IllustrationWHILE DRIVING DOWN THE HIGHWAY THE SPARE TIRE FELL OFF DUE TO THE CABLE RUSTING OUT.*AK
1991 GMC Safari
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 GMC Safari do not stand out strongly from the model-year median of 30.
About this comparison →How this year compares
Owner complaints by model year
Compare all Safari years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 39 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports2 injury reports
What owners actually said
39 reportsWHILE MOVING THE DRIVER'S SEATBACK SNAPPED/RECLINED TO A FULLY RECLINED POSITION DUE TO A SUPPORT BOLT SHEARING OFF. *AK
TIE ROD END BROKE, CAUSED LOSS OF STEERING CONTROL, SPEED 20 MPH.*AK
POOR CONNECTION OF HEATER SWITCH CAUSED SWITCH TO OVERHEAT/START FIRE. *DH
ON DRY ROAD WHEN APPLIED THE BRAKE SOMTIMES BRAKE DOESN'T HOLD, HAVE ABS ANTI-LOCK BRAKES. PLEASE DESCRIBE . *AK
REAR AXLE SEAL GOES OUT CAUSING FLUID TO LEAK ONTO REAR BRAKE PADS; REPAIRED APPROXIMATELY EVERY 6 MONTHS; BRAKES NOT CONSISTENT; EXCESSIVE EFFORT. TT
CRUISE CONTROL RECALL REPAIRS REFUSED DUE TO MANUFACTURER'S CLAIM THAT RECALL LETTERS WERE SENT OUT IN ERROR AND THERE WAS NO DEFECT (94V-099). *AK
ABS ANTI-LOCK BRAKE WARNING LIGHT KEEP COME ON . TT
BRAKE SYSTEM REPLACED.
Official recalls
393V187000 · Seats
Nov 16, 1993
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
93V119000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Aug 2, 1993
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
91V164000 · Seat Belts:front:anchorage
Sep 20, 1991
SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210.
Consequence & remedy
Consequence: VEHICLES WOULD NOT COMPLY WITH FMVSS 210.
Remedy: REPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE97025 · Instrument Panel/dash Electrical Fire
Opened Jun 12, 1997 · Closed Nov 26, 1997
Status: closed (inferred from source dates) · Electrical System
ALLEGED ELECTRICAL FIRES MAY OCCUR IN THE DASH AREA WHILE THE SUBJECT VEHICLES ARE BEING OPERATED OR WHILE PARKED.
EA92022 · Seat Back Bolt Breakage
Opened Jun 24, 1992 · Closed Nov 19, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
EA91028 · Brake Failure
Opened Jun 10, 1991 · Closed Jun 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
PE91052 · Brake Failure
Opened Feb 22, 1991 · Closed Jun 10, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available