NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
58 reportsClear category filter80,000 miles · Jul 30, 2019
Electrical SystemExterior LightingService Brakes
THE BRAKE/TAIL LIGHTS WORK SOMEDAYS, AND NOT OTHER DAYS. ONE DAY THE ARE BOTH WORKING, ONE DAY ONLY ONE WORKS, AND SOME DAYS NEITHER WORK. THIS IS A PROBLEM THAT IS VERY PREVALENT. JUST LOOK ONLINE. I HAVE PERSONALLY PHOTOGRAPHED SEVERAL OF THE SAME ISSUE ON THIS MAKE AND MODEL IN MY HOMETOWN. THE DEALERSHIP WANTS ME TO PAY $130…
Read full complaint
THE BRAKE/TAIL LIGHTS WORK SOMEDAYS, AND NOT OTHER DAYS. ONE DAY THE ARE BOTH WORKING, ONE DAY ONLY ONE WORKS, AND SOME DAYS NEITHER WORK. THIS IS A PROBLEM THAT IS VERY PREVALENT. JUST LOOK ONLINE. I HAVE PERSONALLY PHOTOGRAPHED SEVERAL OF THE SAME ISSUE ON THIS MAKE AND MODEL IN MY HOMETOWN. THE DEALERSHIP WANTS ME TO PAY $1300 TO HAVE NEW LIGHTS INSTALLED AND GMC IS IN DENIAL OF THEIR PROBLEM.(THE BACK UP/REVERSE WHITE LIGHT WORKS ALL OF THE TIME, ITS THE RED BRAKE/TAIL LIGHT THAT DOESN'T WORK) THIS SHOWS THAT ITS AN ISSUE THAT SHOULD BE RECALLED, NOT REPLACED AT THE OWNER'S EXPENSE.
NHTSA ODI #11240628
Mileage unknown · Jun 11, 2019
Electrical SystemExterior Lighting
MY VEHICLE IS A 2015 YUKON XL. IN 2018 I HAD TO REPLACE MY FRONT DRIVER SIDE LED LIGHTS AND MY PASSENGER SIDE REAR BRAKE LIGHT FOR A COST OVER $2,000. I LITERALLY HAD TO CANCEL A FAMILY VACATION IN ORDER TO PAY FOR THE LIGHTS ON MY VEHICLE. IT IS ILLEGAL TO DRIVE WITHOUT WORKING BRAKE LIGHTS. THIS YEAR, JUNE 2019, I NEEDED TO RE…
Read full complaint
MY VEHICLE IS A 2015 YUKON XL. IN 2018 I HAD TO REPLACE MY FRONT DRIVER SIDE LED LIGHTS AND MY PASSENGER SIDE REAR BRAKE LIGHT FOR A COST OVER $2,000. I LITERALLY HAD TO CANCEL A FAMILY VACATION IN ORDER TO PAY FOR THE LIGHTS ON MY VEHICLE. IT IS ILLEGAL TO DRIVE WITHOUT WORKING BRAKE LIGHTS. THIS YEAR, JUNE 2019, I NEEDED TO REPLACE THE DRIVER SIDE BREAK LIGHT AT A COST CLOSE TO $1,000.
NHTSA ODI #11219324
Mileage unknown · Jun 8, 2019
Electrical SystemExterior Lighting
THE HEADLIGHTS HOUSINGS HAVE CONDENSATION IN THEM AND IT HAS CAUSE THE TURN SIGNAL AND LED LIGHTS TO SHORT OUT. THE LED LIGHTS IN THE TAIL LIGHT HOUSING INCLUDING THE BRAKE LIGHTS HAVE ALSO SHORTED OUT. THE LED SCREEN AND COMPUTER IN THE CENTER CONSOLE HAS ALSO SHORTED OUT.
NHTSA ODI #11218668
29,201 miles · Jun 5, 2019
Electrical System
DRIVER AND PASSENGER SIDE TAIL LIGHTS FLICKERING ON AND OFF. TWICE I'VE GOTTEN PULLED OVER FOR TAIL LIGHTS ISSUES AND REAR ENDED BECAUSE OF THEM.
NHTSA ODI #11218094
95,000 miles · May 28, 2019
Electrical SystemExterior Lighting
DRIVER SIDE TAIL LIGHT WOULD INTERMITTENTLY GO IN AND OUT FROM WORKING AND NOT WORKING. THE TAIL LIGHT WOULD DO THIS WHILE IN MOTION, WHILE STATIONARY, IT DID NOT MATTER. THE LOCAL DEALERSHIP THAT WE BOUGHT IT FROM SAID WE WOULD NEED TO REPLACE IT. OVER $750. NOW THE PASSENGER SIDE TAIL LIGHT IS DOING THE EXACT SAME THING. HUGE …
Read full complaint
DRIVER SIDE TAIL LIGHT WOULD INTERMITTENTLY GO IN AND OUT FROM WORKING AND NOT WORKING. THE TAIL LIGHT WOULD DO THIS WHILE IN MOTION, WHILE STATIONARY, IT DID NOT MATTER. THE LOCAL DEALERSHIP THAT WE BOUGHT IT FROM SAID WE WOULD NEED TO REPLACE IT. OVER $750. NOW THE PASSENGER SIDE TAIL LIGHT IS DOING THE EXACT SAME THING. HUGE SAFETY HAZARD. CLEARLY A FAULTY PART, NOT JUST A BULB GOING OUT, BUT THE ENTIRE ELECTRICAL DESIGN OF THE THE TAIL LIGHT IS FLAWED. GM CHARGES YOU TO REPLACE THE ENTIRE HOUSING WITH THE SAME EXACT FAULTY PART THAT WAS ON THERE BEFORE.
NHTSA ODI #11210264
31,893 miles · May 27, 2019
Electrical System
REAR TAIL LIGHTS STOP WORKING ALL OF THE SUDDEN. LEFT AND RIGHT SIDE.
NHTSA ODI #11210136
110,880 miles · Apr 17, 2019
Electrical SystemService Brakes
TAKATA RECALL DRIVER SIDE BRAKE LIGHT STOP WORKING WHILE DRIVING IN THE CITY STREETS
NHTSA ODI #11197068
107,000 miles · Feb 20, 2019
Electrical SystemExterior Lighting
LEFT BRAKE LIGHT WORKING INTERMITTENTLY AND THEN WENT OUT COMPLETELY. RIGHT BRAKE LIGHT FOLLOWED IMMEDIATELY AFTER. DEALER WANTS 1550.00 TO REPLACE
NHTSA ODI #11181340
41,000 miles · Nov 28, 2018
Electrical SystemExterior LightingService Brakes
WE PURCHASED THIS VEHICLE ON 11.21.18 AND THE BRAKE LIGHTS INTERMITTENTLY DON'T WORK. THEY WERE WORKING AT THE TIME WE DROVE IT OFF THE LOT. THE BULBS WERE TESTED BY OUR MECHANIC AND HE STATED THAT THE GMC YUKON OF THIS YEAR ARE KNOWN TO HAVE MAJOR PROBLEMS WITH THE BRAKE LIGHT HOUSING UNITS ON THE REAR OF THE VEHICLE. THE EL…
Read full complaint
WE PURCHASED THIS VEHICLE ON 11.21.18 AND THE BRAKE LIGHTS INTERMITTENTLY DON'T WORK. THEY WERE WORKING AT THE TIME WE DROVE IT OFF THE LOT. THE BULBS WERE TESTED BY OUR MECHANIC AND HE STATED THAT THE GMC YUKON OF THIS YEAR ARE KNOWN TO HAVE MAJOR PROBLEMS WITH THE BRAKE LIGHT HOUSING UNITS ON THE REAR OF THE VEHICLE. THE ELECTRICAL BOARD ASSOCIATED WITH IT HAS ISSUES THE MECHANIC STATED. I REVIEWED MANY POST ONLINE AND WONDER WHY THIS ISN'T A REQUIRED RECALL. TO ME THIS IS A MAJOR SAFETY CONCERN AND WE BOUGHT THIS VEHICLE TO TRANSPORT MY KIDS AND WIFE. I'D LIKE THIS TO BE CONSIDERED A RECALL IMMEDIATELY.
NHTSA ODI #11154415
Mileage unknown · Oct 22, 2018
Electrical SystemExterior LightingService Brakes
MY PASSENGER FRONT LIGHT COVER IS ACQUIRING CONDENSATION WHICH MAKES THE LIGHTS GO OFF AND ON, AND MY DRIVER SIDE BRAKE LIGHT WORKS ONLY INTERMITTENTLY. MY INSURANCE OR WARRANTY WON'T COVER ANYTHING TO FIX THESE LIGHT ISSUES. THESE ISSUES STARTED ABOUT MAY 2018. WE WEREN'T IN A WRECK OR SUSTAINED ANY DAMAGES THAT WOULD HAVE L…
Read full complaint
MY PASSENGER FRONT LIGHT COVER IS ACQUIRING CONDENSATION WHICH MAKES THE LIGHTS GO OFF AND ON, AND MY DRIVER SIDE BRAKE LIGHT WORKS ONLY INTERMITTENTLY. MY INSURANCE OR WARRANTY WON'T COVER ANYTHING TO FIX THESE LIGHT ISSUES. THESE ISSUES STARTED ABOUT MAY 2018. WE WEREN'T IN A WRECK OR SUSTAINED ANY DAMAGES THAT WOULD HAVE LED TO THESE ISSUES. I HAVE TALKED TO TWO OTHER OWNERS OF THE SAME MAKE/MODEL/YEAR VEHICLE AND WE ALL HAVE SAFETY ISSUES THAT ARE NOT BEING RESOLVED BY GM VWARRANTIES. I WANT TO SEE GM ISSUE RECALLS AND ACCEPT COMPLETE FINANCIAL RESPONSIBILITY FOR REPAIRS. I WOULD ALSO LIKE TO SEE THE REAR LIGHTING SYSTEM REDESIGNED SO THE COMPONENTS ARE NOT DEPENDENT ON EACH OTHER. MY BRAKE LIGHT WENT OUT AND INSTEAD OF BEING ABLE TO REPLACE A BULB THE ENTIRE UNIT HAS TO BE REPLACED AT $1700.00 THAT WE JUST SIMPLY DO NOT HAVE.
NHTSA ODI #11141808
Official recalls
2Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration