NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
52 reportsClear category filter32,000 miles · Jul 9, 2019
Service BrakesVehicle Speed Control
1. LOSS OF BRAKING FUNCTION AND COULD NOT STOP VEHICLE, LOSS OF CONTROL OF VEHICLE ON HIGHWAY AND STREET AT SPEEDS OF 70 MPH. BRAKE VACUUM PUMP WAS CONFIRMED DEFECTIVE AT DEALERSHIP 10/17/18. 2. AFTER REPAIR BY DEALERSHIPS BRAKES DID NOT FUNCTION CORRECT AGAIN, CONFIRMED AND STATED ON DEALERSHIP INVOICE 6/28/19 SAME PART NUM…
Read full complaint
1. LOSS OF BRAKING FUNCTION AND COULD NOT STOP VEHICLE, LOSS OF CONTROL OF VEHICLE ON HIGHWAY AND STREET AT SPEEDS OF 70 MPH. BRAKE VACUUM PUMP WAS CONFIRMED DEFECTIVE AT DEALERSHIP 10/17/18. 2. AFTER REPAIR BY DEALERSHIPS BRAKES DID NOT FUNCTION CORRECT AGAIN, CONFIRMED AND STATED ON DEALERSHIP INVOICE 6/28/19 SAME PART NUMBER WAS DEFECTIVE AGAIN, DEALERSHIP THAT CONDUCTED REPAIR ON 10/17/19 REPAIRED DEFECTIVE BRAKE WITH THE SAME DEFECTIVE PART. THERE WAS ANOTHER BRAKE ISSUE WITH THE BRAKING SYSTEM IN FEBRUARY AS WELL. 3 BRAKE ISSUES UNDER 1 YEAR AND REPEAT DEFECTIVE PART USED IN DEALERSHIP FOR REPAIR. MULTIPLE DATES BELOW BUT 10/17/19 SPECIFIES DATE CONFIRMED AT GM DEALERSHIP ED RINKE.
NHTSA ODI #11230416
60,000 miles · Jun 15, 2019
Service Brakes
LOW SPEEDS THE BRAKES FAIL , WHEN PRESSING ON BRAKES YOU GET A HARD BRAKE PEDAL WITH NO BRAKES .
NHTSA ODI #11220355
39,000 miles · Jun 7, 2019
Exterior LightingService Brakes
REAR BRAKE LIGHT LED STRIP IS OUT. VEHICLE ONLY HAS 37K MILES ON IT. DEALERSHIP WILL NOT REPAIR IT BUT WANTS TO SELL A NEW BRAKE ASSEMBLY FOR $750 EACH. IF YOU TAP ON THE LIGHT ASSEMBLY, IT COMES ON MOMENTARY AND GOES OUT AGAIN. BRAKE LIGHTS ON BOTH SIDE OF VEHICLE CONTINUE TO FLASH RAPIDLY, THERE HAS TO BE SOME TYPE O OFELECT…
Read full complaint
REAR BRAKE LIGHT LED STRIP IS OUT. VEHICLE ONLY HAS 37K MILES ON IT. DEALERSHIP WILL NOT REPAIR IT BUT WANTS TO SELL A NEW BRAKE ASSEMBLY FOR $750 EACH. IF YOU TAP ON THE LIGHT ASSEMBLY, IT COMES ON MOMENTARY AND GOES OUT AGAIN. BRAKE LIGHTS ON BOTH SIDE OF VEHICLE CONTINUE TO FLASH RAPIDLY, THERE HAS TO BE SOME TYPE O OFELECTRICAL PROBLEM TO CAUSE THIS ISSUE,
NHTSA ODI #11218428
108,000 miles · May 13, 2019
Power TrainService Brakes
WHEN IN TRAFFIC AT SLOW SPEEDS THE BRAKE SYSTEM SHUTS DOWN AND TAKES MY BODY WEIGHT TO STOP CAR. HAD CHECKED AND NO VISIBLE LEAK. NOW GMC HAS A FIX BUT CHARGE TO FIX IF OVER WARRANTY MILEAGE. SECOND ISSUE IS THE TRANSMISSION WENT AT 96,000 MILES WHILE HIGHWAY DRIVING LOOSING ALL TOP END GEARS AT 65 MPH. GMC DID NOTHING BUT DE…
Read full complaint
WHEN IN TRAFFIC AT SLOW SPEEDS THE BRAKE SYSTEM SHUTS DOWN AND TAKES MY BODY WEIGHT TO STOP CAR. HAD CHECKED AND NO VISIBLE LEAK. NOW GMC HAS A FIX BUT CHARGE TO FIX IF OVER WARRANTY MILEAGE. SECOND ISSUE IS THE TRANSMISSION WENT AT 96,000 MILES WHILE HIGHWAY DRIVING LOOSING ALL TOP END GEARS AT 65 MPH. GMC DID NOTHING BUT DEALER HELPED ON THO AS WELL
NHTSA ODI #11207182
62,000 miles · Apr 4, 2019
Service Brakes
VEHICLE IN MOTION AND BRAKES WOULD NOT WORK UNLESS YOU PUT ALL YOUR BODY WEIGHT ON THE BRAKES, AND THEN JUST BARELY. HAPPENED MULTIPLE TIMES ON AND OFF BOTH AT HIGH RATE OF SPEED ON HIGHWAY AND ON CITY STREETS. TOOK INTO GMC DEALERSHIP AND THEY REPLACED THE VACUUM PUMP FOR THE BRAKES -- PROBLEM SOLVED AFTER SPENDING $800. WE …
Read full complaint
VEHICLE IN MOTION AND BRAKES WOULD NOT WORK UNLESS YOU PUT ALL YOUR BODY WEIGHT ON THE BRAKES, AND THEN JUST BARELY. HAPPENED MULTIPLE TIMES ON AND OFF BOTH AT HIGH RATE OF SPEED ON HIGHWAY AND ON CITY STREETS. TOOK INTO GMC DEALERSHIP AND THEY REPLACED THE VACUUM PUMP FOR THE BRAKES -- PROBLEM SOLVED AFTER SPENDING $800. WE ARE LUCKY THIS IS A MAJOR SAFETY ISSUE THAT COULD HAVE CAUSED A SERIOUS ACCIDENT. I UNDERSTAND THIS EXACT PROBLEM IS A KNOWN PROBLEM CURRENTLY BEING INVESTIGATED. PLEASE FINISH YOUR INVESTIGATION QUICKLY AND ISSUE A RECALL -- SOMEBODY IS GOING TO GET KILLED IF THIS IS NOT FIXED. I LOOK FORWARD TO BEING REIMBURSED FROM GMC WHEN THE RECALL IS FINALLY ISSUED.
NHTSA ODI #11193808
Mileage unknown · Feb 20, 2019
Service Brakes
VACUUM PUMP WENT OUT ON MY VEHICLE RESULTING IN ALMOST BEING HIT BY A SEMI TRAVELING 65MPH. I HAD TO CALL A WRECKER TO PICK UP MY VEHICLE AND HAVE IT TOWED TO THE DEALERSHIP AS IT WAS NO LONGER SAFE TO DRIVE. I PAID OUT OF POCKET FOR THE WRECKER AND THE REPAIR BECAUSE THE VACUUM PUMP WAS NO LONGER COVERED UNDER WARRANTY AT 38,63…
Read full complaint
VACUUM PUMP WENT OUT ON MY VEHICLE RESULTING IN ALMOST BEING HIT BY A SEMI TRAVELING 65MPH. I HAD TO CALL A WRECKER TO PICK UP MY VEHICLE AND HAVE IT TOWED TO THE DEALERSHIP AS IT WAS NO LONGER SAFE TO DRIVE. I PAID OUT OF POCKET FOR THE WRECKER AND THE REPAIR BECAUSE THE VACUUM PUMP WAS NO LONGER COVERED UNDER WARRANTY AT 38,633 MILES. I WAS LEAVING A DRIVEWAY AT A SLOW SPEED TO TURN ONTO A FARM TO MARKET ROAD AND MY BRAKES WOULD NOT WORK.
NHTSA ODI #11181432
52,989 miles · Feb 15, 2019
Service Brakes
THIRD TIME THIS HAPPENED, FIRST TWO TIMES MY HUSBAND WAS DRIVING(HE CALLED THE DEALERSHIP AND THEY SAID THEY HAD NOT HEARD OF ANY PROBLEMS) AND WHEN IT HAPPENED TO ME IT WAS SCARY. I HAD MY KIDS IN THE CAR, NO INJURIES AND NO ONE WAS HURT, THANK GOD. I WAS GOING THROUGH THE DRIVE THRU STOPPED AT THE FIRST WINDOW, ACCELERATED TO …
Read full complaint
THIRD TIME THIS HAPPENED, FIRST TWO TIMES MY HUSBAND WAS DRIVING(HE CALLED THE DEALERSHIP AND THEY SAID THEY HAD NOT HEARD OF ANY PROBLEMS) AND WHEN IT HAPPENED TO ME IT WAS SCARY. I HAD MY KIDS IN THE CAR, NO INJURIES AND NO ONE WAS HURT, THANK GOD. I WAS GOING THROUGH THE DRIVE THRU STOPPED AT THE FIRST WINDOW, ACCELERATED TO NEXT WINDOW (LOW SPEED) AND DIDN'T STOP... IT WAS THE LIKE THE BRAKES LOCKED UP, COULDN'T PRESS DOWN AT ALL. CALLED THE DEALERSHIP FIRST THING IN THE MORNING, SAME THING DIDN'T KNOW OF ANY ISSUES. WELL I GOOGLED IT AND IT IS UNDER INVESTIGATION, SO I KINDLY PRINTED OFF ALL THE ARTICLES SO THEY COULD LET OTHER CUSTOMERS KNOW THERE WAS AN ISSUE (THEY DIDN'T CARE TO KEEP THAT BUT DID ADMIT THEY KNEW THERE HAD BEEN SOME ISSUES). OF COURSE MY CAR IS JUST OUT OF WARRANTY SO THEY SAID I WOULD BE RESPONSIBLE FOR ANY ISSUES. AGAIN, THIS IS A SAFETY ISSUE AND THERE SHOULD BE A RECALL!!! THEY SHOULD BE PAYING FOR IT AND THANKING THERE LUCKY STARS NO ONE WAS INJURED. THE TOTAL CAME TO $950, THEY ASKED IF I WANTED THEM TO FIX THE PUMP, BELT AND BELT KIT (I ASKED IF THIS WAS THE ISSUE OTHERS WERE HAVING AND HE SAID HE BELIEVES SO). WHAT WAS I GOING TO SAY NO? DID I REALLY HAVE AN OPTION?? THE BRAKES WEREN'T WORKING!!!! KIND OF A BIG DEAL!! OF COURSE I WOULD LIKE THEM TO PAY ME BACK (THEY DID GIVE ME A CREDIT OF $208) BUT I DO BELIEVE THEY NEED TO DO A RECALL BEFORE SOMEONE GETS HURT.
NHTSA ODI #11180362
50,000 miles · Jan 21, 2019
Service Brakes
BRAKES FAIL AT LOW SPEEDS AND WHEN REVERSING SLOWLY. CAN REPLICATE PROBLEM. SEARCHED INTERNET AND THIS APPEARS TO BE A WIDESPREAD PROBLEM. SERVICE BULLETINS HAVE EVEN BEEN WRITTEN. WHY NO RECALL FOR A WIDESPREAD ISSUE THAT COULD HAVE CATASTROPHIC CONSEQUENCES. . VEHICLE HAS LESS THAN 50000 MILES.
NHTSA ODI #11171277
56,000 miles · Jan 14, 2019
Service Brakes
WHEN PRESSING THE BRAKE PETAL AT LOW SPEEDS AND IN BUMPER TO BUMPER TRAFFIC THE BRAKE PEDAL BECOMES VERY HARD TO PRESS AND VERY DIFFICULT TO GET THE VEHICLE TO STOP. THIS PROBLEM ALSO IS NOTICED WHEN BACKING THE VEHICLE IN REVERSE AND INTO A PARKING SPOT.
NHTSA ODI #11169844
77,200 miles · Dec 13, 2018
Service Brakes
WHEN PRESSING THE BRAKE PETAL AT LOW SPEEDS AND IN BUMPER TO BUMPER TRAFFIC THE BRAKE PEDAL BECOMES VERY HARD TO PRESS AND VERY DIFFICULT TO GET THE VEHICLE TO STOP. THIS PROBLEM ALSO IS NOTICED WHEN BACKING THE VEHICLE IN REVERSE AND INTO A PARKING SPOT.
NHTSA ODI #11161178
Official recalls
5Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Apr 28, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Silverado 1500 and 2016 Cadillac Escalade, Cadillac Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Sierra, GMC Yukon and GMC Yukon XL vehicles. The front upper control arms may have inadequate welds near the control arm bushing.
Consequence & remedy
Consequence: Inadequate welds may allow the control arm to separate from the bushing, compromising steering and increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the left and right front upper control arms and realign the vehicle, free of charge. The recall began on May 18, 2016. Until the repairs have been made, owners are advised not to drive their vehicles. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, or GMC customer service at 1-800-462-8782. GM's number for this recall is 42190.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration