IllustrationINTERMITTENTLY IT WOULD BE HARD TO START THE VEHICLE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
2000 GMC Jimmy
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jimmy years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
2325–50K
2450–75K
2275–100K
16100–150K
4150K+
94 reports with mileage · 117 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports4 fire reports7 injury reports
What owners actually said
211 reportsON WEDNESDAY JUNE 23, 2004, I WENT TO RED HOLMAN PONTIAC TO REPLACE A HUB AND BEARING ASSEMBLY ON THE FRONT LEFT WHEEL OF MY GMC JIMMY 2000. A GRINDING AND METALLIC NOISE WAS COMING FROM THE FRONT OF THE VEHICLE AND I HAD TO HAVE DONE AT THE DEALER. TWO YEARS AGO, THIS SAME HUB AND BEARING ASSEMBLY WAS REPLACED AT 48000 MILES. N…
Read full complaint
ON WEDNESDAY JUNE 23, 2004, I WENT TO RED HOLMAN PONTIAC TO REPLACE A HUB AND BEARING ASSEMBLY ON THE FRONT LEFT WHEEL OF MY GMC JIMMY 2000. A GRINDING AND METALLIC NOISE WAS COMING FROM THE FRONT OF THE VEHICLE AND I HAD TO HAVE DONE AT THE DEALER. TWO YEARS AGO, THIS SAME HUB AND BEARING ASSEMBLY WAS REPLACED AT 48000 MILES. NOW, THIS VEHICLE HAS 75000 MILES AND I HAVE TO REPLACE THE RIGHT HUB AND BEARING ASSEMBLY. THIS MEANS THAT THIS PART ONLY LASTED 48000 MILES AND THE REPLACEMENT PART LESS THAN 27000 MILES. ON BOTH INSTANCES, THERE WAS ALSO A FAILURE OF THE ABS BRAKE SYSTEM. I HAVE OWNED OVER THE YEARS MORE THAN 11 GM CARS WITH VARIOUS MILEAGES AT TRADING TIME AND I NEVER HAD TO REPLACE A BEARING. WHEN THE FIRST REPLACEMENT ASSEMBLY WAS PUT IN, THE DEALER TOLD ME THAT IT WAS A HAZARD AND FOR THE OTHER WHEEL, THE DEALER ACKNOWLEDGED THE FACT THAT IT IS A SAFETY HAZARD ON MY INVOICE IF THESE PARTS POSE A THREAT TO THE SAFETY OF GMC OWNERS, WHY IS GMC INSTALLING PARTS WITH MATERIAL DEFECTS? I WAS ALSO INFORMED THAT THE REPLACEMENT PART CARRIES ONLY A 12000 MILES WARRANTY AND THE PRICE IS ABOUT $460 AND LABOR $124.00. LUCKILY, THE FIRST REPAIR WAS UNDER WARRANTY, BUT THIS TIME I HAD TO NEGOTIATE WITH THE DEALER AND I HAD TO PAY $284.00. I BELIEVE THAT THESE PARTS SHOULD LAST LONGER SINCE THERE IS NEITHER MAINTENANCE NOR ANY FACILITY TO DISASSEMBLE THE UNIT. I SEE NO FAULT WITH THE DEALER; RATHER I SEE A MANUFACTURER DEFECTIVE PRODUCT. THIS REPAIR SHOULD HAVE BEEN THE GMC RESPONSIBILITY DUE TO THE SHORT LIFE SPAN OF THIS PRODUCT.*AK SINCERELY, CLAUDE DURAND
WHILE DRIVING 60 MPH FRONT END VIBRATED VIOLENTLY. DEALER STATED THE UPPER AND LOWER BALL JOINTS FAILED. *AK
UPON HEARING THE WEAR INDICATOR ON FRONT BRAKES OF MY 2000 GMC JIMMY WITH 24000+ MILES ON IT, I TOOK IT IN FOR REPAIR EXPECTING ONLY PAD REPLACEMENT AND MAYBE MACHINING OF THE ROTORS. AS IT TURNED OUT, ALL 4 ROTORS NEEDED REPLACEMENT DUE TO LARGE AREAS OF DEEP CORROSION THAT, ACCORDING TO THE REPAIR SHOP, WAS SEVERE ENOUGH TO …
Read full complaint
UPON HEARING THE WEAR INDICATOR ON FRONT BRAKES OF MY 2000 GMC JIMMY WITH 24000+ MILES ON IT, I TOOK IT IN FOR REPAIR EXPECTING ONLY PAD REPLACEMENT AND MAYBE MACHINING OF THE ROTORS. AS IT TURNED OUT, ALL 4 ROTORS NEEDED REPLACEMENT DUE TO LARGE AREAS OF DEEP CORROSION THAT, ACCORDING TO THE REPAIR SHOP, WAS SEVERE ENOUGH TO AFFECT BRAKING, AND THUS, PAD WEAR, LEADING TO PREMATURE FAILURE OF THESE CRITICAL COMPONENTS. AN ATTEMPT WAS MADE TO MACHINE ONE ROTOR TO GET PAST THE CORROSION, BUT THE CORROSION WAS TOO DEEP AND WOULD LEAVE THE ROTOR TOO THIN. THE REPAIR SHOP IS BEGINNING TO SEE THIS PROBLEM ON LATE MODEL GM VEHICLES, AND AS SUCH, PROVIDED ME WITH ALL THE PARTS THAT WERE REPLACED (4 ROTORS AND ALL PADS) AS WELL AS AN ITEMIZED LIST OF NEW PARTS USED IN ANTICIPATION OF SOME SORT OF FOLLOW-UP ACTION FROM GM OR THE GOVERNMENT.*AK
LOUD HUMMING SOUNDS, AND FRONT WHEELS LOCK UP WHEN BRAKES APPLIED. BOTH LEFT AND RIGHT SIDE HUB BEARINGS FAILED. BOTH HUB BEARING KITS WERE REPLACED BY THE DEALER AT A COST OF ALMOST $1100.00. THIS VEHICLE HAD JUST TURNED 70,000 MILES AND HAS NEVER BEEN OFF ROADING. *JB
WHILE DRIVING AT 45 MPH, THE CHECK ENGINE LIGHT CAME ON. THE DEALER EXAMINED THE VEHICLE AND CLAIMED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE CONSUMER WAS DRIVING AT THE SAME SPEED AND ALL OF THE LIGHTS ILLUMINATED ON THE DASH. THE CONSUMER PULLED ONTO THE SHOULDER AND THE VEHICLE WAS SMOLDERING UNDER THE HOOD. *JB …
Read full complaint
WHILE DRIVING AT 45 MPH, THE CHECK ENGINE LIGHT CAME ON. THE DEALER EXAMINED THE VEHICLE AND CLAIMED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE CONSUMER WAS DRIVING AT THE SAME SPEED AND ALL OF THE LIGHTS ILLUMINATED ON THE DASH. THE CONSUMER PULLED ONTO THE SHOULDER AND THE VEHICLE WAS SMOLDERING UNDER THE HOOD. *JB *NM
ENGINE NOISE: THIS 2000 JIMMY WITH THE 4.3 VORTEC IS QUITE NOISY. WHEN STARTING COLD ,ABOUT 20 SECONDS LATER A LIFTER WILL START TO RAP, THEN WILL GO AWAY AND THEN BACK. AFTER COMING OFF THE HIGHWAY, SEVERAL LIFTERS WILL GET LOUD. NOW, I HAVE HEARD 4 1998-2000 4.3 IN BLAZERS AND JIMMYS DO THIS. THEN DALERSHIPS SAY THIS IS NORMA…
Read full complaint
ENGINE NOISE: THIS 2000 JIMMY WITH THE 4.3 VORTEC IS QUITE NOISY. WHEN STARTING COLD ,ABOUT 20 SECONDS LATER A LIFTER WILL START TO RAP, THEN WILL GO AWAY AND THEN BACK. AFTER COMING OFF THE HIGHWAY, SEVERAL LIFTERS WILL GET LOUD. NOW, I HAVE HEARD 4 1998-2000 4.3 IN BLAZERS AND JIMMYS DO THIS. THEN DALERSHIPS SAY THIS IS NORMAL...TECHNICIANS SAY THERE IS A VALVE TRAIN ISSUE. THIS IS NOT NORMAL NOISE..INA DDITION, WHEN LOADING THE VEHICLE, LIKE GOING UP A STEEP HILL, ONE OR TWO LIFTERS SOUND LIKE THEY ARE READY TO LET LOOSE.....CAUSE OF PROBLEM? *AK
MY FUEL GAUGE IS MALFUNCTIONING. IT FLOATS BACK AND FOURTH FROM FULL TO EMPTY. HOW SAFE CAN THIS BE? ALSO I HAVE HAD PROBLEMS WITH WINDOWS NOT ROLLING UP AND DOWN AND MY BACK GLASS WILL NOT OPEN FROM THE REAR OUTSIDE BUTTON. *AK
MANY PROBLEMS WITH THIS 2000 JIMMY. BOUGHT IT USED FROM CARMAX AT 18K MILES ON JAN 2003, GOT EXT. WARRANTY, BUT SOON AFTER, FRONT BRAKES NEED TO BE REPLACED, REPLACED BY CARMAX FOR FREE, BUT 6 MOS LATER BRAKES NEEDED REPLACED. WAS ADVISED THAT REAR ROTORS AND BRAKES WERE ALMOST AT END OF LIFE. 9 MOS LATER, REPLACED REAR BRAKE…
Read full complaint
MANY PROBLEMS WITH THIS 2000 JIMMY. BOUGHT IT USED FROM CARMAX AT 18K MILES ON JAN 2003, GOT EXT. WARRANTY, BUT SOON AFTER, FRONT BRAKES NEED TO BE REPLACED, REPLACED BY CARMAX FOR FREE, BUT 6 MOS LATER BRAKES NEEDED REPLACED. WAS ADVISED THAT REAR ROTORS AND BRAKES WERE ALMOST AT END OF LIFE. 9 MOS LATER, REPLACED REAR BRAKES AND ROTORS, NOT COVERED UNDER WARRANTY DUE TO WEAR AND TEAR, SPENT $450 AS WELL AS REPLACING SERPENTINE BELT AND FLUSHING BREAK FLUID, TOTAL COST $650. PROBLEMS WITH SUNROOF STARTED IN APR 2003, IT FINALLY STOPPED WORKING AND WAS REPLACED AT 43K MILES UNDER EXT WARRANTY, HAD TO GET NEW BATTERY, NOISE IN UNDER CARRIAGE ON DRIVERS SIDE, DETERMINED TO BE PROBLEMS WITH HUB BEARINGS AND IDLE ARM, INNER TIE ROD, ALL REPLACED UNDER EXT WARRANTY, TOTAL COST WOULD HAVE BEEN $750. *NM
TOOK CAR IN FOR INSPECTION WAS TOLD LOWER BALL JOINT WAS WORN AND NEEDED TO BE REPLACED BY GM DEALER CAR ONLY HAS 23,330 MILES ON IT AND WAS PURCHASED 9/03. DID NOTICE WHEN DRIVING THE CAR WOULD MAKE A LOUD "POPPING" NOISE WHEN IT WAS TURNING IN EITHER DIRECTION SINCE I PURCHASED CAR. THOUGHT EVERYTHING WAS CHEAKED OUT BY DEALER
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.