DESIGN OF THROTTLE BODY IS NOT DONE PROPERLY, WHEN MOTORCYCLE VIBRATES THROTTLE BODY WILL COME LOOSE AND RPMS WILL START TO REV UP. CONTACTED DEALER.*AK HARLEY DAVIDSON IS AWARE OF THE PROBLEM AND HAS A REMEDY, THE ORIGINAL SCREWS ON THE THROTTLE BODY THAT HOLDS IT TO THE INTAKE MANIFOLD BREAK, OR VIBRATE OUT, CAUSING THROTTLE …
Read full complaint
DESIGN OF THROTTLE BODY IS NOT DONE PROPERLY, WHEN MOTORCYCLE VIBRATES THROTTLE BODY WILL COME LOOSE AND RPMS WILL START TO REV UP. CONTACTED DEALER.*AK HARLEY DAVIDSON IS AWARE OF THE PROBLEM AND HAS A REMEDY, THE ORIGINAL SCREWS ON THE THROTTLE BODY THAT HOLDS IT TO THE INTAKE MANIFOLD BREAK, OR VIBRATE OUT, CAUSING THROTTLE BODY TO SEPARATE FROM INTAKE, THIS CAUSES LARGE VOLUMES OF AIR TO ENTER ENGINE, INCREASING THE RPM TO OVER 4000, CONSUMER HAD TO USE THE IGNITION SWITCH TO SHUT THE MOTORCYCLE DOWN, THE ABOVE IS NOT THE OWNERS INFORMATION. *SLC
ON CERTAIN MOTORCYCLES, THE CLIPS THAT RETAIN THE WIRING FOR THE FRONT FENDER TIP LIGHT CAN BECOME DETACHED FROM THE FENDER, CAUSING THE WIRES TO FRAY AND SHORT.
Consequence & remedy
Consequence: THIS COULD CAUSE THE LIGHTING SYSTEM FUSE TO BLOW, LEAVING THE VEHICLE WITHOUT AN OPERATIONAL FRONT FENDER TIP LIGHT, HEADLIGHT, TAILLIGHT, RUNNING LIGHTS, AND PASSING LAMPS (IF EQUIPPED).
Remedy: DEALERS WILL REPLACE THE FENDER TIP LIGHT WIRING HARNESS RETENTION CLIPS, AND INSPECT AND REPLACE, IF NECESSARY, ANY DAMAGED WIRING HARNESSES. OWNER NOTIFICATION BEGAN JANUARY 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 HARLEY-DAVIDSON Flhr Problems, Complaints & Recalls | Skip That Year
Illustration