The contact owns a 2024 Grand Design Momentum RV. The contact stated that upon purchasing the RV brand new, the dealer hitched the RV to the 2024 Chevrolet Silverado 3500 HD. The trailer brakes warning lights illuminated; however, the dealer advised the contact that the RV could be driven off the lot. The contact stated while pu…
Read full complaint
The contact owns a 2024 Grand Design Momentum RV. The contact stated that upon purchasing the RV brand new, the dealer hitched the RV to the 2024 Chevrolet Silverado 3500 HD. The trailer brakes warning lights illuminated; however, the dealer advised the contact that the RV could be driven off the lot. The contact stated while pulling the RV in the mountains at 50 MPH, the trailer brakes became inoperable. The contact was able to slow down the RV by depressing the brake pedal of the truck as needed. Additionally, the contact had hired a third party inspector, who had inspected the RV before it was driven off the dealer's lot. The inspector had informed the contact that the RV was missing safety pins and locking mechanisms, and that the roof was damaged; however, the dealer advised the contact that the RV was safe to drive without the parts and the parts would be provided later. The contact stated that all the beds of the RV had detached, and the beds frames were flapping against the walls while in transit, causing damage to the beds frame and to the walls. The contact stated that the failure had caused the whole RV to shudder while driving 40-50 MPH, which required the contact to exit the highway a. The RV was taken to the nearby RV dealer. The dealer detached the beds and laid them flat on the floor. The RV was later taken to General RV Center(14000 Automall Dr, Huntley, IL 60142), where the roof was rebuilt; however, the contact requested a trade-in due to safety concerns. The dealer depreciated the RV and rolled the depreciation into the payment of the new RV that the contact had purchased. The manufacturer was notified of the failure, but the manufacturer put the blame onto the dealer and referred the contact to the dealer for assistance. The failure mileage was 0.
NHTSA ODI #11707476
2,700 miles · Oct 22, 2025
Electrical SystemService Brakes, Hydraulic
The contact owns a 2024 Grand Design Recreational Momentum. The contact stated that after the RV was delivered, the brakes were inoperable, a slice was cut in the wiring harness with electrical tape covering the cut, the slide-out frame was out of alignment and unable to close properly, the awning had detached, and ABS was not e…
Read full complaint
The contact owns a 2024 Grand Design Recreational Momentum. The contact stated that after the RV was delivered, the brakes were inoperable, a slice was cut in the wiring harness with electrical tape covering the cut, the slide-out frame was out of alignment and unable to close properly, the awning had detached, and ABS was not equipped in the RV. Additionally, there was water intrusion in the RV, resulting in mold. A mobile independent mechanic replaced the brakes and wiring harness; however, the RV was not repaired. The manufacturer was made aware of the failure and denied five buyback claims. The contact had also filed sixty-two warranty claims. The failure mileage was approximately 2,700.
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence & remedy
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Additional source detail variants (2)
Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Grand Design RV, LLC (Grand Design) is recalling certain 2024-2025 Momentum 320G, 325G, 344M, 250G, 351MS, 381MS, 392M, 395MS, 397THS, 398M, 399TH, 410TH, 414M, and 415G toy haulers, equipped with a removable step assembly. The clip-on bracket mounting bolts may come loose, allowing the steps to detach.
Consequence & remedy
Consequence: Steps that detach while in use increase the risk of injury.
Remedy: Dealers will inspect the clip-on bracket and make repairs as necessary, free of charge. Owner notification letters were mailed May 15, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910050.
Grand Design RV, LLC (Grand Design) is recalling certain 2023-2025 Momentum fifth wheel trailers. The interior step base does not adequately support the step tread.
Consequence & remedy
Consequence: The tread may detach from the step, increasing the risk of a trip and fall injury.
Remedy: Dealers will replace the step riser and step treads, free of charge. Owner notification letters were mailed January 16, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910047.
Additional source detail variants (2)
Structure:body:step/ladder
Grand Design RV, LLC (Grand Design) is recalling certain 2023-2025 Momentum fifth wheel trailers. The interior step base does not adequately support the step tread.
Consequence: The tread may detach from the step, increasing the risk of a trip and fall injury.
Remedy: Dealers will replace the step riser and step treads, free of charge. Owner notification letters were mailed January 16, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910047.
Grand Design RV, LLC (Grand Design) is recalling certain 2023-2025 Momentum fifth wheel trailers. The interior step base does not adequately support the step tread.
Consequence: The tread may detach from the step, increasing the risk of a trip and fall injury.
Remedy: Dealers will replace the step riser and step treads, free of charge. Owner notification letters were mailed January 16, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910047.
Grand Design RV, LLC (Grand Design) is recalling certain 2024 Solitude and Momentum Fifth Wheel trailers. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence & remedy
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the U-bolts, free of charge. Owner notification letters were mailed March 25, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910042.
Additional source detail variants (2)
Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC (Grand Design) is recalling certain 2024 Solitude and Momentum Fifth Wheel trailers. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the U-bolts, free of charge. Owner notification letters were mailed March 25, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910042.
Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC (Grand Design) is recalling certain 2024 Solitude and Momentum Fifth Wheel trailers. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the U-bolts, free of charge. Owner notification letters were mailed March 25, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910042.
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2024 Momentum 23G and 25G travel trailers. The installed safety chains are underrated for the Gross Vehicle Weight Rating (GVWR).
Consequence & remedy
Consequence: Underrated chains can allow the trailer to detach from the tow vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the safety chains, free of charge. Owner notification letters were mailed September 6, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910040.
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence & remedy
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Additional source detail variants (2)
Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2024 Grand Design Momentum Problems, Complaints & Recalls | Skip That Year
Illustration