VEHICLE HAD NO DEFECTIVE BALL JOINTS UNTIL AFTER VEHICLE WAS TAKEN TO DEALERSHIP.*AK CONSUMER WAS INFORMED THAT THE UPPER/LOWER BALL JOINTS NEEDED TO BE REPLACED AS WELL AS THE IDLER ARM TO PASS INSPECTION, CONSUMER COULD NOT UNDERSTAND WHY A VEHICLE WITH ONLY 39,532 WOULD NEED SUCH PARTS, CONSUMER WAS LATER INFORMED THAT GMC W…
Read full complaint
VEHICLE HAD NO DEFECTIVE BALL JOINTS UNTIL AFTER VEHICLE WAS TAKEN TO DEALERSHIP.*AK CONSUMER WAS INFORMED THAT THE UPPER/LOWER BALL JOINTS NEEDED TO BE REPLACED AS WELL AS THE IDLER ARM TO PASS INSPECTION, CONSUMER COULD NOT UNDERSTAND WHY A VEHICLE WITH ONLY 39,532 WOULD NEED SUCH PARTS, CONSUMER WAS LATER INFORMED THAT GMC WOULD REPLACE THE PARTS AT NO CHARGE DUE TO THEIR GOODWILL PROGRAM, HOWEVER CONSUMER STILL HAD TO PAY FOR THE LABOR CHARGE, CONSUMER WAS THEN INFORMED BY A FRIEND THAT THERE WAS A RECALL FOR UPPER BALL JOINTS, BUT WHEN CONSUMER CONTACTED GMC SHE WAS TOLD THAT HER VEHICLE WAS NOT INCLUDED IN THE RECALL.*JB
NHTSA ODI #898244
Mileage unknown · Sep 25, 2001
Power TrainSteering
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #752581
Mileage unknown · Sep 25, 2001
Electrical SystemFuel System, GasolineFuel System, Other
THIS VEHICLE HAS BEEN A NIGHTMARE...UNFORTUNATELY IT WAS A SPUR OF THE MOMENT PURCHASE. ALTHOUGH USED, WITH ONLY 39,000 MILES, I THOUGHT I WOULD BE OK SINCE IT HAD AN EXTENDED WARRANTY TILL 72,000. I HAVE REPLACED BOTH UPPER AND LOWER BALL JOINTS, IDLER ARM, ALTERNATOR, BELT TENSIONER, IGNITION SWITCH, 4WD SENSORS, GAS GAUGE S…
Read full complaint
THIS VEHICLE HAS BEEN A NIGHTMARE...UNFORTUNATELY IT WAS A SPUR OF THE MOMENT PURCHASE. ALTHOUGH USED, WITH ONLY 39,000 MILES, I THOUGHT I WOULD BE OK SINCE IT HAD AN EXTENDED WARRANTY TILL 72,000. I HAVE REPLACED BOTH UPPER AND LOWER BALL JOINTS, IDLER ARM, ALTERNATOR, BELT TENSIONER, IGNITION SWITCH, 4WD SENSORS, GAS GAUGE SENSOR, LEFT REAR AXLE SHAFT AND BOTH REAR AXLE BEARINGS. AT LEAST THESE WERE ALL COVERED UNDER THE WARRANTY, BUT NOT THE RENTAL CARS FOR ALL THE TIME THE TRUCK SPENT IN THE SHOP. NOW THE VEHICLE HAS 90,000 MILES AND THE DEALERSHIP IS TELLING ME THAT THE RECALL FOR THE BALL JOINTS DOES NOT PERTAIN TO MY TRUCK (THE VIN # IS NOT INCLUDED), THE TRANSMISSION DIPSTICK IS RUSTED (I'VE SEEN SEVERAL COMPLAINTS BUT NO RECALL), MY ACCELERATOR PEDAL STICKS SEVERELY (ALSO NUMEROUS COMPLAINTS), AND I'VE ALREADY REPLACED (OUT OF POCKET COST OF $1700) A COMPLETE REAR END. I OWE MORE THAN THIS VEHICLE IS WORTH...BUT WILL NEED TO GET RID OF IT SOON BECAUSE I DO NOT FEEL SAFE DRIVING MY SON AROUND IN IT. MANY OF THESE PROBLEMS COULD HAVE CAUSED A SERIOUS ACCIDENT...
NHTSA ODI #752579
Mileage unknown · Aug 3, 2001
Steering
WHILE DRIVING READ A NOISE AND LOST POWER STEERING. THEN, STARTED DRIVING SLOWLY. TENSIONER BROKE AND PART OF BELT ALSO BROKE.*AK *SLC
NHTSA ODI #893414
Mileage unknown · Feb 8, 2001
EquipmentSteeringCrashInjury
WHEN APPLYING ABS BRAKES WHEN ON A ICY SURFACE, POWER STEERING LOCKS UP UNTIL YOU COME TO A FULL STOP. ALSO AIR BAG DID NOT DEPLOY UPON DIRECT FRONTAL IMPACT AT 30 MPH INTO SLATE MOUNTAIN. WHEN CHANGING A TIRE, JACK SLIPPED OUT OF THE LOCKED POSITION AND DROPPED THE VEHICLE.
NHTSA ODI #740641
Mileage unknown · Apr 18, 2000
Steering
FRONT UPPER AND LOWER BALL JOINT AND IDLE ARM NEEDED REPLACEMENT.
NHTSA ODI #721628
Mileage unknown · Jul 10, 1999
Engine And Engine CoolingExterior LightingSteering
PAN GASKET FAILED CAUSING TRANSMISSION TO LEAK. MJS
NHTSA ODI #547339
Mileage unknown · Apr 21, 1997
Steering
WHILE DRIVING STEERING GEAR BOX BECAME INOPERATIVE, CAUSING SEVERE DIFFICULTY IN MANEUVERING AND CONTROLABILITY. DEALER REPLACED POWER STEERING GEAR BOX. *AK
CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A DRIVER'S SEAT BELT BUCKLE ASSEMBLY THAT CONTAINS AN ENERGY-ABSORBING LOOP. SUSTAINED LOADS OF SUFFICIENT MAGNITUDE AND DURATION ON THE BELT IN SEVERE CRASHES COULD FULLY DEPLOY THE BUCKLE ENERGY-ABSORBING LOOP, INTRODUCING A TOTAL OF 10 ADDITIONAL INCHES OF WEBBING INTO THE SEAT BELT SYSTEM. THE FREE FALLING LATCH PLATE USED IN THIS SYSTEM MAY ALLOW WEBBING TO DYNAMICALLY DISTRIBUTE BETWEEN THE LAP AND SHOULDER BELT AS THE DRIVER'S POSITION CHANGES DURING A MULTIPLE ROLLOVER EVENT.
Consequence & remedy
Consequence: IF THE ENERGY-ABSORBING LOOP FULLY DEPLOYS IN A SEVERE MULTIPLE ROLLOVER CRASH, IT IS POSSIBLE THAT A BELTED DRIVER MAY EXPERIENCE PARTIAL OR EVEN COMPLETE EJECTION FROM THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE ENERGY-ABSORBING SEAT BELT ASSEMBLIES WITH ONE THAT DOES NOT HAVE THE ENERGY-ABSORBING LOOP. OWNER NOTIFICATION BEGAN ON AUGUST 8, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence & remedy
Consequence: IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Consequence & remedy
Consequence: THIS CAN RESULT IN IMPAIRED STEERING OR STEERING LOSS, OR A PARTIAL OR COMPLETE COLLAPSE OF THE FRONT SUSPENSION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH UPPER BALL JOINTS. OWNER NOTIFICATION BEGAN SEPTEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1997 GMC Jimmy Problems, Complaints & Recalls | Skip That Year
Illustration