Electrical SystemEngine And Engine CoolingFuel System, Gasoline
BOTH OUTSIDE MIRRORS HAVE FALLEN OFF BEFORE 90K MILES. THIS WAS DUE TO THE PLASTIC DETERIORATING AT THE JUNCTION WHERE THE MIRROR "FOLDS AWAY." REPLACED EGR VALVE SEVERAL TIMES. THE FIRST THREE WERE UNDER WARRANTY, THE REST HAVE BEEN ON ME. IN ADDITION, MOST MAJOR FUEL SYSTEM COMPONENTS HAVE BEEN REPLACED, OR REPAIRED. THE …
Read full complaint
BOTH OUTSIDE MIRRORS HAVE FALLEN OFF BEFORE 90K MILES. THIS WAS DUE TO THE PLASTIC DETERIORATING AT THE JUNCTION WHERE THE MIRROR "FOLDS AWAY." REPLACED EGR VALVE SEVERAL TIMES. THE FIRST THREE WERE UNDER WARRANTY, THE REST HAVE BEEN ON ME. IN ADDITION, MOST MAJOR FUEL SYSTEM COMPONENTS HAVE BEEN REPLACED, OR REPAIRED. THE IDLE HAS ALWAYS BEEN ROUGH, AND IT WILL ON OCCASION, SMOKE AND OMIT STRONG ODORS OF UNBURNED FUEL. WIPERS FAILED AT 20K MILES. I RESOLDERED THE CIRCUIT BOARD TO CORRECT THE PROBLEM. DRIVERS SEAT WILL NOT STAY IN A LOCKED POSITION, WHICH CAUSES ME SOME CONCERN. BY THE WAY, THE FIRST WEEK I HAD THE CAR (BOUGHT IT NEW), THE SEAT WOULD NOT STAY LOCKED. TOOK IT TO THE DEALER, AND WAS PROMPTLY TOLD THAT "IT IS A NORMAL CONDITION." HMMM, AS A DESIGN ENGINEER I HAVE TO WONDER ABOUT THE LOGIC BEHIND THIS; AS ANY FORWARD OR REARWARD IMPACT WOULD ALLOW THE SEAT TO FLEX WHICH COULD MAKE A MINOR NON-INJURY ACCIDENT SOMETHING FAR WORSE. THE WATER PUMP HAS BEEN REPLACED THREE TIMES, ALTERNATOR TWICE, BATTERY FIVE. ALL PARTS WERE REPLACED WITH ORIGINAL PARTS THROUGH GM. I HAVE HAD ALL BRAKE COMPONENTS REPLACED THREE TIMES, AND STILL THERE IS A PAINFUL CHATTER OF THE PEDAL UNDER CERTAIN CONDITIONS, WHICH IS OUTSIDE THE ABS PARAMETERS. WIND NOISE IS QUITE LOUD, AS THE FIT OF THE DRIVERS SIDE DOOR IS, FOR LACK OF A BETTER WORD, TERRIBLE. THE PLASTIC WHICH COVERS THE A/C WITHIN THE ENGINE COMPARTMENT HAS DETERIORATED TO THE POINT WHERE IT HAS BROKEN AND FALLEN AWAY, PIECE BY PIECE, SOMETIMES LODGING ITSELF ON THE EXHAUST MANIFOLD, CAUSING SOME RATHER UNPLEASANT ODORS. OH, AND SINCE THERE IS NO LONGER ANY COVERING OVER THE A/C, IT GOES WITHOUT SAYING THAT THE COLDNESS, WHICH WAS THE SAVING GRACE OF THIS VEHICLE, HAS BEEN REDUCED TO THAT OF A GLORIFIED FAN. *NM
NHTSA ODI #10168470
7,000 miles · Mar 15, 2003
Electrical SystemEngine And Engine CoolingEquipment
1995 GMC JIMMY SLS 4 DOOR 4WD VORTEC 4.3 L V6. WE HAVE HAD THIS THING FOR 7 YEARS AND NOTHING I HAVE EVER OWNED HAS TAUGHT ME MORE ABOUT BEING A "SHADETREE" MECHANIC! THE LIST IS AS FOLLOWS, BREAK BOOSTER REPLACED 2 TIMES. EGR VALVE REPLACED 3 TIMES. FRONT BRAKES REPLACED AT LEAST 12 TIMES (THEY FAIL EVERY 1500 TO 1800 MILES…
Read full complaint
1995 GMC JIMMY SLS 4 DOOR 4WD VORTEC 4.3 L V6. WE HAVE HAD THIS THING FOR 7 YEARS AND NOTHING I HAVE EVER OWNED HAS TAUGHT ME MORE ABOUT BEING A "SHADETREE" MECHANIC! THE LIST IS AS FOLLOWS, BREAK BOOSTER REPLACED 2 TIMES. EGR VALVE REPLACED 3 TIMES. FRONT BRAKES REPLACED AT LEAST 12 TIMES (THEY FAIL EVERY 1500 TO 1800 MILES!) BACK HATCH WONT OPEN. BOTH SET OF WIPERS, FRONT AND BACK DO NOT WORK( SAFETY ISSUE!) ENGINE OVERHEATS. WATER PUMP REPLACED 2 TIMES. THERMOSTAT REPLACED 3 TIMES. LIGHTS FLICKER AS IF THE ALTENATOR IS GOING BAD,(RESULTING IN POLICE ASKING ME TO CHECK INTO THIS.) BATTERY REPLACED 4 TIMES (AVERAGE LIFE OF NEW BATTERY, 4 YEARS!) TRANSMISSION SHIFTS VERY HARD WHEN ENGINE IS COOL/ HOT! STARTING TO SEE RUST IN TRANS, DIPSTICK. SOMETIMES CANT SHIFT FROM 2 WD TO 4 WD AND WHEN ABLE, TRANSFER CASE MAKES CLICKING SOUND. THIS IS NOT A PHONY COMPLAINT! I NEED HELP WITH THIS AS I NEVER SEE A RECALL, WARRANTY IS OUT AND I CANT AFFORD TO TAKE IT IN. I DON'T THINK I LEFT ANY THING OUT, BUT IM SURE MY WIFE WILL LET ME KNOW. YOU CAN GIVE MY NAME TO WHO EVER WHEN EVER IF IT WILL HELP US FIX THIS SITUATION. *NLM
VEHICLE EXPERIENCED FAILURE OF THE SB 99066 COMPONENT (FUEL INJECTION SYSTEM) ON SEVERAL OCCASIONS PRIOR TO NOTIFICATION CAUSING THE ENGINE TO HESITATE AND SHUT DOWN. *MJS
NHTSA ODI #553258
Mileage unknown · Jun 20, 2000
Structure
EXCESSIVE RUST WAS FOUND ON FRAMES/ GAS & FUEL LINES AND DOORS. TAKEN VEHICLE TO DEALERSHIP & MECHANIC COULD GIVE NO INDICATION OF REASON FOR SEVERE RUSTING.*AK
NHTSA ODI #863882
Mileage unknown · May 5, 2000
Structure
SEVERE RUSTING THROUGHT CAR UNDERSIDE AND DOORS, CAUSING MANY MECHANICAL FAILURES THAT WERE SAFETY RELATED. *AK
NHTSA ODI #722306
Mileage unknown · Oct 4, 1999
Electrical SystemEngine And Engine CoolingEquipment
ALTHOUGH WIPER PULSE CONTROL MODULE FAILED AND WAS REPAIRED UNDER CAMPAIGN 98043 IT CONTINUES TO FAIL INTERMITENTLY CAUSING POOR VISIBILITY. NLM
NHTSA ODI #548869
Mileage unknown · Oct 2, 1997
Structure
ALL FOUR INTERNAL DOOR PANELS ARE POPPING OUT. WORSE CASE GAP IS ABOUT 1 INCH. *AK
NHTSA ODI #523913
Mileage unknown · Jan 9, 1997
Engine And Engine CoolingPower TrainStructure
REAR WINDOW WOULD NOT LOCK--BOLTS HOLDING THE LOCK NEEDED TIGHTENING. TRANSMISSION NOT SHIFTING. ENGINE OVERHEATS. TIRE BLOWOUT. FRONT BRAKES FAIL. ENGINE STALLS. OWNER WANTS TO BE REFUNDED FOR CAR.
NHTSA ODI #513455
Mileage unknown · Oct 31, 1996
SeatsService Brakes, HydraulicStructure
DRIVERS POWER SEAT FAILED.
NHTSA ODI #507405
Mileage unknown · Jun 23, 1995
Structure
THE BACK DOOR OPENS BY ITSELF SOME TIMES. PLEASE DESCRIBE. TT
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
THE BRAKE PEDAL PIVOT BOLT WAS STARTED IN THE WELD NUT, BUT WAS NOT TORQUED CORRECTLY CAUSING THE BOLT TO DISENGAGE FROM THE WELD NUT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A TOTAL LOSS OF BRAKINGCAPABILITY.
Remedy: DEALERS WILL INSPECT FOR HAND-STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO CORRECT SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE99024 · Loss Of Power Assist Braking
Opened Apr 5, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
CONSUMERS ALLEGE A PARTIAL LOSS OF BRAKING ABILITY
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1995 GMC Jimmy Problems, Complaints & Recalls | Skip That Year
Illustration