Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 212 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports5 injury reports
What owners actually said
212 reports
Mileage unknown · Jan 21, 2025
Forward Collision AvoidanceFuel/propulsion System
The contact owns a 2023 GMC Yukon. The contact stated while the vehicle was parked, the vehicle shuddered. The "Service Traction Control" and the "Forward Collision System Unavailable" message was displayed on the instrument panel. The check engine warning light was illuminated. The failure occurred on several different occasion…
Read full complaint
The contact owns a 2023 GMC Yukon. The contact stated while the vehicle was parked, the vehicle shuddered. The "Service Traction Control" and the "Forward Collision System Unavailable" message was displayed on the instrument panel. The check engine warning light was illuminated. The failure occurred on several different occasions. The vehicle was taken to a dealer where it was diagnosed that the fuel injector needed to be replaced. The vehicle was repaired however, over time the failure still persisted. The vehicle was taken back to the dealer where it was diagnosed once again that the fuel injector needed to be replaced. The vehicle was repaired however, over time the failure still persisted. The vehicle was taken back to the dealer for the last time where it was diagnosed once again that the fuel injector needed to be replaced. The vehicle was repaired however, over time the failure still persisted. The manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA ODI #11637294
Mileage unknown · Jan 20, 2025
Engine
The 2023 Yukon XL shut down while traveling at a speed of 70+ MPH.
NHTSA ODI #11637050
Mileage unknown · Jan 20, 2025
Engine
I purchased a 2023 Yukon Denali Ultimate new in December 2023. It has 25,000 miles on it. Last week my wife was driving on the interstate and the vehicle abruptly shut down leaving her stranded on a narrow shoulder on a bridge. After it was towed to the dealer, the diagnosis was a connecting rod failure requiring an engine repla…
Read full complaint
I purchased a 2023 Yukon Denali Ultimate new in December 2023. It has 25,000 miles on it. Last week my wife was driving on the interstate and the vehicle abruptly shut down leaving her stranded on a narrow shoulder on a bridge. After it was towed to the dealer, the diagnosis was a connecting rod failure requiring an engine replacement. It was in the shop 2 weeks prior because the vehicle shifted into neutral on its own while driving at 60 mph on the highway, but the dealer found nothing wrong
NHTSA ODI #11636995
Mileage unknown · Jan 19, 2025
Engine
Hi my 2023 GMC Yukon Denali Ultimate died in the middle of the road due to a catastrophic engine failure. That put my family and I in danger on the highway.
NHTSA ODI #11636880
Mileage unknown · Jan 18, 2025
Engine
ENGINE REPLACED
NHTSA ODI #11636721
Mileage unknown · Jan 15, 2025
Engine
As we were driving down a main road and taking off from a stop light on NW Expressway we had no warning before the car seemed to die and shift itself to N. It said to press the start button, that did nothing and the car would not power back up besides the lights and dash that were still working. We coasted to a stop in a neigh…
Read full complaint
As we were driving down a main road and taking off from a stop light on NW Expressway we had no warning before the car seemed to die and shift itself to N. It said to press the start button, that did nothing and the car would not power back up besides the lights and dash that were still working. We coasted to a stop in a neighborhood entrance. I'm so thankful I was not on the highway during rush hour traffic. Once stopped, we put it in park and tried to start it. A friend came and tried to jump it and still nothing. The dealership has confirmed it needs a full engine replacement. GM has agreed to help with cost but my car has sat inoperable for over 30 days as the engine is on back order with no ETA. It has a 6.2L engine and I had taken it in for pull consumption tests over the past 2 years. The dealerships were unable to duplicate the problem. Two days prior to the failure I had told my husband it was slow to crank and we needed to have the battery checked. I now believe it was the engine, not the battery. There were no warning lights on and my battery indicter showed to be in the middle (not lacking charge). I am aware of a voluntary customer satisfaction program that GM has issued but they have told me my VIN isn't one of the 5000 affected by this. In visiting with the dealership it appears they will not fully break down my engine until the new one has arrived but they are 90% sure of the cause as they've "seen several of these". This could have been catastrophic to have a car die with warning in traffic.
NHTSA ODI #11636156
Mileage unknown · Jan 11, 2025
Unknown Or OtherInjury
During the operation of my 2023 GMC Yukon XL AT4 on [XXX], carbon monoxide (CO) entered the cabin, exposing my children and me to dangerously high levels of CO and causing confirmed carbon monoxide poisoning. We were driving with the engine running and the heater on for approximately 21 minutes when the exposure occurred. Sympto…
Read full complaint
During the operation of my 2023 GMC Yukon XL AT4 on [XXX], carbon monoxide (CO) entered the cabin, exposing my children and me to dangerously high levels of CO and causing confirmed carbon monoxide poisoning. We were driving with the engine running and the heater on for approximately 21 minutes when the exposure occurred. Symptoms began to escalate that day and into the proceeding days, including severe headache, stomachache, pallor, chest pressure, shortness of breath, fatigue, and neurological issues. My children, particularly my [XXX] and [XXX] , experienced the most severe effects— both were very ill especially my [XXX] . Unfortunately, we initially did not believe it was possible for CO to enter the vehicle cabin, which delayed early intervention and appropriate medical care. Blood testing 4 days later confirmed elevated carboxyhemoglobin levels in my [XXX] , the only one tested. During the incident, the battery warning light was the first indication of trouble, but soon after, many additional error messages began flashing on the dashboard. The vehicle then overheated, decelerated, and eventually shut down while driving. We were in the vehicle under 21 minutes. Upon inspection after the incident, my husband noted a severed belt and potential pulley issues. The exact cause of the CO intrusion has not yet been identified. The vehicle is available for inspection and unaltered to preserve evidence. I am writing GMC and requesting further investigation by GMC. This incident reflects a severe safety issue with potentially life-threatening implications for GMC owners. CO exposure can cause significant harm, and delayed identification in this case placed my family at substantial risk. Immediate investigation and corrective action are essential to prevent similar incidents from occurring in the future. Time is critical, as this defect could have catastrophic consequences for other unsuspecting drivers and their families. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11635465
25,100 miles · Dec 31, 2024
Service Brakes, Hydraulic
The contact owns a 2023 GMC Yukon XL. The contact stated that while driving 75 MPH coming to an intersection and attempting to apply the brakes, the vehicle failed to stop as needed. The message brake system failure and speed limited to 62 MPH were displayed on the instrument panel. The vehicle continued and drove through the in…
Read full complaint
The contact owns a 2023 GMC Yukon XL. The contact stated that while driving 75 MPH coming to an intersection and attempting to apply the brakes, the vehicle failed to stop as needed. The message brake system failure and speed limited to 62 MPH were displayed on the instrument panel. The vehicle continued and drove through the intersection. The parking brake failed to stop the vehicle. The vehicle ended up stopping in a ditch and was towed to the dealer to be diagnosed. The contact was informed that the battery terminal had detached, causing 20 different modules to fail. The battery cable was tightened. The manufacturer was made aware of the failure and opened a case for a possible buyback. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 25,100.
NHTSA ODI #11633323
Mileage unknown · Oct 18, 2024
EngineUnknown Or Other
Complete engine failure while operating the vehicle with our children riding along as passengers. The engine failure nearly caused us to wreck. 2023 GMC Yukon XL Denali with only 15,000 miles. And now, I am being told that I need a complete engine replacement and that GMC is well aware of these engine failures and the product d…
Read full complaint
Complete engine failure while operating the vehicle with our children riding along as passengers. The engine failure nearly caused us to wreck. 2023 GMC Yukon XL Denali with only 15,000 miles. And now, I am being told that I need a complete engine replacement and that GMC is well aware of these engine failures and the product defects, yet GMC has refused to issue a recall. To add insult to injury, I’m being told by dealership that it may take several months to get a new engine! We will be pursuing legal action.
NHTSA ODI #11620507
Mileage unknown · Sep 12, 2024
EngineSteeringVehicle Speed Control
Driving in my newer GM Yukon Ultimate at 13k miles on the freeway. Vehicle with no warning shuts down while going 60mph in the middle lane. Was able to safely steer the car to the side of the road to avoid a collision. Vehicle lost all electrical contact. could not shift into neutral to tow. Turns out vehicle engine had to be …
Read full complaint
Driving in my newer GM Yukon Ultimate at 13k miles on the freeway. Vehicle with no warning shuts down while going 60mph in the middle lane. Was able to safely steer the car to the side of the road to avoid a collision. Vehicle lost all electrical contact. could not shift into neutral to tow. Turns out vehicle engine had to be replaced. GM approved a new engine replacement and are planning to return the vehicle back to put on the road. The vehicle is unsafe, at 5k miles, 6 months prior, the vehicle had to have the steering system replaced due to failure as well. Online research shows that others are having the same issue with failed engines on these GM vehicles and models.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 GMC Yukon Xl Problems, Complaints & Recalls | Skip That Year
Illustration