IllustrationUSING A LOT OF OIL BETWEEN OIL CHANGES. ADDED OIL AS NEEDED BUT NOW APPEARS TO BE USING MORE. 3,000 MILES 2 QUARTS DOWN. ABOUT 112,000 MILES OWNED SINCE NEW
2012 GMC Terrain
Owner reports · Recalls · Investigations
More warning signs than most Terrain years
Owner complaints for the 2012 GMC Terrain are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Terrain years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
2625–50K
5850–75K
6975–100K
70100–150K
12150K+
261 reports with mileage · 103 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 169 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports5 fire reports16 injury reports
Engine complaints
169 reportsOIL CONSUMPTION IS OUT OF CONTROL! WHEN I BOUGHT THE SUV USED AT 63K I COULD HEAR WITHIN 65K I NEED OIL JUST FROM THE SOUND OF THE ENGINE. I BOUGHT A 5 QT AT WAL-MART BECAUSE THERE WAS LESS THAN A QUART ON THE STICK. I GOT AND OIL CHANGE PRIOR ON 8-13-19 MECHANIC SHOWED I WAS LOW ALREADY AT 66K AND WASN'T DUE FOR ANOTHER TILL 72…
Read full complaint
OIL CONSUMPTION IS OUT OF CONTROL! WHEN I BOUGHT THE SUV USED AT 63K I COULD HEAR WITHIN 65K I NEED OIL JUST FROM THE SOUND OF THE ENGINE. I BOUGHT A 5 QT AT WAL-MART BECAUSE THERE WAS LESS THAN A QUART ON THE STICK. I GOT AND OIL CHANGE PRIOR ON 8-13-19 MECHANIC SHOWED I WAS LOW ALREADY AT 66K AND WASN'T DUE FOR ANOTHER TILL 72,780 I'M AT 72K AND ENGINE NEEDS OIL! HOPE THE CLASS ACTION LAWSUIT ABIDES TO MY COMPLAINT.
TL* THE CONTACT OWNS A 2012 GMC TERRAIN. WHILE THE VEHICLE WAS AT A STOP LIGHT, IT STALLED. THE VEHICLE WAS RESTARTED AND FUNCTIONED NORMALLY. THE CONTACT ALSO MENTIONED THAT THE OIL CONSUMPTION WAS HIGH. EVERY 1,800 MILES, OIL NEEDED TO BE ADDED TO THE VEHICLE AND AN ABNORMAL NOISE WAS DETECTED. THE VEHICLE WAS TAKEN TO AN INDE…
Read full complaint
TL* THE CONTACT OWNS A 2012 GMC TERRAIN. WHILE THE VEHICLE WAS AT A STOP LIGHT, IT STALLED. THE VEHICLE WAS RESTARTED AND FUNCTIONED NORMALLY. THE CONTACT ALSO MENTIONED THAT THE OIL CONSUMPTION WAS HIGH. EVERY 1,800 MILES, OIL NEEDED TO BE ADDED TO THE VEHICLE AND AN ABNORMAL NOISE WAS DETECTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING CHAIN WAS FAILING AND A MOTOR FLUSH WAS PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 154,000.
I WAS DRIVING MY 2012 GMC TERRAIN AND AS SOON AS I SLOWED DOWN OR STOPPED MY CAR WOULD SHUT OFF AND I WOULD HAVE TO TRY TO RESTART IT. FORTUNATELY, I MADE IT HOME WITHOUT HAVING TO STOP. AS I WAS TURNING IN MY DRIVEWAY IT SHUT OFF AGAIN. ONSTAR SUGGESTS IT MAY BE A TIMING ISSUE. HELP! I TOOK IT TO THE DEALERSHIP TO GET A NEW BAT…
Read full complaint
I WAS DRIVING MY 2012 GMC TERRAIN AND AS SOON AS I SLOWED DOWN OR STOPPED MY CAR WOULD SHUT OFF AND I WOULD HAVE TO TRY TO RESTART IT. FORTUNATELY, I MADE IT HOME WITHOUT HAVING TO STOP. AS I WAS TURNING IN MY DRIVEWAY IT SHUT OFF AGAIN. ONSTAR SUGGESTS IT MAY BE A TIMING ISSUE. HELP! I TOOK IT TO THE DEALERSHIP TO GET A NEW BATTERY AND WHEN I GOT MY CAR BACK THE FUEL SENSOR WAS NOT WORKING. IT WAS WORKING BEFORE THEY GOT IT AND GMC COLLIERVILLE REFUSED TO FIX IT.I CAN'T AFFORD ALL THESE MAJOR REPAIRS AND WILL NOT BY ANOTHER IF GMC DOES NOT RESOLVE THE CONSUMER'S ISSUES.
MY CAR JERKS AND STALLS WHEN IDLING AND MY FOOT IS ON THE BRAKE. I HAVE TO PUT THE CAR IN NEUTRAL OR SHUT IT OFF AND RESTART ALTOGETHER WHEN AT A STOP LIGHT OR WHEN I WILL BE DOING ANY STOPPING. IF NOT, THE CAR JERKS AND STALLS. THIS HAPPENED IN DOWNTOWN NASHVILLE, TN! VERY DANGEROUS! REDUCED POWER NOTIFICATION LIGHT CAME ON AS …
Read full complaint
MY CAR JERKS AND STALLS WHEN IDLING AND MY FOOT IS ON THE BRAKE. I HAVE TO PUT THE CAR IN NEUTRAL OR SHUT IT OFF AND RESTART ALTOGETHER WHEN AT A STOP LIGHT OR WHEN I WILL BE DOING ANY STOPPING. IF NOT, THE CAR JERKS AND STALLS. THIS HAPPENED IN DOWNTOWN NASHVILLE, TN! VERY DANGEROUS! REDUCED POWER NOTIFICATION LIGHT CAME ON AS WELL. I HAVE HAD IT IN THE SHOP MULTIPLE TIMES AND THEY ALL SAY IT IS FROM EXCESS OIL CONSUMPTION. HAVE ALREADY HAD THE TIMING CHAIN REPLACED DUE TO SAID OIL ISSUE. DRIVING THIS CAR WITH MY KIDS IS EXTREMELY DANGEROUS. WHY IS THERE NOT A RECALL ON THIS? THIS HAS BEEN AN ONGOING ISSUE WITH MY CAR SINCE LATE 2015.
2.4 ECOTEC ENGINES EXCESSIVE OIL CONSUMPTION AFFECTS THOUSANDS OF GMC/CHEVY CONSUMERS VEHICLES 2011-2013. ALTHOUGH IN FINAL STAGES OF CLASS ACTION, GMC CONTINUES TO DENY THE SERIOUS NATURE OF THE PROBLEM. OIL INDICATOR DOES NOT ILLUMINATE, ENGINES BLOWN, FAILED CATALYTIC CONVERTERS, REAR MAIN SEALS, TIMING CHAINS AND MORE. NO…
Read full complaint
2.4 ECOTEC ENGINES EXCESSIVE OIL CONSUMPTION AFFECTS THOUSANDS OF GMC/CHEVY CONSUMERS VEHICLES 2011-2013. ALTHOUGH IN FINAL STAGES OF CLASS ACTION, GMC CONTINUES TO DENY THE SERIOUS NATURE OF THE PROBLEM. OIL INDICATOR DOES NOT ILLUMINATE, ENGINES BLOWN, FAILED CATALYTIC CONVERTERS, REAR MAIN SEALS, TIMING CHAINS AND MORE. NOT ONLY A HUGE FINANCIAL IMPACT FOR OWNERS BUT ALSO A SERIOUS SAFETY ISSUE. GMC SUGGESTS A PISTON RING FAILURE BUT ONLY OFFERS RESOLUTION TO VERY FEW OWNERS. PLEASE CONSIDER A RECALL ON THESE VEHICLES. YOU WILL FIND MORE INFORMATION HERE: HTTPS://TOPCLASSACTIONS.COM/LAWSUIT-SETTLEMENTS/CONSUMER-PRODUCTS/AUTO-NEWS/857897-GM-CLASS-ACTION-SAYS-CHEVROLET-EQUINOX-SUVS-BURN-OIL-ALARMING-RATE/ AND HERE: HTTPS://WWW.FACEBOOK.COM/GROUPS/174877126561662/ AND SO MUCH MORE ONLINE. PLEASE CONSIDER A RECALL. THE CLASS ACTION IS NOT FOR THE BENEFIT OF THE CONSUMERS.
THE VEHICLE HAS EXCESSIVE OIL CONSUMPTION. I HAVE TO KEEP ADDING MOTOR OIL A COUPLE WEEKS AFTER DOING OIL CHANGE.
AT 77,894 MILES, & ABOUT 3,000 MILES INTO PREVIOUS OIL CHANGE, THE CAR SHUT OFF WHILE MY WIFE WAS DRIVING WITH OUR CHILDREN IN THE CAR AND STOPPED IN THE MIDDLE OF THE ROAD. SEVERAL ATTEMPTS TO RE-START THE ENGINE WERE UNSUCCESSFUL. PRIOR TO THIS THERE WAS NO WARNING SIGNS OF ISSUES SUCH AS CHECK ENGINE LIGHT, ODD NOISE, ETC. TH…
Read full complaint
AT 77,894 MILES, & ABOUT 3,000 MILES INTO PREVIOUS OIL CHANGE, THE CAR SHUT OFF WHILE MY WIFE WAS DRIVING WITH OUR CHILDREN IN THE CAR AND STOPPED IN THE MIDDLE OF THE ROAD. SEVERAL ATTEMPTS TO RE-START THE ENGINE WERE UNSUCCESSFUL. PRIOR TO THIS THERE WAS NO WARNING SIGNS OF ISSUES SUCH AS CHECK ENGINE LIGHT, ODD NOISE, ETC. THE CAR DID NOT ALLOW TIME FOR THE VEHICLE TO DRIFT OFF THE MAIN ROAD AND CREATED A RISK OF POTENTIAL COLLISION WITH OTHER VEHICLES. LUCKILY THIS OCCURRED IN A RESIDENTIAL AREA AND NOT ON THE HIGHWAY A FEW MINUTES EARLIER. WE HAD THE VEHICLE TOWED TO MY CERTIFIED MECHANIC AND UPON INSPECTION IDENTIFIED THERE WAS NO OIL IN THE CAR. THERE IS NO SIGN OF OIL LEAKAGE, AND THE OIL HAD BEEN CHANGED AND TOPPED OFF LESS THAN 3000 MILES PRIOR TO THIS. APPROX. 2 YEARS PRIOR, WE RECEIVING THE BULLETIN & TOOK THE VEHICLE TO THE GMC DEALER, CORAL SPRINGS AUTO MALL TO CONDUCT A OIL CONSUMPTION TEST. THE SERVICE ADVISOR CHECKED THE DIPSTICK UPON MY RETURN AS INSTRUCTED 2000 MILES LATER & ADVISED IT "APPEARED" THAT MY CAR DID NOT HAVE THE ISSUE. REMEMBERING THIS INSTANCE, 2 YEARS LATER, WHILE STILL WITHIN THE SPECIAL COVERAGE WARRANTY PARAMETERS, I HAD THE CAR TOWED BACK TO CORAL SPRINGS AUTO MALL GMC FOR THE REPAIR. I AM NOW BEING TOLD BY BOTH THE SERVICE MANAGER AND GMC CUSTOMER CARE AGENT THAT SINCE I DID NOT BRING THE VEHICLE IN SOONER, THEY WILL NOT HONOR THE COVERAGE, HOWEVER THEY DO HAVE RECORD OF THE INSPECTION ON 06/06/17 BUT THE ADVISOR DID NOT UPDATE THE TICKET WITH RESULTS. I AM ALSO TOLD THAT BASED ON LOYALTY WITH THE DEALER, THEY COULD HONOR THE COVERAGE, HOWEVER SINCE I DO NOT SERVICE MY CAR THERE, I HAVE NO LOYALTY IN ORDER FOR THEM TO HONOR THE CLAIM AND REPAIR THE VEHICLE. THEY QUOTED $5,800 TO REPLACE AN ENGINE THEY KNOW TO BE FAULTY. DUE TO "LACK OF LUBRICATION" CAUSED BY EXCESSIVE OIL CONSUMPTION THE ENGINE HAS SIGNIFICANT INTERNAL DAMAGE.
CAR JERKS AND STALLS WHEN IDLING AND FOOT ON THE BRAKE. HAVE TO PUT THE CAR IN NEUTRAL WHEN AT A STOP LIGHT OR SIGN. IF NOT, THE CAR JERKS AND STALLS. THIS STARTED HAPPENING LAST MONTH. REDUCED POWER NOTIFICATION LIGHT CAME ON TODAY ALONG WITH THE ENGINE LIGHT.
EXCESSIVE OIL CONSUMPTION AT LESS THAN 65,000 MILES, WARNING LIGHTS DO NOT ACTIVATE TO INDICATE A PROBLEM. NEXT THE TIMING CHAIN BROKE AND WAS REPAIRED, NOW THE CATALYTIC CONVERTER NEEDS REPLACEMENT. ALL RESULT OF OIL CONSUMPTION AND IS A WIDELY KNOWN ISSUE AFFECTING THOUSANDS OF 2010-2013 GMC TERRAINS IN THE US BUT GMC WILL N…
Read full complaint
EXCESSIVE OIL CONSUMPTION AT LESS THAN 65,000 MILES, WARNING LIGHTS DO NOT ACTIVATE TO INDICATE A PROBLEM. NEXT THE TIMING CHAIN BROKE AND WAS REPAIRED, NOW THE CATALYTIC CONVERTER NEEDS REPLACEMENT. ALL RESULT OF OIL CONSUMPTION AND IS A WIDELY KNOWN ISSUE AFFECTING THOUSANDS OF 2010-2013 GMC TERRAINS IN THE US BUT GMC WILL NOT HELP OR TAKE RECALL ACTION. A CLASS ACTION LAWSUIT IS UNDERWAY, BUT IT WON'T BE APPROVED UNTIL OCT 2019 (STATE OF FL), TWO OTHERS ON A STAY (IL AND CA) UNTIL FL IS FINALIZED. I PURCHASED MY VEHICLE USED WITH A SALVAGE TITLE. THE OIL PROBLEM IS IN NO WAY CONNECTED WITH THE SALVAGE TITLE (REAR END DAMAGE, AND CERTIFIED BY STATE AS SAFE). GMC MAILED ME A SPECIAL COVERAGE LETTER DATED MAY 2017 BUT THEY WON'T HONOR IT BECAUSE I DID NOT PURCHASE FROM A GMC DEALER OR HAVE MY ROUTINE MAINTENANCE AT GMC SERVICE. IN FACT WHEN I RECEIVED THE LETTER I FOLLOWED THE INSTRUCTIONS AND CONTACTED A LOCAL GMC SERVICE BUT THEY CALLED ME BACK TELLING ME THEY ARE CANCELLING THE APPOINTMENT BECAUSE WHEN THEY LOOKED UP MY VIN AND SAW IT IS A SALVAGE TITLE. I TOLD THEM I HAVE THE LETTER FROM GM DATED MAY 2017 BUT THEY TOLD ME I SHOULD NOT HAVE RECEIVED THE LETTER, THAT I DON'T QUALIFY. THE LETTER READS IN PART: "GMC IS PROVIDING OWNERS WITH ADDITIONAL PROTECTION FOR THE CONDITION, IF THIS CONDITION OCCURS WITHIN 7 YEARS AND 6 MONTHS OR 120000 MILES THE CONDITION WILL BE REPAIRED AT NO CHARGE." PLEASE SEE TESTIMONIALS HERE FROM AFFECTED CONSUMERS: TERRRAIN-EQUINOX OIL CONSUMPTION RECALL: HTTPS://WWW.FACEBOOK.COM/GROUPS/174877126561662/ HTTPS://WWW.CARCOMPLAINTS.COM/NEWS/2019/GM-OIL-CONSUMPTION-LAWSUIT.SHTML HTTPS://WWW.CLASSACTION.ORG/BLOG/SETTLEMENT-REACHED-IN-CLASS-ACTION-OVER-CHEVY-EQUINOX-GMC-TERRAIN-OIL-CONSUMPTION-HERE-ARE-THE-DETAILS THESE ARE FAMILY VEHICLES AND THEY ARE UNSAFE. PLEASE HELP.
Official recalls
422V137000 · Exterior Lighting:headlights
Mar 8, 2022
General Motors, LLC (GM) is recalling certain 2010-2017 GMC Terrain vehicles. A reflection caused by the headlight housings may illuminate areas above the vehicle and outside of the driver's view with excessively bright light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: The bright reflection may cause a glare for other drivers, reducing their visibility and increasing the risk of a crash.
Remedy: Dealers will install headlamp appliques, free of charge. Owner notification letters were mailed September 8, 2022. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N222363740.
16V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
14V447000 · Seats:front Assembly:power Adjust
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
11V511000 · Tires:pressure Monitoring And Regulating Systems
Oct 19, 2011
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES, MANUFACTURED FROM JULY 18, 2011, THROUGH SEPTEMBER 6, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 138, "TIRE PRESSURE MONITORING SYSTEM" (TPMS). THE TIRE PRESSURE MONITORING SYSTEM IS DESIGNED TO ILLUMINATE THE TIRE PRESSURE WARNING LIGHT WHEN THE PRESSURE IN A TIRE IS 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE. ON THESE VEHICLES, THE LIGHT WILL NOT ILLUMINATE UNTIL THE TIRE PRESSURE IS MORE THAN 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE.
Consequence & remedy
Consequence: UNDERINFLATED TIRES CAN RESULT IN TIRE OVERLOADING AND OVERHEATING, WHICH COULD LEAD TO A BLOWOUT AND POSSIBLE CRASH. THE RESULTING CRASH COULD CAUSE SERIOUS INJURY. UNDERINFLATED TIRES CAN ALSO RESULT IN PREMATURE OR IRREGULAR WEAR, POOR HANDLING, AND POOR FUEL ECONOMY.
Remedy: GM DEALERS WILL UPDATE THE BODY CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 9, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.