IllustrationAIR CONDITIONING TURNS TO EXTREME HEAT WHILE DRIVING! DANGER FOR DRIVER
2005 GMC Yukon
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 GMC Yukon do not stand out strongly from the model-year median of 103.
About this comparison →How this year compares
Owner complaints by model year
Compare all Yukon years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1025–50K
2050–75K
1275–100K
17100–150K
7150K+
75 reports with mileage · 10 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports3 injury reports
Electrical System complaints
28 reportsI HAVE NOTICED OVER THE PAST YEAR THAT THE SHIFT INDICATOR IN THE INSTRUMENT CLUSTER HAS BEEN INTERMITTENT/NOT VISIBLE DURING ANY OPERATION OF CAR OPERATION. THIS HAS BEEN A COMPLAINT TO THE LOCAL DEALER DO TO A SAFETY ISSUE IN WHICH YOU DO NOT SEE WHAT POSITION THE SHIFT INDICATOR IS IN.
TL* THE CONTACT OWNS A 2005 GMC YUKON. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE AIR CONDITIONER VENTS. IN ADDITION, THE CABLE UNDER THE DASHBOARD ON THE PASSENGER SIDE CAUGHT FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAG…
Read full complaint
TL* THE CONTACT OWNS A 2005 GMC YUKON. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE AIR CONDITIONER VENTS. IN ADDITION, THE CABLE UNDER THE DASHBOARD ON THE PASSENGER SIDE CAUGHT FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
TL* THE CONTACT OWNS A 2005 GMC YUKON. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT REMAINED ILLUMINATED. THE ONSTAR DIAGNOSTIC CHECK DETERMINED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.
AT THE INITIAL START UP AND THE FOLLOW ON DRIVE SELECTION OF THE VEHICLE, THE DRIVE SELECTOR INDICATOR ON THE (SPEEDO) SPEED CLUSTER FAILS TO LIGHT UP TO BE ABLE TO SEE THE EXACT GEAR THE VEHICLE IS IN. DURING LOW LIGHT TIMES THE INDICATION IS BARELY VISIBLE AND DAY LIGHT HOURS YOU ARE UNABLE TO SEE THE INDICATION TO ENSURE THE …
Read full complaint
AT THE INITIAL START UP AND THE FOLLOW ON DRIVE SELECTION OF THE VEHICLE, THE DRIVE SELECTOR INDICATOR ON THE (SPEEDO) SPEED CLUSTER FAILS TO LIGHT UP TO BE ABLE TO SEE THE EXACT GEAR THE VEHICLE IS IN. DURING LOW LIGHT TIMES THE INDICATION IS BARELY VISIBLE AND DAY LIGHT HOURS YOU ARE UNABLE TO SEE THE INDICATION TO ENSURE THE PROPER GEAR OF VEHICLE WHICH COULD RESULT IN SELECTING WRONG GEAR. *JS
TL* THE CONTACT OWNS A 2005 GMC YUKON. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO IMMEDIATELY RESTART THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE …
Read full complaint
TL* THE CONTACT OWNS A 2005 GMC YUKON. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO IMMEDIATELY RESTART THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 147,000.
THIS IS THE 2ND OCCURRENCE OF THE SAME INCIDENT IN 3 MONTHS. WHILE MOVING SLOWLY THROUGH A PARKING LOT, THE ENGINE JUST STOPS. NO SHUDDER, NO ROUGH IDLE, NO WARNING. WITHOUT POWER, STEERING IS IMPAIRED OR IMPOSSIBLE. TURNING THE IGNITION KEY RESTARTS THE ENGINE NORMALLY. JIGGLING THE KEY CANNOT REPLICATE THE PROBLEM. *TR
MY SPEEDOMETER QUIT WORKING AND I CHECKED AND IT IS A FACTORY DEFECT. *TR
TL* THE CONTACT OWNS A 2005 GMC YUKON. THE CONTACT STATED THE INSTRUMENT PANEL GAUGES FAILED TO WORK PROPERLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 199,000. UPDATED 11/14/11 *BF
INTERIOR VEHICLE FIRE IN DASH. 1ST SMOKE THEN CENTER OF DASH ERUPTED INTO FLAMES. VEHICLE IS NOW TOTALLED. GMC IS AWARE OF THIS CONDITION AND ISSUED NO RECALLS. APPEARS SERVICE BULLETINS WERE ISSUED ABOUT REPLACING OVER HEATING RESISTORS FOR THE (HAVC) OPERATING SYSTEM. THE FAN WOULD EITHER STOP WORKING IN A FEW POSITIONS /STOP …
Read full complaint
INTERIOR VEHICLE FIRE IN DASH. 1ST SMOKE THEN CENTER OF DASH ERUPTED INTO FLAMES. VEHICLE IS NOW TOTALLED. GMC IS AWARE OF THIS CONDITION AND ISSUED NO RECALLS. APPEARS SERVICE BULLETINS WERE ISSUED ABOUT REPLACING OVER HEATING RESISTORS FOR THE (HAVC) OPERATING SYSTEM. THE FAN WOULD EITHER STOP WORKING IN A FEW POSITIONS /STOP WORKING ALL TOGETHER OR OVERHEAT AND SET FIRE. *TR
Official recalls
305V163000 · Seat Belts:rear/other
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
05V103000 · Service Brakes, Hydraulic:pedals And Linkages
Mar 18, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR THE BRAKE PEDAL PUSHROD RETAINER AND INSTALL ONE IF IT IS MISSING FREE OF CHARGE. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON MARCH 10, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
05V055000 · Power Train:manual Transmission:shift Pattern Indicator
Feb 14, 2005
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.