Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1490–25K
15625–50K
12650–75K
7675–100K
105100–150K
60150K+
672 reports with mileage · 158 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 139 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 134 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
38 crash reports15 fire reports48 injury reports
What owners actually said
830 reports
60,616 miles · Jan 5, 2013
Engine
I OWN A 2007 HONDA ODYSSEY EX-L. HAD VEHICLE IN THE SHOP TODAY FOR PA STATE VEHICLE INSPECTION AND THE VEHICLE FAILED DUE TO A BROKEN FRONT AND REAR ENGINE MOUNT. VEHICLE HAS 66,000 MILES ON IT AND IS ONLY 6,000 MILES OUT OF EXTENDED WARRANTY. THIS APPEARS TO BE COMMON PROBLEM AS SEEN FROM OTHER POSTS ON THE INTERNET ...SO MUC…
Read full complaint
I OWN A 2007 HONDA ODYSSEY EX-L. HAD VEHICLE IN THE SHOP TODAY FOR PA STATE VEHICLE INSPECTION AND THE VEHICLE FAILED DUE TO A BROKEN FRONT AND REAR ENGINE MOUNT. VEHICLE HAS 66,000 MILES ON IT AND IS ONLY 6,000 MILES OUT OF EXTENDED WARRANTY. THIS APPEARS TO BE COMMON PROBLEM AS SEEN FROM OTHER POSTS ON THE INTERNET ...SO MUCH SO THAT THE MECHANIC CERTAINLY WAS AWARE OF IT TO FIND IN LESS THAN A 5 MINUTE LOOK AT THE VEHICLE WITHOUT A DRIVEABILITY COMPLAINT BY ME. NHTSA SHOULD INVESTIGATE THIS COMMON SAFETY FAILURE MODE FOR THE HONDA ODYSSEY. COSTS TO REPAIR TOTALED $1001.84 ($722.99 PARTS AND $278.85 LABOR) TO REPAIR THIS SAFETY ISSUE FOUND DURING STATE SAFETY INSPECTION. *TR
NHTSA ODI #10491529
Mileage unknown · Jan 3, 2013
SteeringSuspension
I WOULD LIKE TO FILE A COMPLAINT REGARDING THE 2007 MODEL YEAR FOR THE HONDA ODYSSEY. THE CAR CURRENTLY PULLS TO THE RIGHT WHILE DRIVING ON FLAT GROUND. THERE IS A CURRENT ISSUE WITH THE WAY THE PLANT ASSEMBLED THE STRUTS AND WE ARE NOT THE ONLY ONES WHO HAVE BEEN AFFECTED AS I HAVE LOOKED ONLINE AND FOUND OTHER DRIVERS AFFECTED…
Read full complaint
I WOULD LIKE TO FILE A COMPLAINT REGARDING THE 2007 MODEL YEAR FOR THE HONDA ODYSSEY. THE CAR CURRENTLY PULLS TO THE RIGHT WHILE DRIVING ON FLAT GROUND. THERE IS A CURRENT ISSUE WITH THE WAY THE PLANT ASSEMBLED THE STRUTS AND WE ARE NOT THE ONLY ONES WHO HAVE BEEN AFFECTED AS I HAVE LOOKED ONLINE AND FOUND OTHER DRIVERS AFFECTED BY THE ISSUE AS WELL. *TR
NHTSA ODI #10490961
25,000 miles · Jan 3, 2013
Service Brakes
TL* THE CONTACT OWNS A 2007 HONDA ODYSSEY. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN THE VEHICLE BEGAN TO VIBRATE AS THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOURS TIMES FOR THE FAILURE. THE ROTORS WERE RESURFACED THREE TIMES AND REPLACED ONCE. THE REPAIRS WERE PERFORMED BY THE DEALER.…
Read full complaint
TL* THE CONTACT OWNS A 2007 HONDA ODYSSEY. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN THE VEHICLE BEGAN TO VIBRATE AS THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOURS TIMES FOR THE FAILURE. THE ROTORS WERE RESURFACED THREE TIMES AND REPLACED ONCE. THE REPAIRS WERE PERFORMED BY THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 25,000. UPDATED 2/4/13 *CN UPDATED 02/22/2013 *JS
NHTSA ODI #10490888
15,000 miles · Dec 24, 2012
Electrical System
TODAY ALL THE LIGHTS ON MY CAR'S DASHBOARD START BLINKING NON-STOP. I WAS ABLE TO DRIVE THE CAR TO THE DEALERSHIP FOR REPAIR BUT THE LIGHTS WERE BLINKING THROUGHOUT THE WHOLE TRIP. *TR
NHTSA ODI #10490021
73,000 miles · Dec 21, 2012
Service Brakes
TL* THE CONTACT OWNS A 2007 HONDA ODYSSEY. THE CONTACT STATED WHILE DRIVING 45 MPH, THE VEHICLE BEGAN TO BRAKE ON ITS OWN. THE CONTACT STATED THAT THE VEHICLE SPEED DECREASED TO 15 MPH BUT THEN STOPPED COMPLETELY. THE CONTACT WAS ABLE TO SAFELY DRIVE THE VEHICLE TO HIS HOME. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND…
Read full complaint
TL* THE CONTACT OWNS A 2007 HONDA ODYSSEY. THE CONTACT STATED WHILE DRIVING 45 MPH, THE VEHICLE BEGAN TO BRAKE ON ITS OWN. THE CONTACT STATED THAT THE VEHICLE SPEED DECREASED TO 15 MPH BUT THEN STOPPED COMPLETELY. THE CONTACT WAS ABLE TO SAFELY DRIVE THE VEHICLE TO HIS HOME. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND STATED THEY COULD NOT DIAGNOSE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE; HOWEVER, THEY PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 73,000.
NHTSA ODI #10489491
45,000 miles · Dec 13, 2012
Structure
AFTER 3.5 YEARS AFTER I BOUGHT MY 2007 HONDA ODYSSEY, I NOTICED THAT THE PAINT ON THE ROOF AND ON THE TOP OF THE FRONT FENDERS STARTED PEELING OFF. I BROUGHT IT TO THE DEALER AND THEY SAID THEY CAN'T DO ANYTHING BECAUSE MY WARRANTY HAD EXPIRED. I TOLD THEM THAT I HAVE THEIR EXTENDED WARRANTY AND SHOWED THEM A COPY OF HONDA SERV…
Read full complaint
AFTER 3.5 YEARS AFTER I BOUGHT MY 2007 HONDA ODYSSEY, I NOTICED THAT THE PAINT ON THE ROOF AND ON THE TOP OF THE FRONT FENDERS STARTED PEELING OFF. I BROUGHT IT TO THE DEALER AND THEY SAID THEY CAN'T DO ANYTHING BECAUSE MY WARRANTY HAD EXPIRED. I TOLD THEM THAT I HAVE THEIR EXTENDED WARRANTY AND SHOWED THEM A COPY OF HONDA SERVICE BULLETIN # 08-031 THAT DESCRIBES THE PAINT PEELING PROBLEM AND HOW TO FIX IT. IN THE SERVICE BULLETIN, HONDA WILL FIX THE PAINT PROBLEM AND WARRANTY THE PAINT FOR 7 YEARS. THEY REFUSED TO DO ANYTHING. I CONTACTED HONDA CUSTOMER SERVICE AND THEY SAID THAT THEY WILL NOT FIX THE PAINT TO PRIMER ADHESION ISSUE. WITHOUT A SOLID PAINT COVERING ON THE VAN, IT WILL RUST PREMATURELY AND LOSE VALUE VERY FAST. THIS PAINT TO PRIMER ISSUE IS WIDESPREAD AMONG MANY HONDA VEHICLES AND MODEL YEARS AND COLORS YET THE SERVICE BULLETIN ONLY MENTIONS PAINT PEELING ON DARK BLUE 2003-2005 ODYSSEYS BUILT AT THE ALABAMA PLANT WITH VINS STARTING WITH 5FN . MY ODYSSEY IS A 2007 WITH LIGHT BLUE PAINT, WAS BUILT AT THE SAME ALABAMA PLANT AND MY VIN STARTS WITH 5FN . I HAVE THE SAME PAINT ISSUE AND THE PICTURES OF PEELING PAINT IN THE SERVICE BULLETIN ARE EXACTLY LIKE MY PROBLEM AND IN EXACTLY THE SAME SPOTS. CLEARLY THE PAINT PROBLEM IS MORE WIDESPREAD THAN HONDA IS WILLING TO ADMIT. PLEASE BRING THIS ISSUE IN BEHALF OF MANY HONDA OWNERS TO HONDA'S ATTENTION AND I HOPE THEY WILL DO THE RIGHT THING AND FIX OUR CARS AND FIX THE POTENTIAL PAINT PEELING PROBLEMS OF NEW CARS. *TR
NHTSA ODI #10488738
80,000 miles · Dec 13, 2012
EnginePower Train
THE VEHICLE IS BURNING 1 QUART OF OIL IN BETWEEN 600 AND 800 MILES. I NOW CHANGE THE OIL EVERY 3000 MILES. THE COMPUTER STILL SHOWS THAT I HAVE UPWARDS OF 40% OF THE OIL LIFE REMAINING WHEN CHANGING THE OIL.MY MECHANIC(NOT HONDA DEALERSHIP) HAS TRIED CONTACTING HONDA BUT GETS NO SOLUTION. I HAVE TRIED CONTACTING DEALER BUT THEY …
Read full complaint
THE VEHICLE IS BURNING 1 QUART OF OIL IN BETWEEN 600 AND 800 MILES. I NOW CHANGE THE OIL EVERY 3000 MILES. THE COMPUTER STILL SHOWS THAT I HAVE UPWARDS OF 40% OF THE OIL LIFE REMAINING WHEN CHANGING THE OIL.MY MECHANIC(NOT HONDA DEALERSHIP) HAS TRIED CONTACTING HONDA BUT GETS NO SOLUTION. I HAVE TRIED CONTACTING DEALER BUT THEY SAY THAT A QUART OF OIL EVERY 600 MILES IS NORMAL. CAR STALLS OUT WHEN UNDER 2 QUARTS OF OIL. HONDA RECALLED YEARS AFTER MY ODYSSEY WITH SAME ISSUE BUT HAS NOT RECALLED MY YEAR. SAME ENGINE AND COMPUTER, SAME PROBLEM. *TR
NHTSA ODI #10488651
Mileage unknown · Dec 12, 2012
Seat Belts
WE HAD RARELY USED OUR THIRD SEAT, WHEN I NOTICED THAT THE THIRD SEAT, PASSENGER-SIDE SEAT BELT HAD A RIP IN IT. IT CAME UNTHREADED STRAIGHT ACROSS THE BELT. AT FIRST I THOUGHT IT WAS OUR DOG; HOWEVER A LARGE BREED DOG COULD NOT HAVE CHEWED STRAIGHT ACROSS THE SEATBELT AND THERE WERE NO OTHER DOG TEETH MARKS ON THE BELT. BUT, …
Read full complaint
WE HAD RARELY USED OUR THIRD SEAT, WHEN I NOTICED THAT THE THIRD SEAT, PASSENGER-SIDE SEAT BELT HAD A RIP IN IT. IT CAME UNTHREADED STRAIGHT ACROSS THE BELT. AT FIRST I THOUGHT IT WAS OUR DOG; HOWEVER A LARGE BREED DOG COULD NOT HAVE CHEWED STRAIGHT ACROSS THE SEATBELT AND THERE WERE NO OTHER DOG TEETH MARKS ON THE BELT. BUT, I REPAIRED IT THINKING THAT IT WAS MY DOG AND THE DOG WAS BANNED FROM THE CAR. HOWEVER, WE HAVE CONTINUED TO HAVE THE SAME PROBLEM WITH THIS BELT. WITH THE SEATBELT RARELY BEING USED, ONCE A NEW SEATBELT IS INSTALLED, IT BEGINS TO FRAY AND BECOMES UNTHREADED STRAIGHT ACROSS THE BELT AND THEN COMES COMPLETELY APART. SOMETIMES THE FRAYING HAS BEEN ABOVE THE COVER AND EXPOSED, BUT ON SEVERAL OCCASIONS THE FRAYING BEGAN IN THE PART OF THE SEATBELT THAT IS COVERED AND INACCESSIBLE TO ANYONE. I HAVE HAD AT LEAST 5 NEW SEATBELTS AND THIS HAS HAPPENED TO EACH ONE. IN ONE CASE, A NEW SEATBELT WAS INSTALLED AND WITHOUT EVER BEING USED, THIS STILL OCCURRED. ONCE THE NEW SEATBELT WAS INSTALLED, I CHECKED THE SEATBELT DAILY, AND 7 DAYS AFTER THE NEW ONE WAS INSTALLED, IT BEGAN TO FRAY AGAIN AND THEN IT COMPLETELY SEPARATELY. THE DEALERSHIP CONTINUES TO BLAME THE USER, ALTHOUGH THESE SEATBELTS WERE NEVER OR RARELY USED. THIS WENT ON FOR OVER TWO YEARS. I HAVE NOT HAD A WORKING SEATBELT IN THAT SEAT FOR OVER ONE YEAR. NOW, THIS PAST WEEK, A SEATBELT THAT IS USED DAILY HAD THE SAME PROBLEM. THERE IS FRAYING ACROSS THE SEATBELT AND IT HAS BECOME UNUSABLE. WE CAN'T EVEN PULL THE SEATBELT BECAUSE THE FRAYED AREA GETS CAUGHT IN THE TOP SHOULDER MECHANISM. *TR
NHTSA ODI #10488634
15,769 miles · Dec 7, 2012
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2007 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE BRAKES ENGAGED INDEPENDENTLY AND THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS MOVED TO THE SHOULDER. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECUR…
Read full complaint
TL* THE CONTACT OWNS A 2007 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE BRAKES ENGAGED INDEPENDENTLY AND THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS MOVED TO THE SHOULDER. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED SEVERAL TIMES AFTER THE INITIAL FAILURE. THE MANUFACTURER WAS CONTACTED ABOUT THE PROBLEM. THE FAILURE MILEAGE WAS 15,769 AND THE CURRENT MILEAGE WAS 29,000. THE CONSUMER STATED THE BRAKES WOULD SELF-ACTIVATE RANDOMLY AND WITHOUT WARNING. WHEN HE ATTEMPTED TO ACCELERATE THE VEHICLE WOULD COME TO A STOP OR NEAR STOP; ONLY THEN WOULD THE BRAKES RELEASE. WHEN THE BRAKES LOCKED UP, IT CAUSED THE TIRES TO DRAG AS THEY WERE BEING FORCED TO ROLL. UNTIL THE CONSUMER COULD GET TO A SAFE PLACE TO STOP. ALSO, THE ROTORS AND CALIPERS WERE GENERATING HEAT.
NHTSA ODI #10487659
Mileage unknown · Nov 19, 2012
Steering
TL* THE CONTACT OWNS A 2007 HONDA ODYSSEY. THE CONTACT STATED THAT WHEN ATTEMPTING TO TURN THE STEERING WHEEL, THE WHEEL WOULD BECOME RESISTANT AND THE CONTACT EXPERIENCED GREAT DIFFICULTY IN TURNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS…
Read full complaint
TL* THE CONTACT OWNS A 2007 HONDA ODYSSEY. THE CONTACT STATED THAT WHEN ATTEMPTING TO TURN THE STEERING WHEEL, THE WHEEL WOULD BECOME RESISTANT AND THE CONTACT EXPERIENCED GREAT DIFFICULTY IN TURNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 62,891.
American Honda Motor Co., Inc. (Honda) is recalling certain 2005-2010 Honda Odyssey vehicles manufactured June 23, 2004, through September 4, 2010. In the affected vehicles, the fuel pump strainer cover may deteriorate allowing fuel to leak out.
Consequence & remedy
Consequence: A fuel leak increases the risk of a fire.
Remedy: Parts to permanently repair the affected vehicles are not currently available. Honda will notify owners with an interim letter during May 2014. A second notice was mailed to owners October 6, 2014 when the remedy became available. Any vehicles that are currently leaking from the fuel pump cover will get a replacement, original cover. All vehicles, including those receiving the interim repair, will get an improved cover when they are available. Owners may contact Honda at 1-800-999-1009. The recall numbers associated with this campaign are JD9 (inspection and/or preliminary part replacement) and JE0 (final parts replacement).
American Honda Motor Company (Honda) is recalling certain model year 2007-2008 Honda Odyssey vehicles manufactured August 8, 2006, through September 8, 2008. Due to a combination of system components and software, the Vehicle Safety Assist System (VSA) may apply the brakes unexpectedly.
Consequence & remedy
Consequence: The vehicle may suddenly and unexpectedly brake hard, and without illuminating the brake lights, increasing the risk of a crash from behind.
Remedy: Parts to remedy these vehicles will not be available until the spring of 2014. Honda will send owners an interim letter notifying them of the issue and instruct them how to prevent unintended braking. A second notification will be sent when the parts become available. Interim notification was mailed in December 2013. The recall began on April 29, 2014. Owners may contact Honda at 1-800-999-1009 or visit their website at www.recalls.honda.com. Honda's recall number is JC5.
HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2007 ODYSSEY AND ACURA RL VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS A LUBRICANT FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
Consequence & remedy
Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER SEAL FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2010. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
HONDA HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2007 AND 2008 ODYSSEY AND ELEMENT PASSENGER VEHICLES MANUFACTURED BETWEEN JULY 28, 2006 AND AUGUST 21, 2008. AIR CAN ENTER THE VSA MODULAR PUMP DURING AN INITIAL SELF-CHECK PROCESS THAT OCCURS SHORTLY AFTER EACH TIME THE ENGINE IS STARTED. IT IS POSSIBLE FOR ENOUGH AIR TO ENTER THE SYSTEM TO RESULT IN A BRAKE PEDAL THAT FEELS SOFT OR LOWER TO THE FLOOR.
Consequence & remedy
Consequence: IF THE OWNER DOES NOT HAVE ANY BRAKE SERVICE OR MAINTENANCE PERFORMED OVER A PERIOD OF MONTHS OR YEARS, THE SYSTEM CAN CONTINUE TO ACCUMULATE ENOUGH AIR TO AFFECT BRAKING PERFORMANCE, INCREASING THE RISK OF A CRASH.
Remedy: HONDA WILL NOTIFY OWNER AND HONDA DEALERS WILL REPAIR THE VSA MODULATOR BY REMOVING ANY EXISTING AIR IN THE BRAKE SYSTEM THEN APPLY SEALANT AND CAPS TO PREVENT AIR FROM ENTERING THE BRAKE SYSTEM FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 3, 2010. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE13024 · Inappropriate Autonomous Braking
Opened Jun 25, 2013 · Closed Nov 4, 2013
Status: closed (inferred from source dates) · Electronic Stability Control
In a letter dated October 31, 2013, Honda Motor Company (Honda) submitted a recall notice to NHTSA's Office of Defects Investigation describing a defect in the Vehicle Stability Assist (VSA) system in approximately 344,187 model year (MY) 2007 and 2008 Honda Odyssey vehicles produced from August 8, 2006 through September 8, 2008 (NHTSA Recall 13V-500, Honda Recall JC5).The report describes a defect condition caused by a combination of VSA system components and software that is unique to the MY 2007-2008 Honda Odyssey vehicles.The condition may result in unexpected brake application by the VSA system with no brake lamp illumination.The braking forces resulting from the condition can approach the maximum braking capability of the vehicle.Honda's investigation determined that (1) if the yaw rate sensor off-set exceeds a certain value, (2) the sensor calibration is not completed before the vehicle starts moving after start-up, and (3) the vehicle is driven in a specific manner; the VSA system may build hydraulic pressure in the brake system resulting in heavy, unexpected braking without the driver applying the brake pedal.Honda estimates that the parts necessary to correct this condition will not be available until March 2014.Pending part availability, Honda will send interim letters to affected owners including instructions to avoid the defect condition using a procedure to ensure proper VSA system calibration after each vehicle start-up, as well as instructions about what to do if unexpected brake application occurs while driving.Once the remedy parts are available, Honda will send a second notice advising owners to bring their vehicle to their dealer for installation of a redesigned yaw rate sensor.This investigation is closed.
EA09014 · Air In Brake System
Opened Oct 19, 2009 · Closed May 11, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
By letter dated March 15, 2010, American Honda Motor Corp. (HMC) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall (NHTSA Recall No. 10V-098) to address a defect in approximately 412,000 model year (MY) 2007 and 2008 Honda Odyssey and Element vehicles equipped with an ABS/VSA/TCS modulator. The recalled Odyssey vehicles were built from August 2006 August 2008.The recalled Element vehicles were built from July 2006 to July 2008. According to Honda, during an initial self-check process that occurs shortly after each engine ignition cycle, the self-diagnostic software for the VSA modulator allows a vacuum condition that can exist for several hours, allowing air to enter the VSA modulator pump.Over time, and thousands of engine ignition cycles, it is possible for enough air to enter the system to result in a brake pedal that feels soft or lower to the floor.If the customer does not have any brake service or maintenance performed over a period of months or years, the system can continue to accumulate enough air to affect braking performance.To correct the safety defect, Honda dealers will remove existing air in the brake system then apply sealant and caps to the VSA modulator to prevent air from entering the brake system, free of charge. The action taken by Honda is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances.Accordingly, this investigation is closed.
PE09024 · Air In Brake System
Opened May 13, 2009 · Closed Oct 19, 2009
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
THE OFFICE OF DEFECTS INVESTIGATION (ODI) HAS RECEIVED 69 COMPLAINTS, AND HONDA HAS RECEIVED 613 COMPLAINTS AND FIELD REPORTS, ALLEGING LOW/SOFT/SPONGY BRAKE PEDAL TRAVEL IN MODEL YEAR (MY) 2006 THROUGH 2008 HONDA ODYSSEY MINIVANS.TWENTY-SIX ODI COMPLAINTS WERE ALSO REPORTED TO HONDA, RESULTING IN A TOTAL COMPLAINT COUNT OF 656.SOME COMPLAINTS ALLEGE THAT THE CONDITION RESULTED IN EXTENDED STOPPING DISTANCES, INCLUDING SOME REPORTS OF ROLLING PAST STOP SIGNS OR TRAFFIC LIGHTS.THERE ARE 14 ALLEGED CRASHES IN THE SUBJECT VEHICLE POPULATION RELATED TO LOW/SOFT PEDALS. IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PRELIMINARY EVALUATION PE09-024, HONDA INDICATED THAT SMALL AMOUNTS OF AIR MAY ENTER THE BRAKE SYSTEM DURING INITIAL DIAGNOSTICS OF THE VEHICLE STABILITY ASSIST (VSA) MODULATOR WHILE THE PUMP IS BRIEFLY ACTUATED FOR SYSTEM DIAGNOSTICS AFTER THE ENGINE IS STARTED.THE AMOUNT OF AIR GRADUALLY INCREASES WITH EACH SUCCESSIVE ENGINE START CYCLE, RESULTING IN PROGRESSIVELY INCREASING BRAKE PEDAL STROKE.ACCORDING TO HONDA, THE CONDITION DOES NOT PRESENT A SIGNIFICANT RISK TO MOTOR VEHICLE SAFETY BECAUSE THE PEDAL STROKE GRADUALLY INCREASES, PROVIDING THE DRIVER WITH INFORMATION THAT THE BRAKE PEDAL HEIGHT IS CHANGING AND REQUIRES ATTENTION.HONDA HAS FURTHER INDICATED THAT THERE IS NO DETERIORATION OF BRAKING PERFORMANCE CAUSED BY THE SUBJECT CONDITION, EVEN THOUGH THE PEDAL HEIGHT AND FEEL ARE DIFFERENT, UNTIL PEDAL STROKE HAS REACHED THE END OF TRAVEL AND THE DRIVER CANNOT PRODUCE ANY ADDITIONAL BRAKE LINE PRESSURE.HONDA STATES THAT IT IS UNAWARE OF ANY VEHICLES THAT HAVE REACHED SUCH A CONDITION AND HONDA TESTING USING A LEAKING FIELD RETURN MODULATOR INDICATES THAT IT WOULD TAKE OVER A YEAR BEFORE THE PEDAL TRAVEL WOULD REACH ITS LIMIT DURING HARD STOPS WITH 200 N (45 LBF) OF PEDAL EFFORT - THE NOMINAL FORCE REQUIRED TO REACH ABS BRAKING MODE. ODI'S ANALYSIS OF WARRANTY DATA INDICATES THAT THE MY 2007-08 ODYSSEY VEHICLES HAVE EXPERIENCED THE ALLEGED DEFECT AT A RATE OF 0.67%.THE MY 2006 ODYSSEY VEHICLES HAVE EXPERIENCED THE ALLEGED DEFECT AT A SIGNIFICANTLY LOWER RATE (0.04%) THAN THE MY 2007-08 ODYSSEY.HONDA IMPLEMENTED A DESIGN CHANGE IN THE MY 2007 VEHICLES TO CHANGE THE VSA DIAGNOSTIC PROGRAM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-014) FOR THE MY 2007-08 ODYSSEY VEHICLES TO CONTINUE TO INVESTIGATE THE SCOPE, FREQUENCY, AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.
2007 Honda Odyssey Problems, Complaints & Recalls | Skip That Year
Illustration