2015 HARLEY-DAVIDSON XG750

MY XG750 WAS LOW ON FUEL. WHEN LEAVING FROM A STOP, AT A STOP & GO LIGHT IT FELT AS THOUGH IT HAD NO POWER CAUSING ME TO TURN THE ACCELERATOR MORE. THEN IT GOT FUEL CATCHING ME OFF GUARD AND LEAPED OUT INTO TRAFFIC.NO ONE WAS HURT BUT I FEEL THIS IS A POTENTIALLY DANGEROUS SITUATION. IT HAS HAPPENED SEVERAL TIMES NOW ALWAYS WHEN THE FUEL IS LOW.

AT ABOUT 81 MILES ON THE TRIP ODOMETER FROM A FULL TANK THERE WAS HESITATION WITH ACCELERATION IN 1ST GEAR TURNING RIGHT FROM A STOP UP A SLIGHT INCLINE. BY 91 MILES ON THE TANK, ANY HARD ACCELERATION WAS FOLLOWED BY HESITATION THEN SURGE. THIS HAPPENED IN ANY GEAR NOT JUST IN 1ST. BY 98 MILES ON THE TANK THERE WAS SO MUCH HESITATION AND SURGE THAT IT FELT TOO DANGEROUS TO RIDE. THIS IS THE SECOND COMPLAINT REGARDING THIS ISSUE (PRIOR COMPLAINT NHTSA ID NUMBER: 10721410) IN SPITE OF THE FUEL PUMP ALREADY BEING REPLACED BY HARLEY DAVIDSON LESS THAN A MONTH AGO FOR THE EXACT SAME PROBLEM. REPLACING A DEFECTIVE PART WITH ANOTHER DEFECTIVE PART IS NOT AN ADEQUATE SOLUTION TO A POTENTIALLY VERY DANGEROUS PROBLEM.

THE LOW FUEL WARNING LIGHT ILLUMINATED FEW MINUTES BEFORE THE INCIDENT. THE INCIDENT HAPPENED AT A RED LIGHT ON A 55 MPH ROAD. I WAS FIRST IN LINE IN MY LANE. I ATTEMPTED TO PROCEED THROUGH THE INTERSECTION WHEN THE LIGHT TURNED GREEN. I ROLLED MAYBE A FEW INCHES AND THE BIKE LOST ALL POWER, FOLLOWED BY AN IMMEDIATE SURGE OF POWER. THIS HAPPENED 3 TIMES WHILE TRYING TO CROSS THE INTERSECTION. MY PASSENGER AND I WERE ALMOST THROWN FROM THE BIKE. IT FELT AS IF EVERY TIME THE FUEL SLOSHED BACK AND FORTH THE SURGE AND STALL WOULD HAPPEN.

I'VE BEEN RIDING MOTORCYCLES FOR ABOUT 10 YEARS NOW. WENT FOR A RIDE ON FRIDAY THE 26 OF JUNE ON THE ISLAND I LIVE ON WITH A FRIEND. I WAS ON A 25 MILE SPEED LIMIT ROAD APPROACHING A DOWN HILL TURN TO THE LEFT. I ENTERED THE TURN MAINTAINING COVER ON BRAKES AND CLUTCH. AS I STARTED LEANING THE BIKE INTO THE TURN THE MOTORCYCLE SURGED THE FUEL BY CUTTING OFF AND COMING BACK ON RAPIDLY GIVING ME TOO MUCH TORQUE. I TRIED BRAKING AND DOWN SHIFTING CAUSING MY REAR WHEEL TO LOCK UP AND SENDING ME SIDEWAYS INTO THE GUARD RAIL. I PINNED MY LEG IN BETWEEN THE GUARD RAIL AND THE MOTORCYCLE CAUSING THE REST OF MY BODY AND HEAD TO HIT ALL OF THE GUARD RAIL AS WELL BEFORE FLIPPING OFF THE BIKE AND LANDING ON MY BACK. LUCKILY FOR ME, MY INJURIES WERE LIMITED TO MUSCLE SORENESS AND NO BROKEN BONES. I JUST FILLED A COMPLAINT LAST WEEK AS WELL ABOUT THE LEAP AND LAG SURGING ISSUE THIS MOTORCYCLE IS HAVING. HARLEY-DAVIDSON NEEDS TO MAKE A RECALL FOR THIS ISSUE BEFORE SOMEONE GETS SEVERELY INJURED!!

THE MOTORCYCLE LAGS AND LEAPS WHEN TAKING OFF FROM A STOP OR WHEN ACCELERATING QUICKLY. IT HAS HAPPENED TO ME SEVERAL TIMES AND I HAVE ONLY HAD THE BIKE A FEW WEEKS. I BOUGHT IT BRAND NEW. LUCKILY THERE WERE NO CARS AROUND WHEN IT HAPPENED TO ME BUT IF THIS HAPPENS TO ANYONE WHILE THEY ARE IN TRAFFIC THEY WILL GET SERIOUSLY INJURED. VERY SCARY.

OK SO FIRST TIME I HAD AN ISSUE WAS IN JANUARY WHEN I NOTICED A MAJOR SURGE TO THE POINT OF STALLING OUT REGUARDLESS OF FUEL LEVEL IN THE TANK. TOOK IT TO HARLEY ONCE AND THEY COULD NOT REPLECATE THE ISSUE. SECOND TIME WITHIN THE SAME MONTH SAME ISSUE THE FIXED IT BY REPLACING THE FUEL PUMP STATING IT WAS FAULTY. HAD NO PROBLEMS FOR MONTHS TILL RECENTLY IN MAY I STARTED NOTICING I WAS ON THE HIGHWAY WHEN MY FUEL WAS LOW AND THE LIGHT CAME ON I PULLED OF AT AN EXIT TO GET GAS AND IT STARTED TO SURGE AGAIN LIKE IT DID BEFORE. TANK WAS ALMOST EMPTY SO I FILLED HER UP. NO PROBLEMS THE REST OF THE DAY. NEXT MONTH OF JUNE I NOTICE MY LIGHT STARTED COMING ON WHEN I WAS LEAVING MY WORK AND WHEN IN FIRST OR SECOND GEAR IT SURGES REALLY QUICK FROM POWER TO NO POWER TO QUICK POWER ALL OF A SUDDEN. SO I WENT AND FILLED UP THE TANK AND YET AGAIN NO PROBLEMS. SEEMS TO BE HAPPENING AROUND 100 MILES PER TANK. AND WHEN AT HALF TANK TAKING RIGHT HAND TURNS IT LOOSES POWER TOO. VERY EASILY COULD THROUGH AN INEXPERINCED RIDER OFF IF THEY DONT KNOW HOW TO MAINTAIN THROTTLE AND CLUTCH CONTROL. ALSO NOTICED SHE HAS ISSUES WITH STARTING IN THE MORNING WHEN COLD IF THE BIKE SITS OUT IN THE LOT, HAVE TO GIVE HER GAS TO WARM UP. LIQUED COOLED AND FUEL INJECTED MOTORS SHOULD NOT HAVE THAT ISSUE ESPECIALLY WITH ONLY 2000 MILES ON THE MOTOR BIKE IS NOT SAFE AT THIS TIME PROBABLY DUE TO THE AMOUNT OF FOREIGN PARTS ON AN AMERICAN MACHINE.

THE FOLLOWING EVENT OCCURRED PREVIOUSLY AT A LOWER MILEAGE AT LEAST ONCE, BUT I ATTRIBUTED IT TO MY INEXPERIENCE. I AM A BEGINNER AT RIDING. ON 6/13/15 WHEN ACCELERATING FROM A COUNTRY ROAD ONTO A STATE HIGHWAY WHERE QUICK ACCELERATION IS DESIRED THE BIKE BOGGED SLIGHTLY AND THEN PROPELLED LIKE A ROCKET SHIP AGAIN ABLE TO CONTROL THIS BUT IT WASN'T THE DESIRED ACCELERATION FOR THE TURN I WAS MAKING. I AGAIN THOUGHT OPERATOR ERROR UNTIL I ACCELERATED FROM THE STOP LIGHT A MILE OR SO DOWN THE ROAD. AGAIN A SLIGHT BOG AND THEN A ROCKET SHIP THROWING ME BACK ON THE SEAT. ABLE TO CONTROL THE BIKE AND GET TO MY DESTINATION,WHICH WAS TO GET FUEL AS THE LOW FUEL LIGHT WAS ON, AND PUT 2.64 GALLONS IN THE TANK. THE PROBLEM DID NOT PRESENT AFTER THIS ADDITION. A QUICK INTERNET SEARCH OF THIS REVEALED THAT I AM NOT THE ONLY ONE EXPERIENCING THIS ISSUE AS I FOUND THESE COMPLAINTS AND A BLOG WERE THE PROBLEM IS BEING DISCUSSED. AFTER READING THESE I ALSO REALIZED THAT THE PREVIOUS OCCURRENCE WAS ON A STATE HIGHWAY ON A LONGER TRIP AND THE LOW FUEL LIGHT CAME ON. WENT TO THE NEAREST GAS STATION AND FUELED. PROBLEM WENT AWAY. TO BE FAIR TOOK THE BIKE TO THE DEALER AND THEY HAVE SAID THEY REPLICATED THE PROBLEM WITH UP TO 1.5 GALLONS IN THE TANK. CURRENTLY THEY ARE WAITING ON A PART IN ORDER TO ATTEMPT THE REPAIR OF THIS ISSUE. PLACING MY EXPERIENCE HERE AS THE OWNERS MANUAL HAS A SECTION WHICH STATES SAFETY DEFECTS MUST BE REPORTED TO THE NHTSA AND HARLEY-DAVIDSON.

FROM A COMPLETE STOP, I ACCELERATED SLOWLY DOWN MY GRAVEL DRIVEWAY TOWARD THE PUBLIC STREET. AS I ACCELERATED AND LEANED LEFT SLIGHTLY TO FOLLOW THE PATH OF THE DRIVEWAY, THE MOTORCYCLE STALLED MOMENTARILY AND THEN IMMEDIATELY ACCELERATED RAPIDLY. I GRABBED THE FRONT BRAKE AND PRESSED DOWN ON THE REAR BRAKE SIMULTANEOUSLY AND THE BIKE SLID AND LAID DOWN. AFTER RECOVERING AND ASSESSING THE SITUATION, I RODE CAUTIOUSLY ON THE PUBLIC STREET TO THE NEAREST GAS STATION AND TOPPED UP THE TANK. AFTER RIDING SEVERAL MILES AND UPON COMING TO A COMPLETE STOP AT A STOP LIGHT, I ATTEMPTED TO ACCELERATE AT THE INTERSECTION AND THE BIKE AGAIN STALLED MOMENTARILY AND THEN ACCELERATED RAPIDLY. THE SAME STALLING OCCURRED MULTIPLE TIMES AT THE SAME AND MULTIPLE SUCCESSIVE INTERSECTIONS. AT NO TIME DID THE LOW FUEL INDICATOR APPEAR LIT ON THE BIKE. AT LAST FAILURE, THE BIKE HAD ROUGHLY ONE-HALF TANK OF FUEL. AT 88 MILES ON THE ODOMETER, MY HUSBAND RODE THE BIKE TO THE DEALER ON 5/23/2015 TO HAVE IT INSPECTED. THERE WERE 95 MILES ON THE ODOMETER WHEN HE DELIVERED THE BIKE TO THE DEALER. THE SERVICE MANAGER AT THE DEALER IMPLIED THERE WAS SIMPLY A LACK OF FUEL IN THE TANK. AFTER HAVING THE BIKE FOR SEVERAL DAYS, THE SERVICE MANAGER CONFIRMED THEY WERE ABLE TO DUPLICATE THE PROBLEM WHILE RIDING THE BIKE. THEY'VE HAD THE BIKE FOR NEARLY 4 WEEKS; 2 WEEKS LONGER THAN I HAD THE BIKE. THE SERVICE PERSONNEL HAVE SINCE INDICATED THEY WON'T HAVE PARTS TO RESOLVE THE ISSUE UNTIL AT LEAST THE THIRD WEEK OF JULY, 2015; OTHER DEALERS ASSERT AUGUST. THE BIKE WAS PURCHASED ON MAY 9TH, 2015 AND HAD BEEN RIDDEN TWICE BY ME BEFORE IT WAS RETURNED FOR WARRANTY REPAIR. INITIALLY, THE DEALER SERVICE PERSONNEL ASSERTED THE REPAIRS WEREN'T LIKELY TO BE COVERED UNDER WARRANTY. THEY'VE NOT YET CONFIRMED THAT POSITION. MY HUSBAND'S IDENTICAL MOTORCYCLE HAS THE SAME ISSUE. THE BIKE IS UNSAFE. *TR

FROM A COMPLETE STOP AT AN INTERSECTION, I ATTEMPTED TO ACCELERATE WHILE TURNING RIGHT AT THE INTERSECTION AFTER STOP LIGHT CHANGED. THE BIKE SEEMED TO STALL MOMENTARILY AND THEN RECOVER, THEN STALL AGAIN AND RECOVER AGAIN. THIS HAS SINCE BECOME A REGULARLY OBSERVABLE PATTERN WHEN THE GAS TANK IS PARTIALLY FULL BUT NO LOW FUEL INDICATOR LIGHT DISPLAYS. TOPPING UP THE TANK RESOLVES THE ISSUE AGAIN TEMPORARILY UNTIL THE TANK IS SLIGHTLY LESS THAN HALF FULL. PROBLEM IS MOST PRONOUNCED WHEN TRAVELLING UPHILL OR LEANING THROUGH A TURN.