I got into my car to run some errands. As I drove away from my house, I made a left turn downhill. I noticed vehicles ahead, so I began to slow down. At that moment, I was driving between 20 and 25 mph. When I tried to brake, my brakes failed and started flashing a brake failure warning light. I kept pumping the brake pedal, an…
Read full complaint
I got into my car to run some errands. As I drove away from my house, I made a left turn downhill. I noticed vehicles ahead, so I began to slow down. At that moment, I was driving between 20 and 25 mph. When I tried to brake, my brakes failed and started flashing a brake failure warning light. I kept pumping the brake pedal, and eventually, the car slowed down and came to a stop. I turned on my hazard lights, and immediately returned home. My nephew and I were both in the car. Our live flashed in front of us. Thankfully, there were no vehicles directly in front of me or pedestrians. This could have turned out to be the worst day of my life if anyone had been injured.
NHTSA ODI #11754196
Mileage unknown · Feb 17, 2026
Electrical SystemEngineService Brakes
2023 Yukon Denali XL 6.2l: GM oil change recall performed (October 2025) and GMC dealership noted no issues. Prior to recall oil change, at aprox 5k miles interval (45K total miles), check engine oil light on dash and was over 1 quart low. Next oil change at aprox 50K miles, no check engine light came on, but certified mechanic…
Read full complaint
2023 Yukon Denali XL 6.2l: GM oil change recall performed (October 2025) and GMC dealership noted no issues. Prior to recall oil change, at aprox 5k miles interval (45K total miles), check engine oil light on dash and was over 1 quart low. Next oil change at aprox 50K miles, no check engine light came on, but certified mechanic drained and measure oil level, 1.5 quarts low. Engine often sounds odd at cold start, ticking sound. Now an oil change is $100 more, due to special oil, but not compensated for extra cost. Brake calibers failed. February 2026, engine light on, then off, then hood latch dash light warning now on and off. Huge safety concerns with the 2023 GMC Yukon 6.2L.
NHTSA ODI #11718440
Mileage unknown · Feb 3, 2026
Service Brakes
Catastrophic brake system failure. When leaving my home in Baltimore County, MD, at approx. 10:00am on February 3rd, my vehicle started up normally. As I descended down a hill in our neighborhood the brake system failed and the vehicle would not stop. By standing on the brake pedal I slowed enough to put the vehicle in park a…
Read full complaint
Catastrophic brake system failure. When leaving my home in Baltimore County, MD, at approx. 10:00am on February 3rd, my vehicle started up normally. As I descended down a hill in our neighborhood the brake system failed and the vehicle would not stop. By standing on the brake pedal I slowed enough to put the vehicle in park as I entered an intersection with the main road. I have since learned this is the 3rd GMC Yukon (years 2023-2024) that has had the same brake failure in 24 hours in our community.
NHTSA ODI #11715252
Mileage unknown · Nov 24, 2025
Electrical SystemEngineService Brakes
tThe dealer ship refused even talk to me
NHTSA ODI #11701352
Mileage unknown · Jul 28, 2025
Electrical SystemEngineService Brakes
My vehicle’s engine failed for the second time while driving on the road. The first time a few months ago while my wife was driving. The engine failed and brakes failed. Fortunately she was on a back road a coasted to a stop. Car was towed to dealership. They said there was no problem. Received recall letter about a month ago ou…
Read full complaint
My vehicle’s engine failed for the second time while driving on the road. The first time a few months ago while my wife was driving. The engine failed and brakes failed. Fortunately she was on a back road a coasted to a stop. Car was towed to dealership. They said there was no problem. Received recall letter about a month ago outlining this issue. Yesterday, [XXX], I was driving with my daughter and the car stopped again while driving. I was in traffic and narrowly missed an accident. Gwinnett county police came to the scene and towed the vehicle to the dealership. I am not sure if the female officer made a report. But she requested the tow truck because I was blocking traffic. We often drive on the highway for work commutes. This could have happened and anyone in my family could have been fatally injured. I would like GMC purchase this vehicle back or replace with a safer model comparable or better. The service department called me this morning from Jim Ellis GMC in Buford, Georgia 678-902-8677, 3600 Buford Drive 30519.I was told that there is no recall for my truck. He told me that there is a safety investigation for a recall. I told him I can bring the letter. He decline. I asked for a courtesy vehicle. He said no, he would have to make a report and it would be up to 48 hours. Once it’s reviewed , then I could go to enterprise car rental to pick up a car. Maybe. The first time Rick Hendrick GMC Duluth , Ga 470-822-3779, 3344 Commerce Ave, Duluth, ga had my truck for about 2 weeks. No fix. No courtesy vehicle or rental. Now I’m without my vehicle for unlimited time. The Jim Elis tech, did acknowledge that there is no fix for what is going on. The local GMC dealers are not making this easy or putting the safety of its customers as a priority. These trucks are NOT safe on the road. This truck cost nearly $100,000 and it is not safe to drive.GMC has a record of the 1st service incident and this latest just happened yesterday. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(
NHTSA ODI #11676562
Mileage unknown · May 13, 2025
Electrical SystemEngineService Brakes
I was driving on a highway with my [XXX] son and 2 dogs when without any warning the vehicle just stopped and completely went dead. I was unable to turn on the hazards so I called 911, the police came within minutes and surrounded the vehicle to keep us from being crashed into. The brakes failed to work, the hazard lights would…
Read full complaint
I was driving on a highway with my [XXX] son and 2 dogs when without any warning the vehicle just stopped and completely went dead. I was unable to turn on the hazards so I called 911, the police came within minutes and surrounded the vehicle to keep us from being crashed into. The brakes failed to work, the hazard lights would not work, the doors would not open other than the driver door. The police had to help remove my child and 2 dogs from the vehicle through the driver door. The vehicle could not be put into neutral so the police had to tow the vehicle from the middle of the highway. The result could have been deadly. The vehicle was completely dead with absolutely no function. After the police towed it to the police tow facility it was then towed to the GMC dealership I purchased the vehicle from. The dealership is Jim Curly GMC in Keyport NJ. The dealership has had the vehicle since Saturday and is claiming to not know what is wrong with the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Good afternoon. Our rental car we picked up from the Denver International Airport on [XXX] had numerous incidents of emergent braking at highway and non highway speeds which were reported to Sixt ( car rental) and documented on the dates in which they occurred, [XXX] (7-8 occurrences ) and [XXX] (3 occurrences-2 after a car was…
Read full complaint
Good afternoon. Our rental car we picked up from the Denver International Airport on [XXX] had numerous incidents of emergent braking at highway and non highway speeds which were reported to Sixt ( car rental) and documented on the dates in which they occurred, [XXX] (7-8 occurrences ) and [XXX] (3 occurrences-2 after a car wash). On the day in which the first occurrences happened, the car rental company representative from Sixt, 3way connected me with a mechanic from Annex who advised washing the vehicle to ensure the sensors were clean. I did proceed to wash the vehicle on 1.25.25. This same company, Annex Automotive, then evaluated the vehicle on 1.29.25 after emergency breaking occurrences continued of which [XXX] was the worst. On [XXX] there were no vehicles in front of or behind us nor to the sides of us and the roads were completely clear. It was also dark out. Attached you will find evaluation with validation there is a mechanical concern with the vehicle. On [XXX] the extremely unsafe occurrence of emergent braking occurred with skidding tires and the doors locking and unlocking at the same time occurred. This vehicle was completely unsafe to drive. I, as well as my passengers/family, are very lucky the road conditions were moderate on [XXX] and clear on [XXX], or these emergency Breaking issues could have caused a serious accident. There were a total of five of us in the vehicle when all of these occurred. I am from Minnesota and have a Yukon XL so I am comfortable with this vehicle This was the scariest vehicle experience I have ever encountered. The company did tow the vehicle on 1.29.25. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11654579
Mileage unknown · Apr 5, 2024
Service Brakes
Urgent Appeal for Investigation into Braking Capacity Discrepancy Dear National Highway Traffic Safety Administration (NHTSA),I am reaching out to bring a critical matter to your attention regarding the braking capacity of my diesel vehicle, which has not been adequately addressed despite multiple notifications to the service c…
Read full complaint
Urgent Appeal for Investigation into Braking Capacity Discrepancy Dear National Highway Traffic Safety Administration (NHTSA),I am reaching out to bring a critical matter to your attention regarding the braking capacity of my diesel vehicle, which has not been adequately addressed despite multiple notifications to the service center.The primary concern I wish to highlight is the inadequate braking capacity of my diesel vehicle, which poses a significant safety risk. This concern is especially troubling when compared to my similar gas-fueled vehicle from the same manufacturer, which exhibits notably superior braking performance. After discussing this matter with the service center, their response was that the braking performance is considered normal for my diesel vehicle. However, the evident disparity in braking effectiveness between my diesel vehicle and the gas-fueled one suggests otherwise. This difference is particularly concerning given that both vehicles utilize the same brake system, despite the diesel vehicle's higher weight. In light of these circumstances, I urgently request NHTSA's intervention to investigate this matter promptly. The inadequate braking capacity of my diesel vehicle presents a tangible risk to road safety, affecting not only myself but potentially all drivers on the road.It is crucial that corrective measures are taken swiftly to address this issue and ensure the safety of all drivers. Your prompt attention to this matter is greatly appreciated.Thank you for your immediate action.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 GMC Yukon Xl Problems, Complaints & Recalls | Skip That Year
Illustration