NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
369 reportsClear category filter4,200 miles · Mar 8, 2019
EngineFuel/propulsion System
I WAS DRIVING OUR 2018 HONDA CR-V 1.5L SUV (WITH 4200 MILES ODOMETER READING AT THE TIME OF THE INCIDENT) ON SATURDAY, MARCH 2 ON IOWA STATE HIGHWAY 92 GOING APPROXIMATE 62MPH AND WERE 25 MILES FROM HOME WHEN THE VEHICLE STALLED AND LOST ENGINE POWER UNEXPECTEDLY AND WE HAD TO GO TO THE SHOULDER OF THE HIGHWAY TO GET OUT OF TRAF…
Read full complaint
I WAS DRIVING OUR 2018 HONDA CR-V 1.5L SUV (WITH 4200 MILES ODOMETER READING AT THE TIME OF THE INCIDENT) ON SATURDAY, MARCH 2 ON IOWA STATE HIGHWAY 92 GOING APPROXIMATE 62MPH AND WERE 25 MILES FROM HOME WHEN THE VEHICLE STALLED AND LOST ENGINE POWER UNEXPECTEDLY AND WE HAD TO GO TO THE SHOULDER OF THE HIGHWAY TO GET OUT OF TRAFFIC COMING BEHIND US ON THE ROAD. THE VEHICLE WOULD NOT ACCELERATE TO MORE THAN 6MPH AND THE ENGINE LIGHT WAS FLASHING WHEN ANY EFFORT TO ACCELERATE WAS MADE. WE CALLED HONDA ROADSIDE ASSISTANCE AND WERE TOLD IT WOULD BE A 4 HOUR WAIT FOR A TOW. THE OUTSIDE TEMPERATURE THAT DAY WAS 16 DEGREES ABOVE ZERO FAHRENHEIT . IT WAS 3 HOURS BEFORE A TOW SERVICE ARRIVED. OUR VEHICLE WAS TOWED TO SMART HONDA IN DES MOINES, IOWA WHICH WAS THE CLOSEST HONDA DEALER. THE SERVICE DEPARTMENT SUSPECTED THE OIL DILUTION PROBLEM AND DID AN OIL CHANGE THAT DAY. WE WERE ASKED TO KEEP OUR VEHICLE AT SMART HONDA UNTIL THEY COULD COMPLETE THE SERVICE REQUIRED. WE WERE NOT GIVEN A LOANER VEHICLE TO USE WHILE THE CR-V WAS AT THE DEALER. WE BOUGHT THIS VEHICLE IN JULY 2018 AND IN OCTOBER OF 2018 WE RECEIVED AN EMAIL FROM CONSUMER REPORTS ABOUT THE OIL DILUTION PROBLEM IN THE 2017-18 CR-V 1.5L ENGINES. WE DID NOT RECEIVE ANY INFO FROM HONDA CORPORATION UNTIL JANUARY 2019 WHEN WE GOT A LETTER ABOUT A SOFTWARE UPDATE DUE TO 'DRIVABILITY CONCERNS'. DUE TO SEVERE WEATHER IN IOWA, WE WERE NOT ABLE TO SCHEDULE A SERVICE APPOINTMENT AND THERE WAS NO EMERGENCY URGENCY IN THE LETTER WE RECEIVED. WE ARE HUGELY DISAPPOINTED AND UPSET ABOUT THIS ISSUE AND CONSIDER IT EXTREMELY UNSAFE TO HAVE A VEHICLE THAT CAN STALL AT ANYTIME AND ANYPLACE. A SAFETY RECALL ON THIS ENGINE SHOULD BE ISSUED BEFORE SOMEONE IS KILLED WITH A STALLED ENGINE OCCURRING COMPLETELY AT RANDOM.
NHTSA ODI #11185038
757 miles · Mar 8, 2019
Electrical SystemEngineFuel/propulsion System
WHILE DRIVING THE CR-V DOWN THE COUNTRY ROADS IN MY AREA THE VEHICLE STARTED TO SHAKE AND LOOSE POWER. THE CHECK ENGINE LIGHT CAME ON AND WHILE TRYING TO FIND A SAFE PLACE TO PULL OFF THE VEHICLE BEGAN LOOSING POWER. WITH THE GAS PRESSED TO THE FLOOR THE VEHICLE WOULD NOT GO ABOVE FIVE MILES AN HOUR. FINDING A LOCATION TO PUL…
Read full complaint
WHILE DRIVING THE CR-V DOWN THE COUNTRY ROADS IN MY AREA THE VEHICLE STARTED TO SHAKE AND LOOSE POWER. THE CHECK ENGINE LIGHT CAME ON AND WHILE TRYING TO FIND A SAFE PLACE TO PULL OFF THE VEHICLE BEGAN LOOSING POWER. WITH THE GAS PRESSED TO THE FLOOR THE VEHICLE WOULD NOT GO ABOVE FIVE MILES AN HOUR. FINDING A LOCATION TO PULL OVER. THE VEHICLE WAS SHUT OFF AND THE ENGINE WAS CRACKLING AND SMELLED LIKE IT WAS BURNING. GETTING OUT OF VEHICLE FOR SAFETY REASONS ALLOWED SHOWED THAT THE SMELL WAS WORSE ON THE OUTSIDE. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE IT WAS DEEMED IN OPERABLE. THEY PROVIDED ME WITH A LOANER; HOWEVER, I AM PAYING FOR A VEHICLE THAT CANNOT BE DRIVEN. THIS VEHICLE WAS ONLY OFF THE LOT FOR THREE MONTHS WITH LESS THAN 800 MILES.
NHTSA ODI #11185026
5,325 miles · Mar 7, 2019
Electrical SystemFuel/propulsion SystemService Brakes
I WAS DRIVING TO HONDA DEALER ON MARCH 6, 2019 FOR MY SECOND OIL CHANGE AS A RESULT OF ME CALLING THE DEALERSHIP AND TELLING THEM MY OIL SMELLED LIKE IT HAD GAS IN IT AGAIN. THIS IS WITH LESS THAN 700 MILES SINCE THE FIRST OIL CHANGE THAT I HAD DONE ON FEBRUARY 13, 2019. MY FIRST OIL CHANGE WAS WITH 4525 MILES, THIS WAS DONE A…
Read full complaint
I WAS DRIVING TO HONDA DEALER ON MARCH 6, 2019 FOR MY SECOND OIL CHANGE AS A RESULT OF ME CALLING THE DEALERSHIP AND TELLING THEM MY OIL SMELLED LIKE IT HAD GAS IN IT AGAIN. THIS IS WITH LESS THAN 700 MILES SINCE THE FIRST OIL CHANGE THAT I HAD DONE ON FEBRUARY 13, 2019. MY FIRST OIL CHANGE WAS WITH 4525 MILES, THIS WAS DONE AS PART OF A RECALL ON MY VEHICLE. ON THIS MARCH 6TH TRIP I WAS ABOUT 40 MILES AWAY FROM THE DEALERSHIP AND MY ACC (ADAPTIVE CRUISE CONTROL) SHUT DOWN, THE COLLISION MITIGATION SYSTEM PROBLEM AND ROAD DEPARTURE MITIGATION SYSTEM PROBLEM LIGHTS ALL CAME UP ON DASH OF CAR AND KEPT SCROLLING ON DASH. WHEN MY CAR DID THIS I WAS UNSURE, FELT UNSAFE AND WAS FRUSTRATED AS NOT KNOWING WHAT WAS GOING ON AND HOW MANY MORE PROBLEMS I AM GOING TO HAVE WITH THIS VEHICLE. I FOUND A SAFE PLACE TO PULL OVER AND CALLED THE DEALER AND TOLD HIM WHAT WAS GOING ON, HE SAID THE CAR WAS SAFE TO DRIVE BUT THOSE SYSTEMS THAT WERE SCROLLING ON DASH WEREN'T OPERATING. IT WAS 6 F OUTSIDE A CLEAR ROAD AND A SUNNY DAY IN NORTH DAKOTA. AFTER THE OIL CHANGE, I WAS TOLD THE OIL WAS HIGH AND THAT THERE WAS AGAIN GAS IN MY OIL AGAIN. AT THIS POINT I AM BEYOND FRUSTRATED AND WONDERING HOW MANY MORE PROBLEMS I WILL BE HAVING WITH THIS NEW VEHICLE AND THE NEAREST DEALERSHIP TO ME IS 100 MILES AWAY, WHICH CAUSES ME TIME AND EXPENSE TO GET TO DEALERSHIP. THIS ALSO CAUSES ME TO WONDER HOW RELIABLE THIS NEW VEHICLE CAN BE IN NORTH DAKOTA IN THE WINTER TIME AS ALSO NOT GETTING MUCH HEAT OUT OF THE HEATING SYSTEM EITHER, SO BETWEEN THE HEAT, THE GAS IN THE OIL AND ELECTRICAL PROBLEMS I AM NOT FEELING THAT THIS IS A SAFE DEPENDABLE VEHICLE TO DRIVE, AS A PERSON COULD FREEZE TO DEATH IF ENDED UP STRANDED WHEN THE CAR SHUTS DOWN AND NO HEAT, LIKE IT DID WHEN I HAD MY APPOINTMENT FOR THE RECALL ON 2-12-19 AND IT HAD TO BE PUT ON FLAT BED TRUCK TO GET RECALL DONE.
NHTSA ODI #11184913
4,000 miles · Mar 6, 2019
EngineFuel/propulsion System
2018 HONDA CR-V TOURING EDITION WITH 4,000 MILES ON IT IN KANSAS CITY, MO. AS I WAS DRIVING DOWN THE INTERSTATE ON THE WAY HOME FROM WORK, AN OVERWHELMING SMELL OF GASOLINE INVADED THE CABIN. AS I WAS ONLY A FEW MILES FROM HOME, I KEPT DRIVING, THINKING IT MAY HAVE BEEN FROM ANOTHER VEHICLE. HOWEVER, THE SMELL REMAINED. WHEN I G…
Read full complaint
2018 HONDA CR-V TOURING EDITION WITH 4,000 MILES ON IT IN KANSAS CITY, MO. AS I WAS DRIVING DOWN THE INTERSTATE ON THE WAY HOME FROM WORK, AN OVERWHELMING SMELL OF GASOLINE INVADED THE CABIN. AS I WAS ONLY A FEW MILES FROM HOME, I KEPT DRIVING, THINKING IT MAY HAVE BEEN FROM ANOTHER VEHICLE. HOWEVER, THE SMELL REMAINED. WHEN I GOT HOME AND PARKED IN THE GARAGE, I OPENED THE HOOD, AND IT WAS CLEAR MY ENGINE WAS THE SOURCE OF THE FUMES. HAD TO KEEP THE GARAGE OPEN FOR FEAR THE FUMES COULD IGNITE. VEHICLE IS CURRENTLY AT THE HONDA DEALERSHIP FOR SERVICE. DEALER CLAIMS THEY'VE NEVER EXPERIENCED THIS TYPE OF ISSUE, AND IS CURRENTLY INVESTIGATING.
NHTSA ODI #11184557
4,525 miles · Mar 5, 2019
EngineFuel/propulsion SystemPower Train
WHEN DRIVING MY VEHICLE ON THE HIGHWAY, IT SHUT DOWN AND THE SERVICE ENGINE LIGHT CAME ON, IT HAD LOST ALL POWER AND IT HAD 4525 MILES ON IT. I WAS ON MY WAY TO TAKE IT UP FOR A RECALL FOR A SOFTWARE UPDATE WITH A/C CONTROL UNIT REPLACEMENT ; DTC P0300, P0301,P0302,P0303,P0304,OR P0172. I HAD TO CALL HONDA ROAD SIDE ASSISTANC…
Read full complaint
WHEN DRIVING MY VEHICLE ON THE HIGHWAY, IT SHUT DOWN AND THE SERVICE ENGINE LIGHT CAME ON, IT HAD LOST ALL POWER AND IT HAD 4525 MILES ON IT. I WAS ON MY WAY TO TAKE IT UP FOR A RECALL FOR A SOFTWARE UPDATE WITH A/C CONTROL UNIT REPLACEMENT ; DTC P0300, P0301,P0302,P0303,P0304,OR P0172. I HAD TO CALL HONDA ROAD SIDE ASSISTANCE AND MY VEHICLE WAS HAULED ON A FLAT BED TRAILER TO GET THE RECALL FIXED. THIS RECALL ALSO INVOLVED AN OIL CHANGE, OF WHICH THEY WERE MAKING THE CUSTOMER RESPONSIBLE TO PAY FOR THE FILTER, THEY WOULD CHANGE THE FILTER WITH THE OIL CHANGE, BUT NOT PAY FOR THE FILTER WHEN CHANGING THE OIL. THERE IS ALSO AN OIL DISILLUSION PROBLEM WITH THIS VEHICLE AS THERE IS GAS GOING INTO THE OIL CAUSING A GAS SMELL IN THE OIL AND THINNING OUT THE OIL. ALSO THERE IS A HEATING PROBLEM WITH THIS VEHICLE AS THERE IS NO HEAT WHICH COMES OUT OF THE BLOWERS, WHICH WHERE I LIVE IS VERY IMPORTANT TO HAVE FOR 6-9 MONTHS OUT OF THE YEAR. I WOULD RATHER NOT HAVE AIR CONDITIONING AS I CAN ROLL DOWN MY WINDOW TO GET COOLED OFF, BUT THERE IS ONLY ONE WAY I CAN GET HEAT IN MY CAR AND THAT IS FROM RUNNING THE ENGINE AND USING THE CLIMATE CONTROL IN THE CAR. IN COLD WEATHER STATES WHEN DRIVING THIS CAR IS NOT SAFE BECAUSE WHEN IT SHUTS DOWN AND ISN'T DRIVABLE AND THE CAR ISN'T ABLE TO PRODUCE HEAT WHEN YOU ARE STRANDED A PERSON COULD FREEZE TO DEATH BECAUSE OF THE CARS INABILITY TO PRODUCE HEAT WHILE STRANDED IN THE COLD WEATHER. MY OIL ALREADY SMELLS OF GAS AND I HAVE DRIVEN IT LESS THAN 700 MILES SINCE THE OIL CHANGE, THAT WAS PERFORMED WITH THE RECALL. I AM TAKING TO HONDA DEALER AGAIN FOR AN EXAM I WAS TOLD, TO CHECK OUT SPARK PLUGS AND X-RAY THEM AND ALSO FOR ANOTHER OIL CHANGE, WITH 5219 MILES ON CAR NOW, SO WITH LESS THAN 700 MILES FROM LAST OIL CHANGE I WILL NOW BE GETTING ANOTHER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #11184408
2,000 miles · Mar 5, 2019
EngineFuel/propulsion System
AT SEVERAL POINTS IN TIME DURING NOVEMBER AND DECEMBER, I SMELLED A FOUL ODOR IN THE PASSENGER CABIN. I NOTIFIED THE DEALER AND THERE WAS A RECALL IN WHICH THEY APPLIED THE FIX. EVEN NOW, THERE APPEARS TO BE A FOUL SMELL ONCE IN A WHILE. THE HEATING SYSTEM TAKES A LONG TIME TO HEAT UP IN THE WINTER. IF IN PARK/IDLE MODE, THE…
Read full complaint
AT SEVERAL POINTS IN TIME DURING NOVEMBER AND DECEMBER, I SMELLED A FOUL ODOR IN THE PASSENGER CABIN. I NOTIFIED THE DEALER AND THERE WAS A RECALL IN WHICH THEY APPLIED THE FIX. EVEN NOW, THERE APPEARS TO BE A FOUL SMELL ONCE IN A WHILE. THE HEATING SYSTEM TAKES A LONG TIME TO HEAT UP IN THE WINTER. IF IN PARK/IDLE MODE, THE HEAT WILL AUTOMATICALLY BE LESS HOT FOR SOME REASON.
NHTSA ODI #11184324
7,648 miles · Mar 4, 2019
EngineFuel/propulsion System
FUMES IN THE CABIN WHEN STARTING DURING COOLER WEATHER. GASOLINE PRESENT IN THE ENGINE OIL, WHICH DILUTES THE OIL AND RESULTS IN LEVELS HIGHER THAN RECOMMENDED BY MANUFACTURER. CONCERNS DOCUMENTED WITH A CERTIFIED HONDA DEALER. AMENDING SOFTWARE HAS NOT SOLVED THE PROBLEM. WE WERE HOLD THAT HONDA ENGINEERS ARE WORKING ON A SOLU…
Read full complaint
FUMES IN THE CABIN WHEN STARTING DURING COOLER WEATHER. GASOLINE PRESENT IN THE ENGINE OIL, WHICH DILUTES THE OIL AND RESULTS IN LEVELS HIGHER THAN RECOMMENDED BY MANUFACTURER. CONCERNS DOCUMENTED WITH A CERTIFIED HONDA DEALER. AMENDING SOFTWARE HAS NOT SOLVED THE PROBLEM. WE WERE HOLD THAT HONDA ENGINEERS ARE WORKING ON A SOLUTION. WE HAVE BEEN TO THE DEALER 4 TIMES WITHOUT A RESOLUTION.
NHTSA ODI #11184153
12,200 miles · Feb 28, 2019
Fuel/propulsion System
TL* THE CONTACT OWNS A 2018 HONDA CR-V. THE CONTACT STATED THAT FUEL WAS LEAKING INTO THE ENGINE OIL AND DILUTING THE ENGINE OIL. IN ADDITION, THE VEHICLE STALLED AND FUEL FUMES CREPT INTO THE VEHICLE, CREATING AN ABNORMAL FUEL ODOR. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HOLMAN HONDA (12 E SUNR…
Read full complaint
TL* THE CONTACT OWNS A 2018 HONDA CR-V. THE CONTACT STATED THAT FUEL WAS LEAKING INTO THE ENGINE OIL AND DILUTING THE ENGINE OIL. IN ADDITION, THE VEHICLE STALLED AND FUEL FUMES CREPT INTO THE VEHICLE, CREATING AN ABNORMAL FUEL ODOR. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HOLMAN HONDA (12 E SUNRISE BLVD, FORT LAUDERDALE, FL 33304, (954) 764-1100) WHERE THE SOFTWARE WAS REFRESHED, BUT THE FAILURE WAS NOT REPAIRED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 12,200.
NHTSA ODI #11183261
9,700 miles · Feb 26, 2019
EngineFuel/propulsion System
I NOTICED THE OIL LEVEL BEING OVER FULL IN THE FALL OF 2018, AT THAT TIME WE HAD ABOUT 6,000 MILES ON THE VEHICLE. AT 7237 MILES I HAD MY FIRST OIL CHANGE OUR DEALER ON OCTOBER 15, 2018. I BECAME AWARE OF THE OIL DILUTION ISSUE AFTER RECEIVING A LETTER FROM HONDA REGARDING SERVICE BULLETIN 18-114. I CHECKED THE OIL LEVEL AND F…
Read full complaint
I NOTICED THE OIL LEVEL BEING OVER FULL IN THE FALL OF 2018, AT THAT TIME WE HAD ABOUT 6,000 MILES ON THE VEHICLE. AT 7237 MILES I HAD MY FIRST OIL CHANGE OUR DEALER ON OCTOBER 15, 2018. I BECAME AWARE OF THE OIL DILUTION ISSUE AFTER RECEIVING A LETTER FROM HONDA REGARDING SERVICE BULLETIN 18-114. I CHECKED THE OIL LEVEL AND FOUND IT TO BE WAY OVER-FILLED ON DECEMBER 1, 2018. I VISITED THE DEALER AND THEY ADVISED THAT A PERMANENT FIX WAS ON ITS WAY AND I SHOULD WAIT FOR A FORMAL RECALL, HOWEVER I WAS VERY CONCERNED ABOUT THE LONG TERM AFFECT ON OUR CAR'S ENGINE SO I RETURNED TO THE DEALER AND EXPRESSED MY DISPLEASURE WITH THE DELAY. THEY CALLED ME A DAY OR TWO LATER INDICATING THAT THEY WOULD PERFORM THE RECALL WORK WHICH WAS COMPLETED ON JANUARY 8, 2019. I CHECKED THE OIL LEVEL IMMEDIATELY AFTER THE OIL CHANGE AND FOUND IT WAS AT THE TOP OF THE ORANGE PLASTIC TIP OF THE DIPSTICK (I REALIZE THE FULL LEVEL IS AT THE TOP HOLE IN THE ORANGE TIP). HOPING THAT THE OIL DILUTION ISSUE WAS FIXED, I CHECKED THE OIL AGAIN TODAY, FEBRUARY 15, 2019 AFTER THE VEHICLE SAT IN THE GARAGE ALL NIGHT. THE OIL LEVEL WAS FOUND TO BE WAY ABOVE THE FULL MARK AND BEYOND THE TOP OF THE ORANGE TIP BY MORE THAN '. THE OIL DILUTION ISSUE HAS NOT BEEN CORRECTED IN MY VEHICLE. I FILED A COMPLAINT WITH HONDA MC AND RECEIVED A PHONE CALL FROM A TECH WHO INFORMED ME THAT "THERE WAS NO ISSUE WITH THE VEHICLE AND IF THE CHECK ENGINE LIGHT CAME ON TO RETURN TO THE DEALER". I EXPRESSED MY DISPLEASURE WITH THIS RESPONSE AND SHE REPEATED HER "CANNED" RESPONSE. I AM NOT THE ONLY OWNER OF THIS VEHICLE/ENGINE WITH THE SAME ISSUE. I REQUEST THAT THE NHTSA FORMALLY INVESTIGATE THIS MATTER AS THE CANADIAN AND CHINESE GOVERNMENTS HAVE AND HAVE FOUND THIS MATTER TO BE REAL.
NHTSA ODI #11182663
2,000 miles · Feb 25, 2019
Electrical SystemEngineFuel/propulsion System
THE ENGINE FAILS TO REACH FULL OPERATING TEMPERATURE. GAS IS FINDING ITS WAY INTO THE OIL PAN AND PRODUCING AN OVERFILL CONDITION. THE CABIN SMELLS OF GASOLINE. THE ELECTRONICS ARE UNREILABLE AND ARE OFTEN OF LINE
NHTSA ODI #11182461
Official recalls
5May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Mar 9, 2023
Honda (American Honda Motor Co.) is recalling certain 2017-2020 CR-V, 2018-2019 Accord and Accord Hybrid, 2018-2020 Odyssey, 2019 Insight, and 2019-2020 Acura RDX vehicles. A manufacturing issue with the front seat belts may cause the seat belt buckle channel to interfere with the release button, preventing the seat belt buckle from latching.
Consequence & remedy
Consequence: An unlatched seat belt cannot properly restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Dealers will replace the driver and front passenger seat belt buckle release buttons or the buckle assemblies as necessary, free of charge. Owner notification letters were mailed April 18, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are NDA, QDB, BDC, MDD, LD9. TDF, FDG, ODH, YDI, ZDE.
Mar 25, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
Sep 27, 2018
Honda (American Honda Motor Co.) is recalling certain 2017-2018 Honda Civic and CR-V vehicles. The magnet that controls the torque sensor output signal for the electronic power steering system may not be properly secured, allowing the magnet to become dislodged. During a full lock turn, the dislodged magnet may cause steering assist to be applied in the opposite direction.
Consequence & remedy
Consequence: The unintended steering input reduces vehicle maneuverability and increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the steering gearbox assembly, free of charge. The recall began November 9, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are C2N, P2O.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24002 · Inadvertent Automatic Emergency Braking
Opened Apr 15, 2024 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking; Forward Collision Avoidance: Sensing System: Camera; Forward Collision Avoidance: Sensing System: Radar; Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (5)
Forward Collision Avoidance: Automatic Emergency Braking
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Camera
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Radar
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE22011 · Rear Differential Seizure
Opened Nov 28, 2022 · Closed Jul 22, 2024
Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly; Power Train:axle Assembly:axle Shaft; Power Train:axle Assembly:axle Shaft:seal; Power Train:driveline:differential Unit; Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Additional source detail variants (6)
Power Train:axle Assembly:axle Shaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly:axle Shaft:seal
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:differential Unit
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
PE22003 · Inadvertent Automatic Emergency Braking
Opened Feb 21, 2022 · Closed Apr 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking; Forward Collision Avoidance: Sensing System: Camera; Forward Collision Avoidance: Sensing System: Radar; Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (5)
Forward Collision Avoidance: Automatic Emergency Braking
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Camera
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Radar
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration