2019 Grand Design Imagine

Brake linings which are available for inspection. The brake lining defects likely caused THREE tire blowouts due to excessive heat from the disintegrating brake linings, also a degradation of stopping performance. Upon performing annual wheel bearing service and brake inspection I found all four brake assemblies with brake lining partially disintegrated and in one case completely missing from the metal backing. This is NOT normal wear and tear but the breaking off of the lining from the metal backing plate. Nobody has inspected the linings but I have notified the RV trailer manufacturer, Grand Design and the manufacturer of the brake linings, Dexter Axle Co. I had THREE tire blowouts, one in September 2020 and two more recently causing significant damage to the RV travel trailer not to mention the p

TL* THE CONTACT OWNS A 2019 GRAND DESIGN IMAGINE TRAILER. THE CONTACT NOTICED THAT THE REAR DRIVER'S SIDE WHEEL BEARING WAS SEPARATING FROM THE AXLE. THE CONTACT DROVE THE VEHICLE TO AN INDEPENDENT MECHANIC WHO USED A TORCH TO REMOVE THE NUT FROM THE AXLE TO ACCESS THE WHEEL BEARING. THE MECHANIC ALSO HAD TO USE A GRINDER TO GRIND THE AXLE AND THE BRAKE PADS HAD TO BE REPLACED. THE CONTACT WAS INFORMED THAT THE TRAILER WAS WELL ENOUGH TO DRIVE HOME; HOWEVER, THE ENTIRE AXLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THEY WOULD REIMBURSE THE CONTACT FOR THE TRAILER REPAIRS. THE CONTACT ALSO INFORMED THE MANUFACTURER THAT THE AXLE NEEDED TO BE REPLACED, BUT THEY REFUSED TO COMPENSATE HIM FOR THAT PARTICULAR REPAIR. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 18V823000 (SUSPENSION); HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE DEALER WAS NOT CONTACTED. THE AXLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 5,000.