NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
25 reportsClear category filter90,000 miles · Jan 10, 2011
Engine And Engine Cooling
ENGINE SYSTEM: OIL COOLING LINES: OIL ( DRIPPING) LOSS FIRST NOTICED NOVEMBER, 2010 AT 90,000MI- DRIP BECAME PROGRESSIVELY WORSE OVER SEVERAL WEEKS CREATING POTENTIAL ENGINE DAMAGE AND FIRE DANGER. OIL COOLER LINES REPLACED FIRST WEEK JANUARY, 2011 AT 94,000 MILES. REPLACEMENT OF THE OIL COOLER LINES HAS BEEN A COMMON AND…
Read full complaint
ENGINE SYSTEM: OIL COOLING LINES: OIL ( DRIPPING) LOSS FIRST NOTICED NOVEMBER, 2010 AT 90,000MI- DRIP BECAME PROGRESSIVELY WORSE OVER SEVERAL WEEKS CREATING POTENTIAL ENGINE DAMAGE AND FIRE DANGER. OIL COOLER LINES REPLACED FIRST WEEK JANUARY, 2011 AT 94,000 MILES. REPLACEMENT OF THE OIL COOLER LINES HAS BEEN A COMMON AND RECURRENT COMPLAINT FOR THE 2000 GMC JIMMY--SEE: MYCARSTATS.COM--SINCE 2002. *TR
NHTSA ODI #10375391
62,948 miles · Jan 22, 2009
Engine And Engine Cooling
NOTICED A UNUSUAL ODOR COMING FROM THE ENGINE AREA IN LATE DECEMBER, 2008. WE TOOK OUR JIMMY IN FOR ROUTINE SERVICE (1/21/2009) IT WAS RECOMMENDED THAT THE ENGINE OIL COOLER LINES WERE LEAKING AND NEED TO BE REPLACED. WE FOUND OUT THAT THE OIL WAS DRIPPING ON THE EXHAUST SYSTEM CAUSING THE UNUSUAL ODOR. THIS COULD RESULT IN A…
Read full complaint
NOTICED A UNUSUAL ODOR COMING FROM THE ENGINE AREA IN LATE DECEMBER, 2008. WE TOOK OUR JIMMY IN FOR ROUTINE SERVICE (1/21/2009) IT WAS RECOMMENDED THAT THE ENGINE OIL COOLER LINES WERE LEAKING AND NEED TO BE REPLACED. WE FOUND OUT THAT THE OIL WAS DRIPPING ON THE EXHAUST SYSTEM CAUSING THE UNUSUAL ODOR. THIS COULD RESULT IN A FIRE AND LOSS OF VEHICLE OR INJURY TO THE OCCUPANTS IF IT WAS NOT NOTED BY THE DEALER TECHNICIAN. *TR
NHTSA ODI #10255994
Mileage unknown · Apr 29, 2008
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
I BOUGHT A 2000 JIMMY FROM OAK MOTORS. I HAVE HAD IT FOR 5 MONTHS. IN THE LAST 5 MONTHS I HAVE REPLACED THE ALTERNATOR, 3 PULLEYS, SERPENTINE BELT. THE BRAKES ARE GOING OUT, POWER STEERING IS GOING OUT, ENGINE IS TAPPING. I TOOK IT BACK AFTER HAVING IT FOR 10 DAYS BECAUSE THE SERVICE ENGINE LIGHT CAME ON. THEY WANTED 175.00…
Read full complaint
I BOUGHT A 2000 JIMMY FROM OAK MOTORS. I HAVE HAD IT FOR 5 MONTHS. IN THE LAST 5 MONTHS I HAVE REPLACED THE ALTERNATOR, 3 PULLEYS, SERPENTINE BELT. THE BRAKES ARE GOING OUT, POWER STEERING IS GOING OUT, ENGINE IS TAPPING. I TOOK IT BACK AFTER HAVING IT FOR 10 DAYS BECAUSE THE SERVICE ENGINE LIGHT CAME ON. THEY WANTED 175.00 TO LOOK AT IT. I WAS TOLD AT THE TIME OF PURCHASE THAT I HAD TO PURCHASE THE WARRANTY FOR 995.00, I THOUGHT THIS WAS TO COVER ANY PROBLEM WITH THE VEHICLE. IT DOESN'T. THEY NOW WANT 540.00 TO FIX IT. PLEASE HELP. *TR
NHTSA ODI #10226039
56,624 miles · Nov 19, 2006
Engine And Engine Cooling
56,000 MILES-GMC ALTERED POSITION- CREATED PISTON SLAP- PREMATURE WEAR-NEEDS REBUILT ENGINE. *JB
NHTSA ODI #10173804
128,000 miles · Mar 15, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED WITHOUT ANY PRIOR WARNING. THE ENGINE WOULD NOT RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC SUGGESTED REPLACING THE FUEL PUMP. ADDITIONALLY, THE MECHANIC DETERMINED TRANSMISSION FLUID WAS LOW AND THE WIR…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED WITHOUT ANY PRIOR WARNING. THE ENGINE WOULD NOT RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC SUGGESTED REPLACING THE FUEL PUMP. ADDITIONALLY, THE MECHANIC DETERMINED TRANSMISSION FLUID WAS LOW AND THE WIRES OF THE WIRING HARNESS NEEDED TO BE REPLACED. THE MECHANIC REPLACED THE FUEL PUMP ASSEMBLY, ADDED TRANSMISSION FLUID, AND NEW WIRES TO THE WIRING HARNESS. AFTERWARDS, THE STALLING PROBLEM PERSISTED. UPDATED 4/6/2006 - *NM
NHTSA ODI #10152751
40,000 miles · May 13, 2005
Engine And Engine CoolingService Brakes, HydraulicCrashInjury
2000 GMC JIMMY EXPERIENCED A PROBLEM WITH THE FRONT RIGHT HUB AND THE WHEEL SPEED SENSOR. *MR THE CONSUMER WAS PULLING INTO A PARKING SPACE AND THE BRAKE PEDAL BECAME STIFF AND OR WOULD NOT ACTIVATE. THE CONSUMER HAD RUN INTO A BRICK WALL AND BOUNCED INTO TRAFFIC. THE CHECK ABS SYSTEM LIGHT HAD IMMEDIATELY ILLUMINATED. TH…
Read full complaint
2000 GMC JIMMY EXPERIENCED A PROBLEM WITH THE FRONT RIGHT HUB AND THE WHEEL SPEED SENSOR. *MR THE CONSUMER WAS PULLING INTO A PARKING SPACE AND THE BRAKE PEDAL BECAME STIFF AND OR WOULD NOT ACTIVATE. THE CONSUMER HAD RUN INTO A BRICK WALL AND BOUNCED INTO TRAFFIC. THE CHECK ABS SYSTEM LIGHT HAD IMMEDIATELY ILLUMINATED. THE CONSUMER WAS THEN ABLE TO APPLY THE BRAKES AND BACKED INTO A PARKING SPACE. THE LEFT FRONT HUB WAS REPLACED DAYS BEFORE THE CONSUMER PURCHASED THE VEHICLE. THE VEHICLE WAS ALSO LOSING COOLANT. THE CONSUMER WAS INFORMED THAT NO COOLANT WAS IN THE VEHICLE. *SC *JB
NHTSA ODI #10121561
Mileage unknown · May 13, 2005
Engine And Engine CoolingFuel System, OtherStructure
2000 GMC JIMMY EXPERIENCING PROBLEM WITH START UP AS WELL AS WITH THE GAS GAUGE ON THE DASHBOARD. *MR THE INCIDENT OCCURRED ON AN EXTREMELY COLD MORNING IN WHICH THE VEHICLE WOULD NOT START. THE FOLLOWING DAY THE VEHICLE STARTED, BUT THE CONSUMER NOTICED THAT THE GAS GAUGE STARTED GOING FROM EMPTY TO FULL. THE CONSUMER WAS…
Read full complaint
2000 GMC JIMMY EXPERIENCING PROBLEM WITH START UP AS WELL AS WITH THE GAS GAUGE ON THE DASHBOARD. *MR THE INCIDENT OCCURRED ON AN EXTREMELY COLD MORNING IN WHICH THE VEHICLE WOULD NOT START. THE FOLLOWING DAY THE VEHICLE STARTED, BUT THE CONSUMER NOTICED THAT THE GAS GAUGE STARTED GOING FROM EMPTY TO FULL. THE CONSUMER WAS INSTRUCTED BY THE MANUFACTURER TO TAKE THE VEHICLE TO THE DEALER AND HAVE THEM REPLACE THE PCM MODULE (POWERTRAIN CONTROL MODULE) FREE OF CHARGE. THE ENGINEER SUGGESTED THAT THIS PROBLEM WOULD OCCUR IF THE WEATHER IS VERY COLD. *SC THE PASSENGER SIDE WEATHER STRIP FAILED. *JB
NHTSA ODI #10121560
61,642 miles · Jan 19, 2005
Engine And Engine CoolingSuspension
AT 50,000 MILES, BOTH FRONT WHEEL BEARINGS HAD TO BE REPLACED, AS THE VEHICLE WAS PULLING OFF THE ROAD AS IT WAS BEING DRIVEN. I WAS TOLD THAT THEY WORE BECAUSE OF NO GREASE. NOW AT 61,000 MILES, THE INTAKE MANIFOLD GASKET IS LEAKING, AND THE OIL LINES ARE ALSO LEAKING. THE DEALERSHIP ESTIMATED REPAIR COSTS AT WELL OVER $1100 DO…
Read full complaint
AT 50,000 MILES, BOTH FRONT WHEEL BEARINGS HAD TO BE REPLACED, AS THE VEHICLE WAS PULLING OFF THE ROAD AS IT WAS BEING DRIVEN. I WAS TOLD THAT THEY WORE BECAUSE OF NO GREASE. NOW AT 61,000 MILES, THE INTAKE MANIFOLD GASKET IS LEAKING, AND THE OIL LINES ARE ALSO LEAKING. THE DEALERSHIP ESTIMATED REPAIR COSTS AT WELL OVER $1100 DOLLARS. THIS IS A 2000 GMC JIMMY, AND ONLY HAS 61,000 MILES. *NM
NHTSA ODI #10107527
68,000 miles · Jun 25, 2004
Engine And Engine CoolingFire
WHILE DRIVING AT 45 MPH, THE CHECK ENGINE LIGHT CAME ON. THE DEALER EXAMINED THE VEHICLE AND CLAIMED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE CONSUMER WAS DRIVING AT THE SAME SPEED AND ALL OF THE LIGHTS ILLUMINATED ON THE DASH. THE CONSUMER PULLED ONTO THE SHOULDER AND THE VEHICLE WAS SMOLDERING UNDER THE HOOD. *JB …
Read full complaint
WHILE DRIVING AT 45 MPH, THE CHECK ENGINE LIGHT CAME ON. THE DEALER EXAMINED THE VEHICLE AND CLAIMED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE CONSUMER WAS DRIVING AT THE SAME SPEED AND ALL OF THE LIGHTS ILLUMINATED ON THE DASH. THE CONSUMER PULLED ONTO THE SHOULDER AND THE VEHICLE WAS SMOLDERING UNDER THE HOOD. *JB *NM
NHTSA ODI #10074205
Mileage unknown · Jun 19, 2004
Engine And Engine Cooling
ENGINE NOISE: THIS 2000 JIMMY WITH THE 4.3 VORTEC IS QUITE NOISY. WHEN STARTING COLD ,ABOUT 20 SECONDS LATER A LIFTER WILL START TO RAP, THEN WILL GO AWAY AND THEN BACK. AFTER COMING OFF THE HIGHWAY, SEVERAL LIFTERS WILL GET LOUD. NOW, I HAVE HEARD 4 1998-2000 4.3 IN BLAZERS AND JIMMYS DO THIS. THEN DALERSHIPS SAY THIS IS NORMA…
Read full complaint
ENGINE NOISE: THIS 2000 JIMMY WITH THE 4.3 VORTEC IS QUITE NOISY. WHEN STARTING COLD ,ABOUT 20 SECONDS LATER A LIFTER WILL START TO RAP, THEN WILL GO AWAY AND THEN BACK. AFTER COMING OFF THE HIGHWAY, SEVERAL LIFTERS WILL GET LOUD. NOW, I HAVE HEARD 4 1998-2000 4.3 IN BLAZERS AND JIMMYS DO THIS. THEN DALERSHIPS SAY THIS IS NORMAL...TECHNICIANS SAY THERE IS A VALVE TRAIN ISSUE. THIS IS NOT NORMAL NOISE..INA DDITION, WHEN LOADING THE VEHICLE, LIKE GOING UP A STEEP HILL, ONE OR TWO LIFTERS SOUND LIKE THEY ARE READY TO LET LOOSE.....CAUSE OF PROBLEM? *AK
NHTSA ODI #10078465
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration