IllustrationMileage unknown · Aug 3, 2023
Unknown Or Other
Unknown
NHTSA ODI #11536339
2001 GMC Sierra 2500
Owner reports · Recalls · Investigations
More warning signs than most Sierra 2500 years
Owner complaints for the 2001 GMC Sierra 2500 are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sierra 2500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
3025–50K
2450–75K
1375–100K
20100–150K
18150K+
111 reports with mileage · 23 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports2 fire reports6 injury reports
What owners actually said
134 reportsUnknown
FUEL IS DUMPING INTO INJECTORS. 2001 GMC SIERRA 2500 DIESEL. ONLY HAS 135,000 MILES!! ENGINE BOGGS DOWN WHEN CLIMBING HILL, BRIDGE, OR TOWING.
I HAVE A 2001 GMC TRUCK THAT THE REAR FRAME HORN ON THE PASSENGER SIDE WERE THE FRAME IS WELDED ABOUT 6 INCHES FROM THAT POINT IT HAS A CRACK ALL THE WAY TO THE TOP OF THE FRAME RIGHT WERE THE BUMP STOP IS ON THE FRAME WITH ONLY ABOUT 1 INCH HOLDING THE FRAME TOGETHER AS OF RIGHT NOW THE REST OF THE FRAME LOOKED OK WHEN INSPECTE…
Read full complaint
I HAVE A 2001 GMC TRUCK THAT THE REAR FRAME HORN ON THE PASSENGER SIDE WERE THE FRAME IS WELDED ABOUT 6 INCHES FROM THAT POINT IT HAS A CRACK ALL THE WAY TO THE TOP OF THE FRAME RIGHT WERE THE BUMP STOP IS ON THE FRAME WITH ONLY ABOUT 1 INCH HOLDING THE FRAME TOGETHER AS OF RIGHT NOW THE REST OF THE FRAME LOOKED OK WHEN INSPECTED
TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE SUDDENLY LOST COMPRESSION AND THE VEHICLE FAILED TO ACCELERATE PROPERLY. THE VEHICLE WAS TAKEN TO COURTESY CADILLAC (1345 EVANGELINE THRUWAY, BROUSSARD, LA) WHERE IT WAS DIAGNOSED THAT ONE OR MORE FUEL INJECTORS WERE FAULTY AND REMAINED OPEN. T…
Read full complaint
TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE SUDDENLY LOST COMPRESSION AND THE VEHICLE FAILED TO ACCELERATE PROPERLY. THE VEHICLE WAS TAKEN TO COURTESY CADILLAC (1345 EVANGELINE THRUWAY, BROUSSARD, LA) WHERE IT WAS DIAGNOSED THAT ONE OR MORE FUEL INJECTORS WERE FAULTY AND REMAINED OPEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE CONTACT INDICATED THAT ALL EIGHT FUEL INJECTORS WERE PREVIOUSLY REPLACED APPROXIMATELY FIVE YEARS; HOWEVER, BUT THE FAILURE RECENTLY RECURRED. THE FAILURE MILEAGE WAS 200,000.
VEHICLE STALLS AND SHUTS OFF WHILE DRIVING AND IDLE. SOMETIMES IT STARTS BACK UP IMMEDIATELY, OTHER TIMES IT WILL JUST CRANK OVER BUT WILL NOT START. AFTER LETTING IT SIT SOMETIMES 5 TO 20 MINUTES AT A TIME IT WILL THEN START BACK UP. ALL RESEARCH AND ISSUES WITH THE VEHICLE INDICATE A MANUFACTURER RECALL OF A CRANKSHAFT POSITI…
Read full complaint
VEHICLE STALLS AND SHUTS OFF WHILE DRIVING AND IDLE. SOMETIMES IT STARTS BACK UP IMMEDIATELY, OTHER TIMES IT WILL JUST CRANK OVER BUT WILL NOT START. AFTER LETTING IT SIT SOMETIMES 5 TO 20 MINUTES AT A TIME IT WILL THEN START BACK UP. ALL RESEARCH AND ISSUES WITH THE VEHICLE INDICATE A MANUFACTURER RECALL OF A CRANKSHAFT POSITION SENSOR. THE VEHICLE WILL STALL OR SHUT OFF AT RANDOM WHETHER IT'S IN MOTION DOWN THE HIGHWAY IN THE MIDDLE OF A INTERSECTION OR AT A STOP SIGN . I HAVE ALMOST BEEN T-BONES DUE TO THE VEHICLE STALLING IN THE MIDDLE OF THE INTERSECTION AND I HAVE ALSO HAD TO REPLACE MY DRIVERS MIRROR DUE TO THE VEHICLE STALLING ON THE INTERSTATE AND NEARLY BEING HIT BY ANOTHER VEHICLE. *TR
HAVING HEARD ABOUT MICHELIN RECALLS I CHECKED THE TIRES ON MY 2001 GMC SIERRA PICKUP. I HAVE MICHELIN LT245/75R16 120/116R XC LT4 TIRES WITH LESS THAN 20,000 MILES WEAR. TWO OF THEM ARE "CRUMBLING" OUT 1 1/2 INCH ABOVE THE RIM. YOU CAN SEE FIBERS IN THE HOLES. THERE ARE CRACKS EVERYWHERE ON ALL THE TIRES. THEY HAVE BEEN CO…
Read full complaint
HAVING HEARD ABOUT MICHELIN RECALLS I CHECKED THE TIRES ON MY 2001 GMC SIERRA PICKUP. I HAVE MICHELIN LT245/75R16 120/116R XC LT4 TIRES WITH LESS THAN 20,000 MILES WEAR. TWO OF THEM ARE "CRUMBLING" OUT 1 1/2 INCH ABOVE THE RIM. YOU CAN SEE FIBERS IN THE HOLES. THERE ARE CRACKS EVERYWHERE ON ALL THE TIRES. THEY HAVE BEEN COVERED FROM THE SUN. GRANTED THE TIRES HAVE AGE BUT I HAVE NEVER SEEN "CRUMBLING" BEFORE.
TL* THE CONTACT OWNS A 2001 GMC 2500 HD. WHILE DRIVING APPROXIMATELY 35 MPH AND DEPRESSING THE BRAKE PEDAL, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE. THE CONTACT ENGAGED THE EMERGENCY BRAKE AND PLACED THE VEHICLE IN PARK. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS DIAGNOSED THAT THE…
Read full complaint
TL* THE CONTACT OWNS A 2001 GMC 2500 HD. WHILE DRIVING APPROXIMATELY 35 MPH AND DEPRESSING THE BRAKE PEDAL, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE. THE CONTACT ENGAGED THE EMERGENCY BRAKE AND PLACED THE VEHICLE IN PARK. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS DIAGNOSED THAT THE DISTRIBUTOR BRAKE BLOCK HAD EXCESSIVE RUST AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. THE VIN WAS UNAVAILABLE.
I UNDERSTAND GM HAD A RECALL ON THE BRAKE BOOSTER SYTEM AND ALSO A FEW YEARS BACK A RECALL ON REPLACING ALL THE FUEL INJECTORS ON THE DIESEL ENGINE ! I AM ORINGINAL OWNER AT THE SAME ADDRESS WHEN I PURCHASED THE VEHICLE NEW ! I MISSED THE RECALLS BECAUSE I NEVER WAS NOTIFIED ! ITS SAD TO BUY A GM PRODUCT AND THEY DON'T ALERT ME …
Read full complaint
I UNDERSTAND GM HAD A RECALL ON THE BRAKE BOOSTER SYTEM AND ALSO A FEW YEARS BACK A RECALL ON REPLACING ALL THE FUEL INJECTORS ON THE DIESEL ENGINE ! I AM ORINGINAL OWNER AT THE SAME ADDRESS WHEN I PURCHASED THE VEHICLE NEW ! I MISSED THE RECALLS BECAUSE I NEVER WAS NOTIFIED ! ITS SAD TO BUY A GM PRODUCT AND THEY DON'T ALERT ME TO A RECALL ! WHAT'S UP WITH THIS?
IGNITION SWITCH FAULTY MY CAR NOT IN RECALL TAKES NUMEROUS ATTEMPTS TO START AND WHEN STARTED AIRBAG CONTINUOUSLY LIGHTS UP WHEN DRIVING.
KUHMO ROAD VENTURE AT TIRE 245/75R/16 TREAD SEPARATION. THIS IS THE SECOND INCIDENT WITH TIRES UNDER 10,000 MILES FOR THIS BRAND AND SIZE TIRE. THE FIRST INCIDENT TORE UP THE SIDE OF MY PICKUP WHILE TOWING A 5TH WHEEL TRAILER. WHEN THE SECOND INCIDENT OCCURRED, I FELT A VIBRATION IN THE TRUCK AND PULLED INTO A ROADSIDE REST AREA…
Read full complaint
KUHMO ROAD VENTURE AT TIRE 245/75R/16 TREAD SEPARATION. THIS IS THE SECOND INCIDENT WITH TIRES UNDER 10,000 MILES FOR THIS BRAND AND SIZE TIRE. THE FIRST INCIDENT TORE UP THE SIDE OF MY PICKUP WHILE TOWING A 5TH WHEEL TRAILER. WHEN THE SECOND INCIDENT OCCURRED, I FELT A VIBRATION IN THE TRUCK AND PULLED INTO A ROADSIDE REST AREA. AFTER I STOPPED AND WAS ALMOST OUT OF THE TRUCK, I HEARD A LOUD POP AND THE TIRE TREAD HAD SEPARATED RIPPING THE SIDE OF THE TIRE OUT. AGAIN, TOWING A 5TH WHEEL TRAILER. IN THE FIRST INCIDENT KUHMO ARGUED FOR THREE MONTHS THAT I HAD DRIVEN THE TIRE FLAT. THEY FINALLY AGREED TO REPLACE THE TIRE AND REPAIR MY TRUCK. THESE TIRES ARE UNSAFE FOR HIGHWAY USE.
Official recalls
201V220000 · Interior Lighting
Jun 26, 2001
VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE SYSTEM WARNING LIGHT IN THE INSTRUMENT CLUSTER THAT MAY NOT ILLUMINATE WHEN THE BRAKE FLUID IS LOW. IN ADDITION, WHEN THE BRAKE FLUID IS LOW, THE VEHICLE MAY NOT MEET THE PARTIAL SYSTEM REQUIREMENTS OF FMVSS NO. 105.
Consequence & remedy
Consequence: THESE CONDITIONS COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD LEAD TO A CRASH.
Remedy: DEALERS WILL CHANGE THE LOCATION OF A WIRE CONNECTION IN THE UNDERHOOD BUSSED ELECTRICAL CENTER. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
01V125000 · Equipment:other:labels
Apr 10, 2001
VEHICLE DESCRIPTION: CERTAIN 2-WHEEL DRIVE PICKUP TRUCKS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE PROBLEM WAS CAUSED BY A COMPUTER ERROR THAT RESULTED IN THE CERTIFICATION LABEL LISTING TIRE SIZE AND INFLATION PRESSURE INFORMATION THAT DIFFER FROM THE TIRE SIZE AND THE INFLATION PRESSURE INFORMATION FOR THE TIRES ON THE VEHICLE. IF THE VEHICLE OWNER OR SOMEONE SERVICING THE VEHICLE INFLATES THE TIRES ACCORDING TO THE PRESSURE SPECIFIED ON THE LABEL VERSUS THE APPROPRIATE PRESSURE FOR THE TIRES, THE TIRES COULD BE UNDER-INFLATED OR OVER-INFLATED DEPENDING ON THE TIRES MOUNTED ON THE VEHICLE.
Consequence & remedy
Consequence: IF THE TIRES ARE UNDER-INFLATED, IT COULD REDUCE THE TREAD LIFE OF THE TIRE, AND THE TIRE COULD DEGRADE TO A POINT OF ALLOWING SUDDEN AIR LOSS. IF THE TIRES ARE OVER-INFLATED, IT COULD REDUCE THE TREAD LIFE OF THE TIRE AND INCREASE SUSCEPTIBILITY TO ROAD HAZARD DAMAGE. IF SUDDEN AIR LOSS OR A ROAD HAZARD CAUSES DAMAGE TO A TIRE, CONTROL OF THE VEHICLE COULD BE ADVERSELY AFFECTED AND COULD RESULT IN A VEHICLE CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH A NEW LABEL AND INSTALLATION INSTRUCTIONS. HOWEVER, A DEALER CAN INSTALL THE LABEL IF THE OWNER SO DESIRES. OWNER NOTIFICATION BEGAN MAY 31, 2001. OWNERS WHO DO NOT RECEIVE THE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA06016 · Crank Position Sensor Failure - Stall
Opened Sep 14, 2006 · Closed Nov 9, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Engine And Engine Cooling:engine
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
PE04004 · Hydraulic Pump Shaft Failures
Opened Jan 8, 2004 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Additional source detail variants (5)
Service Brakes, Hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist:hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist System
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.