PURCHASED BOOSTER SEATS FOR OUR GRANDCHILDREN. A CERTIFIED INSPECTOR SHOWED US THAT ALL FOUR REAR SEAT BELTS DO NOT LOCK WHEN PULLED QUICKLY INDICATING THAT THE SEATBELTS WOULD NOT RESTRAIN THE CHILD IN AN ACCIDENT (OR AN ADULT EITHER). TOOK THE VEHICLE BACK TO THE DEALER. DEALER CLAIMS THE SEATBELTS LOCK WHEN YOU BRAKE HARD,…
Read full complaint
PURCHASED BOOSTER SEATS FOR OUR GRANDCHILDREN. A CERTIFIED INSPECTOR SHOWED US THAT ALL FOUR REAR SEAT BELTS DO NOT LOCK WHEN PULLED QUICKLY INDICATING THAT THE SEATBELTS WOULD NOT RESTRAIN THE CHILD IN AN ACCIDENT (OR AN ADULT EITHER). TOOK THE VEHICLE BACK TO THE DEALER. DEALER CLAIMS THE SEATBELTS LOCK WHEN YOU BRAKE HARD, BUT ARE NOT MADE FOR CHILDREN'S BOOSTER SEATS. WE ARE UNDER THE IMPRESSION THAT VEHICLES MADE AFTER 2001 HAD TO HAVE THE APPROPRIATE SEATBELTS FOR CHILD SAFETY. *JB
CERTAIN MINIVANS HAVE AN INTERFERENCE CONDITION BETWEEN THE LOWER BALL JOINT RUBBER BOOT AND THE STEERING KNUCKLE (BOTH LEFT/RIGHT SIDES), WHICH COULD RESULT IN CUTTING OF THE BOOT THAT IS INTENDED TO SEAL THE BALL JOINT. IF THE LOWER BALL JOINT BOOT WERE CUT, CONTAMINATION FROM THE ROAD (SALT, DIRT, WATER, ETC.) COULD ENTER THE BALL SOCKET AREA OF THE BALL JOINT CAUSING THE JOINT TO WEAR OUT TOO QUICKLY.
Consequence & remedy
Consequence: THE STEERING KNUCKLE COULD SEPARATE FROM THE LOWER CONTROL ARM, DROPPING DOWN THE AFFECTED CORNER OF THE VEHICLE. THE COIL SPRING WOULD PUSH THE CONTROL ARM DOWN INTO CONTACT WITH THE GROUND, CREATING A DRAG THAT WOULD SLOW THE VEHICLE. THE DRIVER COULD HAVE DIFFICULTY IN MAINTAINING THE DIRECTIONAL CONTROL OF THE VEHICLE. IN ADDITION, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE IF FORCES RESULTING FROM THE WHEEL'S DRAGGING ACTION WERE SUFFICIENT TO FRACTURE THE TIE ROD END AND UPPER BALL JOINT CONNECTIONS. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL'S HYDRAULIC BRAKE HOSE, RESULTING IN LOST BRAKING PERFORMANCE FROM THE FRONT BRAKE SYSTEM. VEHICLE STOPPING DISTANCE WOULD INCREASE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING KNUCKLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 8, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 GMC Safari Problems, Complaints & Recalls | Skip That Year
Illustration