NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
96 reportsClear category filter20 miles · Aug 8, 2018
Electrical SystemElectronic Stability Control (esc)Steering
TRUCK HAS 3 PROBLEMS THAT CAN PUT MY FAMILY'S LIFE IN DANGER. 1- SOMETIMES OUT OF NOWHERE AT LOW SPEEDS WHEN YOU TURN THE STEERING WHEEL TO MAKE A LEFT OR RIGHT TURN THE 'STABILITRAC' LIGHT FLASHES IN THE SCREEN AND LOCKS AND WON'T LET YOU TURN THE STEERING WHEEL.AT THIS POINT YOU HAVE NO CONTROL OF THE STEERING WHEEL, IT LOCK…
Read full complaint
TRUCK HAS 3 PROBLEMS THAT CAN PUT MY FAMILY'S LIFE IN DANGER. 1- SOMETIMES OUT OF NOWHERE AT LOW SPEEDS WHEN YOU TURN THE STEERING WHEEL TO MAKE A LEFT OR RIGHT TURN THE 'STABILITRAC' LIGHT FLASHES IN THE SCREEN AND LOCKS AND WON'T LET YOU TURN THE STEERING WHEEL.AT THIS POINT YOU HAVE NO CONTROL OF THE STEERING WHEEL, IT LOCKS AND BOUNCES BACK AT YOU AND IF YOU KEEP TRYING TO TURN IT, THE ENGINE CUTS OFF ALL POWER AND IT STALLS, JUST DIES. I ALMOST GOT READ ENDED A COUPLE OF TIMES ALREADY DUE TO THIS PROBLEM. JUST THIS MORNING I WAS MAKING A RIGHT ONTO A LOCAL MCDONALD'S AND THE STEERING WHEEL LOCKED AND THE ENGINE DIED ON ME. I HAD TO QUICKLY TURN IT ON AGAIN AND KEEP GOING.ANOTHER TIME IT HAPPEN AS I WAS MERGING INTO TRAFFIC. VERY SCARY! PROBLEM NUMBER TWO, I THINK ITS JUST A MATTER OF TIME BEFORE THE STEERING WHEEL LOCKS ON ME ON HIGH SPEEDS. SOMETIMES WHEN I'M ON THE FREEWAY, THE SAME CHIMES COME ON WHEN I STEP ON THE BRAKES, THE CENTER SCREENS GOES BLACK, AND THE SAME 'STABILITRAC' WARNING COMES ON THE SMALLER SCREEN BEHIND THE STEERING WHEEL. I'M AFRAID TO TAKE IT ON A WINDING ROAD FOR FEAR THAT THE STEERING WHEEL WILL LOCK ON ME CAUSE AN ACCIDENT. 3- SERVICE BRAKE CONTROLLER SIGN AND CHIMES COME ON ANT WON'T GO AWAY. IT JUS KEEPS ON POPPING ON AND ON AND ON AND THEY GO AWAY WHEN YOU TURN OFF THE TRUCK, AND COME ON AGAIN MONTHS OR WEEKS LATER. I DID HAVE IT CHECKED AT MY LOCAL DEALERSHIP.THEY TESTED IT, SOLD ME NEW GROUND AND HOT WIRES. IT WAS GOOD FOR ABOUT 4 WEEKS BEFORE THE SAME PROBLEMS CAME BACK AGAIN. I DID SOME RESEARCH ON SOME OF THE FORUMS AND YOU TUBE VIDEOS AND BY FAR I'M THE ONLY ONE WITH THE SAME PROBLEM. VERY AFRAID TO CAUSE AN ACCIDENT.
NHTSA ODI #11118538
60,000 miles · Mar 20, 2018
Electrical SystemUnknown Or OtherFire
VEHICLE HAD A FIRE STARTING IN THE DASHBOARD AREA BEHIND INSTRUMENT CLUSTER I THINK. IT TOOK LESS THAN 15 MINUTES FROM THE SMELL OF AND ISSUE TO FLAMES VISIBLE. I NOTICED THE GAUGES BECOMING ERRATIC THAN THE CHECK ENGINE LIGHT CAME ON WITH WHAT FELT LIKE THE 4 WHEEL DRIVE KICKING IN AND OUT FOLLOWED BY THE MOTOR RUNNING POORLY…
Read full complaint
VEHICLE HAD A FIRE STARTING IN THE DASHBOARD AREA BEHIND INSTRUMENT CLUSTER I THINK. IT TOOK LESS THAN 15 MINUTES FROM THE SMELL OF AND ISSUE TO FLAMES VISIBLE. I NOTICED THE GAUGES BECOMING ERRATIC THAN THE CHECK ENGINE LIGHT CAME ON WITH WHAT FELT LIKE THE 4 WHEEL DRIVE KICKING IN AND OUT FOLLOWED BY THE MOTOR RUNNING POORLY. I PULLED OVER, TURNED THE VEHICLE OFF AS THE SMOKE STARTED. THAN DIALED 911.. TROOPER WAS THERE IN 6 MINUTES WITH FIRE DEPARTMENT SHORTLY AFTER. I WAS ON A HIGHWAY TRAVELING ABOUT 70 MPH. THERE WERE QUITE A FEW POTHOLES AS THIS WAS WINTER TIME. LIGHTS WERE ON, CRUISE WAS ON, HEATED SEATS AND STEERING WHEEL WERE ON, RADIO WAS ON, PHONE AND LAPTOP WERE CHARGING ( LAPTOP UTILIZING 110 OUTLET IN TRUCK).
NHTSA ODI #11080329
Mileage unknown · Dec 25, 2017
Electrical System
HEADLIGHT ON THE 2015 GMC SIERRA 1500 SLT ARE TERRIBLE. THEY ARE THE WORST OF ANY VEHICLE I'VE DRIVEN. THE PROBLEM STEMS FROM THE POORLY DESIGNED REFLECTOR FOR THE HALOGEN BULB.
NHTSA ODI #11056339
60,000 miles · Dec 7, 2017
Electrical System
MY VEHICLE IS EQUIPPED WITH A DRIVER ALERT SYSTEM WHICH NOTIFY THE DRIVER IF THE VEHICLE STRAYS OUT OF ITS LANE OR IF IT APPROACHED STOPPED TRAFFIC. THIS SYSTEM ALERTS THE DRIVER BY EITHER PLAYING AN AUDIBLE TONE OR BY VIBRATING THE SEAT. THE VIBRATION MOTORS IN THE SEAT OF MY VEHICLE HAVE BROKEN THREE TIMES DUE TO A PINCHED WIR…
Read full complaint
MY VEHICLE IS EQUIPPED WITH A DRIVER ALERT SYSTEM WHICH NOTIFY THE DRIVER IF THE VEHICLE STRAYS OUT OF ITS LANE OR IF IT APPROACHED STOPPED TRAFFIC. THIS SYSTEM ALERTS THE DRIVER BY EITHER PLAYING AN AUDIBLE TONE OR BY VIBRATING THE SEAT. THE VIBRATION MOTORS IN THE SEAT OF MY VEHICLE HAVE BROKEN THREE TIMES DUE TO A PINCHED WIRE DUE TO GM'S POOR DESIGN. WHEN THE MOTOR BREAKS, A ERROR IS DISPLAYED SAYING TO SERVICE THE DRIVER ALERT SYSTEM. THIS OCCURRED WHEN THE VEHICLE WAS PARKED AND WHEN IT WAS MOVING.
NHTSA ODI #11052959
10,881 miles · Aug 7, 2017
Electrical SystemUnknown Or Other
MARCH 2017, AT 10,881 MILES I ACCELERATED TO PASS A CAR, LOST POWER, LIKE IT SUDDENLY WENT INTO NEUTRAL. I TRIED SEVERAL GEARS, MULTIPLE TIMES, BEFORE BEING ABLE TO FINALLY GET THE MANUAL GEAR TO GET ME HOME.LOCAL DEALERSHIP CLEANED UP THE TRANSMISSION OF BROKEN METAL PARTS. 2,500 MILES LATER, I TRIED TO ACCELERATE AFTER TURN…
Read full complaint
MARCH 2017, AT 10,881 MILES I ACCELERATED TO PASS A CAR, LOST POWER, LIKE IT SUDDENLY WENT INTO NEUTRAL. I TRIED SEVERAL GEARS, MULTIPLE TIMES, BEFORE BEING ABLE TO FINALLY GET THE MANUAL GEAR TO GET ME HOME.LOCAL DEALERSHIP CLEANED UP THE TRANSMISSION OF BROKEN METAL PARTS. 2,500 MILES LATER, I TRIED TO ACCELERATE AFTER TURNING INTO A LONG DRIVEWAY, AGAIN NO POWER. I TRIED SEVERAL GEARS AS BEFORE AND THE MANUAL GEAR GOT ME TO THE HOUSE.THE ENGINE WAS WORKING AND RPMS REVVED, AND JUST LIKE BEFORE, FELT LIKE IT WAS IN NEUTRAL. DEALERSHIP WENT ABOVE AND BEYOND TO TRY TO DUPLICATE THE PROBLEM. THEY EVEN CHECKED MY TRUCK FOR THE GM RECALL #14192, NHTSA CAMPAIGN ID # 14V374000, BECAUSE IT WAS HAVING THE SAME ISSUES. I THINK THAT THE BROKEN PARTS FOUND THE FIRST TIME WAS AN INCIDENTAL FINDING DUE TO THE FACT THAT THE PROBLEM HAS HAPPENED TWICE. DURING ALL THIS THERE HAS BEEN SMALL ELECTRICAL ISSUES IE: WEAK SOUNDING BUZZERS WHEN I OPEN THE DOOR, INTERNAL LIGHTS EITHER STAYING ON OR NOT COMING ON AT ALL, AND INTERMITTENT ISSUES WITH REMOTE START. MY HUSBAND BOUGHT THIS TRUCK BRAND NEW IN MARCH 2016, 6 WEEKS BEFORE HE DIED, SO THIS TRUCK HAS A LOT OF SENTIMENT, HOWEVER, I AM VERY CONCERNED THAT THIS TRUCK IS UNSAFE. THE FEAR OF BEING T-BONED IN AN INTERSECTION, OR SUDDENLY LOSING POWER IN 70MPH TRAFFIC IS TERRIFYING! I AM MOVING FROM SC TO WYOMING IN 6 WEEKS AND AM SCARED TO DEATH I AM GOING TO HAVE PROBLEMS. I HAVE REPORTED THIS TO THE GM COMPLAINT DEPT. SERVICE CASE # 83120854028. THE ONLY PAPERWORK I HAVE ARE THE SERVICE RECORDS FROM THE LOCAL GM DEALERSHIP.
NHTSA ODI #11013360
5,000 miles · Aug 3, 2017
Electrical SystemExterior Lighting
AS WELL AS HAVING VERY POOR VISABILITY, THE HAEDLIGHT BULBS ON MY TRUCK HAVE BLOWN OUT 5 TIMES IN ONLY TWO YEARS. THERE IS OBVIUOSLY SOMETHING WRONG WITH SOMETHING BESIDES THE BULBS.I AM GOING BROKE REPLACING THEM. I CALLED THE DEALER AND WAS TOLD THAT IT WOULD COST ME 115.00 AN HOUR JUST TO LOOK AT THE TRUCK. I WOULD RATHER GIV…
Read full complaint
AS WELL AS HAVING VERY POOR VISABILITY, THE HAEDLIGHT BULBS ON MY TRUCK HAVE BLOWN OUT 5 TIMES IN ONLY TWO YEARS. THERE IS OBVIUOSLY SOMETHING WRONG WITH SOMETHING BESIDES THE BULBS.I AM GOING BROKE REPLACING THEM. I CALLED THE DEALER AND WAS TOLD THAT IT WOULD COST ME 115.00 AN HOUR JUST TO LOOK AT THE TRUCK. I WOULD RATHER GIVE THE TRUCK BACK, THAN PAY TO HAVE A PROBLAM THAT IS OBVIOUSLY A MANUFACTURING DEFECT, FIXED. THE LIGHTS HAVE WENT OUT BOTH WHILE MOVING, AND STATIONARY.
NHTSA ODI #11012657
38,000 miles · Jun 6, 2017
Electrical SystemUnknown Or OtherFire
I WAS RIDING ON THE FREEWAY AND SOMEONE FLAGGED ME DOWN AND SAID YOU CAR IS ON FIRE. THE FIRE WAS BETWEEN THE CAB AND THE BED OF THE TRUCK ON 3/22/2017. ON 4/11/2017 IS BEGAN TO SMELL OF SMOKE WHENEVER I CRANK. THE SMELL IS COMING THROUGH THE VENTS. ALSO THE VEHICLE WILL NOT PASS INSPECTION BECAUSE OF THE EMISSIONS FOR THE …
Read full complaint
I WAS RIDING ON THE FREEWAY AND SOMEONE FLAGGED ME DOWN AND SAID YOU CAR IS ON FIRE. THE FIRE WAS BETWEEN THE CAB AND THE BED OF THE TRUCK ON 3/22/2017. ON 4/11/2017 IS BEGAN TO SMELL OF SMOKE WHENEVER I CRANK. THE SMELL IS COMING THROUGH THE VENTS. ALSO THE VEHICLE WILL NOT PASS INSPECTION BECAUSE OF THE EMISSIONS FOR THE PAST 4 MONTHS. I AM PAYING A NOTE ON THIS VEHICLE MONTHLY AND AM NOT ABLE TO USE IT. I CAN'T GET IT INSPECTED AND THE REGISTRATION IS OUT THEREFORE I CANNOT DRIVE IT.
NHTSA ODI #10993453
36,579 miles · May 29, 2017
Electrical SystemElectronic Stability Control (esc)Steering
HAS HAD AN ISSUE WITH ACCESSORIES FLASHING OFF AND BACK ON. REPORTED IT TO A GMC DEALER AND THEY WERE UNABLE TO DUPLICATE BUT SAID THAT THE BATTERY WAS BAD AND MOST LIKELY WHAT WAS CAUSING IT. IT DID FINE FOR A WHILE THEN BEGAN DOING IT AGAIN. THIS TIME HOWEVER IT CAUSED A LOSS IN POWER STEERING AND I ENDED UP IN THE DITCH. …
Read full complaint
HAS HAD AN ISSUE WITH ACCESSORIES FLASHING OFF AND BACK ON. REPORTED IT TO A GMC DEALER AND THEY WERE UNABLE TO DUPLICATE BUT SAID THAT THE BATTERY WAS BAD AND MOST LIKELY WHAT WAS CAUSING IT. IT DID FINE FOR A WHILE THEN BEGAN DOING IT AGAIN. THIS TIME HOWEVER IT CAUSED A LOSS IN POWER STEERING AND I ENDED UP IN THE DITCH. LATER IT DID IT IN A PARKING LOT AND WAS ABLE TO VIDEO TAPE IT. TOOK IT TO THE DEALER AND SHOWED THEM THE VIDEO. THEY WERE UNABLE TO DUPLICATE FOR 4 DAYS WHILE I WAS PAYING FOR A RENTAL BECAUSE MINE WASN'T SAFE TO DRIVE. ON THE FOURTH DAY I PROVIDED THEM WITH A SERVICE BULLETIN I FOUND THAT ADDRESSED THE ISSUE AS BEING A FLUCTUATION IN POWER AND FOR THEM TO CHECK THE CABLES AND DO A DROP LOAD TEST. THEY DID AND IT FAILED. I THEN HAD TO PAY 376.00 TO REPLACE THEM PLUS HAVING TO PAY FOR A RENTAL AFTER ASKING FOR A LOANER. THIS IS A PROBLEM A LOT OF PEOPLE ARE HAVING. JUST A QUICK GOOGLE SEARCH MAKES THAT PLAIN. GM ISN'T WANTING TO ADMIT IT. I HAVE THE VIDEO BUT I DON'T THINK IT WILL ALLOW ME TO UPLOAD IT TO THE FORM.
NHTSA ODI #10992047
Mileage unknown · Jan 24, 2017
Electrical SystemPower Train
I PURCHASED MY FIRST NEW VEHICLE IN OCT OF 2015. I'VE OWNED 4 VEHICLES SINCE I'VE HAD MY LICENSE, 2 DODGES AND 2 BMWS. I CHOSE A TRUCK I'VE DREAMED OF HAVING SINCE I WAS 16. I'M CURRENTLY 28. I CHOSE THE SIERRA DENALI. NOT ONLY WAS THIS MY FIRST NEW VEHICLE BUT THIS WAS MY FIRST TRUCK AND MY FIRST GM PRODUCT OF MY LIFE. NOW I'M …
Read full complaint
I PURCHASED MY FIRST NEW VEHICLE IN OCT OF 2015. I'VE OWNED 4 VEHICLES SINCE I'VE HAD MY LICENSE, 2 DODGES AND 2 BMWS. I CHOSE A TRUCK I'VE DREAMED OF HAVING SINCE I WAS 16. I'M CURRENTLY 28. I CHOSE THE SIERRA DENALI. NOT ONLY WAS THIS MY FIRST NEW VEHICLE BUT THIS WAS MY FIRST TRUCK AND MY FIRST GM PRODUCT OF MY LIFE. NOW I'M TEETERING ON IT BEING MY LAST. THROUGH THE 14 MONTHS I'VE OWNED THE VEHICLE (SINCE 4 MILES) I'VE HAD NUMEROUS ISSUES. MY FRONT DIFFERENTIAL HAS BEEN REBUILT NOT ONCE BUT TWICE. MY TRUCK HAS 45K ON IT. IT HAS NEVER TOWED HAULED OR OTHER WISE PERFORMED A TASK REQUIRING IT'S POWER OTHER THAN NORMAL DRIVING. IT HAS BEEN BABIED. CLEANED WASHED OIL CHANGED TIRES ROTATED AND 93 OCTANE FILL UPS. AMONGST OTHER ISSUES WERE THE INFOTAINMENT CENTER FREEZING. CVS AXLE SHAFTS PERFORMING ERRATIC ALONG WITH BUCKING SLAMMING AND NOISES THROUGH THE POWER TRAIN. A RANDOM LEAK IN THE LOWER OIL PAN THAT THE DEALER SAID WAS A MANUFACTURER DEFECT THEY WERE AWARE OF. A AIRBAG SOFTWARE SAFETY RECALL AND A SHIFTING DRIVER SEAT THAT TENDS TO MOVE A BIT DURING CORNERING. NOW TO TOP ALL OF THOSE ISSUES OFF IN THOSE 14 MONTHS I NOW HAVE A LEAK THE EXTENDS OUT FROM THE EDGE ABOUT 5 INCHES FROM THE REAR WINDSHIELD ALL THE WAY FROM THE DRIVER SIDE TO PASSENGER SIDE. I'M NOT IN BUMPER TO BUMPER WARRANTY. I WAS TOLD 100 DOLLARS AND IT WILL BE FIXED. IT SHOULDN'T HAVE TO BE FIXED. NONE OF IT SHOULD HAVE. I HAVE HAD LESS ISSUES IN ALL 4 OF MY LAST VEHICLES PUT TOGETHER THAN THIS 1 VEHICLE I HAVE OWNED FOR 14 MONTHS AND I BOUGHT IT NEW. THIS HAS BEEN A BIG LET DOWN. A DISAPPOINTMENT 12 YEARS IN THE MAKING APPARENTLY. ONE THAT HAS MORE THAN RUINED MY DAY. I HONESTLY DON'T WANT THIS TRUCK. IT'S SCARRED FOR LIFE. THAT'S OBVIOUS AND NOT REVERSIBLE. BUT NOW I'M UNDER WATER ON A LOAN FOR A TRUCK THAT'S NOT WORTH ITS WEIGHT IN SCRAP METAL. THAT'S NEITHER RIGHT NOR FAIR. *TR
NHTSA ODI #10947284
39,000 miles · Dec 21, 2016
Electrical SystemSteering
ON TUESDAY, DECEMBER 20TH 2016 AT APPROXIMATELY 7:15PM WHILE DRIVING SOUTH ON NEW RIVER ROAD IN LINCOLN RI I TRIED TO MAKE A LEFT TURN ONTO A SIDE STREET. WHEN I TURNED THE STEERING WHEEL LEFT IT WAS SNATCHED OUT OF MY HANDS AND THE STEERING WHEEL AUTOMATICALLY TURNED BACK TO CENTER IT SELF. I COULD NOT MANEUVER THE VEHICLE AS I…
Read full complaint
ON TUESDAY, DECEMBER 20TH 2016 AT APPROXIMATELY 7:15PM WHILE DRIVING SOUTH ON NEW RIVER ROAD IN LINCOLN RI I TRIED TO MAKE A LEFT TURN ONTO A SIDE STREET. WHEN I TURNED THE STEERING WHEEL LEFT IT WAS SNATCHED OUT OF MY HANDS AND THE STEERING WHEEL AUTOMATICALLY TURNED BACK TO CENTER IT SELF. I COULD NOT MANEUVER THE VEHICLE AS IT ROLLED UP ONTO THE SIDEWALK WHERE I HAD TO USE THE EMERGENCY BRAKE TO FORCE THE VEHICLE FROM ROLLING INTO A TREE. THE VEHICLE DIC DISPLAYED "PARK ASSIST" AND AFTERWARDS THE VEHICLE WENT COMPLETELY DEAD...NO LIGHTS OR SOUNDS WHEN I TRIED TURNING THE KEY TO RESTART IT. LIFTED UP THE HOOD AND ALL THE ELECTRONICS CAME BACK ON AND VEHICLE STARTED. DIC PROMPT DISPLAYED "OPEN AND THEN CLOSE THE DRIVER SIDE WINDOW" HAD VEHICLE TAKEN TO DEALER FOR SERVICE. *TR
NHTSA ODI #10936662
Official recalls
9Jul 1, 2021
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
Nov 25, 2020
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
Consequence & remedy
Consequence: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
Remedy: GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. Note: GM filed a new recall, number 21V-504 that supersedes this recall. All vehicles previously recalled under 20V-736 will now be repaired under the new recall number 21V-504. GM's numbers for this recall are N202309680, N202309681, and N202309682.
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Sep 7, 2018
General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.
Consequence & remedy
Consequence: If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Apr 12, 2016
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado 1500 and GMC Sierra 1500 trucks manufactured January 29, 2013, to January 21, 2015. While entering the vehicle, the seat belt tensioner cable may be positioned such that the driver slides over it. This movement may result in the fatigue and separation of the cable.
Consequence & remedy
Consequence: If the tensioner cable separates, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will modify the vehicles to prevent the tensioner from being damaged. Any tensioner that has already been damaged will be replaced, free of charge. The recall began on August 11, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 15822.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration