IllustrationLED BRAKE LAMP WENT OUT AT 42K MILES, BUT GM REQUIRES REPLACEMENT OF ENTIRE TAIL LAMP ASSEMBLY AT EXPONENTIAL COST.
2015 GMC Yukon Xl
Owner reports · Recalls · Investigations
More warning signs than most Yukon Xl years
Owner complaints for the 2015 GMC Yukon Xl are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Yukon Xl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
3025–50K
7150–75K
4775–100K
33100–150K
7150K+
200 reports with mileage · 106 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 140 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports2 injury reports
What owners actually said
306 reportsTHE LEFT LED TAIL LIGHT WOULD GO OUT AND THEN COME BACK ON. THIS HAS BEEN HAPPENING FOR OVER A YEAR NOW. POLICE STOPPED ME TWICE BUT THANKFULLY, DID NOT GIVE ME A TICKET. HAD IT REPAIRED 2 OR 3 TIMES. IT MIGHT LAST A DAY OR TWO AND THEN GOES OUT AGAIN. APPARENTLY, THERE IS A THIN METAL PIECE THAT IS SORTED TOGETHER THAT KEE…
Read full complaint
THE LEFT LED TAIL LIGHT WOULD GO OUT AND THEN COME BACK ON. THIS HAS BEEN HAPPENING FOR OVER A YEAR NOW. POLICE STOPPED ME TWICE BUT THANKFULLY, DID NOT GIVE ME A TICKET. HAD IT REPAIRED 2 OR 3 TIMES. IT MIGHT LAST A DAY OR TWO AND THEN GOES OUT AGAIN. APPARENTLY, THERE IS A THIN METAL PIECE THAT IS SORTED TOGETHER THAT KEEPS BREAKING. THE RIGHT ONE HAS STARTED DOING IT TOO. I WAS OVER THE MILEAGE FOR THE RECALL. CAN'T AFFORD THE $1600 OR SO IT WOULD COST FOR NEW IMPROVED TAIL LIGHTS. WHAT DOES MILEAGE HAVE TO DO WITH REPAIRING A DEFECT IN THE PRODUCTS USED IN THE TAIL LIGHT? I AM CONSTANTLY AFRAID SOMEONE WILL REAR END ME SINCE THE LIGHT DOESN'T WORK.
2015 REAR BRAKE LIGHTS WORK INTERMITTENTLY AND NEED TO BE REPLACED OR REPAIRED. GMC KNOW THERE ARE NUMEROUS COMPLAINTS ABOUT THIS PROBLEM AND HAVE DONE NOTHING. HUGE SAFETY ISSUE!!
THIS VEHICLE HAD A FAILED DRIVER'S BRAKE LIGHT AT ABOUT 60K MILES AND IT WAS REPLACED AS A RECALL ITEM. AT 76K MILES THE PASSENGER BRAKE LIGHT HAS FAILED AND WE ARE INFORMED IT IS NO LONGER A RECALL ITEM BECAUSE IT'S OUT OF THE RECALL TIMEFRAME. I'VE ALSO KNOWN 2 OTHER PEOPLE WITH YUKON'S, BOTH NEIGHBORS AND BOTH HAVE HAD AT LEA…
Read full complaint
THIS VEHICLE HAD A FAILED DRIVER'S BRAKE LIGHT AT ABOUT 60K MILES AND IT WAS REPLACED AS A RECALL ITEM. AT 76K MILES THE PASSENGER BRAKE LIGHT HAS FAILED AND WE ARE INFORMED IT IS NO LONGER A RECALL ITEM BECAUSE IT'S OUT OF THE RECALL TIMEFRAME. I'VE ALSO KNOWN 2 OTHER PEOPLE WITH YUKON'S, BOTH NEIGHBORS AND BOTH HAVE HAD AT LEAST 1 FAILED BRAKE LIGHT. IF THIS IS A KNOWN FAILURE AND SAFETY ISSUE, WHY ARE THEY DENYING RECALL AT SUCH A LOW MILEAGE.
THE CLEAR COAT ON MY HOOD AND ROOF IS COMPLETELY GONE. I NOTICED THE HOOD LOOKED A LITTLE DULL ABOUT 6 MONTHS AGO AND IT PROGRESSIVELY GOT WORSE. NOW THE PAIN IS STARTING TO CHIP. THIS VEHICLE IS ONLY 5 YEARS OLD, THERE'S NO WAY THE CLEAR COAT SHOULD BE COMPLETELY GONE.
TOOK MY CERTIFIED PRE-OWNED 2015 YUKON XL INTO DEALER WHILE STILL UNDER WARRANTY WITH INTERMITTENT FAILURE IN BOTH TAIL LAMPS (THE RED PART FOR BRAKE AND TAIL LAMP FUNCTION GOES OUT; TURN SIGNAL STILL WORKS). CONDITION WAS NOT NOTED ON MY SERVICE TICKET SINCE THE TAIL LAMPS WAS WORKING FINE AT THE TIME. WARRANTY EXPIRED, PASSEN…
Read full complaint
TOOK MY CERTIFIED PRE-OWNED 2015 YUKON XL INTO DEALER WHILE STILL UNDER WARRANTY WITH INTERMITTENT FAILURE IN BOTH TAIL LAMPS (THE RED PART FOR BRAKE AND TAIL LAMP FUNCTION GOES OUT; TURN SIGNAL STILL WORKS). CONDITION WAS NOT NOTED ON MY SERVICE TICKET SINCE THE TAIL LAMPS WAS WORKING FINE AT THE TIME. WARRANTY EXPIRED, PASSENGER TAIL LAMP WENT OUT COMPLETELY AND BOTH DEALER AND A CALL TO GMC TOLD ME THAT THEY WOULDN'T ASSIST IN SPITE OF MY ATTEMPT TO ADDRESS WHILE UNDER WARRANTY. NEEDED TAIL LAMP TO PASS STATE INSPECTION AND RETURN MY WIFE AND FOUR KIDS SAFELY TO THE ROAD, SO I HAD TO PAY. AS I WALKED OUT OF THE DEALERSHIP TO RETRIEVE MY VEHICLE AFTER THE $400 PASSENGER TAIL LAMP REPLACEMENT, I FOUND THE DRIVER SIDE TAIL LAMP TO BE INOPERABLE, EVEN THOUGH IT HAD JUST PASSED THE STATE INSPECTION 20 MIN PRIOR. I SHOWED THE SERVICE ADVISOR AND SPOKE TO SERVICE MANAGER. THEY BOTH AGREED THAT THE TAIL LAMP ISSUE IS WIDE-SPREAD, UNSAFE, AND A MAJOR QUALITY ISSUE, BUT THEY WERE BOUND BY GMC POLICIES. YES, GMC EXTENDED THE WARRANTY FOR THESE TAIL LAMPS, BUT I BOUGHT MY VEHICLE AS PREOWNED CERTIFIED WITH 68K MILES. SPECIAL PART WARRANTY WENT TO 70K AND MY CERTIFIED WARRANTY WENT TO 80K. I DID MY PART AND TOOK THE VEHICLE IN AS SOON AS THE PROBLEM AROSE, YET HERE I AM HOLDING AN $800 BAG OF BROKEN TAIL LAMPS. HORRENDOUS QUALITY ISSUE THAT IS A MAJOR SAFETY ISSUE FOR THESE VEHICLES. IT IS TIME TO ISSUE THE RECALL!!!
BOUGHT THE 2015 YUKON XL AS CERTIFIED PREOWNED. WHILE STILL COVERED UNDER CERTIFIED WARRANTY, I COMPLAINED ABOUT THE INTERMITTENT TAIL LAMP FAILURE, BUT THE DEALER COULDN'T REPLICATE. YOU KNOW THE REST...THE CERTIFIED WARRANTY THEN EXPIRED BY MILEAGE, THEN THE TAIL LAMP COMPLETELY FAILED, THEN I TOOK IT BACK IN AND THEY SAY THE…
Read full complaint
BOUGHT THE 2015 YUKON XL AS CERTIFIED PREOWNED. WHILE STILL COVERED UNDER CERTIFIED WARRANTY, I COMPLAINED ABOUT THE INTERMITTENT TAIL LAMP FAILURE, BUT THE DEALER COULDN'T REPLICATE. YOU KNOW THE REST...THE CERTIFIED WARRANTY THEN EXPIRED BY MILEAGE, THEN THE TAIL LAMP COMPLETELY FAILED, THEN I TOOK IT BACK IN AND THEY SAY THEY WON'T COVER IT. I SPOKE TO DEALER SERVICE MANAGER, GMC CUSTOMER SERVICE (PLUS A MANAGER), BUT I"M TOLD THAT THEY WON'T ASSIST SINCE I'M OUT OF WARRANTY. I DID MY PART...I TOOK THE VEHICLE IN WHILE STILL UNDER WARRANTY AS SOON AS THE CONDITION PRESENTED ITSELF. IT'S A SHAME THAT GMC WON'T OWN THIS MASSIVE FAILURE UNTIL A RECALL ISSUED. MAYBE MY COMPLAINT WILL BE THE TIPPING POINT THAT KICKS OFF THAT PROCESS.
I HAVE A 2015 GMC YUKON XL DENALI. TRUCK WAS PURCHASED FROM GMC CERTIFIED DEALER IN JULY 2018, WITH 16,000 MILES. THE TRUCK IS GARAGED KEPT, AND GENTLY USED WITH ONLY 37,500 MILES. WHEN SOMETIMES DRIVING AT LOW SPEEDS, THE TRANSMISSION WILL SOMETIMES SLIP (AKA STUDDER). WHEN STARTING (ENGINE IS COLD) AND SHIFTING INT…
Read full complaint
I HAVE A 2015 GMC YUKON XL DENALI. TRUCK WAS PURCHASED FROM GMC CERTIFIED DEALER IN JULY 2018, WITH 16,000 MILES. THE TRUCK IS GARAGED KEPT, AND GENTLY USED WITH ONLY 37,500 MILES. WHEN SOMETIMES DRIVING AT LOW SPEEDS, THE TRANSMISSION WILL SOMETIMES SLIP (AKA STUDDER). WHEN STARTING (ENGINE IS COLD) AND SHIFTING INTO D, SOMETIMES THE TRANSMISSION SHIFTS HARD, OR SLAMS INTO 1ST GEAR. THAT CAN'T POSSIBLY BE GOOD FOR THE TRANSMISSION. OCCASIONALLY THE TRANSMISSION WILL SHIFT HARD BETWEEN GEARS AT MODERATE SPEED. I HAVE JUST LEARNED THERE ARE SERVICE BULLETINS GOING BACK TO 2016 REGARDING COMPLAINTS FOR THE NEWLY DEVELOPED 8-SPEED M5U/8L90 AUTOMATIC TRANSMISSION. THE LOCAL GMC DEALER HAS SERVICED THE TRUCK 4 TIMES IN PAST 2 YEARS AND NEVER BOTHERED TO ASK ABOUT THE SYMPTOMS OF TRANSMISSION PROBLEMS. OR ALERT ME TO THE DEFECTIVE TRANSMISSION. GM & DEALER COLLUDED TO WITHOUT PERTINENT INFORMATION FROM ME TO CAUSE THE ORIGINAL MANUFACTURER WARRANTY TO EXPIRE, FORCING REPAIRS EXPENSE TO BE OUT-OF-POCKET ON THE CONSUMER. DEALER CHARGED ME $300 TO SWAP THE DRAIN AND FLUSH THE TRANSMISSION FLUID AND SWITCH TO ANOTHER TYPE. IF THE DEALER HAD ALERTED ME TO THE ISSUE ON 1 OF THE 4 PREVIOUS SERVICE VISITS, THE SERVICE WOULD HAVE BEEN COVERED UNDER WARRANTY. BUT NOW THAT THE TRUCK IS 3 MONTHS OUT OF WARRANTY, I HAVE TO PAY OUT OF POCKET. GM AND THE DEALER HAVE KNOWN ABOUT THE ISSUE FOR YEARS, AND DID NOTHING.
OUR 2015 YUKON XL DENALI CAUGHT FIRE IN THE ENGINE COMPARTMENT WHILE WAITING AT STOP LIGHT ON SAT, WITH MY WIFE AND CHILDREN INSIDE. IT WAS A HOT DAY, OVER 95 DEGREES, AND WE WERE TURNING LEFT ACROSS TRAFFIC WHEN WE REALIZED THE SMELL AND SMOKE WAS COMING FROM OUR VEHICLE. SMOKE WHIFFED FROM UNDER THE HOOD AND NOXIOUS FUMES FILL…
Read full complaint
OUR 2015 YUKON XL DENALI CAUGHT FIRE IN THE ENGINE COMPARTMENT WHILE WAITING AT STOP LIGHT ON SAT, WITH MY WIFE AND CHILDREN INSIDE. IT WAS A HOT DAY, OVER 95 DEGREES, AND WE WERE TURNING LEFT ACROSS TRAFFIC WHEN WE REALIZED THE SMELL AND SMOKE WAS COMING FROM OUR VEHICLE. SMOKE WHIFFED FROM UNDER THE HOOD AND NOXIOUS FUMES FILLED THE PASSENGER COMPARTMENT, SCARING ME AND MY FAMILY. WE FINISHED THE TURN AND IMMEDIATELY PULLED OVER, SHUTOFF THE TRUCK, AND ALL ESCAPED FEARING IT WOULD BURST INTO FLAMES. WHATEVER WAS BURNING APPEARED TO STOP ONCE THE IGNITION WAS OFF. I OPENED THE DRIVER DOOR, POPPED AND RAISED THE HOOD TO LOOK FOR THE PROBLEM. I COULD SEE THAT A BELT, BEHIND THE SERPENTINE BELT, HAD SNAPPED, AND THERE WAS CHARRED DEBRIS ON THE EXPOSED MECHANICAL PULLEY FOR THE AC COMPRESSOR. AFTER FURTHER INSPECTION, I RESTARTED THE TRUCK WITH THE AC OFF, AND MONITORED FOR SMOKE. THE TRUCK SEEMED OK TO DRIVE HOME , SO WE DID WITHOUT AC ON A 95 DEGREE DAY. ON MONDAY WE DROVE THE TRUCK TO A TRUSTED MECHANIC FOR INSPECTION. THEY DIAGNOSED THE COMPRESSOR SEIZED AND ESTIMATED REPAIRS WERE $1,240. THE TRUCK IS GARAGED KEPT, AND GENTLY USED WITH ONLY 37,500 MILES. WE PURCHASED THE GMC CERTIFIED TRUCK IN JULY 2018 FROM A DEALER. I CREATED AN ACCOUNT ON GMC.COM & LOOKED THROUGH WARRANTY COVERAGE. A SPECIAL COVERAGE HAD BEEN EXTENDED FOR AC DEFECTS, BUT IT LAPSED IN MARCH, 2020. LOOKING FURTHER; MANY THOUSANDS OF GM OWNERS HAD SAME PROBLEM FROM SAME DEFECTIVE AC CONDENSER COMBI-COOLER. I CALLED GM TO COMPLAIN THEY NEVER TOLD US OF ABOUT A DEFECTIVE AC SYSTEM. THEY SAID ONLY A GM DEALER COULD DIAGNOSE THE PROBLEM, BECAUSE THEY ARE 'EXPERTS'. THAT SAME 'EXPERT' DEALER HAD SERVICED OUR YUKON 4 TIMES OVER THE PAST 2 YEARS AND NEVER ONCE SHARED THE INFORMATION ABOUT THE DEFECTIVE AC SYSTEM. GM & DEALER COLLUDED TO ALLOW WARRANTY TO EXPIRE.
MAJOR SAFETY ISSUES WITH THIS VEHICLE. ANOTHER 2015 YUKON WITH NO TAIL OR STOP LIGHTS. I'M OVER MILLAGE ON SPECIAL RECALL. THERE SHOULD BE NO TIME/MILLAGE ISSUE ON THIS. SEAT BELTS LOCK UP. BRAKES ARE EITHER GOOD OR MUSSY WHENEVER THEY WANT TO BE. HARD TO STOP THE VEHICLE. ALSO WHEN I FIRST PURCHASED THE VEHICLE IT WOULD COMPLET…
Read full complaint
MAJOR SAFETY ISSUES WITH THIS VEHICLE. ANOTHER 2015 YUKON WITH NO TAIL OR STOP LIGHTS. I'M OVER MILLAGE ON SPECIAL RECALL. THERE SHOULD BE NO TIME/MILLAGE ISSUE ON THIS. SEAT BELTS LOCK UP. BRAKES ARE EITHER GOOD OR MUSSY WHENEVER THEY WANT TO BE. HARD TO STOP THE VEHICLE. ALSO WHEN I FIRST PURCHASED THE VEHICLE IT WOULD COMPLETELY DIE (NO LIGHTS MOTOR DIED, NO POWER STEERING, NO AIR BAGS, NO RADIO NOTHING AT ALL ON THE X-WAY AT 70 MPH) AND THE DEALER COULD NOT REPAIR IT! RUST ON FRAME RAILS. (AND MORE).
Official recalls
217V437000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
16V651000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.