THIS IS A MOTORHOME WITH BOSCH DISC BRAKES. THE BRAKES DO NOT ALWAYS RELEASE AFTER A STOP. WHEN THIS HAPPENS, IT IS NOT KNOWN BY THE DRIVER UNTIL YOU SMELL BRAKES BURNING OR THE ABS LIGHT COMES ON BECAUSE IT HAS MELTED FROM THE HEAT. IT CAUSES DAMAGE TO THE BRAKING SYSTEM, BEARINGS, AND OTHER AXLE COMPONENTS. I HAVE DONE SOME…
Read full complaint
THIS IS A MOTORHOME WITH BOSCH DISC BRAKES. THE BRAKES DO NOT ALWAYS RELEASE AFTER A STOP. WHEN THIS HAPPENS, IT IS NOT KNOWN BY THE DRIVER UNTIL YOU SMELL BRAKES BURNING OR THE ABS LIGHT COMES ON BECAUSE IT HAS MELTED FROM THE HEAT. IT CAUSES DAMAGE TO THE BRAKING SYSTEM, BEARINGS, AND OTHER AXLE COMPONENTS. I HAVE DONE SOME RESEARCH ON THE PROBLEM AND IT APPEARS THAT THERE IS A PROBLEM WITH THE DISC CALIPER PISTON NOT RETRACTING OCCASIONALLY AFTER A STOP. I HAVE HAD SEVEN FAILURES THAT I KNOW ABOUT, AND KNOW THAT I HAVE HAD MORE BECAUSE I CHECK THE CONDITION OF THE COMPONENTS. OTHER OWNERS OF MOTORHOMES WITH THIS TYPE OF BRAKE CALIPER HAVE REPORTED ON THE INTERNET OF FIRES AND LOSS OF BRAKING. BOSCH WILL NOT TALK TO ANY OF US ABOUT A REAL FIX FOR THIS PROBLEM.
NHTSA ODI #10409588
3,921 miles · Sep 4, 2003
Service Brakes, Hydraulic
CONSUMER CONTACTED MANUFACTURER, WHO IDENTIFIED AND REMEDIED OPEN RECALL 02V278000. DEALER REPAIRED REAR BRAKES. RECALL DID NOT IDENTIFY SPECIFIC REMEDY VIA ARTEMIS OR NHTSA WEB SITE. CONSUMER WAS CONCERNED WHY DEALER DID NOT REMEDY RECALL BEFORE SELLING VEHICLE, AND WHETHER REMEDY APPLIED TO FRONT BRAKES AS WELL. REMEDY WAS…
Read full complaint
CONSUMER CONTACTED MANUFACTURER, WHO IDENTIFIED AND REMEDIED OPEN RECALL 02V278000. DEALER REPAIRED REAR BRAKES. RECALL DID NOT IDENTIFY SPECIFIC REMEDY VIA ARTEMIS OR NHTSA WEB SITE. CONSUMER WAS CONCERNED WHY DEALER DID NOT REMEDY RECALL BEFORE SELLING VEHICLE, AND WHETHER REMEDY APPLIED TO FRONT BRAKES AS WELL. REMEDY WAS NOT SPECIFICALLY STATED. *AK THE ABS LIGHT APPEARED ON THE DASHBOARD. THE RIGHT REAR BRAKE ASSEMBLY WAS STUCK AND BECAME VERY HOT AND WAS FOLLOWED BY SMOKE. THE ABS SENSOR BURNED OFF THE BRAKE. *SCC *JB
ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.
Consequence & remedy
Consequence: THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.
Remedy: DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
ON CERTAIN MOTORHOMES, THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION COULD CRACK AND BREAK DUE TO AN INADEQUATE WELDING PROCESS.
Consequence & remedy
Consequence: THE I-BEAMS ON THE FRONT AXLE AND THE PANARD BRACKET ON THE REAR AXLE COULD CRACK AND BREAK CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ORIGINAL I-BEAM. ALSO, DEALERS WILL WELD THE STIFFENERS FROM THE PANARD BAR BRACKET TO THE CENTER DIFFERENTIAL OF THE REAR AXLE HOUSING. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-466-6226.
ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
Consequence & remedy
Consequence: THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
VEHICLE DESCRIPTION: MOTOR HOMES. A UNIT IS AFFECTED IF THE INTERMEDIATE STEERING SHAFT IS FULLY COMPRESSED OR IS TOO SHORT TO MEET MAXIMUM EXTENSION SPECIFICATIONS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND/OR REPLACE THE INTERMEDIATE STEERING SHAFT. OWNER NOTIFICATION BEGAN AUGUST 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Holiday Rambler Ambassador Problems, Complaints & Recalls | Skip That Year
Illustration