IllustrationGMC JIMMY 2000 FUEL GAUGE NOT READING THE CORRECT AMOUNT OF FUEL . THIS IS A ONGOING PROBLEM. RUNNING OUT OF GAS IS A BIG PROBLEM IF YOU DON'T TRACK MILEAGE. VERY UNSAFE AS ONE COULD BE STRANDED . *TR
2000 GMC Jimmy
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jimmy years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
2325–50K
2450–75K
2275–100K
16100–150K
4150K+
94 reports with mileage · 117 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports4 fire reports7 injury reports
Fuel System, Gasoline complaints
17 reportsTL *THE CONTACT OWNS 2000 GMC JIMMY. THE STATED THAT WHILE DRIVING, THE VEHICLE SUDDENLY SHUT OFF BECAUSE NO FUEL WAS BEING PUMPED IN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THAT THE FUEL PUMP WAS DEFECTIVE. THE CONTACT STATED THAT THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE M…
Read full complaint
TL *THE CONTACT OWNS 2000 GMC JIMMY. THE STATED THAT WHILE DRIVING, THE VEHICLE SUDDENLY SHUT OFF BECAUSE NO FUEL WAS BEING PUMPED IN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THAT THE FUEL PUMP WAS DEFECTIVE. THE CONTACT STATED THAT THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000 AND THE CURRENT MILEAGE WAS 138,000.
MY 1998 ENVOY HAD THIE SAME ISSUE (WHICH I BOUGHT NEW) AS THE USED 2000 GMC DIAMOND EDITION JIMMY I BOUGHT TO REPLACE IT AFTER I WAS T-BONED IN AUG 2009... FUEL GAUGE IS TOTALLY FAULTY AND I HAVE TO RESET THE TRIPOMETER EVERY TIME I FILL UP OR WILL RUN OUT OF GAS DUE TO FALSE READINGS. AS A SINGLE MOMMY WITH TWO KIDS I AM SC…
Read full complaint
MY 1998 ENVOY HAD THIE SAME ISSUE (WHICH I BOUGHT NEW) AS THE USED 2000 GMC DIAMOND EDITION JIMMY I BOUGHT TO REPLACE IT AFTER I WAS T-BONED IN AUG 2009... FUEL GAUGE IS TOTALLY FAULTY AND I HAVE TO RESET THE TRIPOMETER EVERY TIME I FILL UP OR WILL RUN OUT OF GAS DUE TO FALSE READINGS. AS A SINGLE MOMMY WITH TWO KIDS I AM SCARED OF THE IDEA OF GETTING STUCK ON A DARK HIGHWAY HEADED IN OR OUT OF TOWN BECAUSE OF THIS. IF THE TRIPOMETER EVER GOES I WILL BE AT A LOSS. THE KEY STICKS IN IGNITION AND I HAVE TO TURN THE VEHICLE OF AND ON SOMETIMES 30 OR 40 TIMES WHILE OTHERS ONLY TWICE OR SO... WITH HUNDREDS OF COMPLAINTS POSTED ON THE WEB... )AND THAT IS ONLY AT FIRST GLANCE) I HAVE SEEN WITH THESE KNOWN ISSUES I DO NOT KNOW WHAT TO DO. *TR
TL*THE CONTACT OWNS A 2000 GMC JIMMY. THE CONTACT STATED THAT THE SPIDER PORT INJECTOR WAS LEAKING GASOLINE BETWEEN THE FIREWALL AND THE ENGINE. THERE WAS A RECALL FOR THE PREVIOUS YEAR, MAKE, AND MODEL VEHICLE, BUT NOT FOR THE 2000 JIMMY. THE CONTACT SMELLED GASOLINE IN THE VEHICLE AND TOOK IT TO A PERSONAL MECHANIC. THE DE…
Read full complaint
TL*THE CONTACT OWNS A 2000 GMC JIMMY. THE CONTACT STATED THAT THE SPIDER PORT INJECTOR WAS LEAKING GASOLINE BETWEEN THE FIREWALL AND THE ENGINE. THERE WAS A RECALL FOR THE PREVIOUS YEAR, MAKE, AND MODEL VEHICLE, BUT NOT FOR THE 2000 JIMMY. THE CONTACT SMELLED GASOLINE IN THE VEHICLE AND TOOK IT TO A PERSONAL MECHANIC. THE DEALER STATED THAT GASOLINE LEAKAGE WAS A COMMON FAILURE. THE CONTACT FEELS THAT THIS IS VERY UNSAFE DUE TO THE FACT THAT GASOLINE LEAKING ON A HOT ENGINE MAY CAUSE A FIRE. THE FAILURE WAS NOTICED WHILE DRIVING 25 MPH. THE CURRENT MILEAGE WAS 115,000 AND FAILURE MILEAGE WAS 93,000.
I CONTINUE TO HAVE CONSTANT PROBLEMS WITH MY 2000 GMC JIMMY. FIRST THING THAT HAPPENED WAS THE GAS GAUGE JUST STARTED MESSING UP. GIVING FALSE READING. I RAN OUT OF FUEL TWO TIMES BECAUSE THE GAS GAUGE SHOWED I HAD HALF OF TANK OF GAS AND APPARENTLY IT WAS EMPTY. LEAVING ME SITTING ON THE SIDE OF THE ROAD WAY OUT IN THE COUNTRY.…
Read full complaint
I CONTINUE TO HAVE CONSTANT PROBLEMS WITH MY 2000 GMC JIMMY. FIRST THING THAT HAPPENED WAS THE GAS GAUGE JUST STARTED MESSING UP. GIVING FALSE READING. I RAN OUT OF FUEL TWO TIMES BECAUSE THE GAS GAUGE SHOWED I HAD HALF OF TANK OF GAS AND APPARENTLY IT WAS EMPTY. LEAVING ME SITTING ON THE SIDE OF THE ROAD WAY OUT IN THE COUNTRY. THE SECOND TIME THIS HAPPENED IT COST ME MY CURRENT JOB. MY EMPLOYER DID NOT BELIEVE THAT MY GAS GAGE WOULD GIVE SUCH FALSE READINGS! *TR
TL* - THE CONTACT OWNS A 2000 GMC JIMMY. THE VEHICLE VIBRATED LOUDLY WHEN BEING STARTED. THE REPAIR SHOP REPLACED THE WHEEL CYLINDER FOR A THIRD TIME. ALSO, THE FUEL SENSOR NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 87,000. *AK
THE ENTIRE CAR IS DEFECTIVE, THOUGH IT DOES NOT STATE IT IS A LEMON. I PURCHASED IT USED. I HAVE REPLACED MANY MAJOR PARTS THAT ARE NOT CONSIDERED ROUTINE MAINTENANCE, SUCH A DRIVER'S DOOR HINGES AND BEARINGS, HOOD RELEASE CABLE, STEERING ARM (TWICE) HUBS (TWICE) THE WIRING SYSTEM IS FAULTY. I HAVE GONE THROUGH 4 ALTERNATORS …
Read full complaint
THE ENTIRE CAR IS DEFECTIVE, THOUGH IT DOES NOT STATE IT IS A LEMON. I PURCHASED IT USED. I HAVE REPLACED MANY MAJOR PARTS THAT ARE NOT CONSIDERED ROUTINE MAINTENANCE, SUCH A DRIVER'S DOOR HINGES AND BEARINGS, HOOD RELEASE CABLE, STEERING ARM (TWICE) HUBS (TWICE) THE WIRING SYSTEM IS FAULTY. I HAVE GONE THROUGH 4 ALTERNATORS IN UNDER 2 1/2 YEARS. *JB
FAULTY FUEL PUMP SYSTEM. *JB
2000 GMC JIMMY HAS HAD 4 FUEL PUMPS IN LAST YEAR AND A HALF JUST STOPPING WHILE DRIVING IN TRAFFIC AND 2 TRANSMISSIONS SAME AS FUEL PUMPS STOPPING WHILE IN HEAVY TRAFFIC. WIRING HARNESS VERY BRITTLE. *NM
THE GAS GAUGE DOES NOT WORK ONCE THE AMOUNT OF GAS IS BELOW HALF A TANK. I HAVE A GMC 2000 MODEL. THERE ARE MANY COMPLAINTS ABOUT THIS ON THE INTERNET, YET NO RECALL. THE GAS NEEDLE EITHER STICKS, BOUNCES AROUND OR SHOWS A FULL TANK WHEN EMPTY. I NEVER KNOW HOW MUCH GAS I HAVE OR IF I WILL END UP STRANDED ON THE ROAD AT NIGHT. I…
Read full complaint
THE GAS GAUGE DOES NOT WORK ONCE THE AMOUNT OF GAS IS BELOW HALF A TANK. I HAVE A GMC 2000 MODEL. THERE ARE MANY COMPLAINTS ABOUT THIS ON THE INTERNET, YET NO RECALL. THE GAS NEEDLE EITHER STICKS, BOUNCES AROUND OR SHOWS A FULL TANK WHEN EMPTY. I NEVER KNOW HOW MUCH GAS I HAVE OR IF I WILL END UP STRANDED ON THE ROAD AT NIGHT. I GUESS IF SOMEONE HAS A DEADLY ACCIDENT DUE TO THEIR VEHICLE CUTTING OFF DUE TO AN EMPTY FUEL TANK WITH A GAUGE READING FULL IN HIGH SPEED TRAFFIC, SOMEONE WILL LOOK AT THIS WIDESPREAD PROBLEM THEN. I HOPE THAT I AM NOT THAT PERSON. *NM
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.