NOT TURN OVER. SHE HAD THE TRANSMISSION REPLACED WITH A REBUILT TRANSMISSION. AFTER A MONTH THE LIGHTS WOULD COME ON BUT ENGINE WOULDN'T CRANK. A MECHANIC STATED THAT SHE NEEDED A CRANK SHAFT.*AK
NHTSA ODI #10176506
58,598 miles · Aug 21, 2006
Engine And Engine CoolingSteering
MAJOR AUTOMOTIVE REPAIRS PERFORMED BY DEALERSHIP WHERE PERFORMANCE LEVELS OF WORK COMPLETED ARE UNSATISFACTORY WORKMANSHIP. POWER STEERING, STEERING LINKAGE, TIE ROD ASSEMBLY, INCOMPLETE CAM BEARING REPLACEMENT RESULTING TO ENGINE FAILURE, AND ENGINE REPLACEMENT FOR A VEHICLE WITH LESS THAN 65,000 MILES. OTHER SERVICES NOT PER…
Read full complaint
MAJOR AUTOMOTIVE REPAIRS PERFORMED BY DEALERSHIP WHERE PERFORMANCE LEVELS OF WORK COMPLETED ARE UNSATISFACTORY WORKMANSHIP. POWER STEERING, STEERING LINKAGE, TIE ROD ASSEMBLY, INCOMPLETE CAM BEARING REPLACEMENT RESULTING TO ENGINE FAILURE, AND ENGINE REPLACEMENT FOR A VEHICLE WITH LESS THAN 65,000 MILES. OTHER SERVICES NOT PERFORMED OR NON-REQUESTED SERVICES PERFORMED WERE ONLY TO INCREASE REVENUE. BE ADVISED ONCE DONE, AMERICAN HONDA REFUSED ANY ASSISTANCE TO THE CONSUMER BEFORE OR AFTER REMOVAL OF VEHICLE FROM DEALERSHIP. OWNER WAS FORCED TO DISCONTINUE SERVICE FROM THE DEALERSHIP, REQUEST THE CAR TO BE REASSEMBLED AND ELECTED ALTERNATIVE SERVICES PERFORMED ELSEWHERE. CONTACTED AMERICAN HONDA IN CALIFORNIA AND RECEIVED UNSUPPORTIVE AND CAVALIER EFFORTS RESOLVING ANY OR ALL ISSUES WITH SERVICES PERFORMED IN A 6-MONTH PERIOD. (THIS IS PROBABLY THE REASON WHY HONDA ONLY OFFERS SHORT-TERM VEHICLE WARRANTIES). AMERICAN HONDA HAS NOT MADE ANY EFFORT OR ATTEMPT TO STAND BEHIND THEIR PRODUCTS... UNFORTUNATELY; I AM NOT A PARTICIPANT OF A RACING TEAM WHERE THEY HAVE APPARENT INFLUENCE. CASE NUMBER(S) AND CASE MANAGERS?? HAVE LITTLE OR NO REGARD FOR THE CUSTOMERS AND ALL DEALERSHIPS SEEM TO WORRY ABOUT IS THE MONETARY VALUES IN REVENUE. UNFORTUNATELY, I WAS A LOYAL HONDA OWNER FOR 22 YEARS, AND HONDA STOOD BEHIND THEIR PRODUCT IN THE PAST. WITHIN THE PAST 6 YEARS, HONDA HAS RECEIVED ENORMOUS PUBLICITY ABOUT THEIR AUTOMOBILES, UNFORTUNATELY, HONDA HAS DISREGARDED THEIR PAST, PRESENT CUSTOMERS WHEN PROBLEMS WITH THE VEHICLE OCCURS. UNTIL THE CUSTOMER REALIZES THE DEALERSHIP OR AMERICAN HONDA DID NOT PROVIDE ASSISTANCE RESOLVING CAR PROBLEMS IN OR OUT OF WARRANTY, CONSUMERS HAVE NO RECOURSE WHILE OR UNTIL INVOLVING THE GOVERNMENT OR COURTROOM. AMERICAN HONDA WILL CONTINUALLY SWEEP CONSUMER COMPLAINTS WITH CERTAIN VEHICLES UNDER THE RUG. *NM
NHTSA ODI #10166176
84,000 miles · Jun 15, 2005
Engine And Engine CoolingPower Train
THERE HAVE BEEN NUMEROUS INCIDENTS, BUT AT LEAST THREE OCCASIONS THAT SICK IN MY MIND. THE FEELING THAT MY VEHICLE HAD BEEN REAR ENDED, LOOKING IN THE REAR VIEW MIRROR, NO CAR BEHIND ME. I HAD MY TRUCK IN THE SHOP AT WALT'S AUTOMOTIVE ON AUBURN BLVD. AT LEAST TWO IF NOT THREE TIMES AND TOLD THEM THERE WAS SOMETHING WRONG WITH …
Read full complaint
THERE HAVE BEEN NUMEROUS INCIDENTS, BUT AT LEAST THREE OCCASIONS THAT SICK IN MY MIND. THE FEELING THAT MY VEHICLE HAD BEEN REAR ENDED, LOOKING IN THE REAR VIEW MIRROR, NO CAR BEHIND ME. I HAD MY TRUCK IN THE SHOP AT WALT'S AUTOMOTIVE ON AUBURN BLVD. AT LEAST TWO IF NOT THREE TIMES AND TOLD THEM THERE WAS SOMETHING WRONG WITH THE TRANSMISSION. EACH TIME I WAS TOLD THEY COULD FIND NOTHING WRONG. FINALLY, IN JANUARY I PUT MY TRUCK IN THE SHOP AT DON HILL AUTOMOTIVE. THEY DROVE THE TRUCK, TOLD ME THERE WAS A BAD TRANSMISSION LEAK, AND HAD IT SEND TO THE TRANSMISSION SHOP THEY USE. I WAS TOLD BY THE TRANSMISSION SHOP THAT MY TRANSMISSION WAS "FRIED" AND THAT THE TRANSMISSION WAS TOO FAR GONE TO BE REPAIRED. I WAS TOLD THAT IT WOULD TAKE APPROXIMATELY $3,000 IF NOT MORE TO REPAIR IT. DON HILL AUTOMOTIVE ALSO TOLD ME THAT IT SOUNDED LIKE MY ENGINE WAS GETTING READY TO THROW A ROD. I CONTACTED BOTH THE LOCAL HONDA AND ISUZU TO SEE IF THERE WERE ANY RECALLS. I WAS TOLD THERE WASN'T. I WAS ALSO TOLD BY DON HILL AUTOMOTIVE THAT THERE WERE NUMEROUS OTHER PROBLEMS, SUCH AS THE FLAP THAT EITHER KEEP THE ENGINE COOL OR ENABLES THE ENGINE TO WARM UP WAS STUCK OPEN,AND THAT WOULD COST APPROX. $260.00 TO REPAIR. AT THAT POINT IN TIME I WAS INFORMED THAT IT WOULD COST MORE TO REPAIR THE TRUCK THEN IT WAS WORTH. IT HAS 84,000 MILES ON IT. I EXPECTED TO GET AT LEAST TWICE THAT MUCH BEFORE HAVING THESE PROBLEMS. HELP!!! ARE THERE ANY RECALLS ON THE TRANSMISSION PROBLEM? RIGHT NOW MY TRUCK IS JUST PARKED WHERE I LIVE. I'M AFRAID TO DRIVE IT. IT HAS BEEN PARKED SINCE JANUARY
NHTSA ODI #10125325
500 miles · Apr 19, 2004
Engine And Engine Cooling
WHEN DRIVING AT AN UNDETERMINED SPEED OIL LIGHT APPEARED ON THE DASHBOARD. CONSUMER STATED THAT VEHICLE WAS BURNING TOO MUCH OIL. CONSUMER ADDED ONE QUART OF OIL EVERY 500-600 MILES. *AK
NHTSA ODI #10067326
Mileage unknown · Mar 22, 2004
Engine And Engine Cooling
WHILE STARTING UP THE VEHICLE. THE CHECK ENGINE APPEARS ON THE DASHBOARD AND REMAIN ON. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC CLEANED THE ENGINE SYSTEM TWICE. THE PROBLEM STILL OCCURS. PLEASE PROVIDE FURTHER DETAILS.
NHTSA ODI #10064843
Mileage unknown · Dec 1, 2003
Engine And Engine Cooling
I HAVE HAD MY PASSPORT FOR 2 YEARS NOW AND EVERY SINCE I BOUGHT IT I HAVE HAD THE SAME PROBLEM. I TAKE IT TO A LOCAL SHOP TO HAVE THE OIL CHANGED EVERY 3 MONTHS AND WHEN I CHECK THE OIL LEVEL ABOUT A MONTH LATER I NEED TO ADD A QUART OF OIL. THE TRUCK IS NOT LEAKING OIL,IT NEVER SMOKES, I JUST DON'T KNOW WHERE THE OIL IS GOING…
Read full complaint
I HAVE HAD MY PASSPORT FOR 2 YEARS NOW AND EVERY SINCE I BOUGHT IT I HAVE HAD THE SAME PROBLEM. I TAKE IT TO A LOCAL SHOP TO HAVE THE OIL CHANGED EVERY 3 MONTHS AND WHEN I CHECK THE OIL LEVEL ABOUT A MONTH LATER I NEED TO ADD A QUART OF OIL. THE TRUCK IS NOT LEAKING OIL,IT NEVER SMOKES, I JUST DON'T KNOW WHERE THE OIL IS GOING. I HAVE HEARD OF SIMILAR CASES AND I WOULD LIKE TO KNOW WHAT THE PROBLEM IS.*AK
NHTSA ODI #10049017
50,000 miles · Aug 20, 2003
Engine And Engine Cooling
HAD TO REPLACE ENGINE ON HONDA PASSPORT WITH LESS THAN 50,000 MILES ON CAR.*AK
NHTSA ODI #10033218
Mileage unknown · Mar 12, 2003
Engine And Engine Cooling
IF THE CONSUMER REMOVED HIS FOOT FROM THE ACCELERATOR, THE VEHICLE LOST POWER AS IF IT WOULD CUT OFF. THIS PROBLEM WAS INTERMITTENT. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM .*JB
NHTSA ODI #10011515
Official recalls
1Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration