1996 Honda Odyssey

SRS LIGHT CAME ON AND STAYED ON AT 73522 MI. HONDA DEALER CHECKED ALL CONNECTIONS AND WIRING, ALSO TRIED RE-PROGRAMMING-THAT DID NOT WORK. DEALER SAID THAT AIR BAGS ARE INOPERATIVE, AND THAT A NEW SRS CONTROL UNIT IS NEEDED - AT COST OF OVER $700. THE COST IS PROHIBITIVE FOR US. DEALER SAYS THEY HAVE REPLACED NUMEROUS SRS CONTROL UNITS ON ODYSSEYS. THIS INDICATES A MANUFACTURING DEFECT RENDERING KEY SAFETY SYSTEM INOPERATIVE. THE DEALER INDICATED THAT HONDA HAS NOT ISSUED A RECALL AND DOES NOT ACCEPT RESPONSIBILITY FOR FAILURE OF KEY SAFETY COMPONENT DURING NORMAL USE--THE STATED REASON IS THAT "YOU STILL HAVE YOUR SAFETY BELTS." I BELIEVE THAT THE SRS CONTROL UNIT SHOULD NOT HAVE FAILED WITHIN NORMAL LIFE OF THE VEHICLE, THE OWNER'S MANUAL SAYS THAT IT ONLY NEEDS TO BE CHECKED EVERY 10 YEARS. *NM

I HAVE A 1996 HONDA ODYSSEY LX AND IT HAS STALLED OUT MANY TIMES WITH MY FOUR YEAR OLD DAUGHTER IN ATLANTA, GA RUSH HOUR TRAFFIC. I DRIVE THIRTY MILES TO WORK EACH DAY AND IS VERY DANGEROUS TO NOT KNOW WHEN THE CAR WILL JUST QUIT. I TOOK THE CAR TO CATHERINE'S AUTOMOTIVE REPAIR & SERVICE AND THEY DETERMINED IT WAS AN ELECTRICAL PROBLEM WITH THE IGNITION SWITCH. THEY HAVE SEEN MANY OTHER HONDAS WITH THE SAME PROBLEM AND ARE AWARE OF HONDA RECALLS. MY CAR IS A '96 AND WAS NOT UNDER THE RECALL. I BELIEVE THIS IS UNFAIR THAT A CERTAIN YEAR SHOULD BE DISQUALIFIED WHEN IT HAS EXACTLY THE SAME PROBLEMS AS OTHER HONDAS. *JB

COMPLAINED ABOUT A SMALL OIL LEAK WHEN AT DLR FOR OIL CHANGE AT 90000 MI. WAS TOLD THAT CAM SHAFT SEAL WAS LEAKING. OIL LEAK HAD SATURATED TIME BELT. DLR RECOMMENDED REPLACING TIMING BELT DUE TO POSSIBLE FAILURE DUE TO OIL SATURATION. ORIGINAL OWNER, TIMING BELT HAD ALREADY BEEN REPLACED AT 60000 MI AS PART OF REGULAR MAINTENANCE. REPLACED CAMSHAFT SEAL, BALANCER SHAFT SEAL, GEAR SET, TIMING BELT, AND WATER PUMP AT COST OF $866. NOTED OTHER COMPLAINTS ON SITE OF BALANCER SHAFT SEAL PROBLEMS. *JB

BALANCER SHAFT OIL SEAL FAILED IN JANUARY 2000. OIL HOUSING OIL SEAL (O-RING) FAILED IN JANUARY 2004. BOTH FAILURES CAUSED HEAVY OIL LOSS SO VEHICLE WAS TOWED AT MY EXPENSE. SRS LIGHT IS ON. DEALER CHARGED ME $89 DIAGNOSTIC FEE FOR SRS ESTIMATE AND SAID IT WOULD COST JUST UNDER $1000 TO REPAIR. THIS FEE WAS CHARGED EVEN THOUGH I WAS PAYING FOR THE O-RING REPAIR AT THAT TIME. * CB

I PURCHASED A 1996 HONDA ODYSSEY VAN NEW IN 1996. (VIN#: [XXX]) ON MARCH 11, 2003 WE DROVE IT WITH SOME FRIENDS TO A NEIGHBORHOOD RESTAURANT WHERE WE PARKED AND LOCKED THE CAR, AND WENT IN. ABOUT 15 MINUTES LATER A MAN CAME INTO THE RESTAURANT SAYING THERE WAS A CAR ON FIRE IN THE PARKING LOT. THE DRIVER'S SIDE DOOR OF MY HONDA WAS ON FIRE. FORTUNATELY, THE RESTAURANT OWNER HAD A FIRE EXTINGUISHER, AND WE WERE ABLE TO GET THE DOOR OPEN AND PUT OUT THE FIRE. THE FIRE APPEARS TO HAVE STARTED IN THE ELECTRICAL WIRING WITHIN THE INTERIOR OF THE DRIVER'S DOOR. AS A RESULT OF THE FIRE, THE PLASTIC POWER WINDOW SWITCH ASSEMBLY WAS MELTED, RENDERING THE WINDOWS INOPERATIVE, THE PLASTIC DOOR LATCH MECHANISM THAT ENABLES THE DOOR TO BE OPENED FROM THE INSIDE WAS ALSO MELTED AND INOPERABLE. THIS RENDERED THE DRIVER'S DOOR INOPERATIVE FROM THE INSIDE. THE FIRE FILLED THE CAR WITH SMOKE FROM THE BURNING DOOR PANEL AND INSULATION, THE WIRE INSULATION, AND VARIOUS PLASTIC PARTS OF THE DOOR ASSEMBLY. I'M SURE THE SMOKE WAS QUITE TOXIC, AND HAD SOMEONE BEEN IN THE CAR AT THE TIME OF THE FIRE, THEY WOULD HAVE LIKELY BEEN OVERCOME. PARTICULARLY IF THEY WERE IN THE DRIVERS SEAT AND UNABLE TO OPEN THE DOOR OR THE WINDOW TO LET THE SMOKE OUT OR EXIT THE CAR. TO ANSWER A POTENTIAL QUESTION, WE DO NOT SMOKE, AND DO NOT ALLOW SMOKING IN THE CAR. I REALIZE THIS IS BEYOND THE WARRANTY PERIOD FOR THIS VEHICLE, AND THAT THE FAILURE OF SOME ELECTRICAL PART OF THE DOOR COULD BE DUE TO THE AGE OF THE VEHICLE, AND NORMAL DETERIORATION OF MECHANICAL PARTS WITH AGE. MY CONCERN IS THAT THOUGH SOME PART OF THE ELECTRICAL SYSTEM FAILED CATASTROPHICALLY, THE DESIGN OF THE ELECTRICAL SYSTEM WAS SUCH THAT IT DID NOT FAIL SAFELY. A FUSE OR CIRCUIT BREAKER SHOULD HAVE BEEN THE PROTECTIVE DEVICE THAT FAILED, PROTECTING THE WIRING AND THE OCCUPANTS OF THE CAR FROM A POTENTIALLY VERY HAZARDOUS, AND POSSIBLY FATAL FIRE. *NLM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR