2007 Honda Civic

POPPING NOISE WHILE TURNING AT 5,268 MILES. REPLACED TWO TIRES AT 19,785 MILES. NEED A FRONT END AXLE REPLACEMENT AT 31,839. DIAGNOSED AND ADJUSTED TORQUED REAR SUSPENSION NOISE AT 60,136. REPLACED REAR UPPER CONTROL ARMS 61,275. REPLACED SHOCKS, AND CV BOOTS AT 61,275. STRUTS WERE MAKING NOISE DUE TO CUPPING. STRUTS WERE REPLACED AT 61,275. TWO NEW TIRES THAT WERE RECENTLY REPLACED WERE REPLACED AGAIN. BOTH TIRES WERE FEATHERED AND MAKING NOISE. VEHICLE IS MAINTAINED IN GOOD CONDITION AND IS FOLLOWING THE MANUFACTURER'S MAINTENANCE RECOMMENDATION. CAR WAS ALIGNED AS REQUIRED BY MANUFACTURER. HOWEVER, CUPPING OR FEATHERING OF THE TIRES STILL HAPPENED. WHEN THE REAR CONTROL ARM WAS NOT REPLACED YET, THE REAR NOISE WAS SO LOUD AND DRIVING WAS BAD. THE TIRES FELT FLAT AND THE SHOCK ABSORBER DID NOT SEEM TO BE WORKING. IT IS VERY HARD TO DEAL WITH BOTH HONDA AMERICA AND KOLBE DEALER. BOTH COMPANIES TRIED TO PLAY IGNORANT OF THE ISSUES ALTHOUGH THEY KNEW IT ALL ALONG. I SPENT $1,419.11 FOR PREMATURE EXPENSES. AMERICAN HONDA BLAMED THE PREMATURE DAMAGES TO ME. AMERICAN HONDA NOR KOLBE HONDA DID NOT NOTIFY ME OF THE TECHNICAL BULLETINS THAT WERE ISSUED. ALSO, JUST BECAUSE THERE IS A TECHNICAL BULLETIN OR CORRECTIVE ACTION DOES NOT MEAN THAT THE PROBLEM WILL GO AWAY. DESIGN OF THE REAR UPPER CONTROL ARM MUST BE REVIEWED AGAIN AND TESTED FOR GEOMETRY WITH OTHER PARTS OF THE VEHICLE. HONDA AMERICA SHOULD TIGHTENED ITS QUALITY CONTROL AND QUALITY ASSURANCE SO THAT ITS MANUFACTURING FACILITY WILL NOT RELEASE CARS THAT HAVE DEFECTIVE PARTS. HONDA KNEW VERY WELL THAT THE REAR UPPER CONTROL ARMS HAVE DESIGN FLAWED STARTING WITH 2002 HONDA CIVIC. WHY ARE THEY STILL USING THIS DESIGN? IS IT BECAUSE THEY MANUFACTURED SO MUCH OF THE WRONG PARTS? THE BATTERY, AND WATER PUMP PULLEY WERE REPLACED, UPDATED 07/16/12

REAR TIRES ARE CUPPING AND THEY'VE BECOME VERY NOISY AFTER 5,000 MILES. PROBLEM FIRST NOTICED: NOVEMBER 2011. THE REAR TIRES WERE ALWAYS SLIPPERY IN TIGHT CURVES AT NORMAL SPEED. WENT TO ROUTE 23 HONDA, NJ FOR A CHECK UP ON 02/16/12. THEY BLAMED MY NEW TIRES (10000 MILES OLD). CHARGED ME $96.25 FOR A 4 WHEEL ALIGNMENT, NO PROBLEM FOUND WITH THE REAR WHEELS. I HAVE ASKED THEM ABOUT SERVICE BULLETIN 08-001 (UNEVEN OR RAPID REAR TIRE WEAR) BUT THEY DID NOT ADMIT ANY FAULT. THEY'VE SAID MY CAR DOES NOT NEED A REPAIR AS PER SB 08-001 MENTIONED ABOVE. I HAVE CONTACTED (OPENED ACCOUNT WITH) AMERICAN HONDA MOTOR CO. THEY DID NOT CALL BACK. *TR

I HAVE LESS THAN 65,000 MILES ON MY CAR. IT HAS RECEIVED REGULAR SCHEDULED MAINTENANCE FROM THE HONDA DEALERSHIP. AFTER REPLACING THE 4 ORIGINAL MICHELIN TIRES @ 38,000 MILES I HAVE HAD TO REPLACE THE REAR TIRES 3 ADDITIONAL TIMES. THE CAR HAS AN EXTREMELY LOUD "HUMMING" NOISE COMING FROM THE REAR END. IT EATS UP THE REAR TIRES QUICKLY, WHICH CAUSE THE CAR TO MISHANDLE. EACH NEW SET OF REAR TIRES WEARS OUT MORE QUICKLY THAN THE PREVIOUS ONES. I JUST BOUGHT THE 4TH NEW SET OF REAR TIRES ON 12/18/2011, DROVE DOWN TO THE LOS ANGELES AREA FROM SACRAMENTO. WHEN I RETURNED, I WENT TO THE TIRE STORE WHERE I PURCHASED THE NEW TIRES, TO GAGE/CHECK OUT ANY POSSIBLE WEAR THAT MAY HAVE OCCURRED ON THE TRIP. AT LESS THAN 1000 MILES (850 OF THESE BEING HIGHWAY MILES), THE NEW REAR TIRES WERE ALREADY DOWN TO 8/32. THE HUMMING NOISE IS SO LOUD YOU CAN NOT HAVE A NORMAL CONVERSATION IN THE CAR, OR HEAR A SIREN FOR THAT MATTER AND THE STEERING APPEARS TO BE/FEEL LOOSE. I AM AFRAID TO DRIVE THIS CAR ANY SHORT/LONG DISTANCE. *TR

I REPLACED THE ORIGINAL 2007 TIRES AT 41,887 MILES IN 2009 WITH PREMATURE WEAR. EIGHTEEN MONTHS LATER, I HAD TERRIBLE ROAD NOISE. I THOUGHT IT WAS THE BEARINGS. IT TURNS OUT THAT DESPITE AN ALIGNMENT AND PROPER ROTATION, MY TIRES WERE ALL CUPPED IN LESS THAN 26,000 MILES. THE MECHANIC MENTIONED THE PROBLEM HONDA HAD WITH THE REAR UPPER CONTROL ARMS IN THIS VEHICLE. I JUST SPENT ANOTHER $218 TO GET UPDATED REAR UPPER CONTROLS ARMS ON TOP OF $800 FOR NEW TIRES AND ANOTHER ALIGNMENT. HONDA IS RESPONSIBLE FOR THE POOR QUALITY CONTROL AND NOT ALERTING ME THAT THIS WAS A PROBLEM. THE TIRES I JUST REPLACED WERE GOOD FOR 85,000 MILES. *KB

DANGEROUS HANDLING AND EXTREME UNEVEN TIRE WEAR DUE TO DEFECTIVE REAR SUSPENSION DESIGN. HONDA ISSUES A TSB 08-001 ALERT TO ALL HONDA DEALERS, BUT REFUSES TO REPLACE DEFECTIVE REAR SUSPENSION AT MFG COST. THREE SETS OF TIRES AND A NEW SET OF REAR CONTROL ARMS LATER, AFTER JUST FINDING OUT ABOUT THE TSB 08-001 ALERT, HAS RESULTED IN OVER $3,000 OF REPAIRS TO REPLACE TIRES, BRAKES AND THE FAILED REAR SUSPENSION (CONTROL ARMS) COMPONENTS THAT HAVE CAUSED THESE ISSUES. THERE ARE MULTIPLE CLASS ACTION LAW SUITS BOTH ACTIVE AND PENDING. PLEASE CONTACT US WITH QUESTIONS AS WE HAVE DOCUMENTED ALL OUR MAINTENANCE IN GREAT DETAIL. *TR

UNSAFE HANDLING. THE REAR OF THE CAR ABNORMALLY "DARTS" LATERALLY WHEN GOING OVER CONCRETE EXPANSION JOINTS, POTHOLES OR SIMILAR ROAD IMPERFECTIONS. THIS MOMENTARY "DARTING" - OR INABILITY OF THE REAR SUSPENSION TO TRACK CORRECTLY - IS MORE PRONOUNCED WHEN CORNERING, ESPECIALLY AT HIGHWAY SPEEDS. I EXPERIENCED A SPIN-OUT (FORTUNATELY, NO COLLISION) ON A WET ROAD AT 45-50MPH DUE TO OVERCORRECTION FOR THIS "DARTING" CONDITION. IN CONJUNCTION WITH POOR REAR SUSPENSION HANDLING, ACCELERATED AND EXCESSIVE INNER REAR TIRE WEAR IS EXPERIENCED. EFFECTIVELY SHORTENING THE LIFESPAN OF A 35,000 TO 50,000 MILE TIRE BY AT LEAST HALF, IF NOT MORE. IT IS EVEN MORE EXCESSIVE AND ACCELERATED IF THE TIRES ARE NOT ROTATED. AFTER MY SPIN-OUT, I STARTED RESEARCHING 2007 CIVIC HANDLING / TIRE-WEAR ON-LINE AND IT APPEARS MANY, MANY 2006-2007 CIVIC OWNERS HAVE ONE OR BOTH OF THESE CONDITIONS AND THAT HONDA IS AWARE, BUT NOT WILLING TO RECALL THIS UNSAFE REAR UPPER CONTROL ARM DESIGN/MANUFACTURING FLAW. *TR

I ALSO SAW THERE IS A TSB RECALL (HONDA TSB 08-001) ON THE 2007 CIVIC BUT NOT ON THE SI ON REPLACING THE REAR ARMS. MY 2007 CIVIC SI HAS THE SAME VISIBLE TIRE WEAR AND TREAD CUPPING WHICH WOULD BE FIXED BY THE RECALL BUT MY CAR IS NOT INCLUDED. THE FIX IS A SIMPLE REPLACEMENT OF THE REAR CHAMBER ARMS. I BOUGHT THIS CAR BRAND NEW AND HAD IT IN ON A RECALL FOR THE 3RD GEAR. I'D LIKE THAT SAME TREATMENT AND TO BE INCLUDED ON THE RECALL TO CHANGE MY REAR CHAMBER ARMS. I'M ANNOYED THAT HONDA WILL FIX THE PROBLEM ON ALL THE OTHER TRIM LINES BUT NOT THE CIVIC SI. *TR