DT*: THE CONTACT STATED THAT THERE IS WOOD AND SHEETS OF PLASTIC UNDER THE FLOOR OF THE VEHICLE WHICH SHOULD BE STEEL. THIS WAS CONSIDERED A SAFETY ISSUE BECAUSE FLAMMABLE MATERIALS WERE USED TO CLOSE THE HOT TAIL PIPES, MUFFLER AND GAS TANK. THE SERVICE DEALER DETERMINED THIS WAS THE WAY THE VEHICLE WAS DESIGN. THE MODEL OF…
Read full complaint
DT*: THE CONTACT STATED THAT THERE IS WOOD AND SHEETS OF PLASTIC UNDER THE FLOOR OF THE VEHICLE WHICH SHOULD BE STEEL. THIS WAS CONSIDERED A SAFETY ISSUE BECAUSE FLAMMABLE MATERIALS WERE USED TO CLOSE THE HOT TAIL PIPES, MUFFLER AND GAS TANK. THE SERVICE DEALER DETERMINED THIS WAS THE WAY THE VEHICLE WAS DESIGN. THE MODEL OF THE RECREATIONAL VEHICLE IS SUN VOYAGER. UPDATED 7/31/2006 - THE CONSUMER IS RELUCTANT TO USE THE MOTORHOME BECAUSE OF FIRE HAZARD. *NM THE MOTOR HOME HAD A MAJOR HYDRAULIC LEAK. A NEW POWER GEAR HYDRAULIC PUMP WAS INSTALLED. THE FRONT DASH AIR WAS NOT COOLING ADEQUATELY. UPDATED 08/03/06. *JB UPDATED 8/14/2006 - THE LP GAS FURNACE COMPARTMENT ON THE INTERIOR OF THE COACH WHERE THE GAS FURNACE COMBUSTION CHAMBER IS LOOSELY LINED WITH NON FITTING PIECES OF DRYWALL. ELECTRICAL 110 VOLT LINE AND HEAVY COACH AMP LINE WAS EXPOSED AND LOOSELY PLACED UNDER THE COACHES WOOD FLOOR. THE PLACEMENT OF THE ELECTRICAL BREAKERS, FUSES, ALL MAIN ELECTRICAL LINE JUNCTION LOCATION ALONG WITH CONVERTER BOX WERE PLACED UNDER THE REAR BEDROOM BED. *NM UPDATED 08/14/06. 8JB
Gulf Stream Coach, Inc. (GSC) is recall certain model year 2006 through 2008 Crescendo, Sun Voyager, Independence, Bounty Hunters, and Yellowstone Class A diesel pusher motor homes built on Freightliner Custom Chassis (FCCC) from March 18, 2005, through December 2009. These motorhomes chassis are equipped with Bosch hydraulic disc brakes which, when exposed to long periods of time of non-driving, may experience diametrical brake caliper piston growth and reduced piston to bore clearance potentially leading to brake drag and overheating resulting in reduced brake performance.
Consequence & remedy
Consequence: Reduced brake performance increases the risk of a crash.
Remedy: FCCC will notify owners, and dealers will repair the vehicles, free of charge. An interim letter was mailed by DTNA on August 6, 2012. Owners may contact GSC at 1-800-289-8787 or Daimler Trucks/FCCC at 1-800-547-0712.
GULF STREAM IS RECALLING CERTAIN RECREATIONAL VEHICLES AND FIFTH WHEEL TRAILERS EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence & remedy
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: GULF STREAM IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON MARCH 23, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR GULF STREAM AT 1-574-773-7761.
GULF STREAM IS RECALLING 15 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG.
Consequence & remedy
Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY AND OWNER NOTIFICATION FOR THIS CAMPAIGN PLEASE SEE 09V-110. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731
GULF STREAM IS RECALLING 26,847 MY 2003-2006 RECREATIONAL VEHICLES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.
Remedy: GULF STREAM IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR GULF STREAM AT 1-574-773-7761.
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.
Consequence & remedy
Consequence: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148). THEY WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR GULF STREAM AT 1-574-773-7761.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Gulf Stream Sun Voyager Problems, Complaints & Recalls | Skip That Year
Illustration