99 HARLEY DAVIDSON- CAM BEARING FAILURE- THE COMPANY EXTENDED THE WARRENTY TO 5YRS OR 50,000 MI. THE FAILURE OCCURED AFTER 7 YRS. UNDER NORMAL OPERATION & THE COMPANY HAS ONLY AGREED TO PAY FOR PARTS, NOT THE LABOR, WHICH IS A SUBSTANTIAL AMOUNT. THIS FAILURE COULD HAVE CAUSED THE MOTOR TO SEIZE WHILE IN OPERATION, POTENTIALLY C…
Read full complaint
99 HARLEY DAVIDSON- CAM BEARING FAILURE- THE COMPANY EXTENDED THE WARRENTY TO 5YRS OR 50,000 MI. THE FAILURE OCCURED AFTER 7 YRS. UNDER NORMAL OPERATION & THE COMPANY HAS ONLY AGREED TO PAY FOR PARTS, NOT THE LABOR, WHICH IS A SUBSTANTIAL AMOUNT. THIS FAILURE COULD HAVE CAUSED THE MOTOR TO SEIZE WHILE IN OPERATION, POTENTIALLY CAUSING SERIOUS BODILY INJURY OR DEATH.
NHTSA ODI #10130078
11,601 miles · Sep 10, 2001
Engine And Engine Cooling
THIS WAS ONE OF ELEVEN CAM BEARINGS ELYRIA H-D HAS DONE, THEY ONLY SELL 300 BIKES TOTAL A YEAR. APPROX. 1/3 OF THOSE DID NOT HAVE THE NEW TWIN CAM MOTOR. AK SCC ***DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*****752040
NHTSA ODI #10006455
Mileage unknown · Jun 12, 2001
Engine And Engine Cooling
WHILE TRAVELING ENGINE WAS MAKING A LOUD NOISE AND RUNNING ROUGH, AND WITHOUT ANY INDICATIION VEHICLE WOULD STALL. DEALER HAS REPLACED CAMSHAFT.*AK THE GEAR ON THE CRANK SHAFT TURNED ON THE DRIVE SURFACE OF THE CRANK SHAFT MAKING THE CRANK SHAFT UNSEVICEABLE. *YH
NHTSA ODI #890173
Mileage unknown · May 25, 2001
Engine And Engine Cooling
HARLEY DAVIDSON HAS NOT YET ISSUED A RECALL FOR THE IMPENDING FAILURE OF THE CAM BEARING THAT IS OCCURING IN THE 1999 TWIN CAM ENGINES. THEY HAVE SENT OUT LETTERS STATING THAT THEY WILL FIX THE DAMAGE AFTER FAILURE, NOT BEFORE. AS REPORTED IN MOTORCYCLECONSUMER NEWS CURRENT ISSUE AND PAST ISSUE, THIS FAILURE CAN BE VERY DANGER…
Read full complaint
HARLEY DAVIDSON HAS NOT YET ISSUED A RECALL FOR THE IMPENDING FAILURE OF THE CAM BEARING THAT IS OCCURING IN THE 1999 TWIN CAM ENGINES. THEY HAVE SENT OUT LETTERS STATING THAT THEY WILL FIX THE DAMAGE AFTER FAILURE, NOT BEFORE. AS REPORTED IN MOTORCYCLECONSUMER NEWS CURRENT ISSUE AND PAST ISSUE, THIS FAILURE CAN BE VERY DANGEROUS FOR ITS POTENTIAL OF BODILY HARM AND VEHICLE(S) DAMAGE. CAN YOU GET H-D TO FIX THE PROBLEM BEFORE FAILURE? THIS WOULD INVOLVE A LOT LESS COST AS FAR AS MOTORCYCLE ENGINE REPAIR, AS WELL AS PREVENTING A LOT OF COST DUE TO MEDICAL AND VEHICULAR DUE TO A WRECK CAUSED BY AN ENGINE SEIZING UP. THANK YOU IN ADVANCE FOR ANY AND ALL HELP YOU CAN GIVE CONCERNING THIS SITUATION.
NHTSA ODI #745874
Mileage unknown · Mar 5, 2001
Engine And Engine CoolingPower Train
THE DRIVE BELT WAS LOOSE CAUSING ENGINE NOISE, AFTER THE DRIVE BELT WAS REPLACED THE NOISE PERSISTED, THE CONSUMER REPLACED THE REAR BEARING AND THERE HAS BEEN NO MORE PROBLEMS. NLM
VEHICLE DESCRIPTION: MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH A FUEL TANK VENT FITTING THAT COULD BE PLUGGED ALLOWING THE CARBURETOR TO OVERFLOW FUEL.
Consequence & remedy
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK VENT FITTING AND, IF PLUGGED, WILL CORRECT THIS CONDITION.
VEHICLE DESCRIPTION: MOTORCYCLES. THE ENGINE CAM BOLT CAN LOSE ITS CLAMP LOAD AND/OR BREAK.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE ENGINE TO QUIT RUNNING WITH OR WITHOUT PRIOR WARNING. IN SOME INSTANCES, THE ENGINE COULD RUN ERRATICALLY BEFORE QUITTING.
Remedy: DEALERS WILL REPLACE THE ENGINE CAM BOLTS AND WASHERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1999 HARLEY-DAVIDSON Fxdx Problems, Complaints & Recalls | Skip That Year
Illustration