NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
31 reportsClear category filterMileage unknown · Jul 31, 2024
EngineFuel/propulsion System
SUV gets a slow down warning and it stops shuts off , it’s happened several times now I’m scared!!you wait few minutes it turns back on , mechanic said this a complain about this vehicle all the time , it has not been repaired I’m disabled with no money , I was on the highway and thank God I was on the slow lane if not I would …
Read full complaint
SUV gets a slow down warning and it stops shuts off , it’s happened several times now I’m scared!!you wait few minutes it turns back on , mechanic said this a complain about this vehicle all the time , it has not been repaired I’m disabled with no money , I was on the highway and thank God I was on the slow lane if not I would have been killed by an eighteen wheeler. GMC is waiting for someone to die and probably address this issue
NHTSA ODI #11605745
Mileage unknown · Feb 12, 2024
EngineFuel/propulsion System
Engine Failure: Timing chain had excessive slack causing guide to be sheared off. Timing chain guide bolt was completely stripped requiring both the timing chain and cylinder head to be replaced. Safety: The vehicle stalled while driving Problem: Problem was confirmed by a dealer Warnings: The check engine light came on as th…
Read full complaint
Engine Failure: Timing chain had excessive slack causing guide to be sheared off. Timing chain guide bolt was completely stripped requiring both the timing chain and cylinder head to be replaced. Safety: The vehicle stalled while driving Problem: Problem was confirmed by a dealer Warnings: The check engine light came on as the vehicle stalled
NHTSA ODI #11571561
Mileage unknown · Oct 25, 2023
EngineFuel/propulsion System
My car wouldn’t start, later found out it was due to timing chain issue which ended up blowing up my engine. I live 40 minutes from work and am consistently driving on the interstate for at least an hour a day. GM said there’s nothing they can do even though there’s been class action lawsuits for the engine. My car has also had …
Read full complaint
My car wouldn’t start, later found out it was due to timing chain issue which ended up blowing up my engine. I live 40 minutes from work and am consistently driving on the interstate for at least an hour a day. GM said there’s nothing they can do even though there’s been class action lawsuits for the engine. My car has also had oil consumption problems. I bought my car in March of 2022. The engine blew up by November 2022. I barely got my car back in September 2023. After the engine replacement, still wouldn’t turn on, over heated immediately when I did get it back. After paying $7440 for the engine replacement I had to fork over snother $650 to replace the fuel pump control module, and an engine control unit. My car overheated AGAIN just 2 weeks ago!!!!
NHTSA ODI #11551802
Mileage unknown · Jun 23, 2022
EngineFuel/propulsion SystemPower Train
Was driving home from work had a half tank of gas no lights or anything came on, car just shut off was not able to start it from that point. I spoke with car lot to whom I'm making payments with and not able to get anything done with the vehicle. Now I've lost my job and I'm about to be homeless due to this mechanic problem on t…
Read full complaint
Was driving home from work had a half tank of gas no lights or anything came on, car just shut off was not able to start it from that point. I spoke with car lot to whom I'm making payments with and not able to get anything done with the vehicle. Now I've lost my job and I'm about to be homeless due to this mechanic problem on this vehicle.
NHTSA ODI #11470574
91,000 miles · Dec 3, 2020
EngineFuel/propulsion SystemPower Train
I PURCHASED THE VEHICLE IN MARCH 2018. FROM THE DATE OF PURCHASE, THE SERVICE ENGINE AND/OR CHANGE OIL LIGHTS WOULD TURN ON. EVERY TIME I TOOK THE VEHICLE TO MY MECHANIC, IT NEEDED OIL. IN JANUARY 2020, I GOT A NOTICE FROM GMC ABOUT THE SETTLEMENT OF A LAWSUIT REGARDING VEHICLE OIL CONSUMPTION. I TOOK THE VEHICLE TO MY LOCAL…
Read full complaint
I PURCHASED THE VEHICLE IN MARCH 2018. FROM THE DATE OF PURCHASE, THE SERVICE ENGINE AND/OR CHANGE OIL LIGHTS WOULD TURN ON. EVERY TIME I TOOK THE VEHICLE TO MY MECHANIC, IT NEEDED OIL. IN JANUARY 2020, I GOT A NOTICE FROM GMC ABOUT THE SETTLEMENT OF A LAWSUIT REGARDING VEHICLE OIL CONSUMPTION. I TOOK THE VEHICLE TO MY LOCAL GMC AND THE MANAGER READ THE "NOTICE OF APPROVAL OF CLASS ACTION SETTLEMENT AND CLAIM FORM" THAT WAS SENT TO ME. THE LAWSUIT REQUIRES GMC TO PAY FOR REPAIRS OR REIMBURSE CUSTOMERS FOR THE REPAIRS. MY VEHICLE HAD NOT HAD THE NECESSARY REPAIRS DONE TO IT, SO THE MANAGER INSTRUCTED ME TO APPROVE THE NECESSARY REPAIRS AND PAY FOR THEM OUT OF POCKET BECAUSE GMC WOULD REIMBURSE ME. THE REPAIRS WERE COMPLETED ON FEBRUARY 7, 2020. I FOLLOWED ALL THE GUIDELINES PROVIDED TO ME BY GMC IN ORDER TO GET THE REIMBURSEMENT. I MAILED DOCUMENTS TO THEM A WEEK AFTER THE REPAIRS WERE COMPLETED, MONTHS BEFORE THE DEADLINE OF MAY 16, 2020. AFTER WAITING OVER A MONTH AND NOT GETTING REIMBURSED, I CALLED GMC CUSTOMER SERVICES (1-866-790-5600) ON APRIL 11, 2020. I WAS INFORMED BY GMC CUSTOMER SERVICE TO EXPECT A REIMBURSEMENT CHECK FOR REPAIRS AND RENTAL CAR FEES WITHIN TWO WEEKS. AFTER NOT RECEIVING THE REIMBURSEMENT, I CALLED AGAIN IN JUNE AND JULY 2020 AND GIVEN THE SAME INFORMATION-WAIT. THIS CONTINUED THROUGHOUT THE SUMMER. THE DELAY WAS BLAMED ON COVID-19. I CALLED AGAIN IN LATE SEPTEMBER 2020, AND THEY INSTRUCTED ME TO EMAIL ALL THE DOCUMENTS AND THAT THE CHECK WOULD ARRIVE IN TWO WEEKS. ON SEPTEMBER 30, 2020, I EMAILED ALL THE DOCUMENTS TO GMC. AFTER WAITING ANOTHER TWO WEEKS, I CALLED THEM AND THEY AGAIN SAID IT WOULD COME IN TWO WEEKS. ON NOVEMBER 10, 2020, I SENT ANOTHER EMAIL ASKING FOR THE REIMBURSEMENT CHECK. A WEEK LATER, I GOT A LETTER STATING I DID NOT QUALIFY FOR REIMBURSEMENT BECAUSE THE TIME HAD PASSED/EXPIRED.
NHTSA ODI #11377827
130,000 miles · Sep 22, 2020
EngineFuel/propulsion System
DIAGNOSED WITH OIL CONSUMPTION PROBLEM, P0014 CODE FOR CHECK ENGINE LIGHT, SHOWING 10 DEGREES ON SCANNER, RECOMMENDED TIMING CHAIN ALIGNMENT, MY CAR SHUT OFF WHILE DRIVING IT, GMC HAS CLASS ACTION LAWSUIT, TOLD ME MY VIN WAS ELIGIBLE FOR IT, BUT WILL NOT LET ME SUBMIT A CLAIM, I HAVE OWNED THIS CAR FOR A YEAR, CONSTANT OIL CHANG…
Read full complaint
DIAGNOSED WITH OIL CONSUMPTION PROBLEM, P0014 CODE FOR CHECK ENGINE LIGHT, SHOWING 10 DEGREES ON SCANNER, RECOMMENDED TIMING CHAIN ALIGNMENT, MY CAR SHUT OFF WHILE DRIVING IT, GMC HAS CLASS ACTION LAWSUIT, TOLD ME MY VIN WAS ELIGIBLE FOR IT, BUT WILL NOT LET ME SUBMIT A CLAIM, I HAVE OWNED THIS CAR FOR A YEAR, CONSTANT OIL CHANGES ABOUT EVERY 2 MONTHS.
NHTSA ODI #11360517
85,000 miles · Jul 10, 2020
Fuel/propulsion System
I PURCHASED THE VEHICLE IT RAN GREAT. WITHIN A COUPLE OF WEEKS, IT STARTED STALLING WHEN I GO TO TAKE OFF IN THE MIDDLE OF INTERSECTIONS OR PULLING OUT ONTO A ROAD. IT WILL RUN FINE I STOP IT IDLES OK AND WHEN I TOUCH THE GAS PEDAL IT WILL START OUT INTO THE ROAD AND THEN JUST DIE.
NHTSA ODI #11338668
164,000 miles · May 10, 2020
EngineFuel/propulsion SystemPower Train
THE VEHICLE GOING THROUGH OIL LIKE MADE AND STALLING IN THE MIDDLE OF INTERSECTIONS OR PULLING ONTO A ROAD. THIS HAS CAUSED OTHER PEOPLE TO ALMOST HIT ME OR GO OFF THE ROAD TO AVOID AN ACCIDENT. I WILL START OUT INTO AN INTERSECTION GET IN THE MIDDLE AND IT DIES. TURNING ONTO A DIFFERENT ROAD THIS HAPPENS ALSO IN MOTION GOING AT…
Read full complaint
THE VEHICLE GOING THROUGH OIL LIKE MADE AND STALLING IN THE MIDDLE OF INTERSECTIONS OR PULLING ONTO A ROAD. THIS HAS CAUSED OTHER PEOPLE TO ALMOST HIT ME OR GO OFF THE ROAD TO AVOID AN ACCIDENT. I WILL START OUT INTO AN INTERSECTION GET IN THE MIDDLE AND IT DIES. TURNING ONTO A DIFFERENT ROAD THIS HAPPENS ALSO IN MOTION GOING AT NORMAL SPEEDS FOR THE ROAD. *TR
NHTSA ODI #11324051
164,000 miles · May 10, 2020
EngineFuel/propulsion SystemPower Train
I PURCHASED THE VEHICLE IT RAN GREAT. WITHIN A COUPLE OF WEEKS, IT STARTED STALLING WHEN I GO TO TAKE OFF IN THE MIDDLE OF INTERSECTIONS OR PULLING OUT ONTO A ROAD. IT WILL RUN FINE I STOP IT IDLES OK AND WHEN I TOUCH THE GAS PEDAL IT WILL START OUT INTO THE ROAD AND THEN JUST DIE. IT GOES THOUGH OIL LIKE MAD. *TR
NHTSA ODI #11324048
50,000 miles · Feb 13, 2020
Fuel/propulsion System
WHEN REFUELING VEHICLE AT A GAS STATION, AT A FULL STOP, WITH THE ENGINE TURNED OFF, THE GASOLINE PUMP WILL NOT STAY ON WHILE INSERTED INTO THE FUEL TANK OF MY 2011 GMC TERRAIN, NO MATTER WHICH FUEL VENDOR I BUY A FILL UP FROM. I HAVE HAD THIS CAR FOR SEVERAL YEARS, AND IT HAS NEVER WORKED PROPERLY. I DECIDED TO REACH OUT TO S…
Read full complaint
WHEN REFUELING VEHICLE AT A GAS STATION, AT A FULL STOP, WITH THE ENGINE TURNED OFF, THE GASOLINE PUMP WILL NOT STAY ON WHILE INSERTED INTO THE FUEL TANK OF MY 2011 GMC TERRAIN, NO MATTER WHICH FUEL VENDOR I BUY A FILL UP FROM. I HAVE HAD THIS CAR FOR SEVERAL YEARS, AND IT HAS NEVER WORKED PROPERLY. I DECIDED TO REACH OUT TO SEE IF THIS IS A NORMAL ISSUE FOR THIS VEHICLE. IF IT IS NOT, THEN COULD THIS BE A RECALL EVENT? THANKS FOR YOUR HELPFULNESS.
NHTSA ODI #11309085
Official recalls
4Mar 8, 2022
General Motors, LLC (GM) is recalling certain 2010-2017 GMC Terrain vehicles. A reflection caused by the headlight housings may illuminate areas above the vehicle and outside of the driver's view with excessively bright light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: The bright reflection may cause a glare for other drivers, reducing their visibility and increasing the risk of a crash.
Remedy: Dealers will install headlamp appliques, free of charge. Owner notification letters were mailed September 8, 2022. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N222363740.
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
Dec 15, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC SRX, CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES. THE DRIVER AND /OR FRONT PASSENGER SAFETY BELT BUCKLE ANCHOR MAY FRACTURE AND SEPARATE NEAR THE SEAT ATTACHMENT IN A VEHICLE CRASH.
Consequence & remedy
Consequence: THE SAFETY BELT SYSTEM MAY NOT RESTRAIN THE OCCUPANT(S) AS DESIGNED AND COULD INCREASE THE RISK OF INJURY.
Remedy: DEALERS WILL MODIFY THE PASSENGER AND/OR THE DRIVER SAFETY BELT BUCKLES AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 18, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Illustration