Electrical System. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports0 fire reports2 injury reports

Vehicle Speed Control complaints

2 reports

Clear category filter

3,600 miles · Jul 29, 2005

Vehicle Speed Control

WHILE DRIVING ON THE INTERSTATE AT APPROXIMATELY 60 MPH THE CRUISE CONTROL STARTED TO ACCELERATE T ON ITS OWN. I COULD NOT GET IT TO TURN OFF UNTIL IT HIT 85 MPH. AFTER THAT THE CRUISE CONTROL WAS INOPERABLE UNTIL THE POWER WAS TURNED OFF. *NM

NHTSA ODI #10130558

250 miles · Mar 24, 2005

Vehicle Speed Control

Read full complaint

I PURCHASED THIS NEW 2005 HARLEY DAVIDSON ON 1/20/2005. WHILE RIDING ON THE INTERSTATE FREEWAY I ENGAGED THE CRUISE CONTROL. I ATTEMPTED TO DISENGAGE IT SO I COULD ADJUST MY SPEED. THE CONTROLS DID NOT DISENGAGE IT. I USED MY BRAKES, THOSE DID NOT DISENGAGE IT. I PULLED THE CLUTCH, THAT DID NOT DISENGAGE IT BUT THE ENGINE SPEED JUMP UP TO 6500 RPM. WHEN I RELEASED THE CLUTCH MY SPEED INCREASED TO AROUND 85 MPH. I TURNED OFF THE DASH SWITCH AND THAT DID NOT HAVE ANY EFFECT. I TURNED OFF THE MOTORCYCLE AND COASTED TO AN OFF RAMP. I RESTARTED THE MOTORCYCLE AND RODE TO THE DEALER. THE DEALER MECHANIC PUT THE MOTORCYCLE ON TEST EQUIPMENT AND COULD FIND NOTHING WRONG. THEN HE TOOK IT FOR A TEST RIDE. THE CRUISE LOCKED ON FOR HIM ALSO. WHEN HE GOT BACK HE WORKED ON IT SOME MORE UNTIL I NEEDED TO LEAVE AND GET BACK TO WORK. HE DISCONNECTED THE CRUISE AND I RODE HOME. I TOOK IT BACK TO THEM THE NEXT WEEK AND THEY COULD NOT FIND ANYTHING WRONG. THEY HOOKED EVERYTHING BACK UP AND SENT ME AWAY. IF I HAD BEEN IN HEAVIER TRAFFIC WHEN THIS HAPPENED IT COULD HAVE BEEN VERY SERIOUS.

NHTSA ODI #10114586

Official recalls

04V607000 · Fuel System, Gasoline:carburetor System

Dec 23, 2004

CERTAIN MOTORCYCLES MAY HAVE BEEN PRODUCED WITH DEFECTIVE FUEL SHUT-OFF VALVES. THE FUNCTIONALITY OF THE 'ON' POSITION AND THE 'RESERVE' POSITION OF THE VALVE MAY HAVE BEEN REVERSED.

Consequence & remedy

Consequence: IF THE BIKE WERE OPERATING WITH THE VALVE IN THE 'ON' POSITION, THE BIKE COULD RUN OUT OF FUEL, THE EXPECTED FUEL RESERVE WILL NOT BE AVAILABLE. THIS COULD LEAD TO THE DRIVER RUNNING OUT OF GAS WITHOUT WARNING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE FUEL VALVE AND REPLACE IT, IF NECESSARY. THE RECALL BEGAN FEBRUARY 7, 2005. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4080.

04V465000 · Fuel System, Gasoline:storage:tank Assembly

Sep 30, 2004

ON CERTAIN MOTORCYCLES, A CONDITION OCCURS THAT COULD ALLOW PRESSURE TO BUILD UP IN THE FUEL TANK. ON FUEL INJECTED VEHICLES, THIS CONDITION COULD CAUSE FUEL TO SPRAY OUT UNEXPECTEDLY WHEN THE FUEL CAP IS REMOVED. ON CARBURETED VEHICLES, EXCESSIVE FUEL COULD BE TRANSFERRED TO THE CARBURETOR, WHICH WOULD EVENTUALLY ALLOW FUEL TO DRIP FROM THE AIR CLEANER.

Consequence & remedy

Consequence: THESE SITUATIONS COULD CAUSE SERIOUS PERSONAL INJURY OR CREATE A FIRE HAZARD FOR PERSONS OR PROPERTY ON OR NEAR THE MOTORCYCLE.

Remedy: DEALERS WILL TEST EACH CANISTER FOR BLOCKAGE, THEN REPLACE AS NECESSARY. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.