NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
43 reportsClear category filterMileage unknown · Sep 14, 2026
EnginePower Train
On May 8th of 2026 my 2023 GMC Yukon with approximately 42,900 miles experienced an complete failure of the 6.2L engine requiring replacement. The engine failure occurred despite the engine having recently undergone inspection and special oil being used related to NHTSA 25V274 / GM N252494000 recall. When the engine failed, t…
Read full complaint
On May 8th of 2026 my 2023 GMC Yukon with approximately 42,900 miles experienced an complete failure of the 6.2L engine requiring replacement. The engine failure occurred despite the engine having recently undergone inspection and special oil being used related to NHTSA 25V274 / GM N252494000 recall. When the engine failed, the vehicle could not be towed or pushed out of the flow of traffic because the computer will not allow the vehicle to be shifted into neutral, only showing "Conditions not correct for shift" in the instrument cluster. This sudden and unexpected loss of engine power combined with the inability to remove the vehicle from the lane of traffic creates a dangerous situation.
NHTSA ODI #11764052
Mileage unknown · Sep 3, 2026
Power Train
L87 recall was completed on 10/22/2025. On August 8th 2026 the engine developed a loud knock. It was taken to the dealership on 8/31/2026 after inspection it was determined that the engine had failed and needed to be replaced. There was no warning lamps that indicated there was an issue with the engine. The vehicle was still d…
Read full complaint
L87 recall was completed on 10/22/2025. On August 8th 2026 the engine developed a loud knock. It was taken to the dealership on 8/31/2026 after inspection it was determined that the engine had failed and needed to be replaced. There was no warning lamps that indicated there was an issue with the engine. The vehicle was still driveable when it was taken to the dealership. If the engine had completely failed while on the highway it could have caused a major incident.
NHTSA ODI #11761950
Mileage unknown · Aug 31, 2026
Electrical SystemEnginePower Train
I have a 2023 GMC Yukon that has been to the dealership 3 times in a weeks time, and as of today, 8/31/26 will be the fouth time. On 2 occasions, the SUV has entered Limp Mode while driving. I had the SUV towed for the first limp mode, and the dealer claimed it needed recalibration modules. I picked up the car and drove home eig…
Read full complaint
I have a 2023 GMC Yukon that has been to the dealership 3 times in a weeks time, and as of today, 8/31/26 will be the fouth time. On 2 occasions, the SUV has entered Limp Mode while driving. I had the SUV towed for the first limp mode, and the dealer claimed it needed recalibration modules. I picked up the car and drove home eight miles, and the check engine light came on. I returned the next day for readings and TCM P0700, P1789, U0101, U220F. The dealer's solution was to recalibrate the gateway module this time. I drove the car about 20-ish miles, and at highway speeds on the freeway, I got limp mode again. Off to the dealership, having the SUV towed again. The dealership has claimed the electrionic car codes clear themselves and because of that they can't re-create the codes to find a solution. I am scared to drive my SUV, I do not feel safe in it let alone my children.
NHTSA ODI #11760969
Mileage unknown · Aug 29, 2026
Power Train
My vehicle previously experienced engine problems severe enough that the engine was replaced. Despite the engine replacement, the vehicle is continuing to experience an engine misfire, and the check-engine light has been flashing. A flashing check-engine light and active misfire are a serious safety concern because the vehicle m…
Read full complaint
My vehicle previously experienced engine problems severe enough that the engine was replaced. Despite the engine replacement, the vehicle is continuing to experience an engine misfire, and the check-engine light has been flashing. A flashing check-engine light and active misfire are a serious safety concern because the vehicle may experience rough running, reduced power, hesitation, or potential loss of power while driving. The fact that the misfire continues after an engine replacement raises concerns that the underlying problem was not resolved or that another component or system is malfunctioning. The exact cause of the current misfire is UNKNOWN at this time. The vehicle and/or affected components are available for inspection upon request.
NHTSA ODI #11760669
Mileage unknown · Aug 27, 2026
EngineFuel/propulsion SystemPower Train
My 2023 GMC Yukon AT4 with the 6.2L V8 has experienced multiple serious engine-related failures. The original engine previously was making a whining / knocking noise, then seized and required complete engine replacement under a GM recall/campaign involving 6.2L engine failures. The replacement engine later developed a lifter/va…
Read full complaint
My 2023 GMC Yukon AT4 with the 6.2L V8 has experienced multiple serious engine-related failures. The original engine previously was making a whining / knocking noise, then seized and required complete engine replacement under a GM recall/campaign involving 6.2L engine failures. The replacement engine later developed a lifter/valvetrain failure and required lifter replacement. The vehicle is now again exhibiting a pronounced rhythmic mechanical knocking/tapping noise, primarily during cold starts after sitting for an extended period. The noise occurs on most cold starts and has been documented in multiple videos. The vehicle is currently at a GMC dealership for inspection. I provided the dealer with several videos clearly demonstrating the noise. The dealer has stated that it has not yet been able to reproduce the condition and is attempting additional cold-start testing. The exact cause is currently UNKNOWN. No consistent warning lights or dashboard messages have appeared with the current knocking condition. My concern is that this vehicle has already experienced a catastrophic engine seizure, followed by internal valvetrain/lifter failure in the replacement engine, and is now again exhibiting abnormal mechanical engine noise. I am concerned this may indicate another developing internal engine failure that could potentially result in engine seizure or sudden loss of power while driving, including at highway speeds or in traffic. The vehicle and engine remain available for inspection, and multiple video recordings of the recurring cold-start knocking are available.
NHTSA ODI #11760082
Mileage unknown · Aug 27, 2026
Power Train
The powertrain malfunctioned and it at the dealership for an engine replacement. The vehicle lost propulsion on a 2-lane road while passing another vehicle. It cut off completely and started to decelerate. There was no warning or indication that this would happen and was dangerous in that I was accelerating to pass another vehi…
Read full complaint
The powertrain malfunctioned and it at the dealership for an engine replacement. The vehicle lost propulsion on a 2-lane road while passing another vehicle. It cut off completely and started to decelerate. There was no warning or indication that this would happen and was dangerous in that I was accelerating to pass another vehicle when the event occurred. I was able to safely pull into a driveway, but the vehicle would not crank as it could not detect what gear it should be in. It was towed to a GMC dealership locally who confirmed 2 days later that the engine would have to be replaced. It is under warranty and will take 3-4 weeks.
NHTSA ODI #11759987
Mileage unknown · Aug 6, 2026
Power Train
About 6 times during higher speed operation 80+km/hr during a downshift, the rear wheels lock up causing panic from screeching tires and sudden deceleration. Extremely unsafe. The vehicle is in with the dealership and as suspected, they can't find any issues with codes or transmission pressures. We even have a sound recordin…
Read full complaint
About 6 times during higher speed operation 80+km/hr during a downshift, the rear wheels lock up causing panic from screeching tires and sudden deceleration. Extremely unsafe. The vehicle is in with the dealership and as suspected, they can't find any issues with codes or transmission pressures. We even have a sound recording of the tires locking up. Typical symptoms of the valve body failure. Hopefully there's parts available soon.
NHTSA ODI #11755336
Mileage unknown · Jul 8, 2026
Electrical SystemPower TrainService Brakes
On June 25, 2026 my 2023 GMC Yukon Denali with 53,456 miles was brought to an authorized GMC dealership after displaying a Service 4WD warning light and exhibiting a groaning noise when shifting into Drive and Reverse. The vehicle was diagnosed with the following brake system fault codes: P25A2, C0511, C0517, C1595 and C1596. Th…
Read full complaint
On June 25, 2026 my 2023 GMC Yukon Denali with 53,456 miles was brought to an authorized GMC dealership after displaying a Service 4WD warning light and exhibiting a groaning noise when shifting into Drive and Reverse. The vehicle was diagnosed with the following brake system fault codes: P25A2, C0511, C0517, C1595 and C1596. These codes indicate brake control module failure and wheel speed sensor faults which are safety critical components. The dealership confirmed these findings but stated the repairs are not covered under the GMC powertrain warranty. Given that these are safety critical brake system failures on a nearly new vehicle with only 53,456 miles, we contacted GMC Customer Care on July 1, 2026 to request coverage under goodwill warranty as we believe these failures constitute a manufacturing defect. A case was opened however after 7 days no case advisor has been assigned and no decision has been made despite two promised timelines not being met. The brake system failures on a nearly new vehicle represent a serious safety concern as these systems directly affect the vehicle's ability to stop safely. The vehicle has been at the dealership since June 25, 2026 and remains unrepaired.
NHTSA ODI #11749116
Mileage unknown · Jun 18, 2026
EngineFuel/propulsion SystemPower Train
Vehicle had previously undergone the GM 6.2L engine recall inspection on October 17, 2025, and was determined to have passed. On June 13, 2026, at approximately 80,390 miles, the vehicle suddenly lost propulsion while being driven with five children in the vehicle. The vehicle became inoperable and required towing. Dealer subseq…
Read full complaint
Vehicle had previously undergone the GM 6.2L engine recall inspection on October 17, 2025, and was determined to have passed. On June 13, 2026, at approximately 80,390 miles, the vehicle suddenly lost propulsion while being driven with five children in the vehicle. The vehicle became inoperable and required towing. Dealer subsequently diagnosed engine failure and has ordered a replacement engine. This failure happened with out warning.
NHTSA ODI #11744974
Mileage unknown · May 20, 2026
Power Train
Owner was driving at highway speeds and the vehicle experienced multiple sudden stops. After consulting with the GMC certified repair facility, the control valve body of the transmission was determined to be faulty and replaced. As a result of the sudden stop at highway speeds, the owner experienced a torn rotator cuff and cou…
Read full complaint
Owner was driving at highway speeds and the vehicle experienced multiple sudden stops. After consulting with the GMC certified repair facility, the control valve body of the transmission was determined to be faulty and replaced. As a result of the sudden stop at highway speeds, the owner experienced a torn rotator cuff and could have been involved in a serious motor vehicle crash.
NHTSA ODI #11739081
Official recalls
4Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Sep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Sep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration