SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2005 HARLEY-DAVIDSON Softail

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
4Owner complaints

Model-year median: 3

2Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
4
20027
20034
20044
20052
20071
2008
Compare all Softail years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Electrical System
2Engine And Engine Cooling
1Power Train
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 4 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Power Train complaints

1 reports
Clear category filter
15,000 miles · Jun 16, 2011
Power Train

TL* THE CONTACT OWNS A 2005 HARLEY DAVIDSON SOFT TAIL MOTORCYCLE. THE CONTACT WAS DRIVING 60 MPH WHEN THE REAR WHEEL ALONG WITH THE DRIVE CHAIN UNBOLTED AND DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE THE REAR WHEEL, DRIVE CHAIN, AND BOLTS CONNECTED TO THE DRIVE CHAIN WERE REPLACED. THE CONTACT STATED T…

Read full complaint

TL* THE CONTACT OWNS A 2005 HARLEY DAVIDSON SOFT TAIL MOTORCYCLE. THE CONTACT WAS DRIVING 60 MPH WHEN THE REAR WHEEL ALONG WITH THE DRIVE CHAIN UNBOLTED AND DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE THE REAR WHEEL, DRIVE CHAIN, AND BOLTS CONNECTED TO THE DRIVE CHAIN WERE REPLACED. THE CONTACT STATED THAT THE FAILURE HAD BEEN EXPERIENCED TWICE WITH THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE PARTS WERE NOT CAUSING THE FAILURE BUT THAT THE DEALER HAD NOT PROPERLY REPAIRED THE VEHICLE. THE CONTACT STATED THAT HE DID NOT FEEL SAFE DRIVING THE VEHICLE. THE FAILURE MILEAGE WAS 15,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #10407109

Official recalls

2

04V607000 · Fuel System, Gasoline:carburetor System

Dec 23, 2004

CERTAIN MOTORCYCLES MAY HAVE BEEN PRODUCED WITH DEFECTIVE FUEL SHUT-OFF VALVES. THE FUNCTIONALITY OF THE 'ON' POSITION AND THE 'RESERVE' POSITION OF THE VALVE MAY HAVE BEEN REVERSED.

Consequence & remedy

Consequence: IF THE BIKE WERE OPERATING WITH THE VALVE IN THE 'ON' POSITION, THE BIKE COULD RUN OUT OF FUEL, THE EXPECTED FUEL RESERVE WILL NOT BE AVAILABLE. THIS COULD LEAD TO THE DRIVER RUNNING OUT OF GAS WITHOUT WARNING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE FUEL VALVE AND REPLACE IT, IF NECESSARY. THE RECALL BEGAN FEBRUARY 7, 2005. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4080.

04V465000 · Fuel System, Gasoline:storage:tank Assembly

Sep 30, 2004

ON CERTAIN MOTORCYCLES, A CONDITION OCCURS THAT COULD ALLOW PRESSURE TO BUILD UP IN THE FUEL TANK. ON FUEL INJECTED VEHICLES, THIS CONDITION COULD CAUSE FUEL TO SPRAY OUT UNEXPECTEDLY WHEN THE FUEL CAP IS REMOVED. ON CARBURETED VEHICLES, EXCESSIVE FUEL COULD BE TRANSFERRED TO THE CARBURETOR, WHICH WOULD EVENTUALLY ALLOW FUEL TO DRIP FROM THE AIR CLEANER.

Consequence & remedy

Consequence: THESE SITUATIONS COULD CAUSE SERIOUS PERSONAL INJURY OR CREATE A FIRE HAZARD FOR PERSONS OR PROPERTY ON OR NEAR THE MOTORCYCLE.

Remedy: DEALERS WILL TEST EACH CANISTER FOR BLOCKAGE, THEN REPLACE AS NECESSARY. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.