Illustrationlost power going down highway and coasted to a stop on the side of the road. car was towed to a nearby gmc dealership and after inspection a new 6.2 motor is needed. I did not notice any warning signals when I lost power.
2023 GMC Yukon Xl
Owner reports · Recalls · Investigations
More warning signs than most Yukon Xl years
Owner complaints for the 2023 GMC Yukon Xl are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Yukon Xl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 212 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports5 injury reports
What owners actually said
212 reportsEngine 6.2L failed going down the highway. Very Scary
I was on the highway heading home with my [XXX] son in the backseat and without warning the engine shut down and luckily we were on the exit ramp and away from heavy traffic. I pulled over to the side and tried to start it again but it won’t even crank. The cabin heater stopped working too, It was -9 Degrees outside that day an…
Read full complaint
I was on the highway heading home with my [XXX] son in the backseat and without warning the engine shut down and luckily we were on the exit ramp and away from heavy traffic. I pulled over to the side and tried to start it again but it won’t even crank. The cabin heater stopped working too, It was -9 Degrees outside that day and we started to freeze, luckily my wife was able to get to us in 20minutes. The vehicle was towed to GM dealership and they confirmed the engine seized and will need a new engine under special coverage N252494003-03. This was after the recall was completed for this vehicle. It had only 61392KMS on it. We live in [XXX] and it gets extreme winters with below -40degree temperatures. It’s a remote area and there is no service on the highway for 200KMS when heading south to city, if this would have happened on the highway with no services and extreme weather we wouldn’t have made it out alive. We are a family of 5 with a [XXX] and a [XXX] and we bought this vehicle after knowing that the engine recall was completed and GM deemed it safe. Unfortunately that’s a lie and GM is putting peoples safety and life at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
This vehicle was identified as recalled in 2025 for total engine replacement and the engine did fail in May 2025 it would stall while driving. GMC performed the engine replacement in June of 2025. The car stalled again on Friday May 1. It was taken to the dealer on May 7 and was diagnosed as needing another complete engine repla…
Read full complaint
This vehicle was identified as recalled in 2025 for total engine replacement and the engine did fail in May 2025 it would stall while driving. GMC performed the engine replacement in June of 2025. The car stalled again on Friday May 1. It was taken to the dealer on May 7 and was diagnosed as needing another complete engine replacement. I was told that gmc identified a need to replace more parts after my engine was replaced but I was never informed of this. I was told my this dealership that I am the first vehicle they’ve seen that will require a second full engine replacement It is a 6.3L v8. This car stalled while I was driving with a 3yo in the vehicle.
My 2023 GMC Yukon Denali is currently at the dealership due to a manufacturer recall involving the engine. The engine issue occurred while I was driving with my children in the vehicle, which required me to pull over and have the vehicle towed to the dealership After inspection, I was told the vehicle requires a full engine repl…
Read full complaint
My 2023 GMC Yukon Denali is currently at the dealership due to a manufacturer recall involving the engine. The engine issue occurred while I was driving with my children in the vehicle, which required me to pull over and have the vehicle towed to the dealership After inspection, I was told the vehicle requires a full engine replacement. The dealership has stated there is no estimated time of arrival for the replacement engine due to backorder, and that other customers have been waiting for extended periods. I am currently without my vehicle and have been provided a temporary replacement that is not comparable. The extended delay and lack of timeline are causing significant loss of use.
The contact owns a 2023 GMC Yukon XL. The contact stated that while driving on several occasions at various speeds, the vehicle experienced unexpected gear shifting. The check engine warning light illuminated and then disappeared when the vehicle was restarted. The vehicle was not diagnosed or repaired. The contact used a handhe…
Read full complaint
The contact owns a 2023 GMC Yukon XL. The contact stated that while driving on several occasions at various speeds, the vehicle experienced unexpected gear shifting. The check engine warning light illuminated and then disappeared when the vehicle was restarted. The vehicle was not diagnosed or repaired. The contact used a handheld diagnostic machine and retrieved DTC: P0747. The manufacturer was notified of the failure. The failure mileage was 67,000.
on 2/28/26 i experienced complete engine failure on my 23 Yukon. I was going 70mph on the highway when the engine kicked and and kicked into neutral. the car spent 6 weeks in the dealer to have the engine replaced. i picked up the car on Wednesday, 4/15. On 4/16, i was once again driving, as normal when it suddenly turned off a…
Read full complaint
on 2/28/26 i experienced complete engine failure on my 23 Yukon. I was going 70mph on the highway when the engine kicked and and kicked into neutral. the car spent 6 weeks in the dealer to have the engine replaced. i picked up the car on Wednesday, 4/15. On 4/16, i was once again driving, as normal when it suddenly turned off and kicked into neutral. 1 day after I picked up the vehicle it is once again being towed back to the dealer for the same symptoms it had when the entire engine had to be replaced. Both times, there is no warning. The car dings and a message comes up saying "restart vehicle". On 2/28, the car would not restart. On 4/16, the car did restart but only temporarily This is a major safety problem. The first occurrence I was going 70mph on the highway when i lost power. The second occurrence, I was driving 20mph on my neighborhood street and suddenly lost all power.
I own a 2023 GMC Yukon Denali. In Nov. 2023, at about 4,000 miles, the vehicle suffered a complete engine and electrical failure at highway speed while I was traveling with my husband and three small children. It suddenly lost all power in the fast lane, including acceleration and engine function. Steering became extremely heavy…
Read full complaint
I own a 2023 GMC Yukon Denali. In Nov. 2023, at about 4,000 miles, the vehicle suffered a complete engine and electrical failure at highway speed while I was traveling with my husband and three small children. It suddenly lost all power in the fast lane, including acceleration and engine function. Steering became extremely heavy, consistent with loss of power steering assist, and the electronics shut down. We had to guide the vehicle across traffic while coasting downhill to the shoulder beyond a guardrail. Traffic had to avoid us, creating a serious safety hazard. The vehicle would not restart. The vehicle was towed and required a complete engine replacement under warranty. After that replacement, additional issues followed. There was an HVAC/defrost concern. In June 2025, the vehicle again became inoperable without warning while parked at a store. It would not start despite repeated attempts, including by a dealership representative. A diagnostic scan produced over a page of error codes, but the dealership could not identify a cause and stated the vehicle was safe. In Dec. 2025, the vehicle engine was inspected under a recall and I was told there were no issues. In Feb. 2026, the vehicle lost heat and was found to have no coolant despite regular maintenance and recent inspection. In Mar. 2026, at about 37,700 miles, the vehicle developed a loud clunking noise while driving. I stopped driving and returned it to the dealership, where I was told the engine had failed again and required another full replacement. The vehicle has now had two engine failures and three engines installed in less than three years. There were no warning lights or prior indications before these failures. I no longer believe this vehicle is safe or reliable for transporting my family.
The panoramic sunroof on my 2023 GMC Yukon Denali Ultimate XL spontaneously exploded while driving westbound on I-20 on March 13. There was no impact from road debris, no vehicles ahead, no overpass, and no external cause. The failure sounded like an explosion or gunshot. Tempered glass shattered with the sunroof in the closed p…
Read full complaint
The panoramic sunroof on my 2023 GMC Yukon Denali Ultimate XL spontaneously exploded while driving westbound on I-20 on March 13. There was no impact from road debris, no vehicles ahead, no overpass, and no external cause. The failure sounded like an explosion or gunshot. Tempered glass shattered with the sunroof in the closed position, showering the interior with glass fragments. Five occupants were in the vehicle at the time. No injuries occurred, but the sudden explosive noise and shower of glass created an extreme distraction and safety hazard while operating the vehicle at highway speed. The incident could easily have caused a loss of vehicle control on the interstate. The component that failed is the factory-installed panoramic power sunroof glass, standard equipment on the Denali Ultimate trim. The vehicle was taken to Lugoff Chevrolet for inspection. The dealer confirmed the glass failure and submitted a request to GM for warranty or goodwill coverage. GM offered to cover only 10% of the repair cost, characterizing the failure as an out-of-warranty wear issue despite the spontaneous nature of the defect. There were no warning signs, cracks, chips, warning lamps, or any indication of a problem prior to the failure. The sunroof was closed at the time. The vehicle has been dealer-maintained with no modifications to the sunroof or roof structure. This is a known industry-wide defect. NHTSA has previously investigated spontaneous sunroof shattering and documented over 4,000 complaints. GM has acknowledged awareness of this issue in other GM vehicles and previously issued corrective actions for sunroof glass on the Buick Regal and Chevrolet Cruze. Other GMC Yukon owners have filed NHTSA complaints describing identical failures. The failed sunroof glass and vehicle are available for inspection upon request.
The vehicle has the L87 GM engine. It lost complete power and the engine seized up and would not start again. Fortunately I was able to roll into a neighborhood and get off the main road with no issues. The dealer has confirmed the seized engine and a replacement engine has been ordered with no ETA. There was no prior warning of…
Read full complaint
The vehicle has the L87 GM engine. It lost complete power and the engine seized up and would not start again. Fortunately I was able to roll into a neighborhood and get off the main road with no issues. The dealer has confirmed the seized engine and a replacement engine has been ordered with no ETA. There was no prior warning of the failure, besides a shuddering, like I was running out of gas, and then a lose of complete power.
Official recalls
425V274000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
24V674000 · Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp; Service Brakes, Hydraulic:power Assist:electric:control Module:software
Sep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
23V642000 · Suspension:rear
Sep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
22V903000 · Exterior Lighting:lighting Control Module:software
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.