NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
38 reportsClear category filter105,000 miles · May 24, 2010
Electrical System
2003 YUKON XL WITH 105, 000 MILES SPEEDOMETER NOT WORKING PROPERLY, SPOKE WITH GMC WAS ADVISED THERE IS A SPECIAL COVERAGE TO REPAIR THIS KNOWN PROBLEM, BUT SINCE I AM OVER THE MILEAGE NOT THE YEARS THEY WON'T DO ANYTHING. ALL I WANT IS THE PART AND I WILL PAY FOR THE LABOR THAT'S ONLY FAIR. I HAVE 4 DRIVERS IN THE FAMILY AND IT…
Read full complaint
2003 YUKON XL WITH 105, 000 MILES SPEEDOMETER NOT WORKING PROPERLY, SPOKE WITH GMC WAS ADVISED THERE IS A SPECIAL COVERAGE TO REPAIR THIS KNOWN PROBLEM, BUT SINCE I AM OVER THE MILEAGE NOT THE YEARS THEY WON'T DO ANYTHING. ALL I WANT IS THE PART AND I WILL PAY FOR THE LABOR THAT'S ONLY FAIR. I HAVE 4 DRIVERS IN THE FAMILY AND IT IS UNSAFE FOR THEM TO DRIVE. WE NEVER KNOW WHEN THE SPEEDOMETER WILL STOP WORKING. *TR
NHTSA ODI #10331965
68,472 miles · Apr 8, 2010
Electrical System
RECALL FOR THE SPEEDOMETER IN 2003/2004 THE THERE WAS A RECALL IN 2003/2004 FOR THE SPEEDOMETER AND WHEN I TOOK MY CAR IN FOR ANOTHER PROBLEM I SHOWED THE RECALL LETTER AND THEY SAID THEY ONLY COULD CHANGE IT IF THERE WAS ANY PROBLEM. PAST 7 YEARS AND LESS THAN 70,000 MILES THE SPEEDOMETER STOPPED WORKING WHEN I PARKED MY CAR…
Read full complaint
RECALL FOR THE SPEEDOMETER IN 2003/2004 THE THERE WAS A RECALL IN 2003/2004 FOR THE SPEEDOMETER AND WHEN I TOOK MY CAR IN FOR ANOTHER PROBLEM I SHOWED THE RECALL LETTER AND THEY SAID THEY ONLY COULD CHANGE IT IF THERE WAS ANY PROBLEM. PAST 7 YEARS AND LESS THAN 70,000 MILES THE SPEEDOMETER STOPPED WORKING WHEN I PARKED MY CAR. I TOOK MY CAR IN TO GET FIXED AND THEY CHARGE ME FOR IT, BECAUSE IT HAS PASSED 7 YEARS AND THE WARRANTY FOR THE RECALL HAD EXPIRED. IF THERE WAS A PROBLEM BEFORE THEY KNEW IT THAT SOONER OR LATER WE WOULD HAVE A PROBLEM WITH THE SPEEDOMETER. THIS IS SAFETY IF SOMEONE DRIVES A CAR IN THE FREEWAY AND THE SPEEDOMETER JUST STOPPED, WHAT IT'S GOING TO HAPPEN IF YOU DON'T KNOW YOUR SPEED. *TR
NHTSA ODI #10324610
125,000 miles · Feb 16, 2010
Electrical SystemFuel System, Gasoline
VEHICLE STALLS WHILE IN MOTION. FIGURED OUT IT MAY BE RUNNING OUT OF GAS DUE TO THE GAUGE NOT WORKING. NOW, IT STALLS WHEN IT ONLY HAS A HALF A TANK OF GAS, NOT COMPLETELY EMPTY. PUT 16 GALLONS OF GAS IN THE 30 GALLON TANK, TRUCK RUNS SMOOTH. REPLACED THE FUEL FILTER TWICE. REPLACED THE BATTERY, TESTED THE ALTERNATOR, RESULTS NO…
Read full complaint
VEHICLE STALLS WHILE IN MOTION. FIGURED OUT IT MAY BE RUNNING OUT OF GAS DUE TO THE GAUGE NOT WORKING. NOW, IT STALLS WHEN IT ONLY HAS A HALF A TANK OF GAS, NOT COMPLETELY EMPTY. PUT 16 GALLONS OF GAS IN THE 30 GALLON TANK, TRUCK RUNS SMOOTH. REPLACED THE FUEL FILTER TWICE. REPLACED THE BATTERY, TESTED THE ALTERNATOR, RESULTS NO ALT. PROBLEM. CHECK ENGINE LIGHT ON, SPEEDOMETER IS OFF, GAS GAUGE IS OFF, AND THE REAR VIEW MIRROR DISPLAY LIGHTS GO ON AND OFF ERRATICALLY. BIGGEST PROBLEM IS WHEN I BREAK THE TRUCK WILL SHUT OFF. THIS HAS BEEN GOING ON SINCE NOV. 2010, WHEN WE REPLACED THE BATTERY AND QUIT USING A CERTAIN TYPE OF GAS IT SEEMED TO BE FINE. NOW, IT IS ACTING UP AND TODAY WAS THE FIRST INCIDENT SINCE EARLY DECEMBER. *TR
NHTSA ODI #10311117
118,200 miles · Dec 13, 2009
Electrical System
2003 GMC YUKON XL WITH 118,000 MILES ON IT RECENTLY BEGAN TO HAVE A MALFUNCTIONING SPEEDOMETER, ESPECIALLY IN COLD WEATHER. I WAS ABOUT TO GET ITT REPAIRED, WHEN I LEARNED FROM ANOTHER OWNER OF 2 YUKON/SUBURBAN SUVS THAT THE SAME THING HAPPENED TO THEIR VEHICLES AT ABOUT 100,000 MILES. IF THIS IS A SYSTEMIC ISSUE IN THAT CLASS…
Read full complaint
2003 GMC YUKON XL WITH 118,000 MILES ON IT RECENTLY BEGAN TO HAVE A MALFUNCTIONING SPEEDOMETER, ESPECIALLY IN COLD WEATHER. I WAS ABOUT TO GET ITT REPAIRED, WHEN I LEARNED FROM ANOTHER OWNER OF 2 YUKON/SUBURBAN SUVS THAT THE SAME THING HAPPENED TO THEIR VEHICLES AT ABOUT 100,000 MILES. IF THIS IS A SYSTEMIC ISSUE IN THAT CLASS OF VEHICLES, THERE SHOULD BE A RECALL AND A COMPANY-INITIATED REPAIR OF THE ISSUE. IT IS UNSAFE NOT TO KNOW ONE'S SPEED. *TR
NHTSA ODI #10295496
111,000 miles · Jan 12, 2009
Electrical System
TL*THE CONTACT OWNS A 2003 GMC YUKON XL. THE CONTACT STATED THAT THE SPEEDOMETER IS ERRATIC AND BECOMES STUCK AT DIFFERENT SPEEDS. WHILE DRIVING 50 MPH, THE DIAL WOULD DROP DOWN TO 0 MPH AND DISPLAYS INACCURATE SPEEDS. THE CONTACT RECEIVED A RECALL NOTICE (RECALL NUMBER 07187) FROM GMC, WHICH STATED THAT THE RECALL WAS SEVEN …
Read full complaint
TL*THE CONTACT OWNS A 2003 GMC YUKON XL. THE CONTACT STATED THAT THE SPEEDOMETER IS ERRATIC AND BECOMES STUCK AT DIFFERENT SPEEDS. WHILE DRIVING 50 MPH, THE DIAL WOULD DROP DOWN TO 0 MPH AND DISPLAYS INACCURATE SPEEDS. THE CONTACT RECEIVED A RECALL NOTICE (RECALL NUMBER 07187) FROM GMC, WHICH STATED THAT THE RECALL WAS SEVEN YEARS OR 70,000 MILES. THE VEHICLE CURRENTLY HAS OVER 70,000 MILES; HOWEVER, NO FAILURES WERE OCCURRING AT THE TIME THE RECALL NOTICE WAS RECEIVED. THE DEALER STATED THAT THE VEHICLE WAS OUT OF WARRANTY FOR THE REPAIR. THE FAILURE MILEAGE WAS 111,000.
NHTSA ODI #10254727
77,321 miles · Sep 25, 2008
Electrical SystemFuel System, Gasoline
WHILE DRIVING AT 65 MPH, THE YUKON JUST SHUT DOWN AND THE BATTERY LIGHT CAME ON. GOT TO SHOULDER OF ROAD, PUT IT IN PARK, TURN OF THE IGNITION AND STARTED IT RIGHT BACK UP. DID IT AGAIN, 15 MINUTES LATER - SAME RESULTS. THE NEXT 7 TIMES, THE CAR AT LOW SPEED (15-20 MPH) STARTED ACTING LIKE IT WASN'T GETTING GAS AND RUNNING RO…
Read full complaint
WHILE DRIVING AT 65 MPH, THE YUKON JUST SHUT DOWN AND THE BATTERY LIGHT CAME ON. GOT TO SHOULDER OF ROAD, PUT IT IN PARK, TURN OF THE IGNITION AND STARTED IT RIGHT BACK UP. DID IT AGAIN, 15 MINUTES LATER - SAME RESULTS. THE NEXT 7 TIMES, THE CAR AT LOW SPEED (15-20 MPH) STARTED ACTING LIKE IT WASN'T GETTING GAS AND RUNNING ROUGH, NOT PULLING. PULLED OF ROAD. WOULD TURN OVER AND TRY TO START AND IF IT STARTED, WAS VERY ROUGH. AFTER ABOUT 15 MINUTES, THE YUKON STARTED LIKE NOTHING WAS WRONG AND WOULD RUN FOR 10-15 MINUTES. THIS ALSO HAPPENED TO ME IN JUNE. TOOK TO AN INDEPENDENT MECHANIC WHO COULD FIND NOTHING WRONG. HAPPENED TO MY PARENTS IN 2006 IN THIS VEHICLE TRAVELING TO MISSISSIPPI. GMC DEALER COULD FIND NOTHING WRONG. CURRENTLY THE DEALER WANTS TO CHANGE THE FUEL PUMP. I HAVE RESEARCHED AND OTHERS WITH THIS PROBLEM HAVE REPLACED THE FUEL PUMP AND IT DOESN'T STOP HAPPENING. SPEEDOMETER JUST FAILED TOO. WONDER IF IT COULD BE AN ELECTRONICS/ELECTRICAL PROBLEM. *TR
NHTSA ODI #10243410
70,000 miles · Apr 20, 2008
Electrical System
SPEEDOMETER DOES NOT WORK RIGHT. I HAVE HAD NO LUCK GETTING IT FIXED AND MANY PEOPLE HAVE SAME ISSUE. *TR
NHTSA ODI #10225158
87,122 miles · Apr 14, 2008
Electrical System
I HAVE RECENTLY PURCHASED A 2003 GMC YUKON XL AND SINCE I BOUGHT THIS CAR I HAVE HAD SEVERAL PROBLEMS WITH THE SPEED ODOMETER STICKING AT DIFFERENT MPH OR JUST NOT WORKING ALL THE WAY AROUND. IT WAS NEVER THE WHOLE CLUSTER THAT WENT OUT, JUST THE ODOMETER. I SPOKE TO SEVERAL DIFFERENT PEOPLE I KNOW THAT OWN ANYTHING FROM THE G…
Read full complaint
I HAVE RECENTLY PURCHASED A 2003 GMC YUKON XL AND SINCE I BOUGHT THIS CAR I HAVE HAD SEVERAL PROBLEMS WITH THE SPEED ODOMETER STICKING AT DIFFERENT MPH OR JUST NOT WORKING ALL THE WAY AROUND. IT WAS NEVER THE WHOLE CLUSTER THAT WENT OUT, JUST THE ODOMETER. I SPOKE TO SEVERAL DIFFERENT PEOPLE I KNOW THAT OWN ANYTHING FROM THE GMC YUKON TO THE CHEVY SUBURBAN (TOTAL OF 9 PEOPLE FROM TEXAS TO OKLAHOMA) AND EACH ONE OF THEM HAVE ALSO HAD THIS SAME PROBLEM. I HAVE RECENTLY GOT THE PROBLEM FIXED. TO WHICH THE RECEIPT FROM THE DEALERSHIP STATES THEY REPLACED THE WHOLE CLUSTER. *TR
NHTSA ODI #10224513
64,000 miles · Oct 4, 2007
Electrical System
INSTRUMENT PANEL INOPERATIVE RECALL NOTICE FOR 7 YEARS/70,000 MILES, RECEIVED AFTER 71,000 MILES EVEN WHEN PROBLEM STARTED AT 64,000 MILES, ALL GAUGES GO OUT AT RANDOM AND IS INTERMENT. A CALL TO GENERAL MOTORS AND AN HOUR OF TIME I WAS TOLD NOTHING CAN BE DONE I WAS OUT OF RECALL NOTICE MILEAGE AND I WAS OUT OF LUCK AND HAD TO …
Read full complaint
INSTRUMENT PANEL INOPERATIVE RECALL NOTICE FOR 7 YEARS/70,000 MILES, RECEIVED AFTER 71,000 MILES EVEN WHEN PROBLEM STARTED AT 64,000 MILES, ALL GAUGES GO OUT AT RANDOM AND IS INTERMENT. A CALL TO GENERAL MOTORS AND AN HOUR OF TIME I WAS TOLD NOTHING CAN BE DONE I WAS OUT OF RECALL NOTICE MILEAGE AND I WAS OUT OF LUCK AND HAD TO PAY FOR THE REPAIR MYSELF. *JB *UPDATED 12/12/07 *BF UPDATED 12/12/07 *TR
NHTSA ODI #10204818
Mileage unknown · Sep 19, 2007
Electrical System
ALL GAUGES IN DASH ARE NOT WORKING. THIS PROBLEM HAS OCCURRED SINCE EARLY 2006. TOOK TO THE DEALER TO FIX, BUT AFTER SEVERAL MONTHS THE PROBLEM OCCURRED AGAIN. WHEN I WOULD TAKE BACK TO THE DEALER OF COURSE IT WAS WORKING AGAIN AND DIDN'T NEED TO FIX THE PROBLEM AT THE TIME. NOW HOWEVER, IT HAS BEEN HAPPENING MORE FREQUENTLY, IE…
Read full complaint
ALL GAUGES IN DASH ARE NOT WORKING. THIS PROBLEM HAS OCCURRED SINCE EARLY 2006. TOOK TO THE DEALER TO FIX, BUT AFTER SEVERAL MONTHS THE PROBLEM OCCURRED AGAIN. WHEN I WOULD TAKE BACK TO THE DEALER OF COURSE IT WAS WORKING AGAIN AND DIDN'T NEED TO FIX THE PROBLEM AT THE TIME. NOW HOWEVER, IT HAS BEEN HAPPENING MORE FREQUENTLY, IE. 3 TIMES IN THE LAST 5 DAYS. THE OTHER DAY WE LEFT THE HOUSE AND NOTHING WAS WORKING, HOWEVER WHEN WE LEFT TO GO HOME THE GAUGES WERE WORKING AGAIN. THEN 2 DAYS LATER EVERYTHING WAS WORKING JUST FINE, THEN WHEN I WENT TO DRIVE AGAIN NOTHING WAS WORKING, BUT BY THE NEXT MORNING EVERYTHING WAS WORKING JUST FINE, UNTIL TODAY AGAIN. *TR
NHTSA ODI #10203452
Official recalls
3Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Feb 6, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.
Jan 27, 2003
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, VEHICLES, DURING A 30 DEGREE LEFT ANGLE FRONTAL IMPACT OF SUFFICIENT SEVERITY, A TEAR COULD DEVELOP IN THE MID-FRAME CROSS MEMBER AT ITS ATTACHMENT TO THE LEFT FRAME RAIL. IF THE MID-FRAME CROSS MEMBER TEARS DURING FRONTAL IMPACT AND PRODUCES A SHARP EDGE, CONTACT OF THE SHARP EDGE WITH THE FUEL TANK COULD RESULT IN A PUNCTURE OF THE FUEL TANK AND POSSIBLE FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A FUEL TANK SHIELD. OWNER NOTIFICATION BEGAN FEBRUARY 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration