My Street 750 has 11,800 miles. While riding at 65 mph, sudden loss of drive. Pulled over to notice the motorcycle's belt missing and debris on the belt guide and the back wheel. The bolt holding the front sprocket was out of place and made a hole in the cover. The front sprocket was out of place. I was able to walk back my path…
Read full complaint
My Street 750 has 11,800 miles. While riding at 65 mph, sudden loss of drive. Pulled over to notice the motorcycle's belt missing and debris on the belt guide and the back wheel. The bolt holding the front sprocket was out of place and made a hole in the cover. The front sprocket was out of place. I was able to walk back my path and found the belt shredded.
NHTSA ODI #11424615
38,000 miles · Mar 1, 2019
Power TrainWheels
WHILE AT HIGHWAY SPEED, 65MPH, FRONT BELT PULLEY BOLT BROKE CAUSING PULLEY TO DISLODGE. CAUSES BELT TO WRAP AROUND SHAFT AND JAM LOCKING REAR WHEEL. LUCKILY THE PULLEY DID NOT FALL OFF BELT GUARD AND HIT MYSELF OR ANY OTHER VEHICLES. THIS HAS NOT BEEN ADJUSTED DUE TO NOT NEEDING NEW BELT, AND WAS AT SAME SPECS FROM FACTORY. UPO…
Read full complaint
WHILE AT HIGHWAY SPEED, 65MPH, FRONT BELT PULLEY BOLT BROKE CAUSING PULLEY TO DISLODGE. CAUSES BELT TO WRAP AROUND SHAFT AND JAM LOCKING REAR WHEEL. LUCKILY THE PULLEY DID NOT FALL OFF BELT GUARD AND HIT MYSELF OR ANY OTHER VEHICLES. THIS HAS NOT BEEN ADJUSTED DUE TO NOT NEEDING NEW BELT, AND WAS AT SAME SPECS FROM FACTORY. UPON RESEARCH, FOUND MULTIPLE OWNERS SAME YEAR HAVING SAME FAILURES. SO FAR NO ONE HAS WRECKED OR CAUSED INJURY, HOWEVER HAD I BEEN INEXPERIENCED I LIKELY WOULD HAVE. UPON CONTACTING MY LOCAL DEALER WHERE PURCHASED I WAS TOLD THAT HUMIDITY COULD WEAKEN THE BOLT AND CAUSE FAILURE. THIS WAS FEB 27 @ 1330. WAS TOLD I WOULD HAVE TO PAY FOR DIAGNOSTICS AND REPAIR. I'M SURPRISED THAT HUMIDITY COULD BE BLAMED FOR FAILURE, AND THEN HAVE TO PAY FOR REPAIR. I OPTED TO REMOVE BROKEN BOLT ON OWN WITH BASIC TOOLS PREVIOUSLY . DID NOT WANT TO ASSIST IN WORKING WITH MAIN MANUFACTURER OR INVESTIGATE THE MULTIPLE FAILURES.
NHTSA ODI #11183385
10,000 miles · Sep 2, 2017
Power Train
2015 HARLEY DAVIDSON XG 750. PROBLEM WITH NEUTRAL LIGHT FLASHING. WHILE IN NEUTRAL. DEALER REPLACED NEUTRAL SWITCH. NOW THE LIGHT IS INOPERATIVE. OTHER HARLEY DEALERS INFORMED ME THAT THEY HAVE SEEN THE LIGHT FLASH WHILE IN DRIVE GEARS. ALSO MY TRANSMISSION HAS DEVELOPED A CHATTER WHILE SHIFTING WHEN FULLY WARMED UP. HAS BEEN AT…
Read full complaint
2015 HARLEY DAVIDSON XG 750. PROBLEM WITH NEUTRAL LIGHT FLASHING. WHILE IN NEUTRAL. DEALER REPLACED NEUTRAL SWITCH. NOW THE LIGHT IS INOPERATIVE. OTHER HARLEY DEALERS INFORMED ME THAT THEY HAVE SEEN THE LIGHT FLASH WHILE IN DRIVE GEARS. ALSO MY TRANSMISSION HAS DEVELOPED A CHATTER WHILE SHIFTING WHEN FULLY WARMED UP. HAS BEEN AT DEALER FOR 2 WEEKS.
NHTSA ODI #11021217
7,000 miles · Nov 12, 2015
Power Train
BOLT ON THE FRONT DRIVE PULLEY (MADE OF SOFT METAL) BREAKS WHILE DRIVING AND DRIVE PULLEY COMES LOOSE FROM THE ENGINE DRIVE SHAFT AND DESTROYS THE SHIELD AND DRIVE BELT, CAUSING THE MOTORCYCLE TO LOOSE ALL MOMENTUM AND LIKELY REAR TIRE LOCKUPS. CAN HAPPEN AT ANY TIME WHILE MOTORCYCLE IN BEING DRIVEN...AT ANY SPEED....THIS IS EX…
Read full complaint
BOLT ON THE FRONT DRIVE PULLEY (MADE OF SOFT METAL) BREAKS WHILE DRIVING AND DRIVE PULLEY COMES LOOSE FROM THE ENGINE DRIVE SHAFT AND DESTROYS THE SHIELD AND DRIVE BELT, CAUSING THE MOTORCYCLE TO LOOSE ALL MOMENTUM AND LIKELY REAR TIRE LOCKUPS. CAN HAPPEN AT ANY TIME WHILE MOTORCYCLE IN BEING DRIVEN...AT ANY SPEED....THIS IS EXTREMELY DANGEROUS! HTTP://WWW.HDSTREETFORUMS.COM/FORUM/HARLEY-DAVIDSON-STREET-GENERAL-DISCUSSION/11921-LIST-ISSUES-YOUR-STREET-2.HTML THIS LINK WILL SHOW YOU AN EXAMPLE OF THIS PROBLEM, HASN'T HAPPENED TO MINE, BUT IT COULD ANY TIME AND COULD CAUSE SERIOUS INJURY OR DEATH!
NHTSA ODI #10789887
650 miles · Aug 8, 2015
Fuel/propulsion SystemPower Train
THE MOTORCYCLE ,STALLS FROM A STOP AND THEN ACCELERATES VERY FAST ,THIS HAPPENS WHEN THE BIKES IS LOW ON FUEL , BUT LOW FUEL WARNING LIGHT IS ON. IT IS VEY DANGEROUS. IT STARTS OUT FROM A DEAD STOP OK , THEN STALLS REAL FAST , AND AFTER THE STALL IT ACCELERATES RAPIDLY WITH NO INPUT FROM ME THE RIDER ON THE THROTTLE CONTROL.
NHTSA ODI #10747200
198 miles · May 27, 2015
EngineFuel/propulsion SystemPower Train
I EXPERIENCED A LAG AND LEAP ISSUE. I WAS RIDING MY BIKE WITH ABOUT 83 MILES ON THE TANK OF GAS AND OUT OF NOWHERE IT WOULD PRETEND TO STALL AND THEN TAKE OFF. WOULD CONTINUALLY DO THIS IN THE LOWER GEARS. ADDED A NEW TANK OF GAS AND IT WENT AWAY. GOT TO THE SAME MILEAGE AND HAPPENED ALL OVER AGAIN. HARLEY REPLACED MY FUEL …
Read full complaint
I EXPERIENCED A LAG AND LEAP ISSUE. I WAS RIDING MY BIKE WITH ABOUT 83 MILES ON THE TANK OF GAS AND OUT OF NOWHERE IT WOULD PRETEND TO STALL AND THEN TAKE OFF. WOULD CONTINUALLY DO THIS IN THE LOWER GEARS. ADDED A NEW TANK OF GAS AND IT WENT AWAY. GOT TO THE SAME MILEAGE AND HAPPENED ALL OVER AGAIN. HARLEY REPLACED MY FUEL PUMP BUT IT WAS VERY SCARY AND I AM WORRIED IT MAY HAPPEN AGAIN.
NHTSA ODI #10721773
350 miles · May 11, 2015
EngineFuel/propulsion SystemPower Train
"WITH ROUGHLY .9 GALLONS OF FUEL IN TANK, WHEN LEAVING A FULL STOP, VEHICLE PAUSES HARD ON ACCELERATION. PROBABLE CAUSE IS FUEL STARVATION CAUSED BY FUEL FLOWING BACK IN THE TANK, AWAY FROM THE FRONT-LOCATED FUEL PUMP, STARVING EFI SYSTEM OF GASOLINE. AS FUEL MOVES FORWARD AFTER A BRIEF PAUSE IN FORWARD MOMENTUM, THE PUMP HAS AC…
Read full complaint
"WITH ROUGHLY .9 GALLONS OF FUEL IN TANK, WHEN LEAVING A FULL STOP, VEHICLE PAUSES HARD ON ACCELERATION. PROBABLE CAUSE IS FUEL STARVATION CAUSED BY FUEL FLOWING BACK IN THE TANK, AWAY FROM THE FRONT-LOCATED FUEL PUMP, STARVING EFI SYSTEM OF GASOLINE. AS FUEL MOVES FORWARD AFTER A BRIEF PAUSE IN FORWARD MOMENTUM, THE PUMP HAS ACCESS TO THE FUEL AND THE BIKE SUDDENLY LURCHES FORWARD. THIS HAPPENS MULTIPLE TIMES AS THE FUEL IN TANK TRAVELS FORWARD AND AFT. EXTREMELY UNSAFE CONDITION AT LOW SPEEDS, ESPECIALLY AT INTERSECTIONS WHEN THIS IS MOST LIKELY TO OCCUR."
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain model year 2015 XG500 motorcycles manufactured January 20, 2014, to July 7, 2015, and XG750 motorcycles manufactured May 12, 2014, to July 7, 2015. The fuel pump modules on these motorcycles have a poor seal at the fuel pump inlet.
Consequence & remedy
Consequence: If there is a poor seal at the fuel pump inlet it can cause interruption to the fuel supply, possibly causing a brief hesitation with the abrupt restoration of power. This abrupt restoration of power can lead to loss of control, increasing the risk of a crash.
Remedy: Harley-Davidson will notify owners, and dealers will install a new fuel pump assembly, free of charge. The recall began on August 21, 2015. Owners may contact Harley-Davidson customer service at 1-414-343-4056. Harley-Davidson's number for this recall is 0167.
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain model year 2015 XG500 motorcycles manufactured January 28, 2014, to March 9, 2015, and 2015 XG750 motorcycles manufactured May 12, 2014, to March 9, 2015. The affected motorcycles may have been manufactured without a rear reflector assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the motorcycle is missing the rear reflector it can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Harley-Davidson will notify owners, and dealers will install a rear reflector assembly, free of charge. The recall began on April 29, 2015. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0620.
Additional source detail variants (2)
Exterior Lighting
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain model year 2015 XG500 motorcycles manufactured January 28, 2014, to March 9, 2015, and 2015 XG750 motorcycles manufactured May 12, 2014, to March 9, 2015. The affected motorcycles may have been manufactured without a rear reflector assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the motorcycle is missing the rear reflector it can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Harley-Davidson will notify owners, and dealers will install a rear reflector assembly, free of charge. The recall began on April 29, 2015. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0620.
Visibility
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain model year 2015 XG500 motorcycles manufactured January 28, 2014, to March 9, 2015, and 2015 XG750 motorcycles manufactured May 12, 2014, to March 9, 2015. The affected motorcycles may have been manufactured without a rear reflector assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the motorcycle is missing the rear reflector it can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Harley-Davidson will notify owners, and dealers will install a rear reflector assembly, free of charge. The recall began on April 29, 2015. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0620.
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain model year 2015 XG500 and XG750 motorcycles manufactured June 11, 2014, to August 14, 2014. The fuel tank filler neck may be insufficiently flat, preventing the fuel cap from sealing properly.
Consequence & remedy
Consequence: If the fuel cap doesn't properly seal, fuel may leak, increasing the risk of a vehicle fire.
Remedy: Harley-Davidson will notify owners, and dealers will inspect the motorcycle and test to see if fuel can leak from under the fuel cap. Any motorcycle that leaks fuel from under the fuel cap will have its gas tanked replaced, free of charge. The recall began in late September 2014. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0161.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE15015 · Inconsistent Throttle Response
Opened Apr 20, 2015 · Closed Aug 18, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery
This investigation was opened on April 20, 2015 to investigate reports of inconsistent throttle control on all MY 2015 HD XG750 and XG500 motorcycles.At the time, ODI had 14 consumer complaints and no crashes reported.At the time of closing this investigation ODI has 51 reports (6 of which allege a crash occurred). In addition to requesting information from Harley-Davidson (HD), ODI interviewed complainants and dealer service/parts department personnel.ODI staff also test rode one of the crash bikes to experience the alleged condition first-hand.At low fuel levels (typically below .8 gallon), the engine may stumble and/or stall when fuel flow from the pump to engine is interrupted.This is due to a poor seal at the fuel pump inlet. Ultimately, HD decided to recall (15V-474) the affected motorcycles (MY 2015 XG500 and XG750 produced 1-20-14 through 6-24-15) to install a new fuel pump assembly.With the recall, our information request is moot and this PE is closed.
2015 HARLEY-DAVIDSON XG750 Problems, Complaints & Recalls | Skip That Year
Illustration