NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
29 reportsClear category filter90,000 miles · Mar 4, 2026
Power Train
The contact owns a 2022 GMC Yukon XL. The contact stated that while driving approximately 45 MPH, the vehicle jerked as if the brake pedal was depressed and failed to accelerate as intended, with the check engine warning light illuminated. The message "Reduced Acceleration - Drive with Care" was displayed. The contact stated tha…
Read full complaint
The contact owns a 2022 GMC Yukon XL. The contact stated that while driving approximately 45 MPH, the vehicle jerked as if the brake pedal was depressed and failed to accelerate as intended, with the check engine warning light illuminated. The message "Reduced Acceleration - Drive with Care" was displayed. The contact stated that when the vehicle was stopped, the gear shifter was shifted into reverse, but the vehicle failed to respond. The vehicle was towed to the dealer, where it was diagnosed, and determined that there was a failure with the transmission valve. The contact was informed that the transmission valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.
NHTSA ODI #11721927
Mileage unknown · Mar 4, 2026
Power TrainUnknown Or Other
I noticed vehicle jerked a couple times when it shifted gears while driving. Shortly after, reduced power mode light came on. Vehicle did not shift past lower gears and had no reverse. Took to local dealership, they said it needed a transmission valve body overhaul. This is a known problem with 2022 gmc yukon xl, however, the…
Read full complaint
I noticed vehicle jerked a couple times when it shifted gears while driving. Shortly after, reduced power mode light came on. Vehicle did not shift past lower gears and had no reverse. Took to local dealership, they said it needed a transmission valve body overhaul. This is a known problem with 2022 gmc yukon xl, however, they said it was not associated with my vin. This cost me almost $2,000 out of pocket to repair.
NHTSA ODI #11721894
Mileage unknown · Feb 25, 2026
EnginePower TrainUnknown Or Other
On January 24, 2026, my wife was driving the vehicle we purchased in May 2025 from Ziegler GMC in Lincolnwood, Illinois. While traveling on the highway in WI the vehicle suddenly lost power without warning. She was traveling with our [XXX] son at the time and was able to safely maneuver the vehicle off the highway onto an exit …
Read full complaint
On January 24, 2026, my wife was driving the vehicle we purchased in May 2025 from Ziegler GMC in Lincolnwood, Illinois. While traveling on the highway in WI the vehicle suddenly lost power without warning. She was traveling with our [XXX] son at the time and was able to safely maneuver the vehicle off the highway onto an exit ramp. Despite multiple attempts, the vehicle would not restart. She contacted me and arranged for a tow. We waited approximately four hours for roadside assistance before the vehicle was towed to the nearest GMC dealership, located roughly one mile from where the breakdown occurred. Several days later, the dealership completed diagnostics and informed us that the engine required full replacement. At that time, no replacement vehicle was provided. Approximately one week later, we were finally issued a loaner vehicle. As of today, the vehicle has remained in the shop continuously since January 24. On February 23, we were informed that the necessary parts had only just arrived. There is still no estimated completion date for the repair. The vehicle is covered under both the manufacturer’s warranty and an extended warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11720338
65,000 miles · Feb 17, 2026
Power Train
The contact owns a 2022 GMC Yukon XL. While the contact’s wife was driving at an undisclosed speed, the vehicle unexpectedly went into LIMP Mode, and the check engine warning light illuminated. The vehicle failed to accelerate to exceed 30 MPH. The vehicle was taken to the dealer, where it was diagnosed, and it was determined th…
Read full complaint
The contact owns a 2022 GMC Yukon XL. While the contact’s wife was driving at an undisclosed speed, the vehicle unexpectedly went into LIMP Mode, and the check engine warning light illuminated. The vehicle failed to accelerate to exceed 30 MPH. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the transmission valve body had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 65,000.
NHTSA ODI #11718448
Mileage unknown · Feb 4, 2026
Power TrainSteering
After a dealership repair to the rear differential, my 2022 GMC Yukon XL experienced a sudden driveline failure. A component detached underneath the vehicle, resulting in loss of control and immediate disablement. This occurred shortly after service and without warning. The vehicle is routinely driven at highway speeds while tra…
Read full complaint
After a dealership repair to the rear differential, my 2022 GMC Yukon XL experienced a sudden driveline failure. A component detached underneath the vehicle, resulting in loss of control and immediate disablement. This occurred shortly after service and without warning. The vehicle is routinely driven at highway speeds while transporting multiple minor children. This appears to be a serious post-repair safety defect.
NHTSA ODI #11715518
Mileage unknown · Jan 28, 2026
EngineForward Collision AvoidancePower Train
Two weeks ago I heard a faint ticking sound. I had a professional look at it and they said that I had a cylinder sticking and to add an additive the next oil change. I still had 1,500 miles until then and so I did not do that. That noise stopped a day later. Last Friday, it started to tick again, and then it got very loud. I liv…
Read full complaint
Two weeks ago I heard a faint ticking sound. I had a professional look at it and they said that I had a cylinder sticking and to add an additive the next oil change. I still had 1,500 miles until then and so I did not do that. That noise stopped a day later. Last Friday, it started to tick again, and then it got very loud. I live rurally and was 45 minutes from home. The engine went from ticking to full clunking and very low power in just a moment. I luckily found a small engine shop to check the codes, but as I was parked there, the car would not go in reverse! He had to clear the codes to get it to go into reverse. I had to then slowly drive 45 minutes back to our small town. I drove to and immediately parked it at our local repair shop. It can not be driven now. The lights that came on were the Rear axle system off, forward collision system, service traction control, engine light flashing, and service ESC light. Not to forget that it would not go into reverse. Also the suspension system seemed to malfunction and not lift or lower the car.It seemed to clunk and try, but nothing happened. The whole car basically went down. I see there is a recall for this year or car, but my VIN is not included. I am hoping that it will be included as the repair shop is telling me it will be close to $10,000.
NHTSA ODI #11714036
92,000 miles · Dec 5, 2025
Power TrainVehicle Speed Control
The contact owns a 2022 GMC Yukon XL. The contact stated that while driving approximately 55 - 60 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended for approximately one second before accelerating. A dealer was contacted. No warning light was illuminated. The contact stated that the failure had …
Read full complaint
The contact owns a 2022 GMC Yukon XL. The contact stated that while driving approximately 55 - 60 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended for approximately one second before accelerating. A dealer was contacted. No warning light was illuminated. The contact stated that the failure had occurred on several occasions. The vehicle was taken to a dealer to be diagnosed; however, the diagnosis was unknown. The vehicle was not repaired. The manufacturer was notified of the failure and was in the process of towing the vehicle to another location. The approximate failure mileage was 92,000.
NHTSA ODI #11703342
Mileage unknown · Aug 31, 2025
EnginePower Train
At highway speed, in heavy traffic, and falling snow, the engine seized with sudden loss of power, including loss of brake and steering sensitivity. We were traveling downhill so, while avoiding other traffic and weather, maintained momentum to pull over to the side. We were stranded at night in snowy weather in remote Utah. It …
Read full complaint
At highway speed, in heavy traffic, and falling snow, the engine seized with sudden loss of power, including loss of brake and steering sensitivity. We were traveling downhill so, while avoiding other traffic and weather, maintained momentum to pull over to the side. We were stranded at night in snowy weather in remote Utah. It took hours to get towed to the nearest town, Fillmore, where the mechanic determined that the engine was seized and that no mechanic in the town could repair the issue. GM would not tow vehicle to our home, they would only tow to nearest dealership - which was farther away from our home (over 3 hours away). After repeated attempts with GM for tow assistance over the course of 13 days, we towed the vehicle to Salt Lake City, our home city at our own expense. The Dealer said 6 of 8 rod bushings were bad, ordered a new engine which took over 2 months to receive and install. Catastrophic event occurred [XXX], Time trying to get GM to tow vehicle, ending with our own expense 2/26/2025, Finally returned from dealership with new engine 5/1/2025 - 64 days from dealership receipt of vehicle - 77 days from catastrophic event. Continues to have electrical issues that affect controls like radio, ac/heat, start/stop. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11684203
Mileage unknown · Jul 15, 2025
Fuel/propulsion SystemPower Train
issue: Transmission safety complaint: immediate reduction in forward motion dealer: Dealer currently has the car, stuck transmission valve Solenoid's. Has the vehicle or component been inspected by the manufacturer: awaiting backorder part to see 30 days warning lights: Car had no current warning lights before car immedia…
Read full complaint
issue: Transmission safety complaint: immediate reduction in forward motion dealer: Dealer currently has the car, stuck transmission valve Solenoid's. Has the vehicle or component been inspected by the manufacturer: awaiting backorder part to see 30 days warning lights: Car had no current warning lights before car immediately down accelerated while on the highway.
NHTSA ODI #11673801
Mileage unknown · Jun 26, 2025
Power Train
GMC refusing to provide new engine and repair. GM sent letter with no date for repair. GM will not provide alternate transportation. GM states engine failure could cause loss of power resulting in an accident but will not provide alternate transportation.
NHTSA ODI #11669574
Official recalls
4Feb 13, 2026
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence & remedy
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Aug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
Consequence & remedy
Consequence: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration