Service Brakes. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Power Train complaints

3 reports

Clear category filter

42,000 miles · Feb 2, 2018

Power Train

Read full complaint

I WOULD LIKE TO BRING TO LIGHT AN ISSUE I HAVE RECENTLY HAD FOUND. I RIDE A 2008 HARLEY DAVIDSON ELECTRAGLIDE. I ONLY HAVE 42000 MILES ON IT. LAST FALL I WAS COMING BACK FROM A MEMORIAL MISSION WITH THE AMERICAN LEGION RIDERS. I NOTICED A STRANGE RATTLE IN MY PRIMARY CASE AREA. I GOT HOME AND PARKED IT UNTIL I COULD OPEN IT UP TO SEE WHAT THE ISSUE IS. A FEW WEEKS LATER I FINALLY WAS ABLE TO OPEN UP THE PRIMARY CASE. WHAT I FOUND WAS 2 LARGE PIECES OF METAL LOOSE IN THE PRIMARY CASE. THIS IS WHERE THE CLUTCH, DRIVE CHAIN, COMPENSATOR, AND STATOR ARE. IMMEDIATELY I WAS SCARED AND THANKFUL THAT ONE OF THOSE PIECES DIDN'T GET STUCK IN THE DRIVE CHAIN AND SPROCKET. IF IT HAD WHEN I WAS GOING DOWN THE ROAD IT WOULD HAVE LOCKED UP THE REAR WHEEL IMMEDIATELY AND I WOULD NOT BE HERE. I FINALLY WAS ABLE TO DETERMINE THE PIECES CAME OFF THE COMPENSATOR. I BEGAN SEARCHING THE INTERNET TO SEE IF THIS WAS COMMON. TO MY SURPRISE IT IS COMMON AND HARLEY DAVIDSON CORPORATE KNEW ABOUT THE FLAWED DESIGN AND DID NOT DO A RECALL OR INFORM OWNERS OF THE ISSUE. I CONTACTED SALEM HARLEY DAVIDSON AND THEY PUT ME IN TOUCH WITH HARLEY DAVIDSON CUSTOMER CARE. WHEN I TALKED TO THEM I FOUND THEY KNEW OF THE ISSUE AND CHANGED THE DESIGN IN 2012. I WAS TRYING TO GET THEM TO FIX MY BIKE BUT THEY REFUSED SAYING IT WAS OUT OF WARRANTY. GRANTED IT IS BUT THIS WAS A KNOWN ISSUE AND OWNERS SHOULD HAVE BEEN NOTIFIED. ONE OF THE MAIN REASONS FOR CONTACTING YOU IS TO HOPEFULLY MAKE PEOPLE AWARE OF THE PROBLEM. I CAN'T HELP TO WONDER HOW MANY MOTORCYCLE RIDERS HAVE LOST THEIR LIVES DUE TO THE SAME THING HAPPENING TO THEM. EXCEPT THEY WEREN'T AS FORTUNATE AS I WAS. AS I SAID BEFORE IF 1 OF THOSE PIECES GOT STUCK IN THE PRIMARY CHAIN WHILE GOING DOWN THE ROAD IT WOULD BE CATASTROPHIC. UNFORTUNATELY THE ACTUAL CAUSE MAY NOT BE FOUND BECAUSE OF THE EXTENSIVE DAMAGE.

NHTSA ODI #11066699

36,000 miles · Dec 2, 2013

Fuel/propulsion SystemPower Train

THROTTLE GAVE OUT FOR NO APPARENT REASON. HAD NO RESPONSE FROM THE THROTTLE. STOPPED AND REMOVED HAND GRIP AND MOVED THE ELECTRONIC PART AND REPLACED HAND GRIP. THROTTLE WAS THE OK, THIS HAS HAPPENED ON 2 MORE OCCASIONS ON AUGUST 31ST AND SEPTEMBER 1ST, I DID THE SAME TO FIX THE PROBLEM. LUCKILY I WAS NOT A BUSY FREEWAY WHEN THE…

Read full complaint

NHTSA ODI #10554371

14,000 miles · Mar 14, 2013

Electrical SystemPower Train

BIKE WENT INTO LIMP MODE CAUSING THE BIKE TO SUDDENLY SHUT DOWN TO ABOUT 15 MPH. CAUSE WAS FRETTING OF THROTTLE BODY WIRING CONNECTOR PINS. FACTORY HAS KNOWN OF PROBLEM AND HAS A TCB OUT ON ISSUE. THIS IS VERY DANGEROUS WHEN RIDING ON HIGHWAYS. COMPANY NEED TO HAVE RECALL BUT THEY WON'T. *TR

NHTSA ODI #10502754

Official recalls

18V076000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:fluid

Jan 29, 2018

Harley-Davidson Motor Company (Harley-Davidson) is recalling all 2008-2011 Touring, CVO Touring and VSRC motorcycles equipped with anti-lock brakes (ABS), including Road King (FLHR), Road King Police (EFI) (FLHP), Road King Police (EFI) (FLHPE), Electra Glide Standard Police (EFI) (FLHTP), Electra Glide Classic (EFI) (FLHTC), Electra Glide Ultra Classic (EFI) (FLHTCU) and Street Glide (EFI) (FLHX), 2008 VROD (VRSCAWA), CVO Road King 4 (FLHRSE4), Night Rod (VRSCDA), CVO Ultra Classic 3 (FLHTCUSE3), Night Rod Special (VRSCDXA), 2008-2010 Road King Classic (EFI) (FLHRC), 2008-2009 Road Glide (EFI) (FLTR) and Electra Glide Standard (EFI) (FLHT), 2009-2010 V-Rod (VRSCAW), 2009 CVO Ultra Classic (FLHTCUSE4) and CVO Road Glide 3 (FLTRSE3), 2009-2011 Night Rod Special (VRSCDX) and V-Rod Muscle (VRSCF), 2010 CVO Ultra Classic 5 (FLHTCUSE5) and CVO Street Glide (FLHXSE), 2010-2011 Electra Glide Ultra Limited (FLHTK) and Road Glide Custom (FLTRX), 2011 Road Glide Ultra 103 (FLTRU103), Street Glide 103 (FLHX103), Road King Classic 103 (FLHRC103), CVO Ultra Classic 6 (FLHTCUSE6), CVO Road Glide Ultra (FLTRUSE), Road Glide Custom 103 (FLTRX103), and CVO Street Glide 2 (FLHXSE2) motorcycles. Deposits may form on components within the brake system if the DOT 4 brake fluid is not replaced for a prolonged period of time beyond the 2-year maintenance schedule specified in the Owners Manual.

Consequence & remedy

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

Remedy: Harley-Davidson will notify owners, and dealers will flush the entire brake system with new Platinum Label DOT 4 brake fluid, free of charge. The recall began on February 14, 2018. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0171.

Additional source detail variants (2)

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

Remedy: Harley-Davidson will notify owners, and dealers will flush the entire brake system with new Platinum Label DOT 4 brake fluid, free of charge. The recall began on February 14, 2018. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0171.

Service Brakes, Hydraulic:fluid

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

08V357000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

Jul 30, 2008

HARLEY DAVIDSON IS RECALLING 47,579 MY 2008 FLHP, FLHPE, FLHR, FLHRC, FLHRSE4, FLHT, FLHTC, FLHTCU, FLHTCUSE3, FLHTP, FLHX, AND FLTR MOTORCYCLES. THESE MOTORCYCLES MAY EXPERIENCE A CRACKING OF THE FUEL FILTER SHELL LEADING TO LOSS OF FUEL PRESSURE. THIS LOSS OF FUEL PRESSURE CAN CAUSE DIMINISHED PERFORMANCE AND, IN SOME CASES, MAY CAUSE AN ENGINE STALL OR A NO-START CONDITION.

Consequence & remedy

Consequence: THIS CONDITION COULD LEAD TO A CRASH WHICH COULD CAUSE INJURY OR DEATH TO THE RIDER.

Remedy: DEALERS WILL REPLACE THE FUEL FILTER SHELL FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2008. OWNERS MAY CONTACT HARLEY DAVIDSON AT 1-414-343-4056.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE16009 · Sudden Brake Failure - Motorcycle

Opened Jul 6, 2016 · Closed Apr 23, 2018

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) opened this investigation in July 2016 based on forty-three (43) Vehicle Owner Questionnaires (VOQ).During the course of this investigation ODI received a total of 145 VOQs related to the alleged defect on the subject motorcycles.Owners allege they experience a sudden and complete loss of brakes on one or both wheels.To better understand the cause of the braking issue on the subject motorcycles, ODI requested NHTSA's Vehicle Research and Test Center (VRTC) conduct inspections and testing of affected vehicle braking systems.Through its work, VRTC determined that deposits were forming on the valves in the Hydraulic Control Unit (HCU) of the Antilock Braking System (ABS). These deposits could prevent the proper function of the HCU and render the brakes ineffective.To understand why deposits were forming in the HCU, Harley Davidson completed an analysis of the Dow 460 brake fluid used as original equipment on the subject motorcycles and determined that it had stability issues if left in the brake system for an extended period of time.Harley Davidson found that if a brake fluid flush was not conducted as outlined in the owner?s manual for the motorcycles, and was left in the system for a period of time beyond their recommendation; deposits could form in the HCU.Through further testing, Harley Davidson identified an alternate, commercially available, brake fluid that did not have the same stability issues as the original fluid and could stop the proliferation of any current brake system deposits.ODI sent Information Request (IR) letters to Harley Davidson and Dow Chemical (the supplier of the brake fluid on the subject motorcycles) to collect information about the subject bikes and the alleged defect.Harley Davidson responded in full on Sept 30, 2016 and Dow responded with a confidential submission on October 25, 2017.ODI analyzed the information contained in both IR responses and concluded that motorcycles manufactured during Model Years (MY) 2008, 2009, 2010, and 2011 were failing at a rate greater than their peers.Based on this analysis and the brake fluid study conducted by Harley Davidson, a group of motorcycles was identified that were potentially affected by the instability of the original brake fluid.2008 marked the introduction of ABS on Harley Davidson motorcycles and a change in the Dow 460 brake fluid used in the 2012 MY vehicles provided the bases for the scope of the affected population.With recall action 18V-076 taken by Harley Davidson this investigation is closed as further use of agency resources does not appear to be warranted.The ODI reports cited above can be reviewed at: https://www.nhtsa.gov/ using the complaint identification numbers attached to this resume.

PE08043 · Motorcycle Stalling

Opened Jul 17, 2008 · Closed Aug 8, 2008

Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery

THE SUBJECT FUEL FILTER HOUSING (P/N 62229-08) CRACKS, RESULTING IN SUDDEN ENGINE STALL DUE TO UNREGULATED FUEL PRESSURE.HARLEY-DAVIDSON HAS MODIFIED THE HOUSING WITH A NEW PART NUMBER 62229-08A.SHORTLY AFTER OPENING THIS PE, ODI RECEIVED HARLEY'S DEFECT NOTIFICATION INDICATING THAT THE SUBJECT VEHICLES WERE BEING RECALLED TO INSTALL THE NEW FUEL FILTER HOUSING.WITH THAT RECALL, RECEIVED PRIOR TO RELEASE OF OUR INFORMATION REQUEST, THIS INVESTIGATION IS CONCLUDED.

Additional source detail variants (2)

Fuel System, Gasoline:delivery

Fuel System, Gasoline