NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
10 reportsClear category filterMileage unknown · Jul 8, 2026
Electrical SystemPower TrainService Brakes
On June 25, 2026 my 2023 GMC Yukon Denali with 53,456 miles was brought to an authorized GMC dealership after displaying a Service 4WD warning light and exhibiting a groaning noise when shifting into Drive and Reverse. The vehicle was diagnosed with the following brake system fault codes: P25A2, C0511, C0517, C1595 and C1596. Th…
Read full complaint
On June 25, 2026 my 2023 GMC Yukon Denali with 53,456 miles was brought to an authorized GMC dealership after displaying a Service 4WD warning light and exhibiting a groaning noise when shifting into Drive and Reverse. The vehicle was diagnosed with the following brake system fault codes: P25A2, C0511, C0517, C1595 and C1596. These codes indicate brake control module failure and wheel speed sensor faults which are safety critical components. The dealership confirmed these findings but stated the repairs are not covered under the GMC powertrain warranty. Given that these are safety critical brake system failures on a nearly new vehicle with only 53,456 miles, we contacted GMC Customer Care on July 1, 2026 to request coverage under goodwill warranty as we believe these failures constitute a manufacturing defect. A case was opened however after 7 days no case advisor has been assigned and no decision has been made despite two promised timelines not being met. The brake system failures on a nearly new vehicle represent a serious safety concern as these systems directly affect the vehicle's ability to stop safely. The vehicle has been at the dealership since June 25, 2026 and remains unrepaired.
NHTSA ODI #11749116
Mileage unknown · Apr 20, 2026
Service Brakes
Brakes failed to engage. Many lights lit up on dashboard and warning not to exceed 35 mph. It was determined this was due to a faulty brake system control module.
NHTSA ODI #11732405
Mileage unknown · Jan 23, 2026
Electrical SystemService Brakes
While driving approximately 63 mph on a busy roadway, my 2023 GMC Yukon experienced a sudden failure of the brake system, including loss of normal braking capability along with failures of the Electronic Stability Control (ESC) and ABS systems. The vehicle displayed warning messages stating “Brake System Failure” and “Service ES…
Read full complaint
While driving approximately 63 mph on a busy roadway, my 2023 GMC Yukon experienced a sudden failure of the brake system, including loss of normal braking capability along with failures of the Electronic Stability Control (ESC) and ABS systems. The vehicle displayed warning messages stating “Brake System Failure” and “Service ESC” and entered a reduced-speed mode. Prior to this incident, there were no warning lights, messages, or symptoms indicating a problem. During the failure, the brakes became largely unresponsive, placing me, my two minor children who were passengers in the vehicle, and surrounding motorists at serious risk of a high-speed collision. After extended deceleration, a minimal amount of braking power partially returned, allowing the vehicle to eventually come to a stop. The vehicle has not yet been inspected by a dealer, manufacturer, police, or insurance representatives, and the issue has not yet been reproduced or confirmed by a service center. The vehicle remains available for inspection upon request and has not been repaired. This incident occurred without prior warning and involved a sudden and dangerous loss of braking capability at highway speed.
NHTSA ODI #11712998
Mileage unknown · Dec 17, 2025
Forward Collision AvoidanceService BrakesSteering
Vehicle lost steering and brakes suddenly. Many errors on screen such as: Brake System Failure, ABS Failure, ESC Failure, Traction Control Failure, Maximum Vehicle Speed 43mph. Was able to slowly get home with no power assisted brakes. Did not drive it any more until it was taken to dealer 2 days later and the dealer could n…
Read full complaint
Vehicle lost steering and brakes suddenly. Many errors on screen such as: Brake System Failure, ABS Failure, ESC Failure, Traction Control Failure, Maximum Vehicle Speed 43mph. Was able to slowly get home with no power assisted brakes. Did not drive it any more until it was taken to dealer 2 days later and the dealer could not replicate the errors. Dealer was able to see stored error codes; however, they could not verify any errors in any of the modules or computer. Dealer wants us to take it back and wife is scared to drive it due to no fixes or repairs. Loss of brakes and steering is NOT a situation to ask an owner to 'bring back when it happens again"
NHTSA ODI #11705535
Mileage unknown · Dec 10, 2025
Forward Collision AvoidanceService BrakesVehicle Speed Control
While driving in approximately 10°F weather after the vehicle had been parked outside overnight during snowfall in Chicago, the vehicle displayed a warning that said “Do Not Drive — Maximum Speed 43 MPH.” At the same time, the brake pedal became extremely hard and the vehicle had significantly reduced braking ability, requiring …
Read full complaint
While driving in approximately 10°F weather after the vehicle had been parked outside overnight during snowfall in Chicago, the vehicle displayed a warning that said “Do Not Drive — Maximum Speed 43 MPH.” At the same time, the brake pedal became extremely hard and the vehicle had significantly reduced braking ability, requiring much longer stopping distance. This occurred without any brake warning lights beforehand. After the vehicle warmed up and was restarted, the message eventually cleared but then there was a new transmission warning and the check engine light went on. After driving for a long commute, eventually all warnings disappeared. I personally know another 2023 Yukon owner who experienced the exact same message and braking loss under similarly cold conditions, which suggests this may be a broader safety issue affecting this model year. Because this involved a sudden safety-system activation combined with temporary brake loss, there was a real risk of being unable to stop the vehicle safely or avoid a collision. My vehicle is within the year range of GM’s brake-system software recall N242447990 (eBCM brake fluid loss detection issue), and it is unclear whether my case is related, but the symptoms point to a potential systemic braking or electronic brake control problem in the 2023 Yukon. This issue warrants investigation due to the combination of: • Hard brake pedal • Reduced braking performance • Speed-limiting safety warning • No prior diagnostic warning • Occurrence in very cold temperatures A sudden loss of braking ability is a serious safety defect.
NHTSA ODI #11704198
Mileage unknown · Nov 14, 2025
Service Brakes
8/26/2025 I purchased the vehicle from Maguire in Syracuse, NY with open recalls. It is my understanding a dealership is required to have these fixed prior to selling a vehicle. I now have to drive 45 mins each way to get them fixed and miss additional 2 hours for wait time from work. Brakes could fail causing an accide…
Read full complaint
8/26/2025 I purchased the vehicle from Maguire in Syracuse, NY with open recalls. It is my understanding a dealership is required to have these fixed prior to selling a vehicle. I now have to drive 45 mins each way to get them fixed and miss additional 2 hours for wait time from work. Brakes could fail causing an accident.
NHTSA ODI #11699334
Mileage unknown · Aug 11, 2025
Service BrakesSteering
1. First incident While driving, the brakes failed and the entire infotainment/tablet system locked up. This presented a severe safety risk to my family and others on the road. The vehicle had to be towed to DEALER where I was told that “no problems were found.” I documented the incident with photos and videos showing the wa…
Read full complaint
1. First incident While driving, the brakes failed and the entire infotainment/tablet system locked up. This presented a severe safety risk to my family and others on the road. The vehicle had to be towed to DEALER where I was told that “no problems were found.” I documented the incident with photos and videos showing the warning messages and system status. 2. Second incident Approximately one week ago, after shutting off the vehicle, a “steering wheel lock” warning appeared and the truck became completely disabled. Even with jumper cables, it would not start. The vehicle had to be flatbed towed to DEALER. I again documented the incident with photos and videos showing the warnings.
NHTSA ODI #11679904
Mileage unknown · May 13, 2025
Service Brakes
My wife was driving in the vehicle with our two (2) infants on Dixie Hwy in Boca Raton, FL when the breaks suddenly stopped working. Fortunately, there was not a lot of traffic on the road at this time and eventually the vehicle slowed down and no one was injured. No warning lights came on. Once the car came to a complete stop m…
Read full complaint
My wife was driving in the vehicle with our two (2) infants on Dixie Hwy in Boca Raton, FL when the breaks suddenly stopped working. Fortunately, there was not a lot of traffic on the road at this time and eventually the vehicle slowed down and no one was injured. No warning lights came on. Once the car came to a complete stop my wife turned off the vehicle and started it back up; still no warning lights or anything. My wife drove a little further to get to a safer location (not in the middle of the road), unfortunately the car then completely stopped working and my wife was still stuck in the middle of the road...eventually a police officer (crash inspector) came to the scene and the car was towed to the dealership for repairs.
NHTSA ODI #11660704
Mileage unknown · Jan 27, 2025
Service BrakesUnknown Or Other
I took my SUV (Yukon SLT 2023) to the GMC Dealership 4/5 months ago because of 2 recalls, Failed Brake Fluid Leak Detection and Serial Data Gateway Model. The car was repaired according to the dealership. About 2 weeks ago, I entered my garage to auto start my vehicle and my SUV would not auto start. I waited a few minutes and t…
Read full complaint
I took my SUV (Yukon SLT 2023) to the GMC Dealership 4/5 months ago because of 2 recalls, Failed Brake Fluid Leak Detection and Serial Data Gateway Model. The car was repaired according to the dealership. About 2 weeks ago, I entered my garage to auto start my vehicle and my SUV would not auto start. I waited a few minutes and tried to start it again from inside the vehicle and it started. When it started, the engine light was on and on the dashboard, brake system failure was displaying. It was very strange. So, I let my vehicle idle for a couple of minutes and tried to move the car in the garage. The car started jerking when I put it in drive and a message displayed on the dashboard telling me not to drive my SUV over 40 mph. The brake system failure and engine light were still on. It was very strange. I parked my SUV and let it sit. I'm taking my SUV back to the dealership on Thursday. I'm thankful I wasn't on the highway traveling to work, who knows what could have happened. There are massive problems with these vehicles, brakes, engine, computer systems, etc. I do not feel safe driving my SUV. I drive 41 miles each way for work and I don't feel safe driving this vehicle now with all the recalls, including the engine.
NHTSA ODI #11638837
44,871 miles · Nov 25, 2024
Power TrainService BrakesTraction Control System
The contact owns a 2023 GMC Yukon. The contact stated that after starting the vehicle, the transmission shifter failed to shift from park. The contact stated that the "Braking System", Brake Pad Monitor, and Traction Control messages were displayed. The vehicle was towed to the local dealer. The cause of the failure was not yet …
Read full complaint
The contact owns a 2023 GMC Yukon. The contact stated that after starting the vehicle, the transmission shifter failed to shift from park. The contact stated that the "Braking System", Brake Pad Monitor, and Traction Control messages were displayed. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was not yet contacted. The failure mileage was 44,871.
NHTSA ODI #11627169
Official recalls
4Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Sep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Sep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration